NKR-SWZ1ZWave Remote Control Module

Wistron NeWeb Wistron NeWeb Corporation 20 Park Avenue II, Hsinchu Science Park, Hsinchu 308, Taiwan, R.O.C. Phone: 886-3-666-7799 Fax: 886-3-666-7711 Website: www.wneweb.com Wistron NeWeb Confidential Document 1 User Manual Model Name: SWZ1 (Sigma Design SD3402) (ZWave Embedded Module) Revision: 1.0 Issue Date: 2010/05/14 This document and the information contained herein is the property of Wistron NeWeb Corporation and reproduction by any means (including, but not limited to, xerographic, chemical, electronic) and distribution is expressly prohibited without prior written consent from Wistron NeWeb Corporation. The document and information contained herein are confidential and may not be divulged without express written consent from Wistron NeWeb Corporation, located at 20 Park Avenue II, Hsinchu Science Park, Hsinchu 308, Taiwan, R.O.C. Copyright 2010 by Wistron NeWeb Corporation / All rights reserved. Wistron NeWeb Wistron NeWeb Corporation 20 Park Avenue II, Hsinchu Science Park, Hsinchu 308, Taiwan, R.O.C. Phone: 886-3-666-7799 Fax: 886-3-666-7711 Website: www.wneweb.com Wistron NeWeb Confidential Document 2 Revision History Edition # Reason for revision Issue date Author 1.0
Initial Draft Document 2010/05/14 Lydia Tsai



Wistron NeWeb Wistron NeWeb Corporation 20 Park Avenue II, Hsinchu Science Park, Hsinchu 308, Taiwan, R.O.C. Phone: 886-3-666-7799 Fax: 886-3-666-7711 Website: www.wneweb.com Wistron NeWeb Confidential Document 3 Federal Communication Commission Interference Statement Federal Communication Commission Interference Statement This equipment has been tested and found to comply with the limits for a Class B digital device, pursuant to Part 15 of the FCC Rules. These limits are designed to provide reasonable protection against harmful interference in a residential installation. This equipment generates, uses and can radiate radio frequency energy and, if not installed and used in accordance with the instructions, may cause harmful interference to radio communications. However, there is no guarantee that interference will not occur in a particular installation. If this equipment does cause harmful interference to radio or television reception, which can be determined by turning the equipment off and on, the user is encouraged to try to correct the interference by one of the following measures: ● Reorient or relocate the receiving antenna. ● Increase the separation between the equipment and receiver. ● Connect the equipment into an outlet on a circuit different from that to which the receiver is connected. ● Consult the dealer or an experienced radio/TV technician for help. FCC Caution: Any changes or modifications not expressly approved by the party responsible for compliance could void the user’s authority to operate this equipment. This device complies with Part 15 of the FCC Rules. Operation is subject to the following two conditions: (1) This device may not cause harmful interference, and (2) this device must accept any interference received, including interference that may cause undesired operation. Wistron NeWeb Wistron NeWeb Corporation 20 Park Avenue II, Hsinchu Science Park, Hsinchu 308, Taiwan, R.O.C. Phone: 886-3-666-7799 Fax: 886-3-666-7711 Website: www.wneweb.com Wistron NeWeb Confidential Document 4 Canadian ICES-003 C Statement This Class B digital apparatus complies with Canadian ICES-003. Operation is subject to the following two conditions: (1) this device may not cause interference, and (2) this device must accept any interference, including interference that may cause undesired operation of the device. Cet appareil numérique de la classe B est conforme á la norme NMB-003 du Canada. Wistron NeWeb Wistron NeWeb Corporation 20 Park Avenue II, Hsinchu Science Park, Hsinchu 308, Taiwan, R.O.C. Phone: 886-3-666-7799 Fax: 886-3-666-7711 Website: www.wneweb.com Wistron NeWeb Confidential Document 5 1. General Description The SWZ11 module is ZWave single chip solutions for embedded module. It’s very small and cost-effective modules and comlete wireless solution for application in home control and AV control consisting of an integrated multi band, multi channel, multi speed RD transceiver. And SWZ1 use an 8051 micorcontroller, a comprehensive set of peripherals, RAM, OTP memory storage for user application software and the ZWave software. Through an integrated HW key matrix scanner, SWZ1 had on-chip IR coding support, the ID learning features, its low power design, and advanced power management. 2. Usage & Key Features  SWZ1 is the perfect solution for managing energy consumption in the home.  SWZ1 enable the right solutions to the consumer through o Home Health Care o Home Security o Energy Management o Entertainment Control  Using Z-Wave SD3402 Signle Chip  64 kbyte OTP memory for Z-Wave protocol + API + customization device application SW  W/I printed ANT on the board  URAT available for general use  AES-128 security hardware acceleration  Power-on reset / brown-out detector which is active in all power modes. Wistron NeWeb Wistron NeWeb Corporation 20 Park Avenue II, Hsinchu Science Park, Hsinchu 308, Taiwan, R.O.C. Phone: 886-3-666-7799 Fax: 886-3-666-7711 Website: www.wneweb.com Wistron NeWeb Confidential Document 6 3. Module Outline Wistron NeWeb Wistron NeWeb Corporation 20 Park Avenue II, Hsinchu Science Park, Hsinchu 308, Taiwan, R.O.C. Phone: 886-3-666-7799 Fax: 886-3-666-7711 Website: www.wneweb.com Wistron NeWeb Confidential Document 7 4. Pin Configuration & RF Spec.  Main Parts:  IC SD3402 Single Chip, QFN48  TXC- XTAL 32MHz, 12pF  Atmel- Serial EEPROM, SPI, 128K  KYOCERA SF16-0908M4UU01 SAW Filter  TAI- TA0602A SAW Filter  PCB Dimension: 65 x 20 mm  Antennas: Printed ANT on the board  Z-Wave SD3403 single chip:  QFN48 (7x7mm)  Optimized 8051 CPU Core  64kbyte OTP memory  16kbyte data SRAM  RF communication:  FSK / GFSK/ 4-FSK modulation  Band  Data rate 9.6 / 40 / 100 kbit/s  Power Consumption  TX: 30~40mA  RX:…

Text truncated - open the document above for the full version.

Page No. : 20 Limited Module Approval Request Letter Subject: Limited Module Approval Date: 2010/5/19 FCC ID: NKR-SWZ1 Dear Reviewer, We, Sporton International Inc., are authorized by Wistron NeWeb Corporation to have their state-of-the-art ZWave Remote Control Module approved under limited module approval authorization. The application of this module is specified to mobile host equipment. The requirements regulated in Public Notice DA00-1407 have been fulfilled and clearly explained below. 1. The requirement of RF shielding: The shielding of the radio portion can be demonstrated in exhibition External Photo. 2. The requirement of buffered inputs: Buffered data inputs stage has been integrated in chip SD3402. 3. The requirements of section 15.203 and 15.204(C): The requirements of antenna connector and spurious emission have been fulfilled. Please reference the exhibition Test Report. 4. The requirement of stand-alone test configuration: Please reference exhibition Test Configuration Photo for the stand-alone test configuration. 5. The requirement of labeling: The instruction on the labeling rule of the end product has been stated in the users manual of this module. Please also see the exhibition Label Sample. 6. The requirement of compliance on specific rule or operating requirements: The required FCC rule has been fulfilled and all the instructions for maintaining compliance has been clearly stated in the Users Manual. 7. The requirement of RF exposure: RF exposure requirement can be fulfilled only for mobile configuration. 8. or The requirement of RF exposure: Please refer exhibition RF Exposure for the compliance of MPE RF exposure rule. 9. or The requirement of RF exposure: N/A as exempted due to low output power Below items have not been fulfilled in module approval request: 1. The requirement of power supply regulation: No power regulator can provide stability power source. But specific of hosts have 3.3Vdc regulator to provide stability power via mini-PCI interface to EUT. Please do not hesitate to contact me for any questions of this request letter. Thank you. Company name : Sporton International Inc. Company Address : No.8, Lane 724, Bo-ai St., Jhubei City, Hsinchu County 302, Taiwan, R.O.C. Signature : Name : Leo Huang Job Title : Manager

SPORTON International Inc. PAGE NUMBER : A1 OF A1 TEL : 886-2-2696-2468 ISSUED DATE : May 14, 2010 FAX : 886-2-2696-2255 APPENDIX A. Photographs of EUT

SPORTON International Inc. PAGE NUMBER : A1 OF A2 TEL : 886-2-2696-2468 ISSUED DATE : May 14, 2010 FAX : 886-2-2696-2255 APPENDIX A. Photographs of EUT SPORTON International Inc. PAGE NUMBER : A2 OF A2 TEL : 886-2-2696-2468 ISSUED DATE : May 14, 2010 FAX : 886-2-2696-2255

SPORTON International Inc. No. 52, Hwa Ya 1st Rd., Kwei-Shan Hsiang, TaoYuan Hsien, Taiwan, R.O.C. Ph: 886-3-327-3456 / FAX: 886-3-327-0973 / www.sporton.com.tw Report Format Version: 01 FCC RADIO TEST REPORT Applicant’s company Wistron NeWeb Corporation Applicant Address 20 Park Avenue II, Hsinchu Science Park, Hsinchu 308,Taiwan,R.O.C. FCC ID NKR-SWZ1 Manufacturer’s company Wistron NeWeb Corporation Manufacturer Address 20 Park Avenue II, Hsinchu Science Park, Hsinchu 308,Taiwan,R.O.C. Product Name ZWave Remote Control Module Brand Name WNC Model Name SWZ1 Test Rule Part(s) 47 CFR FCC Part 15 Subpart C § 15.249 Test Freq. Range 908.40~916.00 MHz Received Date May 05, 2010 Final Test Date May 13, 2010 Submission Type Original Equipment Statement The test result in this report refers exclusively to the presented test model / sample. Without written approval of SPORTON International Inc., the test report shall not be reproduced except in full. The measurements and test results shown in this test report were made in accordance with the procedures and found in compliance with the limit given in ANSI C63.4-2003 and 47 CFR FCC Part 15 Subpart C. The test equipment used to perform the test is calibrated and traceable to NML/ROC. Report No.: FR050531 Report Format Version: 01 Page No. : i of ii FCC ID: NKR-SWZ1 Issued Date : May 19, 2010 Table of Contents 1. CERTIFICATE OF COMPLIANCE ......................................................................................................................... 1 2. SUMMARY OF THE TEST RESULT .......................................................................................................................... 2 3. GENERAL INFORMATION .................................................................................................................................. 3 3.1. Product Details....................................................................................................................................................................................3 3.2. Accessories .........................................................................................................................................................................................3 3.3. Table for Carrier Frequencies .............................................................................................................................................................3 3.4. Table for Test Modes ...........................................................................................................................................................................3 3.5. Table for Testing Locations..................................................................................................................................................................4 3.6. Table for Supporting Units ...................................................................................................................................................................4 3.7. Test Configurations .............................................................................................................................................................................5 4. TEST RESULT ..................................................................................................................................................... 7 4.1. AC Power Line Conducted Emissions Measurement...........................................................................................................................7 4.2. Field Strength of Fundamental Emissions Measurement ...................................................................................................................11 4.3. 20dB Spectrum Bandwidth Measurement ........................................................................................................................................16 4.4. Radiated Emissions Measurement ....................................................................................................................................................19 4.5. Band Edge Emissions Measurement .................................................................................................................................................28 4.6. Antenna Requirements .....................................................................................................................................................................31 5. LIST OF MEASURING EQUIPMENTS ................................................................................................................... 32 6. TEST LOCATION.............................................................................................................................................. 34 7. TAF CERTIFICATE OF ACCREDITATION ............................................................................................................. 35 APPENDIX A. PHOTOGRAPHS OF EUT.......................................................................................................... A1 ~ A3 APPENDIX B. TEST PHOTOS.......................................................................................................................... B1 ~ B6 Report No.: FR050531 Report Format Version: 01 Page No. : ii of ii FCC ID: NKR-SWZ1 Issued Date : May 19, 2010 History of This Test Report Original Issue Date: May 19, 2010 Report No.: FR050531 ■ No additional attachment. □ Additional attachment were issued as following record: Attachment No. Issue Date Description 15.205(a) 15.209(a) 47 CFR FCC Part 15 Subpart C Further, this requirement does not apply to intentional radiators that must be professionally installed. Report No.: FR050531 Report Format Version: 01 Page No. : 2 of 35 FCC ID: NKR-SWZ1 Issued Date : May 19, 2010 2. SUMMARY OF THE TEST RESULT Applied Standard: 47 CFR FCC Part 15 Subpart C Part Rule Section Description of Test Result Under Limit 4.1 15.207 AC Power Line Conducted…

Text truncated - open the document above for the full version.

Report No.: FR050531 FCC ID: NKR-SWZ1 Page No. : 1 of 6 Appendix B. Test Photos Report No.: FR050531 FCC ID: NKR-SWZ1 Page No. : 2 of 6 1. Photographs of Conducted Emissions Test Configuration FRONT VIEW REAR VIEW Report No.: FR050531 FCC ID: NKR-SWZ1 Page No. : 3 of 6 2. Photographs of Radiated Emissions Test Configuration Test Configuration: 9kHz ~30MHz FRONT VIEW REAR VIEW Report No.: FR050531 FCC ID: NKR-SWZ1 Page No. : 4 of 6 30MHz~1GHz FRONT VIEW REAR VIEW Report No.: FR050531 FCC ID: NKR-SWZ1 Page No. : 5 of 6 SIDE VIEW Report No.: FR050531 FCC ID: NKR-SWZ1 Page No. : 6 of 6 Above 1GHz FRONT VIEW REAR VIEW