R49SM-S220Mobile Printer

Mobile Printer SM-S220 SERIES Hardware Manual < USA model > Federal Communications Commission Radio Frequency Interference Statement FCC ID : R49SM-S220 This device complies with Part 15 of the FCC Rules. Operation is subject to the following two conditions: (1) This device may not cause harmful interference, and (2) this device must accept any interference received, including interference that may cause undesired operation. CAUTION: Changes or modifications not expressly approved by the party responsible for compliance could void the user’s authority to operate the equipment. Note: This equipmen t has been tested and found to comply with the limits for a Class B digital device, pursuant to part 15 of the FCC Rules. These limits are designed to provide reasonable protection against harmful interference in a residential installation. This equipment generates, uses and can radiate radio frequency energy and, if not installed and used in accordance with the instructions, may cause harmful interference to radio communications. However, there is no guarantee that interference will not occur in a particular installation. If this equipment does cause harmful interference to radio or television reception, which can be determined by turning the equipment off and on, the user is encouraged to try to correct the interference by one or more of the following measures: • Reorient or relocate the receiving antenna. • I ncrease the separ ation bet ween the equipmen t and r eceiver. • Connect the equipment into an outlet on a circuit different from that to which the receiver is connected. • Consult the dealer or an experienced radio/TV technician for help. Modifica tions not expressly approved by the manufacturer could void the user’s authority to operated the equipment under FCC rules. This transmitter must not be co-located or operated in conjunction with any other antenna or transmitter. This equipment complies with FCC radiation exposure limits set forth for uncontrolled equipment and meets the FCC radio frequency (RF) Exposure Guidelines in Supplement C to OET65. This equipment has very low levels of RF energy that it is deemed to comply without testing of specific absorption ratio (SAR). FCC WARNING Changes or modifications not expressly approved by the party responsible for compliance could void the user’s authority to operate the equipment. For compliance with the Federal Noise Interference Standard, this equipment requires a shielded cable. For RF interference suppression, if a ferrite core is provided with this device, affix it to the interface cable. The above statement applies only to equipments marketed in U.S.A. <Europe model> English: Hereby, STAR MICRONICS CO.,LTD. declares that this Wireless Device is in compliance with the essential requirements and other relevant provisions of Directive 1999/5/EC Deutsch: Hiermit erklärt STAR MICRONICS CO.,LTD., dass sich das Gerät Wireless Device in Übereinstimmung mit den grundlegenden [German] Anforderungen und den übrigen einschlägigen Bestimmungen der Richtlinie 1999/5/EG befindet. Svenska: Härmed intygar STAR MICRONICS CO.,LTD. att denna Wireless Device står I överensstämmelse med de väsentliga egenskapskrav [Swedish] och ö vriga r elevanta bestämmelser som fr amgår a v dir ektiv 1999/5/EG. E spañol: Por medio de la pr esente STAR MICRONICS CO.,LTD. declara que el Wireless Device cumple con los requisitos esenciales y cualesquiera [Spanish] otras disposiciones aplicables o exigibles de la Directiva 1999/5/CE. Português: STAR MICR ONICS CO.,LTD. declara que este Wireless Device está conforme com os requisitos essenciais e outras disposições [Portuguese] da Directiva 1999/5/CE. Français: Par la présente STAR MICRONICS CO.,LTD. déclare que l’appareil Wireless Device est conforme aux exigences essentielles et aux [French] autres dispositions pertinentes de la directive 1999/5/CE. Suomi: STAR MICRONICS CO.,LTD. vakuuttaa täten että Wireless Device tyyppinen laite on direktiivin 1999/5/EY oleellisten vaatimusten ja [Finnish] sitä koskevien direktiivin muiden ehtojen mukainen. Italiano: Con la presente STAR MICRONICS CO.,LTD. dichiara che questo Wireless Device è conforme ai requisiti essenziali ed alle altre [Italian] disposizioni per tinenti stabilit e dalla dir ettiva 1999/5/CE . Dansk: Undertegnede STAR MICRONICS CO.,LTD. erklærer herved, at følgende udstyr Wireless Device overholder de væsentlige krav og [Danish] øvrige relevante krav i direktiv 1999/5/EF. Nederlands: Hierbij verklaart STAR MICRONICS CO.,LTD. dat het toestel Wireless Device in overeenstemming is met de essentiële eisen en de [Dutch] andere relevante bepalingen van richtlijn 1999/5/EG E esti: Käesolevaga k innitab ST AR MICR ONICS C O.,LTD. seadme Wir eless D evice v astavust dir ektiivi 1999/5/EÜ põhinõuet ele ja nimeta tud [Estonian] direktiivist tulenevatele teistele asjakohastele sätetele. Ελληνική: ΜΕ ΤΗΝ ΠΑΡΟΥΣΑ STAR MICRONICS CO.,LTD. ΔΗΛΩΝΕΙ ΟΤΙ Wireless Device ΣΥΜΜΟΡΦΩΝΕΤΑΙ ΠΡΟΣ ΤΙΣ ΟΥΣΙΩΔΕΙΣ ΑΠΑΙΤΗΣΕΙΣ [Greek] ΚΑΙ ΤΙΣ ΛΟΙΠΕΣ ΣΧΕΤΙΚΕΣ ΔΙΑΤΑΞΕΙΣ ΤΗΣ ΟΔΗΓΙΑΣ 1999/5/ΕΚ. Slovensky: STAR MICRONICS CO.,LTD. týmto vyhlasuje, že Wireless Device spĺňa základné požiadavky a všetky príslušné ustanovenia Smernice [Slovak] 1999/5/ES. Slovensko: STAR MICR ONICS CO.,LTD. izjavlja, da je ta Wireless Device v skladu z bistvenimi zahtevami in ostalimi relevantnimi določili direktive [Slovenian] 1999/5/ES. Česky: STAR MICR ONICS CO.,LTD. tímto prohlašuje, že tento Wireless Device je ve shodě se základními požadavky a dalšími príslušnými [Czech] ustanoveními smernice 1999/5/ES. Trademark acknowledgments SM-S220: Star Micronics Co., Ltd. Notice • All rights reserved. Reproduction of any part of this manual in any form whatsoever, without STAR’s express permission is forbidden. • The contents of this manual are subject to change without notice. • All efforts have been made to ensure the accuracy of the contents of this manual at the time of going to press. However, should any errors be detected,…

Text truncated - open the document above for the full version.

Appendix C. External Photographs Report no. ETLE121018.1221, Page C1 of C8 Head Office: # 371-51 Gasan-dong, Geumcheon-gu, Seoul, 153-803, Korea Tel : 82-2-858-0786 Fax : 82-2-858-0788 ETLQP-21-F22-0 FCC ID:R49SM-S220 View of total construct Appendix C. External Photographs Report no. ETLE121018.1221, Page C2 of C8 Head Office: # 371-51 Gasan-dong, Geumcheon-gu, Seoul, 153-803, Korea Tel : 82-2-858-0786 Fax : 82-2-858-0788 ETLQP-21-F22-0 FCC ID:R49SM-S220 Front view of EUT Front side view of EUT Appendix C. External Photographs Report no. ETLE121018.1221, Page C3 of C8 Head Office: # 371-51 Gasan-dong, Geumcheon-gu, Seoul, 153-803, Korea Tel : 82-2-858-0786 Fax : 82-2-858-0788 ETLQP-21-F22-0 FCC ID:R49SM-S220 Front side view of EUT (Paper cover open) Appendix C. External Photographs Report no. ETLE121018.1221, Page C4 of C8 Head Office: # 371-51 Gasan-dong, Geumcheon-gu, Seoul, 153-803, Korea Tel : 82-2-858-0786 Fax : 82-2-858-0788 ETLQP-21-F22-0 FCC ID:R49SM-S220 Rear view of EUT Rear side view of EUT Appendix C. External Photographs Report no. ETLE121018.1221, Page C5 of C8 Head Office: # 371-51 Gasan-dong, Geumcheon-gu, Seoul, 153-803, Korea Tel : 82-2-858-0786 Fax : 82-2-858-0788 ETLQP-21-F22-0 FCC ID:R49SM-S220 Rear view of EUT (Without Battery) Appendix C. External Photographs Report no. ETLE121018.1221, Page C6 of C8 Head Office: # 371-51 Gasan-dong, Geumcheon-gu, Seoul, 153-803, Korea Tel : 82-2-858-0786 Fax : 82-2-858-0788 ETLQP-21-F22-0 FCC ID:R49SM-S220 View of port View of battery pack Appendix C. External Photographs Report no. ETLE121018.1221, Page C7 of C8 Head Office: # 371-51 Gasan-dong, Geumcheon-gu, Seoul, 153-803, Korea Tel : 82-2-858-0786 Fax : 82-2-858-0788 ETLQP-21-F22-0 FCC ID:R49SM-S220 View of Adapter (for Battery charger) Appendix C. External Photographs Report no. ETLE121018.1221, Page C8 of C8 Head Office: # 371-51 Gasan-dong, Geumcheon-gu, Seoul, 153-803, Korea Tel : 82-2-858-0786 Fax : 82-2-858-0788 ETLQP-21-F22-0 FCC ID:R49SM-S220 View of Adapter label (for Battery charger)

Appendix A. FCC ID Label and Location Report no. ETLE121018.1221, Page A1 of A1 Head Office: # 371-51 Gasan-dong, Geumcheon-gu, Seoul, 153-803, Korea Tel : 82-2-858-0786 Fax : 82-2-858-0788 ETLQP-21-F22-0 FCC ID:R49SM-S220 Product Label Sample with FCC Label information Following is a sample copy of the label that will be placed on the rear cabinet of the product. The FCC ID Label and compliance statement are marked in the product label. The warning statement and Information to the User are described in the user manual. STAR MICRONICS CO., LTD. Mobile Printer FCC ID : R49SM-S220 Model No. : SM-S220 Serial No. : Proto type This device complies with part 15 of the FCC Rules. Operation is subject to the following two conditions: (1) This device may not cause harmful interference, and (2) This device must accept any interference received, including interference that may cause undesired operation. Manufacturer: Woosim Systems Inc. Made in Korea Label Location The label shown shall be permanently affixed at a conspicuous location on the device and be readily visible to the user at the time purchase.(Labeling requirements per 2.925) Label here

Appendix D. Internal Photographs Report no. ETLE121018.1221, Page D1 of D7 Head Office: # 371-51 Gasan-dong, Geumcheon-gu, Seoul, 153-803, Korea Tel : 82-2-858-0786 Fax : 82-2-858-0788 ETLQP-21-F22-0 FCC ID:R49SM-S220 Inside view of EUT Appendix D. Internal Photographs Report no. ETLE121018.1221, Page D2 of D7 Head Office: # 371-51 Gasan-dong, Geumcheon-gu, Seoul, 153-803, Korea Tel : 82-2-858-0786 Fax : 82-2-858-0788 ETLQP-21-F22-0 FCC ID:R49SM-S220 Top side view of main board Bluetooth Module Appendix D. Internal Photographs Report no. ETLE121018.1221, Page D3 of D7 Head Office: # 371-51 Gasan-dong, Geumcheon-gu, Seoul, 153-803, Korea Tel : 82-2-858-0786 Fax : 82-2-858-0788 ETLQP-21-F22-0 FCC ID:R49SM-S220 Bottom side view of main board Appendix D. Internal Photographs Report no. ETLE121018.1221, Page D4 of D7 Head Office: # 371-51 Gasan-dong, Geumcheon-gu, Seoul, 153-803, Korea Tel : 82-2-858-0786 Fax : 82-2-858-0788 ETLQP-21-F22-0 FCC ID:R49SM-S220 Top side view of sub board Appendix D. Internal Photographs Report no. ETLE121018.1221, Page D5 of D7 Head Office: # 371-51 Gasan-dong, Geumcheon-gu, Seoul, 153-803, Korea Tel : 82-2-858-0786 Fax : 82-2-858-0788 ETLQP-21-F22-0 FCC ID:R49SM-S220 Bottom side view of sub board Appendix D. Internal Photographs Report no. ETLE121018.1221, Page D6 of D7 Head Office: # 371-51 Gasan-dong, Geumcheon-gu, Seoul, 153-803, Korea Tel : 82-2-858-0786 Fax : 82-2-858-0788 ETLQP-21-F22-0 FCC ID:R49SM-S220 Top side view of Bluetooth Module Appendix D. Internal Photographs Report no. ETLE121018.1221, Page D7 of D7 Head Office: # 371-51 Gasan-dong, Geumcheon-gu, Seoul, 153-803, Korea Tel : 82-2-858-0786 Fax : 82-2-858-0788 ETLQP-21-F22-0 FCC ID:R49SM-S220 Bottom side view of Bluetooth Module

Appendix J. Radio Frequency Exposure Report no. ETLE121018.1221, Page J1 of J1 Head Office: # 371-51 Gasan-dong, Geumcheon-gu, Seoul, 153-803, Korea Tel : 82-2-858-0786 Fax : 82-2-858-0788 ETLQP-21-F22-0 FCC ID:R49SM-S220 According to §15.247(e)(i) and §1.1307(b)(1), systems operating under the provisions of this section shall be operated in a manner that ensures that the public is not exposed to radio frequency energy level in excess of the Commission’s guidelines. According to TCB Exclusions list, no SAR required if power is lower than the flowing threshold: BT Frequency Range Low Frequency [MHz] High Frequency [MHz] Center Frequency [MHz] 60/f SAR Limitation [mW] 2 402 2 480 2 441 24.580 Maximum measured transmitter power: Output Power Type of Modulation [dBm] [mW] Max Antenna Gain [dBi] EIRP [mW] GFSK 7.360 5.445 -3.000 2.729 8DPSK 5.560 3.597 -3.000 1.803 Conclusion: No Stand Alone SAR is required.

Report no. ETLE121018.1221, Page 2 of 51 Head Office: # 371-51 Gasan-dong, Geumcheon-gu, Seoul, 153-803, Korea Tel : 82-2-858-0786 Fax : 82-2-858-0788 ETLQP-21-F22-0 FCC TEST REPORT FCC ID:R49SM-S220 Table of Contents FCC Measurement Report 1. Introduction 2. Product Information 3. Description of Tests 4. Test Condition 5. Test Results 5.1 Summary of Test Results 5.2 Channel Bandwidth and Frequency Separation 5.3 Maximum Peak Output Power 5.4 Bandwidth of Frequency Band Edges 5.5 Number of Hopping Channels 5.6 Time of Occupancy (Dwell time) 5.7 Spurious Emissions 5.8 Conducted Emissions Test 5.9 Radio Frequency Exposure 6. Sample Calculation 7. List of test Equipment used for Measurement Appendix A. FCC ID Label and Location Appendix B. Test Setup Photographs Appendix C. External Photographs Appendix D. Internal Photographs Appendix E. Block Diagram Appendix F. Circuit Diagram Appendix G. User Manual Appendix H. Operational Description Appendix I. Antenna Requirement Appendix J. Radio Frequency Exposure Report no. ETLE121018.1221, Page 3 of 51 Head Office: # 371-51 Gasan-dong, Geumcheon-gu, Seoul, 153-803, Korea Tel : 82-2-858-0786 Fax : 82-2-858-0788 ETLQP-21-F22-0 FCC TEST REPORT FCC ID:R49SM-S220 FCC MEASUREMENT REPORT Scope – Measurement and determination of electromagnetic emission (EME) of radio frequency devices including intentional radiators and/or unintentional radiators for compliance with the technical rules and regulations of the U.S Federal Communications Commission(FCC) General Information  EUT Type : Mobile Printer  Model Number : SM-S220  S/N : Proto type  Freq. Range : 2 402 MHz - 2 480 MHz  Number of Channels : 79  Modulation Technique : FHSS (GFSK (Normal), 8DPSK (EDR))  Frequency Channel : 2 402 MHz to 2 480 MHz and Channel Spacing 1 MHz (79 Ch)  Air Data Rate : Normal (1 Mbps), EDR (3 Mbps)  Antenna Type : Printed Monopole Antenna (Integral)  Antenna Gain : -3.00 dBi max  RF Power : 5.445 mW  FCC Rule Part(s) : FCC Part 15 Subpart C  Test Procedure : ANSI C63.4-2003  FCC Classification : DSS (Part 15 Spread Spectrum Transmitter)  Place of Tests : ETL Inc. Testing Lab. Radiated Emission test; #499-1, Sagot-ri, Seosin-myeon, Hwaseong-si, Gyeonggi-do, 445-882, Korea Conducted Emission test; ETL Inc. Testing Lab. 371-51, Gasan-dong, Geumcheon-gu, Seoul, 153-803, Korea Applicant Name : STAR MICRONICS CO., LTD. Address : 20-10 Nakayoshida, Suruga-ku, Shizuoka-shi, Shizuoka, 422-8654, Japan Attention : Masamitsu Ozawa / Manager Report no. ETLE121018.1221, Page 4 of 51 Head Office: # 371-51 Gasan-dong, Geumcheon-gu, Seoul, 153-803, Korea Tel : 82-2-858-0786 Fax : 82-2-858-0788 ETLQP-21-F22-0 FCC TEST REPORT FCC ID:R49SM-S220 1. INTRODUCTION The measurement test for radiated and conducted emission test was conducted at the ETL Inc. The site is constructed in conformance with the requirements of the ANSI C63.4-2003 and CISPR Publication 16. The ETL has site descriptions on file with the FCC for 3 m and 10 m site configurations. Detailed description of test facility was found to be in compliance with FCC Rules according to the ANSI C63.4-2003 and registered to the Federal Communications Commission (FCC Designation Number : KR0022). The measurement procedure described in American National Standard for Method of Measurement of Radio- Noise Emission from Low-Voltage Electrical and Electronic Equipment in the Range of 9 kHz to 40 GHz (ANSI C63.4-2003) was used in determining radiated and conducted emissions from the STAR MICRONICS CO., LTD. Model: SM-S220 Report no. ETLE121018.1221, Page 5 of 51 Head Office: # 371-51 Gasan-dong, Geumcheon-gu, Seoul, 153-803, Korea Tel : 82-2-858-0786 Fax : 82-2-858-0788 ETLQP-21-F22-0 FCC TEST REPORT FCC ID:R49SM-S220 2. PRODUCT INFORMATION 2.1 Equipment Description The Equipment Under Test (EUT) is the Mobile Printer (model: SM-S220). 2.2 General Specification Item Specification Printing method Direct line thermal printing Characters per line Maximum 42 cpl Alphanumeric characters: 12 dots x 24 dots, 9 dots x 24 dots and 7 dots x 17 dots Character size Japanese characters: 24 dots x 24 dots Character types Alphanumeric characters, expanded graphic characters, JIS Level-1 Kanji Set, JIS Level-2 Kanji Set and special characters Dot density 203 dpi (8 dots/mm) Printing width 48 mm (384 dots) Print speed 80 mm/s (max) or 50 mm/s (default) Bluetooth Spec. Bluetooth Ver 2.1+EDR, Class2 (10 m) Frequency Range 2.4 GHz ISM BAND (2 402 MHz ~ 2 480 MHz) RF Power Below 10 dBm Modulation method FHSS (GFSK, 8DPSK) Bluetooth Oscillation method PLL Interface RS-232C x 2 Roll paper Thermal roll paper ((57.5 ± 0.5) mm wide with a diameter of Ф 40 mm) 1D: JAN, EAN, UPC, ITF, Code39, Code93, Code128, CODABAR (NW-7) Barcode 2D: PDF417, QR Code, DATA Matrix Communication packet size Maximum 8 kByte Emulation ESC/POS Report no. ETLE121018.1221, Page 6 of 51 Head Office: # 371-51 Gasan-dong, Geumcheon-gu, Seoul, 153-803, Korea Tel : 82-2-858-0786 Fax : 82-2-858-0788 ETLQP-21-F22-0 FCC TEST REPORT FCC ID:R49SM-S220 Item Specification LCD 128 dots x 32 dots (LED backlight) Battery pack Lithium Ion 7.4 V DC (rechargeable), 1 130 mAh Approximately 8 hours (normal mode) Battery operating time Approximately 45 minutes (continuous printing) Input: 100 V – 250 V AC, 50 Hz – 60 Hz, 0.5 A Battery charger Output: 8.4 V DC, 0.8 A, Time required for full charge: 4 H (25 ± 25) °C (for operation) Temperature (20 ± 40) °C (for storage) (55 ± 25) % R.H. (for operation) Environmental Requirements Humidity (50 ± 40) % R.H. (for storage) Print head life Approximately 50 km Drop resistance 1.2 m, Please note that this value was obtained under testing conditions stipulated - Frequency Channel Table Report no. ETLE121018.1221, Page 7 of 51 Head Office: # 371-51 Gasan-dong, Geumcheon-gu, Seoul, 153-803, Korea Tel : 82-2-858-0786 Fax : 82-2-858-0788 ETLQP-21-F22-0 FCC TEST REPORT FCC ID:R49SM-S220 3. DESCRIPTION OF TESTS The tests documented in this report were performed in accor…

Text truncated - open the document above for the full version.

Appendix B. Test Setup Photographs Report no. ETLE121018.1221, Page B1 of B4 Head Office: # 371-51 Gasan-dong, Geumcheon-gu, Seoul, 153-803, Korea Tel : 82-2-858-0786 Fax : 82-2-858-0788 ETLQP-21-F22-0 FCC ID:R49SM-S220 Radiated Emission Test Setup (Below 30 MHz) Appendix B. Test Setup Photographs Report no. ETLE121018.1221, Page B2 of B4 Head Office: # 371-51 Gasan-dong, Geumcheon-gu, Seoul, 153-803, Korea Tel : 82-2-858-0786 Fax : 82-2-858-0788 ETLQP-21-F22-0 FCC ID:R49SM-S220 Radiated Emission Test Setup (Below 1 GHz) Appendix B. Test Setup Photographs Report no. ETLE121018.1221, Page B3 of B4 Head Office: # 371-51 Gasan-dong, Geumcheon-gu, Seoul, 153-803, Korea Tel : 82-2-858-0786 Fax : 82-2-858-0788 ETLQP-21-F22-0 FCC ID:R49SM-S220 Radiated Emission Test Setup (Above 1 GHz) Appendix B. Test Setup Photographs Report no. ETLE121018.1221, Page B4 of B4 Head Office: # 371-51 Gasan-dong, Geumcheon-gu, Seoul, 153-803, Korea Tel : 82-2-858-0786 Fax : 82-2-858-0788 ETLQP-21-F22-0 FCC ID:R49SM-S220 Conducted Emission Test Setup