2ACSOGDRD5X6XAPulse Radar Level Instrument

Beijing GODA Instruments Co.,Ltd. 北京古大仪表有限公司 Pulse Radar Level Instrument Level Measurement Expert Table of Contents 1 For your safety...... ............... ....1 2 Measurement Principle ................ ...2 3 Product Overview.................... ....3 4 Mounting Requirement................. ...7 5 Electrical Connection.................. ...13 6 Adjustment Instructions................. ..15 7 Dimensional Drawings.................. ..18 8 Technical Specifications...................22 9 Selection & Ordering Information............27 10 Application Questionnaire ............ ...33 1 1.For your safety All operations described in this operating instructions manual must be carried out ouly by trained specialist personnel authorised by the plant operator. During work on and with the device the required personal protective equipment must always be worn. Operational reliability is ensured only if the instrument is properly used according to the specifications in the operating instructions manual as well as possible supplementary instructions. This device complied with Part 15 of the FCC Rules. Operation is subject to the following two conditions: (1)this device may not cause harmful interference, and (2)this device must accept any interference received, including interference that may cause undesired operation. Changes or modifications not expressly approved by the manufacturer could void the user's authority to operate the equipment. Authorised personal Appropriate use FCC Certification Warning: User must keep a safety distance of at least 20cm from the antenna. NOTE: This equipment has been tested and found to comply with the limits for a Class B digital device, pursuant to Part 15 of the FCC Rules. These limits are designed to provide reasonable protection against harmful interference in a residential installation. This equipment generates, uses and can radiate radio frequency energy and, if not installed and used in accordance with the instructions, may cause harmful interference to radio communications. However, there is no guarantee that interference will not occur in a particular installation. If this equipment does cause harmful interference to radio or television reception, which can be determined by turning the equipment off and on, the user is encouraged to try to correct the interference by one or more of the following measures: -- Reorient or relocate the receiving antenna. -- Increase the separation between the equipment and receiver. -- Connect the equipment into an outlet on a circuit different from that to which the receiver is connected. -- Consult the dealer or an experienced radio/TV technician for help. 2.Measurement Principle The extremely narrow microwave pulse emitted by the antenna on radar level instrument can travel at the speed of light and part of its energy, which is reflected off the surface of target medium, is received by the very same antenna. The time lapse between pulse emission and reception by the antenna is proportional to the distance between the surface of target medium and the reference point on antenna. However, due to the fact that the electromagnetic wave is transmitted at extremely high speed, which leads to the tiny time lapse (nanosecond level) and makes it difficult to be identified, GDRD series of radar level instrument have adopted a special demodulation technology, enabling itself to detect the time lapse between pulse emission and reception correctly, and eventually generate accurate measurement result. Principle The pulse radar level instrument, adopted K band range as transmission frequency, which make this series have specialties as below: Small beam angle, which centralize energy, make GDRD high ability of anti-jamming, hence high accuracy and reliable. Small antenna size, easy to mount and easy to equip extra dust protection. Small blind zone, good accuracy even for small vessels. Shorter wave-length, suitable for small power. Equipped with advanced microprocessor and unique EchoDiscovery echo processing technology, the radar level instrument can be used under various hazardous process conditions The pulse radar level instrument, with pulses as its working tool and extremely low emission power, can be mounted on various metal or nonmetal vessels, harmless towards the environment and human beings. Features 2 3 Product Overview Max Measurement Range:: Measurement Accuracy: Process Temperature: Process Pressure: Signal Output: Power: Display module: Housing: Process Connection: Flange Accessories: Antenna: Application: Liquid Level measurement in liquids, especially highly erosive liquids 10m ±5mm o (-40～130) C (-0.1～0.3)MPa (4～20)mA/HART 2-wire(DC24V) A F L R GDRD55 GDRD61 Liquid Common 30m Enhanced 70m ±3mm ±10mm o (-40～100) C Ordinary pressure (4～20)mA/HART 2-wire(DC24V) None Pa66 Lifting frame or 1’NPT 3 GDRD56 Liquid Level measurement in liquids, under certain temperature and pressure, mildly erosive liquids 30m ±3mm o (-40～80) C o (-40～130) C o (-60～250) C o (-60～400) C Normal (-0.1～4)MPa (-0.1～40)MPa (4～20)mA/HART 2-wire(DC24V) Optional A H/I/J/K L/M/P T/V GDRD57 Liquid Level measurement of highly erosive medium under certain pressure/ temperature limit and suitable for 20m ±3mm o (-40～150) C (-0.1～0.5)MPa (4～20)mA/HART 2-wire(DC24V) Optional A U 4 GDRD58 Solid strong dew/dust/crystal 70m ±15mm o (-40～80) C o (-40～120) C o (-60～250) C o (-60～400) C Normal (-0.1～4)MPa (-0.1～40)MPa (4～20)mA/HART 2-wire(DC24V) Optional A H/I/J/K L/M/P T/V GDRD59 Solid Normal Temperature/Normal Pressure 15m ±10mm o (-40～80) C Normal (4～20)mA/HART 2-wire(DC24V) Optional A G L/M/N T 5 Pulse Radar Level Instrument Serial number Material Specialty Serial number F H I J K Material PFA Stainless Steel Stainless Steel\\ Stainless Steel Stainless Steel Flange (Huff） Serial number L M P Material (PTFE/PP)Flange Stainless Steel Flange Stainless Steel Gimbal Flange Specialty Rust tolerated High temp./High Pressure High temp./Normal Pressure Serial number R T U V W M…

Text truncated - open the document above for the full version.

EXTERNAL PHOTO DOCUMENTATION 16803597 001 for Pulse Radar Level Instrument Beijing GODA Instruments Co., LTD. This documentation consists of 6 pages (excluding this cover page). Photo Documentation Report Number: 16803597 001 Model: Pulse Radar Level Instrument - Page 1 of 6 1 Side view of GDRD56 series 2 Side view of GDRD56 series Photo Documentation Report Number: 16803597 001 Model: Pulse Radar Level Instrument - Page 2 of 6 3 Top view of GDRD56 series 4 Bottom view of GDRD56 series Photo Documentation Report Number: 16803597 001 Model: Pulse Radar Level Instrument - Page 3 of 6 5 Side view of GDRD57 series 6 Side view of GDRD57 series Photo Documentation Report Number: 16803597 001 Model: Pulse Radar Level Instrument - Page 4 of 6 7 Top view of GDRD57 series 8 Bottom view of GDRD57 series Photo Documentation Report Number: 16803597 001 Model: Pulse Radar Level Instrument - Page 5 of 6 9 Side view of GDRD61 series 10 Side view of GDRD61 series Photo Documentation Report Number: 16803597 001 Model: Pulse Radar Level Instrument - Page 6 of 6 11 Top view of GDRD61 series 12 Bottom view of GDRD61 series

For GDRD56 series: WARNING label： ID Label: For GDRD57 series: WARNING label: ID Label: For GDRD61 series: WARNING label: ID Label:

INTERNAL PHOTO DOCUMENTATION 16803597 001 for Pulse Radar Level Instrument Beijing GODA Instruments Co., LTD. This documentation consists of 27 pages (excluding this cover page). Photo Documentation Report Number: 16803597 001 Model: Pulse Radar Level Instrument - Page 1of 27 For GDRD56 series: 1 antenna with electronic part 2 antenna with connector top view Photo Documentation Report Number: 16803597 001 Model: Pulse Radar Level Instrument - Page 2of 27 3 electronic part front view 4 electronic part top view Photo Documentation Report Number: 16803597 001 Model: Pulse Radar Level Instrument - Page 3of 27 5 electronic part back view 6 electronic part bottom view Photo Documentation Report Number: 16803597 001 Model: Pulse Radar Level Instrument - Page 4of 27 7 PCB POWER BOARD top view with shielding 8 PCB POWER BOARD top view without shielding Photo Documentation Report Number: 16803597 001 Model: Pulse Radar Level Instrument - Page 5of 27 9 PCB POWER BOARD bottom view 10 PCB MCU BOARD top view Photo Documentation Report Number: 16803597 001 Model: Pulse Radar Level Instrument - Page 6of 27 11 PCB MCU BOARD bottom view 12 PCB DISPLAY BOARD top view Photo Documentation Report Number: 16803597 001 Model: Pulse Radar Level Instrument - Page 7of 27 13 PCB DISPLAY BOARD bottom view 14 PCB HF BOARD top view with shielding Photo Documentation Report Number: 16803597 001 Model: Pulse Radar Level Instrument - Page 8of 27 15 PCB HF BOARD bottom view with shielding 16 PCB HF BOARD top view without shielding Photo Documentation Report Number: 16803597 001 Model: Pulse Radar Level Instrument - Page 9of 27 17 PCB HF BOARD bottom view without shielding Photo Documentation Report Number: 16803597 001 Model: Pulse Radar Level Instrument - Page 10of 27 For GDRD57 series: 1 antenna with electronic part 2 antenna with connector top view Photo Documentation Report Number: 16803597 001 Model: Pulse Radar Level Instrument - Page 11of 27 3 electronic part front view 4 electronic part top view Photo Documentation Report Number: 16803597 001 Model: Pulse Radar Level Instrument - Page 12of 27 5 electronic part back view 6 electronic part bottom view Photo Documentation Report Number: 16803597 001 Model: Pulse Radar Level Instrument - Page 13of 27 7 PCB POWER BOARD top view with shielding 8 PCB POWER BOARD top view without shielding Photo Documentation Report Number: 16803597 001 Model: Pulse Radar Level Instrument - Page 14of 27 9 PCB POWER BOARD bottom view 10 PCB MCU BOARD top view Photo Documentation Report Number: 16803597 001 Model: Pulse Radar Level Instrument - Page 15of 27 11 PCB MCU BOARD bottom view 12 PCB DISPLAY BOARD top view Photo Documentation Report Number: 16803597 001 Model: Pulse Radar Level Instrument - Page 16of 27 13 PCB DISPLAY BOARD bottom view 14 PCB HF BOARD top view with shielding Photo Documentation Report Number: 16803597 001 Model: Pulse Radar Level Instrument - Page 17of 27 15 PCB HF BOARD bottom view with shielding 16 PCB HF BOARD top view without shielding Photo Documentation Report Number: 16803597 001 Model: Pulse Radar Level Instrument - Page 18of 27 17 PCB HF BOARD bottom view without shielding Photo Documentation Report Number: 16803597 001 Model: Pulse Radar Level Instrument - Page 19of 27 For GDRD61 series: 1 antenna with electronic part 2 antenna with connector top view Photo Documentation Report Number: 16803597 001 Model: Pulse Radar Level Instrument - Page 20of 27 3 electronic part front view 4 electronic part top view Photo Documentation Report Number: 16803597 001 Model: Pulse Radar Level Instrument - Page 21of 27 5 electronic part back view 6 electronic part bottom view Photo Documentation Report Number: 16803597 001 Model: Pulse Radar Level Instrument - Page 22of 27 7 PCB POWER BOARD top view with shielding 8 PCB POWER BOARD top view without shielding Photo Documentation Report Number: 16803597 001 Model: Pulse Radar Level Instrument - Page 23of 27 9 PCB POWER BOARD bottom view 10 PCB MCU BOARD top view Photo Documentation Report Number: 16803597 001 Model: Pulse Radar Level Instrument - Page 24of 27 11 PCB MCU BOARD bottom view 12 PCB DISPLAY BOARD top view Photo Documentation Report Number: 16803597 001 Model: Pulse Radar Level Instrument - Page 25of 27 13 PCB DISPLAY BOARD bottom view 14 PCB HF BOARD top view with shielding Photo Documentation Report Number: 16803597 001 Model: Pulse Radar Level Instrument - Page 26of 27 15 PCB HF BOARD bottom view with shielding 16 PCB HF BOARD top view without shielding Photo Documentation Report Number: 16803597 001 Model: Pulse Radar Level Instrument - Page 27of 27 17 PCB HF BOARD bottom view without shielding

Produkte Products TÜV Rheinland LGA Products GmbH  Tillystraße 2  D - 90431 Nürnberg  Tel.: +49 911 655 5225  Fax: +49 911 655 5226 Mail: [email protected]  Web: www.tuv.comom Prüfbericht-Nr.: Test Report No.: 16803597 001 Auftrags-Nr.: Order No.: 1140013772 Seite 1 von 37 Page 1 of 37 Kunden-Referenz-Nr.: Client Reference No.: 412990 Auftragsdatum: Order date: 2014-06-18 Auftraggeber: Client: Beijing GODA Instruments Co., LTD. Hongfu Enterprise Incubation Yard 10, No.2 Workshop 2-4, Chang Ping Dist, Beijing 102209 P.R. China Prüfgegenstand: Test item: Pulse Radar Level Instrument Bezeichnung / Typ-Nr.: Identification / Type No.: Refer to section 2.2 Auftrags-Inhalt: Order content: FCC certification Prüfgrundlage: Test specification: FCC Part 15 Subpart C Section 15.256 Wareneingangsdatum: Date of receipt: 2014-06-18 Prüfmuster-Nr.: Test sample No.: Engineering sample Prüfzeitraum: Testing period: 2014-08-11 to 2014-08-12 Ort der Prüfung: Place of testing: Refer to section 1.1 Prüflaboratorium: Testing laboratory: Refer to section 1.1 Prüfergebnis*: Test result*: Pass Refer to external photo geprüft von / tested by: 2014-08-12 Yang, Kai/ PE kontrolliert von / reviewed by: 2014-08-12 Sun, Lixun/Reviewer Datum Date Name / Stellung Name / Position Unterschrift Signature Datum Date Name / Stellung Name / Position Unterschrift Signature Sonstiges / Other: Zustand des Prüfgegenstandes bei Anlieferung: Condition of the test item at delivery: Prüfmuster vollständig und unbeschädigt Test item complete and undamaged * Legende: 1 = sehr gut 2 = gut 3 = befriedigend 4 = ausreichend 5 = mangelhaft P(ass) = entspricht o.g. Prüfgrundlage(n) F(ail) = entspricht nicht o.g. Prüfgrundlage(n) N/A = nicht anwendbar N/T = nicht getestet Legend: 1 = very good 2 = good 3 = satisfactory 4 = sufficient 5 = poor P(ass) = passed a.m. test specification(s) F(ail) = failed a.m. test specification(s) N/A = not applicable N/T = not tested Dieser Prüfbericht bezieht sich nur auf das o.g. Prüfmuster und darf ohne Genehmigung der Prüfstelle nicht auszugsweise vervielfältigt werden. Dieser Bericht berechtigt nicht zur Verwendung eines Prüfzeichens. This test report only relates to the a. m. test sample. Without permission of the test center this test report is not permitted to be duplicated in extracts. This test report does not entitle to carry any test mark. Produkte Products Prüfbericht - Nr.: Test Report No. 16803597 001 Seite 2 von 37 Page 2 of 37 TEST SUMMARY 4.1.1 MODULATED BANDWIDTH RESULT: Passed 4.1.2 FUNDAMENTAL EMISSION RESULT: Passed 4.1.3 ANTENNA REQUIRMENT RESULT: Passed 4.1.4 RADIATED SPURIOUS EMISSION RESULT: Passed 4.1.5 FREQUENCY STABILITY RESULT: Passed 4.2.1 ELECTROMAGNETIC FIELDS RESULT: Passed Produkte Products Prüfbericht - Nr.: Test Report No. 16803597 001 Seite 3 von 37 Page 3 of 37 Contents 1. TEST SITES ...................................................................................................................... 4 1.1 TEST FACILITIES ............................................................................................................... 4 1.2 LIST OF TEST AND MEASUREMENT INSTRUMENTS ............................................................... 4 1.3 TRACEABILITY .................................................................................................................. 6 1.4 CALIBRATION ................................................................................................................... 6 1.5 MEASUREMENT UNCERTAINTY........................................................................................... 6 2. GENERAL PRODUCT INFORMATION .................................................................................... 7 2.1 PRODUCT FUNCTION AND INTENDED USE ........................................................................... 7 2.2 RATINGS AND SYSTEM DETAILS ........................................................................................ 7 2.3 INDEPENDENT OPERATION MODES .................................................................................. 10 2.4 NOISE GENERATING AND NOISE SUPPRESSING PARTS ..................................................... 10 2.5 SUBMITTED DOCUMENTS ................................................................................................ 10 3. TEST SET-UP AND OPERATION MODES ............................................................................ 11 3.1 PRINCIPLE OF CONFIGURATION SELECTION ...................................................................... 11 3.2 TEST OPERATION AND TEST SOFTWARE .......................................................................... 11 3.3 SPECIAL ACCESSORIES AND AUXILIARY EQUIPMENT ........................................................ 11 3.4 COUNTERMEASURES TO ACHIEVE EMC/RF COMPLIANCE ................................................. 12 3.5 TEST SETUP DIAGRAM .................................................................................................... 12 4. TEST RESULTS ............................................................................................................... 13 4.1 TRANSMITTER REQUIREMENT & TEST SUITES .................................................................. 13 4.1.1 Modulated Bandwidth ................................................................................................................. 13 4.1.2 Fundamental Emission ............................................................................................................... 15 4.1.3 Antenna Requirment .................................................................................................................. 25 4.1.4 Radiated Spurious Emission ...................................................................................................... 26 4.1.5 Frequency Stability ..................................................................................................................... 34 4.2 RADIO FREQUENCY EXPROSURE COMPLIANCE.........…

Text truncated - open the document above for the full version.

Produkte Products Prüfbericht - Nr.: Test Report No. 16803597 001 Seite 36 von 37 Page 36 of 37 4.2 Radio Frequency Exprosure Compliance 4.2.1 Electromagnetic Fields RESULT: Passed Date of testing : 2014-08-11 Test standard : FCC KDB Publication 447498 D01 General RF Exposure Guidance v05r02 FCC 1.1310 MPE Calculation According to the formula Where Pd = power density in mW/cm2 Pout = output power to antenna in mW G = Antenna gain in numeric π = 3.14159 R = Distance between observation point and the center of radiator in cm The antenna of this product, under normal use condition, is at least 20cm away from the body of the user. Warning statement to the user for keeping the safety distance from the antenna should be included in the user manual. The highest measured power including antenna gain is -11.3dBm(0.0741mW), hence the Maximum Permissible Exposure (MPE) value: 225 22 /1/10474.1 2014159.34 10741.0 4 * cmmWcmmW R GPout Pd      Therefore the device is exclusion from SAR test, and compliance with MPE limit.

Produkte Products Prüfbericht - Nr.: Test Report No. 16803597 001 Seite 1 von 5 Page 1 of 5 1. Photographs of the Test Set-Up Photograph 1: Set-up for Radiated Spurious Emissions, below 1GHz Photograph 2: Set-up for Spurious Emissions,above 1GHz 1-18GHz Produkte Products Prüfbericht - Nr.: Test Report No. 16803597 001 Seite 2 von 5 Page 2 of 5 18-26.5GHz 26.5-40GHz Produkte Products Prüfbericht - Nr.: Test Report No. 16803597 001 Seite 3 von 5 Page 3 of 5 40-60GHz 60-90GHz Produkte Products Prüfbericht - Nr.: Test Report No. 16803597 001 Seite 4 von 5 Page 4 of 5 90-110GHz Photograph 3: Set-up for Fundamental emission bandwidth and Frequency stability test Produkte Products Prüfbericht - Nr.: Test Report No. 16803597 001 Seite 5 von 5 Page 5 of 5 Photograph 4: Set-up for Fundamental emission test