NI4TMLF15-1Smart LF Oscillator

Smart LF Oscillator Model TMLF15-1 FCC ID: NI4TMLF15-1 IC:2842A-TMLF151 For vehicles sold in U.S.A.: NOTE This device complies with part 15 of the FCC Rules. Operation is subject to the following two conditions: (1) This device may not cause harmful interference, and (2) this device must accept any interference received, including interference that may cause undesired operation. FCC CAUTION Changes or modifications not expressly approved by the party responsible for compliance could void the user’s authority to operate the equipment. For vehicles sold in Canada: NOTE This device complies with Industry Canada’s licence-exempt RSSs. Operation is subject to the following two conditions: (1) This device may not cause interference; and (2) This device must accept any interference, including interference that may cause undesired operation of the device. Le présent appareil est conforme aux CNR d'Industrie Canada applicables aux appareils radio exempts de licence. L'exploitation est autorisée aux deux conditions suivantes : 1) l'appareil ne doit pas produire de brouillage; 2) l'utilisateur de l'appareil doit accepter tout brouillage radioélectrique subi, même si le brouillage est susceptible d'en compromettre le fonctionnement. Note: We will not supply the user’s manual because our product(TMLF15-1) is one of the vehicle parts. However, we will ask the vehicle manufacturer to include the above statements in the vehicle user’s manual in accordance FCC & IC requirements.

Toyota Motor Corporation [Model: TMLF15-1 ]

Approval Mark （Note） The layout and design of the approval mark may be changed. The location of FCC ID code and Canadian approval number may be changed. This device will be installed inside vehicle and end-user will not see the mark. FCC compliance statement will be included in User Manual as it is not practical to place on the device according to FCC Rules §15.19. Smart LF Oscillator TMLF15-1

Photographs of Smart LF Oscillator Model TMLF15-1 ○ Computer Assy, Smart Key Representative Printed Circuit Board Front View (Refer to next page) ○ Computer Assy, Smart Key Representative Printed Circuit Board Rear View (Refer to next page) Photo: Smart LF Oscillator TS-9TY Extra1/Extra 2/ Extra 3/ Back Door Antenna (Representative) Front View Rear View Photo: Smart LF Oscillator TS-9TY Left View Right View

Test report No. : 10616579H-A-R1 Page : 1 of 28 Issued date : January 27, 2015 Revised date : March 17, 2015 FCC ID : NI4TMLF15-1 UL Japan, Inc. Ise EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8999 Facsimile : +81 596 24 8124 RADIO TEST REPORT Test Report No. : 10616579H-A-R1 Applicant : TOYOTA MOTOR CORPORATION Type of Equipment : Smart LF Oscillator Model No. : TMLF15-1 FCC ID : NI4TMLF15-1 Test regulation : FCC Part 15 Subpart C: 2015 Test Result : Complied 1. This test report shall not be reproduced in full or partial, without the written approval of UL Japan, Inc. 2. The results in this report apply only to the sample tested. 3. This sample tested is in compliance with above regulation. 4. The test results in this report are traceable to the national or international standards. 5. This test report must not be used by the customer to claim product certification, approval, or endorsement by NVLAP, NIST, or any agency of the Federal Government. 6. This test report covers Radio technical requirements. It does not cover administrative issues such as Manual or non-Radio test related Requirements. (if applicable) 7. This report is a revised version of 10616579H-A. 10616579H-A is replaced with this report. Date of test: January 9 and 13, 2015 Representative test engineer: Shinya Watanabe Engineer Consumer Technology Division Approved by: Motoya Imura Engineer Consumer Technology Division 13-EM-F0429 NVLAP LAB CODE: 200572-0 This laboratory is accredited by the NVLAP LAB CODE 200572-0, U.S.A. The tests reported herein have been performed in accordance with its terms of accreditation. *As for the range of Accreditation in NVLAP, you may refer to the WEB address, http://www.ul.com/japan/jpn/pages/services/emc/about/ma rk1/index.jsp#nvlap Test report No. : 10616579H-A-R1 Page : 2 of 28 Issued date : January 27, 2015 Revised date : March 17, 2015 FCC ID : NI4TMLF15-1 UL Japan, Inc. Ise EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8999 Facsimile : +81 596 24 8124 REVISION HISTORY Original Test Report No.: 10616579H-A Revision Test report No. Date Page revisedContents - (Original) 10616579H-A January 27, 2015 - - 1 10616579H-A-R1 March 17, 2015 P.4 Correction of Model number in Clause 2.2 Test report No. : 10616579H-A-R1 Page : 3 of 28 Issued date : January 27, 2015 Revised date : March 17, 2015 FCC ID : NI4TMLF15-1 UL Japan, Inc. Ise EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8999 Facsimile : +81 596 24 8124 CONTENTS PAGE SECTION 1: Customer information ..................................................................................................... 4 SECTION 2: Equipment under test (E.U.T.) ........................................................................................ 4 SECTION 3: Test specification, procedures & results ........................................................................ 5 SECTION 4: Operation of E.U.T. during testing ................................................................................. 8 SECTION 5: Radiated emission (Fundamental and Spurious Emission) ........................................ 10 SECTION 6: -26dB Bandwidth ............................................................................................................ 12 SECTION 7: 99% Occupied Bandwidth ............................................................................................. 12 APPENDIX 1: Data of EMI test ........................................................................................................... 13 Radiated Emission below 30MHz (Fundamental and Spurious Emission) ................................. 13 Radiated Emission above 30MHz (Spurious Emission) ................................................................. 17 -26dB Bandwidth and 99% Occupied Bandwidth ......................................................................... 21 APPENDIX 2: Test instruments .......................................................................................................... 23 APPENDIX 3: Photographs of test setup ............................................................................................ 24 Radiated Emission ............................................................................................................................. 24 Worst Case Position .......................................................................................................................... 27 Test report No. : 10616579H-A-R1 Page : 4 of 28 Issued date : January 27, 2015 Revised date : March 17, 2015 FCC ID : NI4TMLF15-1 UL Japan, Inc. Ise EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8999 Facsimile : +81 596 24 8124 SECTION 1: Customer information Company Name : TOYOTA MOTOR CORPORATION Address : 1, Toyota-Cho, Toyota, Aichi, 471-8572 Japan Telephone Number : +81-565-94-1006 Facsimile Number : +81-565-94-1162 Contact Person : Hiroki Okada SECTION 2: Equipment under test (E.U.T.) 2.1 Identification of E.U.T. Type of Equipment : Smart LF Oscillator Model No. : TMLF15-1 Serial No. : Refer to Section 4, Clause 4.2 Rating : DC12.0V (Max 0.5A) Receipt Date of Sample : December 22, 2014 Condition of EUT : Production prototype (Not for Sale: This sample is equivalent to mass-produced items.) Modification of EUT : No Modification by the test lab 2.2 Product Description Smart LF Oscillator, model: TMLF15-1 is a transmitter that is installed in a motor vehicle and is used as part of Smart System. Radio Specification Radio Type : Transmitter Frequency of Operation : 134.2kHz Modulation : ASK Method of Frequency Genenration : Crystal Antenna type : Coil Antenna Smart LF Oscillator (model: TMLF15-1) consists of the following parts: - Computer Assy, Smart Key (ECU) - Door Antenna *1) - Trunk Antenna *1) - Room Antenna / Luggage Antenna *2) *1) The output value of Door Antenna and Trunk Antenna is not variable. Ma…

Text truncated - open the document above for the full version.

Test report No. : 10616579H-A-R1 Page : 24 of 28 Issued date : January 27, 2015 Revised date : March 17, 2015 FCC ID : NI4TMLF15-1 UL Japan, Inc. Ise EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8999 Facsimile : +81 596 24 8124 APPENDIX 3: Photographs of test setup Radiated Emission Door Antenna Photo 1 Photo 2 Test report No. : 10616579H-A-R1 Page : 25 of 28 Issued date : January 27, 2015 Revised date : March 17, 2015 FCC ID : NI4TMLF15-1 UL Japan, Inc. Ise EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8999 Facsimile : +81 596 24 8124 Radiated Emission Trunk Antenna Photo 1 Photo 2 Test report No. : 10616579H-A-R1 Page : 26 of 28 Issued date : January 27, 2015 Revised date : March 17, 2015 FCC ID : NI4TMLF15-1 UL Japan, Inc. Ise EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8999 Facsimile : +81 596 24 8124 Radiated Emission Room Antenna / Luggage Antenna Photo 1 Photo 2 Test report No. : 10616579H-A-R1 Page : 27 of 28 Issued date : January 27, 2015 Revised date : March 17, 2015 FCC ID : NI4TMLF15-1 UL Japan, Inc. Ise EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8999 Facsimile : +81 596 24 8124 Worst Case Position Door Antenna Below 30MHz:X-axis Above 30MHz(Hori:X-axis /Vert:X-axis) Trunk Antenna Below 30MHz:X-axis Above 30MHz(Hori:X-axis /Vert:X-axis) X-axis X-axis Y-axis Y-axis Z-axis Z-axis Test report No. : 10616579H-A-R1 Page : 28 of 28 Issued date : January 27, 2015 Revised date : March 17, 2015 FCC ID : NI4TMLF15-1 UL Japan, Inc. Ise EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8999 Facsimile : +81 596 24 8124 Worst Case Position Room Antenna / Luggage Antenna Below 30MHz:X-axis Above 30MHz(Hori:X-axis /Vert:X-axis) ECU Below 30MHz:X-axis Above 30MHz(Hori:X-axis /Vert:X-axis) X-axis X-axis Y-axis Y-axis Z-axis Z-axis End of Report