APYDMR0161Microwave Oven

Follow by letter indicating color K = Black, W = White Q = Bisque, S = Stainless Steel ODE L R -2 1 2 0 J R -2120J ma nua l#3824/15/04, 11: 16 AM1 PRELIMINARY 2 To aid in reporting this microwave oven in case of loss or theft, please record below the model number and serial number located on the unit. We also suggest you record all the information listed and retain for future reference. MODEL NUMBER________________________SERIAL NUMBER______________ DATE OF PURCHASE______________________ DEALER____________________________TELEPHONE________________ SERVICER___________________________TELEPHONE________________ PRECAUTIONS TO AVOID POSSIBLE EXPOSURE TO EXCESSIVE MICROWAVE ENERGY (a) Do not attempt to operate this oven with the door open since open-door operation can result in harmful exposure to microwave energy. It is important not to defeat or tamper with the safety interlocks. (b) Do not place any object between the oven front face and the door or allow soil or cleaner residue to accumulate on sealing surfaces. (c) Do not operate the oven if it is damaged. It is particularly important that the oven door close properly and that there is no damage to the: (1) door (bent), (2) hinges and latches (broken or loosened), (3) door seals and sealing surfaces. (d) The oven should not be adjusted or repaired by anyone except properly qualified service personnel. TO PHONE: DIAL 1-800-BE-SHARP ( 237-4277 ) for : SERVICE (for your nearest Sharp Authorized Servicer) PARTS (for your authorized parts distributor) ADDITIONAL CUSTOMER INFORMATION DIAL 1-800-642-2122 for : ACCESSORIES and COOKBOOK TO WRITE: Sharp Electronics Corporation Customer Assistance Center 1300 Naperville Drive Romeoville, IL 60446-1091 TO ACCESS INTERNET: www.sharp-usa.com FOR CUSTOMER ASSISTANCE Please provide the following information when you write or call: model number, serial number, date of purchase, your complete mailing address (including zip code), your daytime telephone number (including area code) and description of the problem. R-2120J manual#3824/15/04, 11:16 AM2 3 CONTENTS For Customer Assistance ..........................2 Precautions to Avoid Possible Exposure to Excessive Microwave Energy ...........2 Contents ......................................................3 Consumer Limited Warranty .....................4 Product Information Card ..........................4 Important Safety Instructions ...................5 Unpacking and Installation Instructions . 6-14 Unpacking and Examining Your Oven ......6 Installation Instructions ............................. 6-14 Optional Accessories ...............................14 Information You Need to Know ................. 15-17 About Your Oven ......................................15 About Food ...............................................15 About Utensils and Coverings ..................16 About Children and the Microwave ...........16 About Microwave Cooking ........................17 About Safety .............................................17 Part Names ................................................. 18-19 Before Operating ........................................20 To Set the Clock .......................................20 Stop/Clear .................................................20 Manual Operation .......................................21 Time Cooking ............................................21 To Set Power Level ..................................21 Using the Rack ..........................................21 Manual Defrost ..........................................21 Special Features ......................................... 22-29 Sensor Center ...........................................22 Reheat ...................................................... 22-23 Cook ......................................................... 23-24 Popcorn ....................................................24 Sensor Center Recipes .............................25 Meal Time .................................................26 Breakfast Bar ............................................ 26-27 Lunch on the Run .....................................27 Dinner Delights .........................................28 Dinner Delights Recipes ........................... 28-29 Easy Defrost ............................................. 29-30 Keep Warm Plus .......................................30 Short Cuts .................................................31 Other Convenient Features ....................... 32-33 Custom Help .............................................32 Multiple Sequence Cooking ......................32 Demonstration Mode ................................33 Minute Plus ...............................................33 Help ..........................................................33 Timer .........................................................33 More or Less Time Adjustment .................33 Light Hi/Lo .................................................33 Fan Hi/Lo ..................................................33 Cleaning and Care ......................................34 Replacing Parts ..........................................35 Service Call Check .....................................36 Cookbook Information ...............................36 Specifications .............................................37 Notes ...........................................................38 Guia Auto-Touch ........................................ 39-40 Auto-Touch Guide .................41-Back Cover R-2120J manual#3824/15/04, 11:16 AM3 4 SHARP ELECTRONICS CORPORATION warrants to the first consumer purchaser that this Sharp brand product (the “Product”), when shipped in its original container, will be free from defective workmanship and materials, and agrees that it will, at its option, either repair the defect or replace the defective Product or part thereof with a new or remanufactured equivalent at no charge to the purchaser for parts or labor for the period(s) set forth below. This warranty does n…

Text truncated - open the document above for the full version.

1 Subject:FW: Sharp Corporation , FCC ID: APYDMR0161, Assessment NO.: AN05T4767, Notice#1 05U3347-1 FCC Repot.pdf From: Danielle Zhan Sent: Wednesday, May 04, 2005 12:39 PM To: Helen Zhao Subject: RE: Sharp Corporation , FCC ID: APYDMR0161, Assessment NO.: AN05T4767, Notice#1 Please check the answer from Hitesh below. Thanks! Regards, Question #1: Test Report - Section 6.3 RF output power: Please revisit the formula used for calculating the RF output power. The values listed in the table are incorrect. Please recalculate the RF output power. ANS.- CHANGES MADE Question #2: Test Report - Section 6.5 Radiated spurious emission limit: the limit is associated with measured RF output power. Since you need to recalculate RF output power (Q2), please recalculate the radiated spurious emission limit and apply the new limit in section 6.5 Radiated emisssion. ANS. - CHANGES MADE Question #3: Test Report - Section 6.5.1 Radiated emission below 1GHz: if there is any offset used during the test, please indicate in the test report. ANS. - CHANGES MADE Best Regards,

PROPOSED FCC ID LABEL AND LOCATION SHARP CORPORATION FCC ID: APYDMR0161 FCC ID LABEL LOCATION

SHARP REVISIONS 4 3 2 1 MADE BY APPROVALS MAT. NO.FIN. NO.PROCESS NO. DATE MICROWAVE OVEN ENGINEERING * * SCALE UNIT mm TITLE LAST LETTER USED 1st2nd3rdthISSUE TYP.=TYPICAL REF.=REFERENCE MODEL F AMILY ISSUED MDL. NO. PARTS NO. SHARP MANUFACTURING COMPANY OF AMERICA 155+2 95+2 JULIAN MARTIN 4/22/2005 1 1 SCHEMATIC DIAGRAM TMAPCB096MRR0 PAPER: ADHESIVE: RELEASE LINER: PIGMENT: VARNISH: ARTWORK SUPPLIED BY SMCA FITCHBURG 60-lb White Britekote FITCHBURG 630 permanent FITCHBURG 40-lb Semi-bleach Kraft Water Ink Technologies WG0421 (Jet Black) B.A.S.F. 79U5566 (Flexo Gem O. P.) Prohibited Substances: CFCs/Halon/Carbon tetrachloride/1.1.1-Trichloroethane (Methyl chloroform) 1 2 This product, Assembly, or component must not contain any of the above mentioned substances. This product, Assembly, or component is not manufactured using any of the above mentioned substances. <PROHIBITION TO USE OZONE DEPLETING SUBSTANCES> ORJ RED BLK BLU WHT RED BLK RED FUSE 20A RED ORG RED RED A5 RY3 A7 WHT BLK BLK WHT HOOD CAPACITOR HOOD MOTOR RED YL W BLU YL W RED RY4 RY5 BLU BLU BLU BLU PPL ORG WHT N. O. OVEN LAMP RELAY COM. GR Y WHT ORG BRN GRY WHT BLU WHT STIRRER MOTOR WHT BRN BRNBRN BRN ORG WHT RED BLU ORJ MODEL ORG ORG E1 E2 BLK GRN STOP SWITCH YLW PPL TMAPCB096MRR0 BLU WHT RY1 ORG RED C3 B1 RY6 C5 B3 A1 A3 A9 HUMIDITY SENSOR F3 F2 F1 ORG WHT COM N.C. FAN MOTOR WITH TEMP. FUSE I1R0 WHT BLK BLU CUT OUT CONTROL UNIT LOW HIGH YLW GND WHT GRN COM OVEN THERMAL PRIMARY INTERLOCK SWITCH BLK RED ORG ORG N.O. ORG BLU 60Hz 120VAC BLK HOOD FAN CUT OUT THERMAL H3 H1 L N O IS E F IL T E R N C 1 C 2 C 4 C 3 H

FCC CFR47 PART 18 SUBPART C ISM EQUIPMENT TEST REPORT FOR MICROWAVE OVEN MODEL NUMBER: ORJ MAGNETRON MODEL: 2M268J(L) FCC ID: APYDMR0161 REPORT NUMBER: 05U3347-1 ISSUE DATE: MAY 4, 2005 Prepared for SHARP CORPORATION 22-22 NAGAIKE-CHO, ABENO-KU RELIABILITY CONTROL GROUP OSAKA, JAPAN, 545-8522 Prepared by COMPLIANCE CERTIFICATION SERVICES 561F MONTEREY ROAD, MORGAN HILL, CA 95037, USA TEL: (408) 463-0885 FAX: (408) 463-0888 REPORT NO: 05U3347-1 DATE: MAY 4, 2005 EUT: MICROWAVE OVEN FCC ID: APYDMR0161 Page 2 of 31 COMPLIANCE CERTIFICATION SERVICES DOCUMENT NO: CCSUP4031A 561F MONTEREY ROAD, MORGAN HILL, CA 95037 USA TEL: (408) 463-0885 FAX: (408) 463-0888 This report shall not be reproduced except in full, without the written approval of CCS. Revision History Rev. Revisions Revised By REPORT NO: 05U3347-1 DATE: MAY 4, 2005 EUT: MICROWAVE OVEN FCC ID: APYDMR0161 Page 3 of 31 COMPLIANCE CERTIFICATION SERVICES DOCUMENT NO: CCSUP4031A 561F MONTEREY ROAD, MORGAN HILL, CA 95037 USA TEL: (408) 463-0885 FAX: (408) 463-0888 This report shall not be reproduced except in full, without the written approval of CCS. TABLE OF CONTENTS 1. ATTESTATION OF TEST RESULTS............................................................................................. 4 2. PRODUCT DESCRIPTION .............................................................................................................. 5 3. TEST FACILITY................................................................................................................................ 5 4. ACCREDITATION AND LISTING ................................................................................................. 5 5. MEASUREMENT EQUIPMENT LIST ........................................................................................... 6 6. LIMITS AND RESULTS ................................................................................................................... 7 6.1. RADIATION HAZARD MEASUREMENT .................................................................................... 7 6.2. INPUT POWER ............................................................................................................................ 9 6.3. RF OUTPUT POWER MEASUREMENT ................................................................................... 10 6.4. OPERATING FREQUENCY MEASUREMENTS ....................................................................... 11 6.4.1. VARIATION IN OPERATING FREQUENCY WITH TIME........................................... 12 6.4.2. VARIATION IN OPERATING FREQUENCY WITH VOLTAGE ................................. 14 6.5. RADIATED EMISSIONS.............................................................................................................18 6.5.1. RADIATED EMISSIONS – BELOW 1GHz ..................................................................... 20 6.5.2. RADIATED EMISSIONS – ABOVE 1GHz ...................................................................... 24 6.6. CONDUCTED EMISSIONS ....................................................................................................... 25 7. SETUP PHOTO ................................................................................................................................ 29 REPORT NO: 05U3347-1 DATE: MAY 4, 2005 EUT: MICROWAVE OVEN FCC ID: APYDMR0161 Page 4 of 31 COMPLIANCE CERTIFICATION SERVICES DOCUMENT NO: CCSUP4031A 561F MONTEREY ROAD, MORGAN HILL, CA 95037 USA TEL: (408) 463-0885 FAX: (408) 463-0888 This report shall not be reproduced except in full, without the written approval of CCS. 1. ATTESTATION OF TEST RESULTS COMPANY NAME: SHARP ELECTRONIC CORP 22-22 NAGAIKE-CHO, ABENO-KU RELIABILITY CONTROL GROUP OSAKA, JAPAN, 545-8522 EUT DESCRIPTION: MICROWAVE OVEN MODEL NUMBER: ORJ . SERIAL NUMBER: 112703 & 112704 MAGNETRON MODEL: 2M268J(L) DATE TESTED: APRIL 14, 2005 APPLICABLE STANDARDS STANDARD TEST RESULTS FCC PART 18 SUBPART C & FCC METHEROD OF MEASUREMENTS OF RADIO NOISE EMISSION FROM INDUSTRIAL, SCIENTIFIC, AND MEDICAL EQUIPMENT FCC / OST MP-5 NO NON-COMPLIANCE NOTED Compliance Certification Services, Inc. tested the above equipment in accordance with the requirements set forth in the above standards. The test results show that the equipment tested is capable of demonstrating compliance with the requirements as documented in this report. Note: The results documented in this report apply only to the tested sample, under the conditions and modes of operation as described herein. This document may not be altered or revised in any way unless done so by Compliance Certification Services and all revisions are duly noted in the revisions section. Any alteration of this document not carried out by Compliance Certification Services will constitute fraud and shall nullify the document. No part of this report may be used to claim product certification, approval, or endorsement by NVLAP, NIST, or any government agency. Approved & Released For CCS By: Tested By: YAN ZHENG HITESH H. SOLANKI EMC SUPERVISOR EMC ENGINEER COMPLIANCE CERTIFICATION SERVICES COMPLIANCE CERTIFICATION SERVICES REPORT NO: 05U3347-1 DATE: MAY 4, 2005 EUT: MICROWAVE OVEN FCC ID: APYDMR0161 Page 5 of 31 COMPLIANCE CERTIFICATION SERVICES DOCUMENT NO: CCSUP4031A 561F MONTEREY ROAD, MORGAN HILL, CA 95037 USA TEL: (408) 463-0885 FAX: (408) 463-0888 This report shall not be reproduced except in full, without the written approval of CCS. 2. PRODUCT DESCRIPTION The equipment under test is a microwave oven sold for consumer use. Model: ORJ is s 1200W microwave oven with digital controls panel. Magnetron Model: 2M268J(L) 3. TEST FACILITY The open area test sites and conducted measurement facilities used to collect the radiated data are located at 561F Monterey Road, Morgan Hill, California, USA. The sites are constructed in conformance with the requirements of ANSI C63.7, ANSI C63.4 and CISPR Publication 22. 4. ACCREDITATION AND LISTING The test facilities used to perform radiated and conducted emissions …

Text truncated - open the document above for the full version.

REPORT NO: 05U3347-1 DATE: APRIL 18, 2005 EUT: MICROWAVE OVEN FCC ID: APYDMR0161 Page 29 of 31 COMPLIANCE CERTIFICATION SERVICES DOCUMENT NO: CCSUP4031A 561F MONTEREY ROAD, MORGAN HILL, CA 95037 USA TEL: (408) 463-0885 FAX: (408) 463-0888 This report shall not be reproduced except in full, without the written approval of CCS. 7. SETUP PHOTO Radiation Hazard Measurement Operating Frequency Measurements REPORT NO: 05U3347-1 DATE: APRIL 18, 2005 EUT: MICROWAVE OVEN FCC ID: APYDMR0161 Page 30 of 31 COMPLIANCE CERTIFICATION SERVICES DOCUMENT NO: CCSUP4031A 561F MONTEREY ROAD, MORGAN HILL, CA 95037 USA TEL: (408) 463-0885 FAX: (408) 463-0888 This report shall not be reproduced except in full, without the written approval of CCS. AC Line Conduction Front AC Line Conduction back REPORT NO: 05U3347-1 DATE: APRIL 18, 2005 EUT: MICROWAVE OVEN FCC ID: APYDMR0161 Page 31 of 31 COMPLIANCE CERTIFICATION SERVICES DOCUMENT NO: CCSUP4031A 561F MONTEREY ROAD, MORGAN HILL, CA 95037 USA TEL: (408) 463-0885 FAX: (408) 463-0888 This report shall not be reproduced except in full, without the written approval of CCS. Radiation Measurement front Radiation Measurements back END OF REPORT