NI4TMLF12-6Smart LF Oscillator

Smart LF Oscillator Model TMLF12-6 FCC ID: NI4TMLF12-6 Since this device is always used with vehicle, it is not sold to general end users separately. Therefore there is no user manual of this device by alone. The following statements must be described on the user manual of the vehicle; For vehicles sold in U.S.A.: NOTE This device complies with part 15 of the FCC Rules. Operation is subject to the following two conditions: (1) This device may not cause harmful interference, and (2) this device must accept any interference received, including interference that may cause undesired operation. FCC CAUTION Changes or modifications not expressly approved by the party responsible for compliance could void the user’s authority to operate the equipment.

TMLF12-6 (1/2) Photographs of Smart LF Oscillator Model TMLF12-6 ○ Computer Assy, Smart Key (Representative) Rear View Front View Appearance Printed Circuit Board Front View Rear View External Photo TMLF12-6 Left Right Bottom Antenna Connection TMLF12-6 (2/2) Printed Circuit Board - end - ○ Door Antenna (Representative) Front View Rear View ○ Trunk Antenna (Representative) Appearance Front View Rear View ○ Room Antenna/Luggage Antenna (Representative) Appearance Front View Rear View Front ViewRear View

Approval Mark （Note） The layout and design of the approval mark may be changed. The location of FCC ID code and Canadian approval number may be changed. This device will be installed inside vehicle and end-user will not see the mark. FCC compliance statement will be included in User Manual as it is not practical to place on the device according to FCC Rules §15.19. Smart LF Oscillator Model: TMLF12-6

TMLF12-6 (1/2) Photographs of Smart LF Oscillator Model TMLF12-6 ○ Computer Assy, Smart Key (Representative) Rear View Front View Appearance Printed Circuit Board Front View Rear View TMLF12-6 (2/2) Printed Circuit Board ※There are no internal photos since there is no PCB used in Trunk Antenna, Room Antenna and Luggage Antenna. - end - ○ Door Antenna (Representative) Front View Rear View ○ Trunk Antenna (Representative) Appearance Front View Rear View ○ Room Antenna/Luggage Antenna (Representative) Appearance Front View Rear View Front ViewRear View

Test report No. : 10232789H-A Page : 1 of 29 Issued date : March 26, 2014 FCC ID : NI4TMLF12-6 UL Japan, Inc. Head Office EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8999 Facsimile : +81 596 24 8124 RADIO TEST REPORT Test Report No. : 10232789H-A Applicant : Toyota Motor Corporation Type of Equipment : Smart LF Oscillator Model No. : TMLF12-6 FCC ID : NI4TMLF12-6 Test regulation : FCC Part 15 Subpart C: 2013 Test Result : Complied 1. This test report shall not be reproduced in full or partial, without the written approval of UL Japan, Inc. 2. The results in this report apply only to the sample tested. 3. This sample tested is in compliance with above regulation. 4. The test results in this report are traceable to the national or international standards. 5. This test report must not be used by the customer to claim product certification, approval, or endorsement by NVLAP, NIST, or any agency of the Federal Government. Date of test: August 1 to 29, 2013 and March 12 to 13, 2014 Representative test engineer: Keisuke Kawamura Engineer of WiSE Japan, UL Verification Service Approved by: Masanori Nishiyama Manager of WiSE Japan, UL Verification Service 13-EM-F0429 NVLAP LAB CODE: 200572-0 This laboratory is accredited by the NVLAP LAB CODE 200572-0, U.S.A. The tests reported herein have been performed in accordance with its terms of accreditation. *As for the range of Accreditation in NVLAP, you may refer to the WEB address, http://www.ul.com/japan/jpn/pages/services/emc/about/ma rk1/index.jsp#nvlap Test report No. : 10232789H-A Page : 2 of 29 Issued date : March 26, 2014 FCC ID : NI4TMLF12-6 UL Japan, Inc. Head Office EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8999 Facsimile : +81 596 24 8124 REVISION HISTORY Original Test Report No.: 10232789H-A Revision Test report No. Date Page revisedContents - (Original) 10232789H-A March 26, 2014 - - Test report No. : 10232789H-A Page : 3 of 29 Issued date : March 26, 2014 FCC ID : NI4TMLF12-6 UL Japan, Inc. Head Office EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8999 Facsimile : +81 596 24 8124 CONTENTS PAGE SECTION 1: Customer information ..................................................................................................... 4 SECTION 2: Equipment under test (E.U.T.) ........................................................................................ 4 SECTION 3: Test specification, procedures & results ........................................................................ 5 SECTION 4: Operation of E.U.T. during testing ................................................................................. 8 SECTION 5: Radiated emission (Fundamental and Spurious Emission) ........................................ 10 SECTION 6: -26dB Bandwidth ............................................................................................................ 12 SECTION 7: 99% Occupied Bandwidth ............................................................................................. 12 APPENDIX 1: Data of EMI test ........................................................................................................... 13 Radiated Emission below 30MHz (Fundamental and Spurious Emission) ................................. 13 Radiated Emission above 30MHz (Spurious Emission) ................................................................. 17 -26dB Bandwidth and 99% Occupied Bandwidth ......................................................................... 21 APPENDIX 2: Test instruments .......................................................................................................... 23 APPENDIX 3: Photographs of test setup ............................................................................................ 25 Radiated Emission ............................................................................................................................. 25 Worst Case Position .......................................................................................................................... 28 Test report No. : 10232789H-A Page : 4 of 29 Issued date : March 26, 2014 FCC ID : NI4TMLF12-6 UL Japan, Inc. Head Office EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8999 Facsimile : +81 596 24 8124 SECTION 1: Customer information Company Name : Toyota Motor Corporation Address : 1, Toyota-Cho, Toyota, Aichi, 471-8572 Japan Telephone Number : +81-565-94-1006 Facsimile Number : +81-565-94-1162 Contact Person : Hiroki Okada SECTION 2: Equipment under test (E.U.T.) 2.1 Identification of E.U.T. Type of Equipment : Smart LF Oscillator Model No. : TMLF12-6 Serial No. : Refer to Section 4, Clause 4.2 Rating : DC12.0V (Max 0.5A) Receipt Date of Sample : July 25, 2013, February 21, 2014 Condition of EUT : Production prototype (Not for Sale: This sample is equivalent to mass-produced items.) Modification of EUT : No Modification by the test lab 2.2 Product Description Smart LF Oscillator, model: TMLF12-6 is a transmitter that is installed in a motor vehicle and is used as part of Smart System. Radio Specification Radio Type : Transmitter Frequency of Operation : 134.2kHz Modulation : ASK Method of Frequency Genenration : Crystal Antenna type : Coil Antenna Smart LF Oscillator (model: TMLF12-6) consists of the following parts: - Computer Assy, Smart Key (ECU) - Door Antenna - Trunk Antenna - Room Antenna / Luggage Antenna Test report No. : 10232789H-A Page : 5 of 29 Issued date : March 26, 2014 FCC ID : NI4TMLF12-6 UL Japan, Inc. Head Office EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8999 Facsimile : +81 596 24 8124 SECTION 3: Test specification, procedures & results 3.1 Test Specification Test Specification : FCC Part 15 Subpart C: 2013, final revised on September 30, 2013 and effective October 30, 2013 Title : FCC 47CFR Part15 Radio Frequency De…

Text truncated - open the document above for the full version.

Test report No. : 10232789H-A Page : 25 of 29 Issued date : March 26, 2014 FCC ID : NI4TMLF12-6 UL Japan, Inc. Head Office EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8999 Facsimile : +81 596 24 8124 APPENDIX 3: Photographs of test setup Radiated Emission Door Antenna Photo 1 Photo 2 Test report No. : 10232789H-A Page : 26 of 29 Issued date : March 26, 2014 FCC ID : NI4TMLF12-6 UL Japan, Inc. Head Office EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8999 Facsimile : +81 596 24 8124 Radiated Emission Trunk Antenna Photo 1 Photo 2 Test report No. : 10232789H-A Page : 27 of 29 Issued date : March 26, 2014 FCC ID : NI4TMLF12-6 UL Japan, Inc. Head Office EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8999 Facsimile : +81 596 24 8124 Radiated Emission Room Antenna / Luggage Antenna Photo 1 Photo 2 Test report No. : 10232789H-A Page : 28 of 29 Issued date : March 26, 2014 FCC ID : NI4TMLF12-6 UL Japan, Inc. Head Office EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8999 Facsimile : +81 596 24 8124 Worst Case Position Door Antenna Below 30MHz:X-axis Above 30MHz(Hori:X-axis /Vert:X-axis) Trunk Antenna Below 30MHz:X-axis Above 30MHz(Hori:X-axis /Vert:X-axis) X-axis X-axis Y-axis Y-axis Z-axis Z-axis Test report No. : 10232789H-A Page : 29 of 29 Issued date : March 26, 2014 FCC ID : NI4TMLF12-6 UL Japan, Inc. Head Office EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8999 Facsimile : +81 596 24 8124 Worst Case Position Room Antenna / Luggage Antenna Below 30MHz:X-axis Above 30MHz(Hori:X-axis /Vert:X-axis) ECU Below 30MHz:X-axis Above 30MHz(Hori:X-axis /Vert:X-axis) X-axis X-axis Y-axis Y-axis Z-axis Z-axis End of Report