PJ5MTX9-S3Leisure Marine Radar

Raymarine Limited. Registered in England. Company No. 1177969 Registered Office: Anchorage Park, Portsmouth PO3 5TD Raymarine Limited Pathfinder Radar scanners FCC ID: PJ5MTX9-S3 Owner's Handbook Note 1: This Draft Owner's Handbook also covers the 2kW Radome Scanner (PJ5MTX2-S3), the 4kW Radome Scanner (PJ5MTX4-S3), the 4kW Open Array Scanner (PJ5MTX5-S3). Note 2:The information within the handbook is complete and up-to-date, except that the EC Declarations of Conformity will be replaced with new versions after of the current CE application. Pathfinder Radar Scanners Owner’s Handbook Document number: 81154_6 Date: 11th March2002 Pathfinder Radar Scannersi Pathfinder Radar Scanners Owners Handbook January 2002 Intended Use The scanner units detailed in this handbook form part of naviga- tional radar systems intended for light marine use. These radar systems are only an aid to navigation. WARNING: The 4D radome scanner connected to an SL70, SL70 PLUS or SL70RC PLUS 7" LCD display unit DOES NOT conform to the EU directive 95/5/EC, therefore such a system cannot be installed on a vessel within the EU . Safety Notices This radar equipment must be installed and operated in accord- ance with the instructions contained in this manual. Failure to do so can result in personal injury and/or navigational inaccuracies. In particular: 1. High Voltage. The scanner unit contains high voltages. Adjust- ments require specialised service procedures and tools only avail- able to qualified service technicians – there are no user serviceable parts or adjustments. The operator should never remove the scanner unit internal covers or attempt to service the equipment. 2. Electromagnetic Energy. The radar scanner transmits electro- magnetic energy. It is important that the radar is turned off when- ever personnel are required to come close to the scanner to perform work on the scanner assembly or associated equipment. It is recommended that the radar scanner is mounted out of range of personnel (above head height). Do not look directly at the antenna at close range as your eyes are the most sensitive part of the body to electromagnetic energy. When properly installed and operated, the use of this radar will conform to the requirements of ANSI/IEEE C95.1-1992 Standard for Safety Levels with Respect to Human Exposure to Radio Fre- quency Electromagnetic Fields, 3 Hz to 300 GHz and NRPB, iiPathfinder Radar Scanners Board Statement on Restrictions on Human Exposure to Static and Time Varying Electromagnetic Fields and Radiation, Doc NRPB, No. 5 (1993). 3. Navigation Aid. This radar unit is only an aid to navigation. Its accuracy can be affected by many factors, including equipment failure or defects, environmental conditions, and improper han- dling or use. It is the user’s responsibility to exercise common prudence and navigational judgements. This radar unit should not be relied upon as a substitute for such prudence and judgement. Raymarine products are supported by a network of Authorized Service Representatives. For information on Raymarine products and services, contact either of the following: United StatesRaymarine Inc. Recreational Products 22 Cotton Road, Unit D Nashua NH 03063-4219, USA Telephone +1 603 881 5200 Fax +1 603 864 4756 www.raymarine.com EuropeRaymarine Limited Anchorage Park Portsmouth Hampshire PO3 5TD England Telephone +44 (0)23 9269 3611 Fax +44 (0)23 9269 4642 www.raymarine.com Copyright © Raymarine Ltd. 2002 The technical and graphical information contained in this hand- book, to the best of our knowledge, was correct as it went to press. However, the Raymarine policy of continuous improvement and updating may change product specifications without prior notice. As a result, unavoidable differences between the product and handbook may occur from time to time, for which liability cannot be accepted by Raymarine. SeaTalk is a registered trademark of Raymarine Limited. HSB and hsb 2 are trademarks of Raymarine Limited. Pathfinder is a trademark of Raymarine Limited. Pathfinder Radar Scannersiii Preface This handbook describes the following Raymarine Pathfinder radar scanners: 2D 18" 2 kW Radome Scanner 4D 24" 4 kW Radome Scanner 5S48" 4 kW Open Array Scanner 7S72" 4 kW Open Array Scanner 9S48" 10 kW Open Array Scanner 11S 72" 10 kW Open Array Scanner These scanner units may be connected to any HSB/hsb 2 display unit. In addition, the 2D radome scanner unit may be connected to an SL70, SL70 PLUS or SL70RC PLUS 7" LCD display. CAUTION: The open array scanners must not be used with the SL70, SL70 PLUS, SL70RC PLUS or Autohelm 7" LCD Display Unit. This may result in damage to the display due to the high power requirements of the open array scanner. The handbook contains very important information on the instal- lation and operation of your new equipment. In order to obtain the best results in operation and performance, please read this hand- book thoroughly. Raymarine’s Technical Support representatives or your local dealer will be available to answer any questions you may have. Display Software Version For full operation of the Pathfinder scanners, the display unit requires an appropriate software version. For new displays, the correct software version is normally already installed in the dis- play unit and is fully compatible with the Pathfinder scanners. Early display units may not have the correct software and will therefore require upgrading. The software version can be confirmed by switching-on the dis- play and checking the version number during the magnetron warm-up sequence. ivPathfinder Radar Scanners Note: If a scanner unit is not connected the version number is only displayed for 10 seconds. Where, necessary Software Upgrade Kits are available from your dealer, distributor or from Raymarine. We recommend that where a repeater display is fitted, both the repeater and the master display are upgraded. Warranty To register your Pathfinder Radar Scanner ownership, please take a few minutes …

Text truncated - open the document above for the full version.

Raymarine Limited. Registered in England. Company no. 1177969 Registered Office: Anchorage Park, Portsmouth PO3 5TD Raymarine Limited Anchorage Park Portsmouth Hampshire PO3 5TD England 023 9269 3611 023 9269 4642 (Fax) Raymarine Inc. 22 Cotton Road, Suite 280 Nashua NH 03063 4219 U.S.A. 603 881-5200 800-539-5539 (Fax) www.raymarine.com BABT Claremont House 34 Molesey Road Hersham, Walton-on-Thames Surrey KT12 4RQ 18 th February, 2003 Gentlemen, FCC ID: PJ5MTX9-S3 The Commission has already given a grant of type acceptance for the Raymarine 'Pathfinder' 10kW Open Array Radar Scanner Unit (FCC ID: PJ5MTX9), when used with either a 48" or 72" antenna and in combination with a range of specified Display Units. This application for authorization of a new grant has resulted from proposed changes to enhance performance, which affect the characteristics originally reported to the commission. The new Scanner Unit can be connected to either antenna and any of the same Display Units that are currently in use, to form light marine radar systems (see Annex 1 below). The primary changes are to the magnetron (transmitting device) and to the associated circulator, which now incorporates an isolator and low pass filter (LPF). The purpose of these changes is to improve the Spurious Emissions and Out of Band Emissions of the transmitter in accordance with the requirements of ITU-R M1177. The peak-radiated power remains the same at 10 kW, as do the Pulse Repetition Frequencies (PRF). Of the 8 available Pulse Widths, the two shortest have been increased in width. Removal of the unwanted emissions has been mainly achieved by filtering. The new 10kW Scanner Unit has been fully tested to the appropriate parts of CFR 47 Part 2 and Part 80. The measurement data taken demonstrates that the scanner continues to be compliant with the Rules and its performance is within the technical ratings specified by Raymarine (manufacturer). The modifications will be introduced to all new scanner units of this type in production after the grant has been authorized. Sincerely, Chris Bird, Approvals Manager, Raymarine Limited. - 2 - Raytheon Marine Limited. Registered in England. Company no. 04578449 Registered Office: Anchorage Park, PO3 5TD ANNEX 1 The following Raymarine Display Units are combined with the Raymarine 9S - 10kW, 48" or 11S - 10kW, 72" Open Array Scanner Unit to form operational light marine radar systems. Display Unit Scanner Unit Radar System SL70M PLUS – 7" mono LCD 9S – 10kW, 48" O/A SL79M PLUS SL70MRC PLUS – 7" mono LCD/Chart 9S SL79MRC PLUS RL70 PLUS – 7" mono LCD/hsb² 9S RL79 PLUS RL70RC PLUS – 7" mono LCD/hsb²/Chart 9S RL79RC PLUS R70 PLUS – 7" CRT/hsb² 9S R79 PLUS R70RC PLUS – 7" CRT/hsb²/Chart 9S R79RC PLUS R80 PLUS – 10" CRT/hsb² 9S R89 PLUS R80RC PLUS – 10" CRT/hsb²/Chart 9S R89RC PLUS SL70C PLUS – 7" Colour LCD 9S SL79C PLUS SL70CRC PLUS – 7" Colour LCD/Chart 9S SL79CRC PLUS RL70C PLUS – 7" Colour LCD/hsb² 9S RL79C PLUS RL70CRC PLUS – 7" Colour LCD/hsb²/Chart 9S RL79CRC PLUS RL80C PLUS – 10" Colour LCD/hsb² 9S RL89C PLUS RL80CRC PLUS – 10" Colour LCD/hsb²/Chart 9S RL89CRC PLUS Display Unit Scanner Unit Radar System SL70M PLUS – 7" mono LCD 11S – 10kW, 72" O/A SL711M PLUS SL70MRC PLUS – 7" mono LCD/Chart 11S SL711MRC PLUS RL70 PLUS – 7" mono LCD/hsb² 11S RL711PLUS RL70RC PLUS – 7" mono LCD/hsb²/Chart 11S RL711C PLUS R70 PLUS – 7" CRT/hsb² 11S R711PLUS R70RC PLUS – 7" CRT/hsb²/Chart 11S R711RC PLUS R80 PLUS – 10" CRT/hsb² 11S R811PLUS R80RC PLUS – 10" CRT/hsb²/Chart 11S R811RC PLUS SL70C PLUS – 7" Colour LCD 11S SL711C PLUS SL70CRC PLUS – 7" Colour LCD/Chart 11S SL711CRC PLUS RL70C PLUS – 7" Colour LCD/hsb² 11S RL711C PLUS RL70CRC PLUS – 7" Colour LCD/hsb²/Chart 11S RL711CRC PLUS RL80C PLUS – 10" Colour LCD/hsb² 11S RL811C PLUS RL80CRC PLUS – 10" Colour LCD/hsb²/Chart 11S RL811CRC PLUS Key: The allocated designation for each unit or system is shown in bold. hsb² (high speed bus) – allows the connection of one or more repeater display unit Chart – Chartplotter feature built-in

Ra ymarine Limit ed. R egistered in England. C ompany No. 04578449 Registered Office: Anchorage Park, Portsmouth PO3 5TD Raymarine Limited10 kW, Open Array Ra dars FCC ID: PJ5 MTX 9-S3 ID Label Drawings

Ra ymarine Limit ed. R egistered in England. C ompany No. 04578449 Registered Office: Anchorage Park, Portsmouth PO3 5TD Raymarine Limited10 kW, Open Array Ra dars FCC ID: PJ5 MTX 9-S3 ID Label Drawings

Raymarine Limited, Anchorage Park, Portsmouth, England Raymarine Limited Raytheon Pathfinder Series Radar Photographs –Internal FCC ID: PJ5MTX9-S3 10kW, Open Array Scanner Unit Raymarine Limited, Anchorage Park, Portsmouth, England 10Kw Open Array Scanner Unit Pedestal open Core Assembly Gear Box Raymarine Limited, Anchorage Park, Portsmouth, England 10Kw Open Array Scanner Unit Pedestal open Core Assembl y Isolator/Isolator/LPF Magnetron Raymarine Limited, Anchorage Park, Portsmouth, England 10Kw Open Array Scanner Unit Gearbox and part of Co-axial tube assembly Raymarine Limited, Anchorage Park, Portsmouth, England 4kW and 10kW Open array Scanner Unit Co-axial tube assembly Raymarine Limited, Anchorage Park, Portsmouth, England 10kW Open Array Scanner Unit Top view of Core Circulator/ Isolator/ LPF Magnetron Low Noise Converter Raymarine Limited, Anchorage Park, Portsmouth, England 10kW Open Array Scanner Unit Under view of core Raymarine Limited, Anchorage Park, Portsmouth, England 10kW Open Array Scanner Unit Underside of Modulator PCB, with screening plate removed Raymarine Limited, Anchorage Park, Portsmouth, England 10kW Open Array Scanner Unit Modulator PCB Raymarine Limited, Anchorage Park, Portsmouth, England 10kW Open Array Scanner Unit Underside of IF PCB, with screening plate removed Raymarine Limited, Anchorage Park, Portsmouth, England 10kW Open Array Scanner Unit IF PCB Raymarine Limited, Anchorage Park, Portsmouth, England ‘Pathfinder’ Scanner Unit Low Noise Converter (LNC) and cover

1 Part 5 Chapter 2 Technical Description Technical Description 4kW and 10kW Open Array Scanner Units 1. Overview Scanner configuration D6144-1 60dBm (maximum) 4kW/10kW CirculatorLPF IF Receiver, micro, I/O board Magnetron Low Noise Converter Scanner uplink connection Motor Antenna/Rotary joint assembly Modulator, PSU board Transition Ships power Waveguide Limiter (10kW only) Isolator Figure 1. Scanner Block Diagram The system comprises the functional blocks as shown in the above diagram. The basis of operation is as follows: The Modulator, PSU board generates a high voltage pulse of between 75ns and 1.05us duration (1.0us maximum for 4kW unit) dependant upon the range setting and the corresponding IF/Video filter control lines. This pulse begins on the rising edge of a negative going trigger at a pulse repetition frequency (PRF) also defined by the range setting. The resulting pulse is output to the magnetron which converts the energy into an RF pulse at a frequency of 9.41GHz (nominal). All supply requirements are also provided by the Modulator, PSU board. The RF pulse is routed to an antenna via a 3-port circulator combined with an isolator and LPF (IFC) , which propagates microwave energy in only one direction and thereby provides isolation between the transmit source and the low noise converter. Note that the circulator for the 10kW system incorporates a waveguide diode limiter to reduce the power entering the receiver. A rotary joint is used to maintain continuity between a waveguide output from the circulator and a coaxial input to the antenna. The energy is then radiated, with a narrow azimuth beam shape (1.85° for the 48" antenna and 1.15° for the 72" antenna), with low sidelobe levels (<-22dB). The elevation beamwidth is maintained at approximately 25° in order to illuminate targets during pitch and roll of the transmitting vessel. Echoes are returned due to reflections from potential targets such as boats, buoys, land etc, and in the form of clutter from sea, rain, etc. The returned energy is collected by the same antenna used to transmit the original pulse and is routed through the IFC to the low noise converter (LNC). These comparatively low level signals are 2 Part 5 Chapter 2 Pathfinder Radar/Chartplotter Series amplified by a low noise transistor in order to maintain signal/noise performance and are mixed down to an IF frequency of 60MHz nominal for further amplification and subsequent detection. The IF receiver board provides further low noise amplification and adjustable gain to maximise the dynamic range (“dynamic attenuation control”) in the presence of clutter, target and range variations. The IF board also includes a logarithmic detection stage with approximately 50dB dynamic range, which provides a compressed signal output in terms of dB input power versus output Voltage level. Various filtering stages are also employed in the IF Receiver to provide optimum signal/noise characteristics for the detected pulse and to provide some immunity against the bulk effects of rain. The IF Receiver also provides the interface for the up-link commands to the scanner, including clutter and gain selection, 3-phase motor control and display synchronisation pulse generation. Receiver configuration (LNC/IF) The basic configuration of the microwave and IF receiver circuitry is as follows : Low Noise Converter (LNC)IF Receiver Board Filter select logic Limiter LNA 90 deg 90 HYB Switched Filter Logarithmic Detector Video Filter Curve Splitter Autotune Receiver LNC Supplies Scanner uplink MBS / STC / Rain / Sea / Gain Generation and Summing Network Lineariser Lineariser D4055-1 Figure 2. Receiver Configuration (LNC/IF) Low Noise Converter/Limiter (LNC) The primary function of the LNC is to provide low noise amplification of the low level signal returns and mixing to an IF frequency of 60MHz nominal. The low noise amplification is provided by a single low noise FET, with bias conditions, and associated matching set to minimise noise figure and maximise gain and compression levels. Maximum gain is required so as to minimise the noise figure contribution from subsequent stages. The mixing function is carried out in an image reject mixer configuration which reduces image noise by 20dB nominal in order to minimise the degradation in overall noise figure. Protection is provided in the form of three limiter diodes which are configured to become forward biased in the presence of increasing RF power. Note that the circulator for the 10kW system also incorporates a waveguide diode limiter. NOTE. There are no user / dealer serviceable parts within the LNC due to its high frequency of operation. 3 Part 5 Chapter 2 Technical Description LNA Limiter 90 degrees Mixer Constant current bias circuitry +5Volts -5Volts Ground μW I/P VCO tune compensation 90 HYB 60MHZIF Tune_V D4056-1 Figure 3. LNC Configuration D4648-2 Modulator/PSU/Motor Magnetron 3-Phase Motor P7 LNC P1 P2P4 Ship's Heading Sensor CN2 CN5 CN7 CN8 CN3 CN6 CN10 CN9 Ships Supply Display Unit Scanner Disable Switch IF Receiver CN2 IF Inter-connect CN3 3-Phase Motor CN5 Ships Header Transducer CN6 Magnetron CN7 IF Display Interface Inter-connect CN8 Display Inter-connect CN9 Scanner Disable Switch CN10 Ships Power CN11 Cooling Fan (10 kW only) JP1 Service Motor enable Jumper Note: CN3, CN5, CN8, CN9, CN10, JP1 are fitted to non-component side to give access to the installer. JP1 CN11 Figure 4. Scanner Interfaces 4 Part 5 Chapter 2 Pathfinder Radar/Chartplotter Series 2. Modulator / PSU – Interface Description The interfaces to the Mod/PSU are shown in Figure 4. and the individual signal functions are described below :- Ship Supply Power Input (CN10) Ref.Signal NameTypeStateFunction CN10-7+V_SHIPPower input–Ships power i/p CN10-8 CN10-1–V_SHIPPower input–Ships power return CN10-2 Modulator Control/Status (CN2) Ref.Signal NameTypeStateFunction CN2-18RADAR_TX_ENLogic input1Enable modulator (magnetron) pulses 0 (default)Disable modulator, regardless…

Text truncated - open the document above for the full version.

Raymarine Limited. Registered in England. Company No. 04578449 Registered Offic e: Anchorage Park, P O3 5TD Raymarine Limited Pathfinder Radar scanners FCC ID: PJ5MTX9-S3 Tune-up Procedures There are no Tune-up Procedures associated with the 10kW Open Array Scanner (PJ5MTX9-S3)

Raymarine Limited. Registered in England. Company no. 04578449 Registered Office: Anchorage Park, PO3 5TD. Raymarine Limited 10kW Open Array Radars FCC ID: PJ5MTX9-S3 Parts Lists Index Mod/PSU PCB 4357-048 LNC 4346-006 IF PCB 4473-012 Part NoDescriptionQtyCct Designator 3039-073-AH/S_Bracket1Brkt1 15096H/S-CLIP1CLIP1 07395WEIDMULLER LU 10.16/901CN1 07335PicoFlex2x101CN2 07371Molex-39-30-10801CN3 07349Molex_KK_1x4_RA1CN5 07307CON21CN6 07370PicoFlex2x51CN7 07369Wago-733-3681CN8 07368Molex_KK_1x3_RA1CN9 07327MOLEX_KK_1X21CN11 07364M60-04-30-114P1CN12 3030-214NF/3030-214/3030-2141CT1 3030-2143030-2141CT2 93041000P1n28C1,C2,C3,C4,C6,C7,C8,C9,C10,C11,C12,C13,C14,C15,C16,C80, C92,C102,C140,C141,C159,C162,C164,C186,C215,C252,C265,C270 930147P47p4C5,C202,C209,C259 9302100P100p15C17,C18,C19,C20,C21,C22,C165,C170,C253,C254,C255, C256,C257,C258,C269 93BDHXXX4N74n77C23,C24,C27,C129,C130,C163,C261C25,C26,C28,C32,C41,C66,C69, 93070U1100n54C70,C71,C72,C73,C74,C76,C77,C81,C82,C83,C96,C101,C104,C105, C106,C107,C108,C116,C117,C118,C124,C135,C137,C145,C158,C160, C177,C178,C191,C192,C193,C195,C206,C217,C218,C219,C226,C227, C235,C237,C238,C239,C241,C242,C243,C246,C251 93FDHBXXX4U74.7u4C34,C35,C40,C268 93EDOBXX100N100n4C36,C37,C38,C39 93040U0110n21C42,C45,C48,C54,C55,C56,C57,C75,C84,C85,C87,C100, C122,C132,C161,C167,C185,C203,C204,C210,C267 93BDHXXX2N22n27C43,C46,C49,C109,C112,C138,C179 03132680u5C44,C47,C50,C133,C172 0315147n5C51,C52,C53,C146,C154 10kW Open Array Scanner Unit Mod/PSU PCB PCB Assy. 4357-048 Page 1 of 6 Part NoDescriptionQtyCct Designator 932410U10u2C60,C182 9324100U100u2C65,C61 9306105X7R1u12C62,C63,C64,C114,C115,C143,C144,C181,C214,C245,C249,C260 031224n71C67 93060U47470n1C79 930433N33n4C88,C134,C175,C176 9301470P470p4C89,C90,C91,C196 03152100n1C94 030832n22C166,C103 031341000u2C110,C123 03135220u5C111,C136,C152,C155,C213 031461uF1C113 03093100n4C120,C121,C169,C188 9300220P220p6C127,C128,C168,C180,C220,C262 93BDHBXX330P330p1C139 93HEFEXX4U74u72C147,C142 93HEHEXX1U1u1C148 030661000u3C149,C150,C151 030901n1C153 0314847p4C156,C157,C171,C183 03155100n1C184 930122P22p1C194 930147P47p1C198 9300220P220p1C199 930122P22p1C200 930122P22p1C201 03031100u1C208 03089100pF2C224,C223 03135220u1C225 031384n71C228 03149100u2C234,C233 031611u51C250 0308047u1C266 9203BZX12VBZX84C12V5D1,D12,D13,D14,D34 9200BAS19BAS199D8,D9,D10,D26,D40,D60,D63,D66,D69 Page 2 of 6 Part NoDescriptionQtyCct Designator 9200UF1A200VMURS120T32D15,D17 920010BQ06010BQ0608D19,D21,D23,D49,D61,D62,D64,D65 9200BAV99BAV992D38,D22 02087UF1804D27,D28,D42,D50 920010BQ06010BQ0602D54,D29 02082BYV27-2001D33 920010BQ06010BQ0601D37 9203BZX84C5V1BZX84C5V11D39 02074BZV85-C181D41 9203BZX6V8BZX84C6V81D43 9200BAV70BAV703D52,D53,D70 02077UX-F5B2D57,D56 020861N54071D58 02078UF54041D59 02092APT15DS60B2D72,D73 15249BL01RN1-A624FB1,FB2,FB3,FB4 1536240mm-Fan1Fan1 15347SW50-22HT1,HT2 3036-172HEATSINK-3036-1721HT3 07350Motor-On(C)1JP1 07350Remote-Switch-On(C)1JP2 9600L1BEAD_L17L2,L3,L5,L9,L10,L13,L14 15185100uH3L6,L7,L8 9400PC357DPC357-D5OP1,OP2,OP3,OP4,OP5 3015-185-D3015-1851PCB 05052STP60N05FI7Q1,Q5,Q9,Q13,Q14,Q15,Q16 9500BC856BC8566Q2,Q6,Q10,Q25,Q51,Q52 9500BC846BC84611Q3,Q7,Q11,Q22,Q29,Q30,Q32,Q39,Q45,Q47,Q49 950039062N39063Q4,Q8,Q12 9500IMX1IMX16Q17,Q27,Q34,Q38,Q40,Q43 9500IMZ1IMZ14Q18,Q19,Q33,Q46 95002N2222A2N2222A3Q20,Q28,Q44 9500BC807BC8073Q23,Q48,Q50 9500IMT1IMT12Q24,Q26 05055IRFP28072Q21,Q31 Page 3 of 6 Part NoDescriptionQtyCct Designator 950039042N39043Q35,Q36,Q37 05064APT6017B2LL1Q41 26008RIV-SCREW9RIV1,RIV2,RIV3,RIV4,RIV5,RIV6,RIV7,RIV8,RIV9 01205PTH9M04BC222TS2F3331RT1 91072KEVM2K1RV1 91064K74k731R25,R37,R38,R39,R44,R45,R53,R54,R55,R61,R62,R63, R74,R77,R80,R83,R86,R89,R110,R127,R130,R142,R164, R196,R225,R235,R244,R254,R358,R361,R0 91060R00R1R1 91063K93K91R5 910615K15K3R7,R214,R255 910310R10R14R8,R9,R95,R97,R99,R116,R119,R147,R228,R245,R247, R352,R356,R368 91031K1K040R10,R15,R16,R17,R18,R42,R58,R106,R117,R124,R148, R149,R150,R151,R152,R153,R171,R194,R205,R207,R215, R216,R217,R218,R229,R238,R239,R240,R243,R259,R262, R276,R277,R285,R297,R308,R343,R344,R347,R351 91DCFXXX1R01R01R11 9106120R120R1R12 91063R33R31R13 910647K47K10R14,R46,R52,R193,R260,R264,R265,R266,R360,R369 9103100R100R19R20,R93,R96,R98,R143,R146,R156,R157,R158,R159, R198,R199,R203,R223,R234,R257,R278,R283,R371 91062K22K212R21,R48,R60,R72,R73,R78,R79,R84,R85,R94,R213,R296 910310K10K44R22,R32,R40,R57,R59,R64,R65,R66,R104,R108,R132,R133,R166, R168,R188,R195,R197,R201,R206,R208,R267,R268,R269,R270, R271,R272,R273,R274,R275,R280,R281,R284,R287,R288,R298, R304,R305,R306,R312,R355,R362,R363,R364,R370 9106220R220R6R23,R29,R49,R50,R51,R160 91035K65K66R24,R27,R43,R162,R311,R349 910327K27k5R26,R56,R67,R68,R294 9106100K100K15R28,R33,R34,R47,R113,R114,R115,R128,R176,R211, R237,R286,R345,R350,R375 9106470R470R7R30,R100,R101,R103,R145,R209,R210 91033K33K37R31,R41,R70,R109,R112,R163,R309 Page 4 of 6 Part NoDescriptionQtyCct Designator 9106220K220K3R35,R372,R373 910333K33K3R36,R261,R291 91061K51K55R71,R226,R248,R258,R263 910647R47R21R75,R76,R81,R82,R87,R88,R129,R135,R136,R137,R138, R139,R140,R154,R155,R167,R186,R212,R293,R317,R318 0123810R3R90,R91,R92 0123120m1R102 910622K22K5R111,R187,R200,R241,R374 91060R00R01R131 910615K15K1R134 910622R22R4R141,R144,R204,R313 910618K18K1R161 9106680R680R2R224,R165 91063R33R31R170 0121133R4R172,R202,R230,R322 91061K81K83R178,R292,R365 910310K10K1R179 910622K22K1R180 91FCGXXXX1K1K1R181 91AAAXXX56K56K1R189 910612K12K1R190 9103270R270R2R191,R192 01234220K1R242 91036K86K81R249 910333K33K1R289 910639K39K1R290 91031K1K1R299 91060R00R01R301 91062K72K71R307 91036K86K82R310,R348 910368K68K1R314 01227470K1R315 91061R01R04R316,R319,R320,R321 0124010R1R323 910310R10R1R330 Page 5 of 6 Part NoDescriptionQtyCct Designator 012351R01R338 012412R21R339 0119110R1R340 01232470K2R341,R342 910612K12K1R346 01242/27R1R357 91060R00R1R359 91031K1K01R367 91FCGXXX0R10R12R377,R378 21117ST-SCREW-4X12MM4SCRW2,SCRW3,SCRW4,SCRW5 15306TO247-SILPAD1SIL1 3030-2103030-2101TX1 3030-2113030-2111TX2 3030-213303…

Text truncated - open the document above for the full version.

Raymarine Limited. Registered in England. Company No. 04578449 Registered Office: Anchorage Park, PO3 5TD Raymarine Limited 10kW Open Array Radar FCC ID: PJ5MTX9-S3 Schematics Index Scanner Interconnect 4357-033 Sht. 1 Modulator/PSU 4357-024 Sht. 1 Modulator/PSU (Top Level) Sht. 2 Power I/P Filter Sht. 3 Ship's Heading Interface Sht. 4 Stepper Motor (not fitted) Sht. 5 3 Phase DC Brushless Motor Drive Sht. 6 Auxiliary PSU Sht. 7 Modulator Sht. 8 Main PSU Low Noise Converter (LNC) 4346-028 Sht. 1 IF Receiver 4437-004 Sht. 1 IF Receiver (Top Level) Sht. 2 IF Strips Sht. 3 IF Log Det/Video Sht. 4 Scanner Micro Sht. 5 Control Interface Sht. 6 STC Generator ANTENNA -- 48" or 72" Open Array ISOLATOR/ FILTER/ CIRCULATOR MAF 1561B (4kW) MAF 1565B (10kW) CScanner compliance1--10--02 N MTR4 normally linked through D6 BAT14-03W SOD323 D12 BAT14-03W SOD323 D13 BAT14-03W SOD323 D7 BAT14-03W SOD323 88 77 66 55 44 33 22 11 D D C C B B A A Multi-Channel D/A Note: SHP_OUT and SHP_OUTBare not connected ISS DESCRIPTION OF CHANGE DATE FIRST ISSUE LNC Connector 8-way Molex Connector MOD/PSU Connector 10-way Picoflex Connector A 24.07.00 B L28 deleted 16.02.01 C R142 value corrected to 1k2 ECN 4473-003/002 19.04.01 D Common-mode chokes TF1-3 added. ESD protection array U20 added. 18.07.01 E BF999 mod (due to change in process of part): R130 now 100R, R113 now 100R, R118 now 470R 24.01.02 F Mask Micro part number updated to 940378054 19.09.02G Resistor R386 added (RL90 shut down mod)- pull down on micro TX_ENAll connectors fitted for generic buildstandard for OA and dome systems 19.11.02 4473-004 G IF Receiver (For Radome Update and Open Array) C 1 6 Tuesday, November 19, 2002 Title Size Document Number Iss. Date: Sheet of THE INFORMATION CONTAINED HEREIN SHALL NOT BE REPRODUCED IN WHOLE OR IN PART WITHOUTTHE PRIOR WRITTEN PERMISSION OF RAYMARINE LTD. C 2001 Raymarine Ltd. Drawn Approved Checked R ON BOARD a ym arine CONTROL INTERFACESTC_GEN1 FTC_levelRF_atten VIDBW RF_ATTENV IFBW TUNEV BWsel0BWsel1TUNE_FTUNE_C FTCV VIDBW2 BWsel2 MICROCONTROLLERMICRO +12V +5VSWITCHED RADAR_TX_ENMOD_ISENSEHEATER_OKMOTOR_EN_NSTEP_IOSHP_INPRI_PLSHEAT_EN_NPW1PW0DACDATDACLDDACCLK PRI_OUT PRI_OUTB SER_IO SER_IOB AZ_SHP_OUT AZ_SHP_OUTB SHP_OUT SHP_OUTB TUNIND T0TRIG_N BWSEL0BWSEL1BWSEL2 VIDTEST SPARE REMOTE_SW+REMOTE_SW- STC GENERATORSTC_GEN2 MBS_ampSea_clutRain_clut Gain IF_gain IFSTC MBS_durT0TRIG_N 10VREF 5VREF R_4 IF STRIPSIF_AMPAG 60MHZIF LOGIN GAINIFSTCIFBW TUNIND IF DET/VIDEOIF_LOGAM LOGINVIDBW VIDEO FTCVVIDBW2 VIDTEST GND 60MHZIF N/C1 RF_ATTENV TUNE_V GND -5VIN+5VIN+26VINGND V_SIGNAL PTx_ADJUST BWsel0 VIDTEST PW_ADJUST BWsel1BWsel2 DAC11DAC12 VGNDVIDEOVGNDSPARE PRI_OUTPRI_OUTBSER_IOSER_IOBAZ_SHP_OUTAZ_SHP_OUTB BWsel0BWsel1 VIDEOVGND DAC11 BWsel1 PTx_ADJUST N/C DAC12 BWsel0 PW_ADJUST GNDREMOTE_SW+PW0 IF5 MBS_amp HEATER_OK IF0 TUNE_C AZ_SHP_OUT SHP_OUTSHP_OUTB MOD_ISENSE T0TRIG_N T0TRIG_N IF13 M[0..6] TUNE_F SHP_IN M4 PRI_PLS M3 PRI_OUT IF2 FTC_level IF1 TUNE_F IF7 R_4 IF3 RF_atten PW1 M1 SER_IO HEAT_EN_N STEP_IO M5 DACDAT D0 Rain_clutR_4 STEP_IOSHP_IN RF_atten TUNIND M6 MOTOR_EN_N M2 HEAT_EN_N PW0 M0 DACDATDACCLK BWsel2 MBS_dur D[0..2] IF_gain DACLD IF6 IF_gain PW1 IF[0..13] MBS_ampTUNE_CSea_clut +12VRAW PRI_OUTB IF9 Rain_clut RADAR_TX_EN SER_IOB TUNIND IF12 IF8 Sea_clut AZ_SHP_OUTB MOTOR_EN_N FTC_level DACCLK D2 DACLD D1 IF4 MBS_dur PRI_PLS VIDTESTSPARE REMOTE_SW- VIDEOVGND V_SIGNAL +5V +5VSWITCHED +12V +12VIN -5V +5V +26V 5VREF 5VREF +5VIN 10VREF +5VSWITCHED GND GND GND GND GND GND GND GND GND GNDGND GND R3442k2 L17 3u3 9600L13 L3216 FID1 1 C2061n TP321 1 P2 07370 12345678910 TP320 1 P407335 123456789 1011121314151617181920 TP258 1 TTP15 1 C22910n C2041n SK1 07301 12345678 HF2Fixing-hole 1 TP230 1 HF5Fixing-hole 1 TP318 1 TP255 1 R3452k2 L189600L1 L1206 C2071n TP228 1 DATUM 1 R3420R FID2 1 P1 9600CLH110 12345678910 11121314151617181920 L16 9600L1 L1206 R3462k2 C2051n HF3Fixing-hole 1 L153u3 9600L13 L3216 TP1 1 U1MB88346B 101819234567891213141 1120161517 VDD AO1AO2AO3AO4AO5AO6AO7AO8AO9 AO10AO11AO12 DO VSS VCCGNDCLKLDDI R3472k2 TP227 1 FID3 1 R3410Rno-fit R3430R TP256 1 TH2 1 TP226 1 HF4Fixing-hole 1 TP322 1 TP229 1 L27 ZJYS51R5-2P 12 34 AB B' A' HF1Fixing-hole 1 R3400Rno-fit TP257 1 TP317 1 C23010n TP319 1 88 77 66 55 44 33 22 11 D D C C B B A A IF Gain Control IF Amplifier IF BW Switch Autotune From LNC 4437-004 G IF Strips B 2 6 Tuesday, November 19, 2002 Title Size Document Number Iss. Date: Sheet of THE INFORMATION CONTAINED HEREIN SHALL NOT BE REPRODUCED IN WHOLE OR IN PART WITHOUTTHE PRIOR WRITTEN PERMISSION OF RAYMARINE LTD. C 2001 Raymarine Ltd. Drawn Approved Checked R ON BOARD a ym arine +12V +12V -5V +12V +12V +12V 10VREF +12VIN GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND R12847k C88 1n +- GNDGND GAIN O-O+ VCC U9MC1350D 4637 5182 TP101 1 C259 100n C45 22p R1041k Q35BF999 2 13 TP114 1 Q31BF999 2 13 + C46 10u R3360RNF TP25 1 TP29 1 C47 1n R102 120R TP123 1 L2610uH C48 22p C50 22p TP30 1 +- GNDGND GAIN O-O+ VCC U10MC1350D 4637 5182 CTP1 1 TP103 1 + C5110u D16BAS16 2 3 C521n R103 100R TP120 1 TP116 1 Q372N3904 2 13 C53 22p R105 560R TP118 1 TP102 1 TP109 1 C55 22p TP115 1 L110uH C4210n TP127 1 TP113 1 L4 220nH 31 L2 220nH TP278 1 TP104 1 TP124 1 TP27 1 R111 22R D17 HSMP3830 23 R217680R C73 100n R112 22R L610uH TP111 1 Q34BF999 2 13 R113 100R TP126 1 TTP18 1 R114 1k TP106 1 C6315p C6415p TP107 1 L7 220nH 31 TP112 1 C20810n TP24 1 TTP22 1 C6527p Q32 BF999 2 13 TP105 1 L8 220nH 31 R115 1k C67 1p5 C6910n R130 100R TP122 1 C56 27p TTP20 1 C711n TP121 1 AR1MSA-1105 3 1 4 2 R11622R TTP19 1 C258 100n R333NF R12922R TTP21 1 L9 220nH 31 C9727p TTP17 1 R117 3k3 TP117 1 Q332N3906 2 1…

Text truncated - open the document above for the full version.