O8Z69112201Go kart lap timing transmitter

Manual timing & identification system using EP-30 & BP-60 1 MANUAL TIMING & IDENTIFICATION DECODER WITH THE THE EP-30 OR BP-60 TIMING TRANSPONDER PRELIMANARY MANUAL VERSION : 0.0 Notice: The information in this document is subject to change in order to improve reliability, design, or function without prior notice and does not represent a commitment on the part of this company. In no event will we be liable for direct, indirect, special, incidental, or consequential damages arising out of the use or the possibility of such damages. This device complies with part 15 of the FCC Rules. Operation is subject to the following two conditions: (1) This device may not cause harmful interference, and (2) this device must accept any interference received, including interference that may cause undesired operation. To assure continued compliance,any changes or modifications not expressly approved by the party responsible for compliance could void the user's authority to operate this equipment. DE HAARDT Electronic Engineering BV Pascalweg 24 6662 NX Elst (GLD) The Netherlands Tel : +31 481 351315 Fax:+31 481 351356 E-mail : [email protected] This publication has been written with great care. However, the manufacture cannot be held responsible, either for any errors occurring in this publication or for the consequences. Manual timing & identification system using EP-30 & BP-60 2 Table of contents 1 INTRODUCTION...............................................................................................................................................3 1.1 S YSTEM CONFIGURATION................................................................................................................................3 2 INSTALLATION................................................................................................................................................4 2.1 D ETECTION ANTENNA MOUNTING...................................................................................................................4 2.2 M OUNTING OF DETECTION ANTENNA IN THE CIRCUIT.....................................................................................4 2.3 T IMING AND IDENTIFICATION DECODER..........................................................................................................5 2.4 B ACKSIDE CONNECTION DESCRIPTIONS..........................................................................................................5 2.5 O PERATING THE TIMING AND IDENTIFICATION DECODER................................................................................5 2.6 T RANSPONDER MOUNTING ON GO-KARTS.......................................................................................................6 2.7 F IXING OF THE TIMING TRANSPONDER ON THE GO-KART................................................................................7 2.8 P OWER CONNECTION OF TIMING TRANSPONDER............................................................................................7 2.9 T HE BACK-UP PRINTER....................................................................................................................................7 3 CONNECTOR CONFIGURATIONS...............................................................................................................9 3.1 S ERIAL PORT :.................................................................................................................................................9 3.2 O PTION PORT...................................................................................................................................................9 3.3 B ACKUP PRINTER:...........................................................................................................................................9 4 DECLARATION OF CONFORMITY FOR EUROPEAN UNION............................................................11 Manual timing & identification system using EP-30 & BP-60 3 1 Introduction The timing and identification decoder is specially developed for precise and reliable lap & section timing for go-karts. An detection antenna mounted in the circuit on the start/finish line , reads the numbers of the transponders above the antenna, and forwards it through a coax cable to the timing and identification decoder. In the timing and identification decoder the passing transponder numbers are linked to the pass time, and transmitted by the RS-232 in a special record format to the time management computer. 1.1 System configuration The total system consists of the next parts : 1. Detection antenna in the circuit 2. Connection box 3. Coax cable 4. Timing and identification decoder 5. Serial cable 6. Adapter 7. Printer cable 8. Timing transponder Manual timing & identification system using EP-30 & BP-60 4 9. Printer 10. PC 2 Installation 2.1 Detection antenna mounting Every time when a go-kart is right above the detection antenna, the detection antenna picks up the signal of the passing transponder. This signal is fed into the coax cable, which connects the detection antenna to the timing and identification decoder. 2.2 Mounting of detection antenna in the circuit The detection antenna is placed inside a groove in the surface of the track and positioned in such a way that the timing transponder is in the middle above the detection antenna when the front of the go-kart is above the finish line. For the mounting of the detection antenna, it is necessary to make 2 grooves, 65cm / 2 ft apart, over the full width of the track ( maximum 10m / 33 ft ). The cutting depth of the groove must be 15mm - 5/8” and 3mm – 1/8” width. The detection antenna is placed in the rectangle shaped groove and filled with silicon. Be sure that the sharp groove corners do not cut the detection antenna wire. Manual timing & identification system using EP-30 & BP-60 5 The wire ends of the detection antenna are connected to the connection box. Because the detection antenna is sensitive to interference, which can …

Text truncated - open the document above for the full version.

Nederlands Meetinstituut P.O. Box 15 9822 ZG Niekerk (NL) Smidshornerweg 18 9822 TL Niekerk (NL) Telephone: +31 594 505005 Telefax: +31 594 504804 Email: [email protected] Web: http://www.nmicertin.com NMi B.V. (Chamber of Commerce Nr. 27228701) Offices: Delft, Bergum, Dordrecht, Niekerk, Utrecht, Kawasaki (Japan) Salesoffice USA: East Haddam CT Subsidiary companies: NMi Certin B.V. (Nr. 27233418) NMi Van Swinden Laboratorium B.V. (Nr. 27228703) Date Curtis-Straus LLC, Dept. of TCB September 19, 2000 Attn: Certification manager Your reference 527 Great Road - Littleton, MA 01460 Our reference USA 2K0660la8 Subject Request for confidentiality Dear Sir/Madam, Herewith we request that below listed exhibits related to this application for FCC ID: O8Z69112201 to be kept confidential and that the contents of these exhibits will not be disclosed to other parties than De Haardt Electronic Engineering B.V. and NMi Certin B.V. The following items are required to be kept confidential: -circuit diagram -technical description -parts list -block diagram The reason for this request for confidentiality is that the information contained in the exhibits as listed above has been classified as company confidential. Disclosure of any portion of this information to other parties would cause substantial competitive harm. Yours sincerely, NMi Certin B.V. Derick Sariredjo BSc.EE. Project Manager Telecom Type Approvals NMi Certin BV, Dept. EMC and telecom P.O.Box 15, 9822ZG Niekerk, The Netherlands tel: +31 594 50 5005, fax: +31 594 50 4804 Email: [email protected] Website: http://www.nmicertin.nl/

Testing and certification of, consultancy and research concerning, electronic and electric appliances, systems, installations and telecommunication systems Nederlands Meetinstituut P.O. Box 15 9822 ZG Niekerk (NL) Smidshornerweg 18 9822 TL Niekerk (NL) Telephone: +31 594 505005 Telefax: +31 594 504804 E-mail: [email protected] NMi B.V. (Chamber of Commerce Haaglanden No. 27228701) Offices: Delft, Bergum, Dordrecht, Niekerk, Utrecht, Tinton Falls NJ (USA), Kawasaki (Japan), Hortolândia SP (Brazil) Subsidiary companies: NMi Certin B.V. (27233418) NMi Van Swinden Laboratorium B.V. (27228703) NMi International B.V. (27239176) Registration number: 10121784P01Page 1 of 10 PHOTOGRAPHS OF A LOW POWER 7.732 MHz RF LAP TIMING TRANSPONDER, BRAND DE HAARDT, MODEL NUMBERS EP-30 AND BP-60. Accredited by Competent body Notified body Designated laboratory Notified test service FCC listed VCCI listed Certification body : : : : : : : : STERLAB accreditation number L029 D.A.R., TTI-P-G.127/96-00 Article 10-2 EMC Directive Article 10-5 EMC Directive Low Voltage Directive Number 0122 TTE Directive TTE Directive Automotive Directive 31040/SIT R 592 and C 507 Electrical Products Safety Regulation Hong Kong FCC ID: Description of EUT: Manufacturer: Brand mark: Model numbers: O8Z69112201 7.732 MHz RF Transponder De Haardt Electronic Engineering B.V. De Haardt EP-30 and BP-60 Registration number: 10121784P01Page 2 of 10 Table of contents 1Photographs of the test item ............................................................................................................ 3 1.1Over view of model number EP-30.............................................................................................................3 1.2Over view of model number BP-60.............................................................................................................4 1.3 Rear exterior over view ................................................................................................................................5 1.4Internal over view........................................................................................................................................6 1.5Front view of PCB ........................................................................................................................................7 1.6Rear view of PCB..........................................................................................................................................8 1.7View of label of model EP-30......................................................................................................................9 1.8View of label of model BP-60 ...................................................................................................................10 FCC ID: Description of EUT: Manufacturer: Brand mark: Model numbers: O8Z69112201 7.732 MHz RF Transponder De Haardt Electronic Engineering B.V. De Haardt EP-30 and BP-60 Registration number: 10121784P01Page 3 of 10 1 Photographs of the test item 1.1 Over view of model number EP-30 FCC ID: Description of EUT: Manufacturer: Brand mark: Model numbers: O8Z69112201 7.732 MHz RF Transponder De Haardt Electronic Engineering B.V. De Haardt EP-30 and BP-60 Registration number: 10121784P01Page 4 of 10 1.2 Over view of model number BP-60 FCC ID: Description of EUT: Manufacturer: Brand mark: Model numbers: O8Z69112201 7.732 MHz RF Transponder De Haardt Electronic Engineering B.V. De Haardt EP-30 and BP-60 Registration number: 10121784P01Page 5 of 10 1.3 Rear exterior over view FCC ID: Description of EUT: Manufacturer: Brand mark: Model numbers: O8Z69112201 7.732 MHz RF Transponder De Haardt Electronic Engineering B.V. De Haardt EP-30 and BP-60 Registration number: 10121784P01Page 6 of 10 1.4 Internal over view FCC ID: Description of EUT: Manufacturer: Brand mark: Model numbers: O8Z69112201 7.732 MHz RF Transponder De Haardt Electronic Engineering B.V. De Haardt EP-30 and BP-60 Registration number: 10121784P01Page 7 of 10 1.5 Front view of PCB FCC ID: Description of EUT: Manufacturer: Brand mark: Model numbers: O8Z69112201 7.732 MHz RF Transponder De Haardt Electronic Engineering B.V. De Haardt EP-30 and BP-60 Registration number: 10121784P01Page 8 of 10 1.6 Rear view of PCB FCC ID: Description of EUT: Manufacturer: Brand mark: Model numbers: O8Z69112201 7.732 MHz RF Transponder De Haardt Electronic Engineering B.V. De Haardt EP-30 and BP-60 Registration number: 10121784P01Page 9 of 10 1.7 View of label of model EP-30 FCC ID: Description of EUT: Manufacturer: Brand mark: Model numbers: O8Z69112201 7.732 MHz RF Transponder De Haardt Electronic Engineering B.V. De Haardt EP-30 and BP-60 Registration number: 10121784P01Page 10 of 10 1.8 View of label of model BP-60

Label fixing and position for timing transponder EP-30 & BP-60 The label is (screen) printed on a plastic material, which is permanently fixed on the topside of the timing transponder.

Testing and certification of, consultancy and research concerning, electronic and electric appliances, systems, installations and telecommunication systems Nederlands Meetinstituut P.O. Box 15 9822 ZG Niekerk (NL) Smidshornerweg 18 9822 TL Niekerk (NL) Telephone: +31 594 505005 Telefax: +31 594 504804 E-mail: [email protected] NMi B.V. (Chamber of Commerce Haaglanden No. 27228701) Offices: Delft, Bergum, Dordrecht, Niekerk, Utrecht, Tinton Falls NJ (USA), Kawasaki (Japan), Hortolândia SP (Brazil) Subsidiary companies: NMi Certin B.V. (27233418) NMi Van Swinden Laboratorium B.V. (27228703) NMi International B.V. (27239176) Registration number: 10121784P01Page 1 of 10 PHOTOGRAPHS OF A LOW POWER 7.732 MHz RF LAP TIMING TRANSPONDER, BRAND DE HAARDT, MODEL NUMBERS EP-30 AND BP-60. Accredited by Competent body Notified body Designated laboratory Notified test service FCC listed VCCI listed Certification body : : : : : : : : STERLAB accreditation number L029 D.A.R., TTI-P-G.127/96-00 Article 10-2 EMC Directive Article 10-5 EMC Directive Low Voltage Directive Number 0122 TTE Directive TTE Directive Automotive Directive 31040/SIT R 592 and C 507 Electrical Products Safety Regulation Hong Kong FCC ID: Description of EUT: Manufacturer: Brand mark: Model numbers: O8Z69112201 7.732 MHz RF Transponder De Haardt Electronic Engineering B.V. De Haardt EP-30 and BP-60 Registration number: 10121784P01Page 2 of 10 Table of contents 1Photographs of the test item ............................................................................................................ 3 1.1Over view of model number EP-30.............................................................................................................3 1.2Over view of model number BP-60.............................................................................................................4 1.3 Rear exterior over view ................................................................................................................................5 1.4Internal over view........................................................................................................................................6 1.5Front view of PCB ........................................................................................................................................7 1.6Rear view of PCB..........................................................................................................................................8 1.7View of label of model EP-30......................................................................................................................9 1.8View of label of model BP-60 ...................................................................................................................10 FCC ID: Description of EUT: Manufacturer: Brand mark: Model numbers: O8Z69112201 7.732 MHz RF Transponder De Haardt Electronic Engineering B.V. De Haardt EP-30 and BP-60 Registration number: 10121784P01Page 3 of 10 1 Photographs of the test item 1.1 Over view of model number EP-30 FCC ID: Description of EUT: Manufacturer: Brand mark: Model numbers: O8Z69112201 7.732 MHz RF Transponder De Haardt Electronic Engineering B.V. De Haardt EP-30 and BP-60 Registration number: 10121784P01Page 4 of 10 1.2 Over view of model number BP-60 FCC ID: Description of EUT: Manufacturer: Brand mark: Model numbers: O8Z69112201 7.732 MHz RF Transponder De Haardt Electronic Engineering B.V. De Haardt EP-30 and BP-60 Registration number: 10121784P01Page 5 of 10 1.3 Rear exterior over view FCC ID: Description of EUT: Manufacturer: Brand mark: Model numbers: O8Z69112201 7.732 MHz RF Transponder De Haardt Electronic Engineering B.V. De Haardt EP-30 and BP-60 Registration number: 10121784P01Page 6 of 10 1.4 Internal over view FCC ID: Description of EUT: Manufacturer: Brand mark: Model numbers: O8Z69112201 7.732 MHz RF Transponder De Haardt Electronic Engineering B.V. De Haardt EP-30 and BP-60 Registration number: 10121784P01Page 7 of 10 1.5 Front view of PCB FCC ID: Description of EUT: Manufacturer: Brand mark: Model numbers: O8Z69112201 7.732 MHz RF Transponder De Haardt Electronic Engineering B.V. De Haardt EP-30 and BP-60 Registration number: 10121784P01Page 8 of 10 1.6 Rear view of PCB FCC ID: Description of EUT: Manufacturer: Brand mark: Model numbers: O8Z69112201 7.732 MHz RF Transponder De Haardt Electronic Engineering B.V. De Haardt EP-30 and BP-60 Registration number: 10121784P01Page 9 of 10 1.7 View of label of model EP-30 FCC ID: Description of EUT: Manufacturer: Brand mark: Model numbers: O8Z69112201 7.732 MHz RF Transponder De Haardt Electronic Engineering B.V. De Haardt EP-30 and BP-60 Registration number: 10121784P01Page 10 of 10 1.8 View of label of model BP-60

Testing and certification of, consultancy and research concerning, electronic and electric appliances, systems, installations and telecommunication systems Nederlands Meetinstituut P.O. Box 15 9822 ZG Niekerk (NL) Smidshornerweg 18 9822 TL Niekerk (NL) Telephone: +31 594 505005 Telefax: +31 594 504804 E-mail: [email protected] NMi B.V. (Chamber of Commerce Haaglanden No. 27228701) Offices: Delft, Bergum, Dordrecht, Niekerk, Utrecht, Tinton Falls NJ (USA), Kawasaki (Japan), Hortolândia SP (Brazil) Subsidiary companies: NMi Certin B.V. (27233418) NMi Van Swinden Laboratorium B.V. (27228703) NMi International B.V. (27239176) Registration number: 10121772.R02Page 1 of 17 EMISSION MEASUREMENTS IN ACCORDANCE WITH FCC PART 15 AND ANSI C63.4-1992 OF A LAPTIMING TRANSPONDER, BRAND DE HAARDT, MODELNUMBERS EP-30 AND BP-60. FCC ID: O8Z69112201 Accredited by Competent body Notified body nr. 0122 Certification body Designated laboratory Notified test service FCC listed VCCI registered : : : : : : : : STERLAB accreditation number L029 D.A.R., TTI-P-G.127/96-00 Article 10-2 EMC Directive Article 10-5 EMC Directive Low Voltage Directive TTE Directive Electrical Products Safety regulation, Hong Kong TTE Directive Automotive Directive 31040/SIT R-592 C-607 FCC report layout endorsed by the FCC by Public Notice of March 11, 1992. Description of EUT: Manufacturer: Brand mark: Type: FCC ID: RF Transponder De Haardt Electronic Engineering B.V. De Haardt EP-30 and BP-60 O8Z69112201 Registration number: 10121772.R02Page 2 of 17 MEASUREMENT/TECHNICAL REPORT De Haardt Electronic Engineering B.V. FCC ID: O8Z69112201 Date: September 20, 2000 This report concerns: Verification / Notification / Certification Equipment type: Intentional radiator Deferred grant requested per 47 CFR 0.457(d)(1)(ii) No If yes defer until: not applicable Transition Rules Request per 15.37: No Report prepared by:Name:D.S. Sariredjo, B.Sc.E.E. Company name:NMi Certin B.V. Address:Smidshornerweg 18 Telephone number:+ 31 594 505005 Telefax number:+ 31 594 504804 Mailing address:P.O. Box 15 City/Place/Postal cd.:9822 ZG NIEKERK Country:The Netherlands Email:[email protected] The data taken for this test and report herein was done in accordance with FCC Part 15 and ANSI C63.4-1992 measurements. NMi Certin B.V.. location Niekerk, The Netherlands, certifies that the data is accurate and contains a true representation of the emission-profile of the Equipment Under Test (EUT) on the date of the test noted in the test report. I have reviewed the test report and find it to be an accurate description of the test(s) performed and the EUT so tested. Date: September 20, 2000Signature: J.S. Sikkema, B.Sc.E.E. Department EMC and Telecommunication Description of EUT: Manufacturer: Brand mark: Type: FCC ID: RF Transponder De Haardt Electronic Engineering B.V. De Haardt EP-30 and BP-60 O8Z69112201 Registration number: 10121772.R02Page 3 of 17 Table of contents 1General Information. ..........................................................................................................................................4 1.1Product description. ....................................................................................................................................4 1.2Related Submittal(s)/grant(s). .....................................................................................................................4 1.3Test Methodology. ......................................................................................................................................4 1.4Test facility. ..................................................................................................................................................4 1.5List of measurement equipment.................................................................................................................4 1.6Bandwidth and antenna factors. ................................................................................................................5 2Product labelling.................................................................................................................................................5 3System test configuration. .................................................................................................................................6 3.1Justification. .................................................................................................................................................6 3.2Equipment modifications. ...........................................................................................................................6 3.3Description of tested EUT............................................................................................................................7 3.3.1Transponder EP-30 and EP-60 ..............................................................................................................7 4Radiated measurement photos..........................................................................................................................8 5Radiated emission data. ...................................................................................................................................11 5.1Radiated field strength measurement (30 MHz - 1000 MHz, E-field).....................................................11 5.1.1EP-30 / BP-60 .......................................................................................................................................11 5.2Radiated field strength measurement (9 kHz - 30 MHz, H-field). ..........................................................12 5.2.1Radiated field strength x-orientation ...............................................................................................12 5.2.2Radiated field strength y-orientation ...............................................................................................13 5.2.3Radiated field strength z-orient…

Text truncated - open the document above for the full version.

Subject: Re: request for certification FCC ID: O8Z69112201 Date: Tue, 3 Oct 2000 10:51:15 +0100 From: [email protected] To: Certification Manager <[email protected]> Hello Jon, Thanks for your quick response indeed. Please find our response below in CAPS. Thanks and looking forward to your response, Derick Certification Manager <[email protected]> on 10/02/2000 11:07:55 PM To: Derick Sariredjo/Nmi cc: Subject: Re: request for certification FCC ID: O8Z69112201 Hi Derick, This application was a good one! Thank you for your business. Only a couple of issues to address. 1. The unit is powered by 8-12V alternator supplied power. I need data to support a claim of conformance to the requirements of 15.31 (e) which requires that the fundamental be measured under conditions of 85% and 115% of rated power. Or a statement that a fully charged battery was used for testing. RESPONSE: A FULLY CHARGED BATTERY WAS USED FOR TESTING. 2. I need an agency letter from DeHaart authorizing you to sign the 731 form on their behalf. RESPONSE: WE INDEED FORGOT TO UPLOAD THIS LETTER YESTERDAY. PLEASE FIND IT ATTACHED. (See attached file: nmi authorization letter de haardt.pdf) Sincerely, Jon Curtis. [email protected] wrote: > Dear mr. Jon Curtis, > Please find attached part 1 of 2 of the zipped pdf exhibits in support of > certification of the low power lap timing transponder transmitter with brand de > Haardt, model numbers EP-30 and BP-60, FCC ID O8Z69112201. > > (See attached file: O8Z69112201_FCCreport.zip)(See attached file: > O8Z69112201_Coverletters.zip) > Thanks, best regards and looking forward to your response., > > Derick Sariredjo > NMi Niekerk NL > > ------------------------------------------------------------------------ > Name: O8Z69112201_FCCreport.zip > O8Z69112201_FCCreport.zip Type: Netzip File (application/zip) > Encoding: base64 > Description: .ZIP File > > Name: O8Z69112201_Coverletters.zip > O8Z69112201_Coverletters.zip Type: Netzip File (application/zip) > Encoding: base64 > Description: .ZIP File -- Jon D. Curtis Certification Manager Curtis-Straus LLC Telecom Certification Body 527 Great Road Littleton, MA 01460 USA t:978-486-8880 f:978-486-8828