NI4TMLF15-2Smart LF Oscillator

Approval Mark （Note） The layout and design of the approval mark may be changed. The location of FCC ID code and Canadian approval number may be changed. This device will be installed inside vehicle and end-user will not see the mark. FCC compliance statement will be included in User Manual as it is not practical to place on the device according to FCC Rules §15.19. Smart LF Oscillator Model： TMLF15-2

Photo of Smart LF Oscillator Model: TMLF15-2 ○ Computer Assy, Smart Key (Representative) FRONT Photo of Smart LF Oscillator Model: TMLF15-2 BACK Photo: Smart LF Oscillator TS-9TY Extra1/Extra 2/ Extra 3/ Back Door Antenna (Representative) Front View Rear View Photo: Smart LF Oscillator TS-9TY Left View Right View

Test report No. : 10516910H-A-R1 Page : 1 of 28 Issued date : November 19, 2014 Revised date : February 20, 2015 FCC ID : NI4TMLF15-2 UL Japan, Inc. Ise EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8999 Facsimile : +81 596 24 8124 RADIO TEST REPORT Test Report No. : 10516910H-A-R1 Applicant : Toyota Motor Corporation Type of Equipment : Smart LF Oscillator Model No. : TMLF15-2 FCC ID : NI4TMLF15-2 Test regulation : FCC Part 15 Subpart C: 2014 Test Result : Complied 1. This test report shall not be reproduced in full or partial, without the written approval of UL Japan, Inc. 2. The results in this report apply only to the sample tested. 3. This sample tested is in compliance with above regulation. 4. The test results in this report are traceable to the national or international standards. 5. This test report must not be used by the customer to claim product certification, approval, or endorsement by NVLAP, NIST, or any agency of the Federal Government. 6. This test report covers Radio technical requirements. It does not cover administrative issues such as Manual or non-Radio test related Requirements. (if applicable) 7. This report is a revised version of 10516910H-A. 10516910H-A is replaced with this report. Date of test: October 10 and 11, 2014 Representative test engineer: Masatoshi Nishiguchi Engineer Consumer Technology Division Approved by: Motoya Imura Engineer Consumer Technology Division 13-EM-F0429 NVLAP LAB CODE: 200572-0 This laboratory is accredited by the NVLAP LAB CODE 200572-0, U.S.A. The tests reported herein have been performed in accordance with its terms of accreditation. *As for the range of Accreditation in NVLAP, you may refer to the WEB address, http://www.ul.com/japan/jpn/pages/services/emc/about/ma rk1/index.jsp#nvlap Test report No. : 10516910H-A-R1 Page : 2 of 28 Issued date : November 19, 2014 Revised date : February 20, 2015 FCC ID : NI4TMLF15-2 UL Japan, Inc. Ise EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8999 Facsimile : +81 596 24 8124 REVISION HISTORY Original Test Report No.: 10516910H-A Revision Test report No. Date Page revisedContents - (Original) 10516910H-A November 19, 2014- - 1 10516910H-A-R1 February 20, 2015 P. 4 Addition of note ;*1) and *2) 1 10516910H-A-R1 February 20, 2015 P. 8 Correction of test mode notation Test report No. : 10516910H-A-R1 Page : 3 of 28 Issued date : November 19, 2014 Revised date : February 20, 2015 FCC ID : NI4TMLF15-2 UL Japan, Inc. Ise EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8999 Facsimile : +81 596 24 8124 CONTENTS PAGE SECTION 1: Customer information ..................................................................................................... 4 SECTION 2: Equipment under test (E.U.T.) ........................................................................................ 4 SECTION 3: Test specification, procedures & results ........................................................................ 5 SECTION 4: Operation of E.U.T. during testing ................................................................................. 8 SECTION 5: Radiated emission (Fundamental and Spurious Emission) ........................................ 10 SECTION 6: -26dB Bandwidth ............................................................................................................ 12 SECTION 7: 99% Occupied Bandwidth ............................................................................................. 12 APPENDIX 1: Data of EMI test ........................................................................................................... 13 Radiated Emission below 30MHz (Fundamental and Spurious Emission) ................................. 13 Radiated Emission above 30MHz (Spurious Emission) ................................................................. 17 -26dB Bandwidth and 99% Occupied Bandwidth ......................................................................... 21 APPENDIX 2: Test instruments .......................................................................................................... 23 APPENDIX 3: Photographs of test setup ............................................................................................ 24 Radiated Emission ............................................................................................................................. 24 Worst Case Position .......................................................................................................................... 27 Test report No. : 10516910H-A-R1 Page : 4 of 28 Issued date : November 19, 2014 Revised date : February 20, 2015 FCC ID : NI4TMLF15-2 UL Japan, Inc. Ise EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8999 Facsimile : +81 596 24 8124 SECTION 1: Customer information Company Name : Toyota Motor Corporation Address : 1, Toyota-Cho, Toyota, Aichi, 471-8572 Japan Telephone Number : +81-565-94-1006 Facsimile Number : +81-565-94-1162 Contact Person : Hiroki Okada SECTION 2: Equipment under test (E.U.T.) 2.1 Identification of E.U.T. Type of Equipment : Smart LF Oscillator Model No. : TMLF15-2 Serial No. : Refer to Section 4, Clause 4.2 Rating : DC12.0V (Max 0.5A) Receipt Date of Sample : October 1, 2014 Condition of EUT : Production prototype (Not for Sale: This sample is equivalent to mass-produced items.) Modification of EUT : No Modification by the test lab 2.2 Product Description Smart LF Oscillator, model: TMLF15-2 is a transmitter that is installed in a motor vehicle and is used as part of Smart System. Radio Specification Radio Type : Transmitter Frequency of Operation : 134.2kHz Modulation : ASK Method of Frequency Genenration : Crystal Antenna type : Coil Antenna Smart LF Oscillator (model: TMLF15-2) consists of the following parts: - Computer Assy, Smart Key (ECU) - Door Antenna *1) - Trunk Antenna *1) - Room Antenna / Luggage …

Text truncated - open the document above for the full version.

Test report No. : 10516910H-A-R1 Page : 24 of 28 Issued date : November 19, 2014 Revised date : February 20, 2015 FCC ID : NI4TMLF15-2 UL Japan, Inc. Ise EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8999 Facsimile : +81 596 24 8124 APPENDIX 3: Photographs of test setup Radiated Emission Door Antenna Photo 1 Photo 2 Test report No. : 10516910H-A-R1 Page : 25 of 28 Issued date : November 19, 2014 Revised date : February 20, 2015 FCC ID : NI4TMLF15-2 UL Japan, Inc. Ise EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8999 Facsimile : +81 596 24 8124 Radiated Emission Trunk Antenna Photo 1 Photo 2 Test report No. : 10516910H-A-R1 Page : 26 of 28 Issued date : November 19, 2014 Revised date : February 20, 2015 FCC ID : NI4TMLF15-2 UL Japan, Inc. Ise EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8999 Facsimile : +81 596 24 8124 Radiated Emission Room Antenna / Luggage Antenna Photo 1 Photo 2 Test report No. : 10516910H-A-R1 Page : 27 of 28 Issued date : November 19, 2014 Revised date : February 20, 2015 FCC ID : NI4TMLF15-2 UL Japan, Inc. Ise EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8999 Facsimile : +81 596 24 8124 Worst Case Position Door Antenna Below 30MHz:X-axis Above 30MHz(Hori:X-axis /Vert:X-axis) Trunk Antenna Below 30MHz:X-axis Above 30MHz(Hori:X-axis /Vert:X-axis) X-axis X-axis Y-axis Y-axis Z-axis Z-axis Test report No. : 10516910H-A-R1 Page : 28 of 28 Issued date : November 19, 2014 Revised date : February 20, 2015 FCC ID : NI4TMLF15-2 UL Japan, Inc. Ise EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8999 Facsimile : +81 596 24 8124 Worst Case Position Room Antenna / Luggage Antenna Below 30MHz:X-axis Above 30MHz(Hori:X-axis /Vert:X-axis) ECU Below 30MHz:X-axis Above 30MHz(Hori:X-axis /Vert:X-axis) X-axis X-axis Y-axis Y-axis Z-axis Z-axis End of Report