C44TCE2098TOYSInteractive Toy

Analog Toy Block Diagram MOTOR DRIVER MICRO COM PANDER / EXPAN DER BATTERIESTX RX TRANCEIVER Am plifier Am plifier MIC Speaker SENSORS / LEDS Filter Filter POW ER REGULATOR Channels' frequencies describe the LO frequencies. 4M hz ch1 - 925.3MHz ch8 - 927.05MHz ch1 - 892.1MHz ch8 - 893.85MHz

Analog Toy External Photos. Assembled Product, Front/Top View , Rear View without Cover Battery Cover Rear Cover Disassembled Plastic Box Construction Picture with Disassembled Speaker Sensor

FCC ID Label {Length: 4.5cm height: 2.4cm} Location of Label on EUT Label affixed with permanent adhesive on rear of unit MODEL: 900M VER.5.2 (Analog Toy) FCC ID: C44TCE2098TOYS This device complies with part 15 of the FCC rules. Operation is subject to the following two conditions: 1. This device may not cause harmful interference. 2. This device must accept any interference received, including interference that may cause undesired operation. Team Concepts Electronics Ltd. Made In China

Analog Toy Internal Photos Analog Toy PCB Analog Toy PCB

Analog Toy Product Description Toy Operation The toy device operated by system micro-controller, that receives instructions from PC. Digital data transmitted to toy in a slow rate (2 Kbps in Manchester code) using RF channel (FSK modulation, ∆f ~ 11 Khz). Micro-controller applies error correction algorythms on transmitted and also received data. Micro-controller’s crystal frequency: 4.0 Mhz. Motor, sensors and LEDs mounted inside the toy and wires connectting it to the electronic circuit. Transmitted audio signal passes througth automatic gain control (AGC) for flat audio level. Received audio signal passes througth expander to increasing the dynamic range. Tranceiver is an integrated RF module manfactured by Samsung Corporation, Electronic Components Group, model RU0926H18HKB. Four size D 1.5V batteries feeds the toy power. Input voltage may swing from 4.0 up to +6.5V without affecting the system operation. Voltage regulator at the toy input stabilazed the voltage for system componets espdghesialy to the RF module. System Test Start Up and Configuration Toy When toy is powered up, the toy performs self - test routine and initialization, that includes motor and mechanics test. After self-test is passed, the toy starts searching the RF channels in order to find the valid channel and establishes the communication with the base and the PC software. If the base found, the toy enters its normal operation mode, while waiting for commands from the base. Toy may be entered into sleep mode by the PC’s software or by the user.

MAI N CREAT OR LTD. CONFIDENTIAL B 17Sunday, July 16, 2000 Title Si zeDocument NumberRev Date:Sheet of POWER AMPLIF IER PWRAMP. SCH AUDIOSPK1 SPK2 AGND AUDGND PVAUD OPT I ON2 OPT I ON3 GENERAT OR AUDIO&DATA PROCESSOR A&DPROCE. SCH AUDRXAUDIO MIC RXDAT A RXCLK MICOFF AGND TXDAT A PANA AUDOFF AUDTX RF RX&TX UNIT RFUNIT . SCH ANT AGND AUDRX PANA AUDTX RFDAT A RFCLK RFCE _RXEN _TXEN _CD LDT MOTOR AND SENSOR MOT&S ENS. SCH MOTNU INNER MOT ORN MOT ORP LED1A LED2A LEDEY ELA LEDEY ERA MGND OUTER OPT OUTER OPTINNER LEDK MOTPU PDIG AGND PANA PMTR CONTROLLER MCU.SCH OUTER INNER RXDAT A RXCLK DGND MOTNU GENERAT OR TXDAT A MICOFF RFDAT A RFCLK RFCE LEDEY E AOFF PWRAUDOFF AUDOFF PDIG MOTPU SWAR M_L SWARM_R _TXEN _RXEN _CD LDT OPT I ON2 OPT I ON3 SWLEG_R SWLEG_L BAT RC6 RC7 PWR_MOT RST POWER CONTROL PWRCON.SCH MGND DGND AOFF PVAUD AUDGND PWRAUDOFF PDIG PMTR PANA AGND PWR_MOT RST BAT _CON RET BAT BATT ERY ARMSW(L) ARMSW(R) LEGSW MOTOR OPT OSENSOR EY ELED MICROPHONE SPEAKER PROGRAMMER BAT _CON RET SWAR M_L DGND SWARM_RANTAUDRXAUDI OSPK1MOTNUMOT ORN DGNDAUDTXSPK2MOTPUMOT ORP MIC RFDAT ALED1A RFCLKRXDAT AOPT I ON2LED2A RFCERXCLKOPT I ON3OPTOUTER OPTINNERL EDEY ELA SWLEG_L_CDMICOFFGENERAT ORLEDEY ERA DGNDLDTOUTER TXDAT AINNERL EDK SWLEG_R_RXEN _TXENAUDOFFPVAUDPMTR AGNDAUDGNDMGND PANAPANAPANAPDIG AGNDAGNDAGNDAGND MOT ORP MOT ORN LED1A LED2A LEDK DGNDBAT _CONPMTRMOTNU OPT OUTERBATMGNDOUTERMOTPU OPTINNERRETINNERPWR_MOT PVAUD_CD AUDGNDLDTAUDOFF RXDAT A AOFFPDIGRXCLKAOFF DGNDSWAR M_LGENERAT OR LEDEY ELARSTSWARM_RTXDAT A LEDEY EPANASWLEG_LMICOFF AGNDSWLEG_RRFDAT A LEDEY ERARFCLK PWRAUDOFFRFCE PWR_MOTRST_ TXEN PDIG_RXEN DGNDLEDEY E PWRAUDOFF MICRC6 AGNDOPT I ON2RC7 OPT I ON3 BAT SPK1 SPK2 RST BAT RET SWLEG_R SWARM_R RC6 RC7 FI D1 CSFD CSFI D 1 1 FI D2 CSFD CSFI D 1 1 FI D3 CSFD CSFI D 1 1 FI D4 CSFD CSFI D 1 1 FI D5 PSFD PSFI D 1 1 FI D6 PSFD PSFI D 1 1 FI D7 PSFD PSFI D 1 1 FI D8 PSFD PSFI D 1 1 CR1 CREAT OR CREAT OR 1 1 J1 CON2 CONTC2 1 1 2 2 J2 CON2 CONTC2 1 1 2 2 J3 CON2 CONTC2 1 1 2 2 J5 CON2 CONTC2 1 1 2 2 J9 CON2 CONTC2 1 1 2 2 J10 CON2 CONTC2 1 1 2 2 J4 CON4 CONTC4 1 1 2 2 3 3 4 4 J6 CON6 CONTC6 1 1 2 2 3 3 4 4 5 5 6 6 J8 CON4 CONTC4 1 1 2 2 3 3 4 4 J14 ANT PAD 1 1 J13 CON10 CONTC10 1 1 2 2 3 3 4 4 5 5 6 6 7 7 8 8 9 9 10 10 R111 300R 0805 1 2 TXT2 PS PS 1 1 TXT1 CS CS 1 1 A&DPRO CE. SCH AU DI O&DAT A PRO CESSO R CREAT OR LT D. CO NFIDENT I AL B 37Su nd ay, J uly 16, 20 00 Title Si zeDocum en t Num b erRev Da te:S hee t of AGND PANA PANA RXDT RXCLK PANA PANA AGNDAGND RXDAT A RXCLKAUDOF F TXDAT A AGND AGND PANA AGND AUDRX AUDI O AUDRXPANAPANARXDAT A RXCLK MIC AGND MI COFF VREFAGND AUDT X AUDI O TXDAT A RXDT AUDT X AG NDPANA VREF AUDOF F MI COFF VREF VREF AGND AGND MIC AGNDMIC VREF AGND C11 100 nF 0805 1 2 C15 100 nF 0805 12 C16 100 nF 0805 12 R43 10K 0805 1 2 C17 100 nF 0805 12 C20 10u F /1 6V CAP10 0RP 1 2 C21 10u F /1 6V CAP10 0RP 1 2 U4B 4013 SO 14 D 9 CLK 11 Q 13 Q 12 S 8 R 10 U5B 4070 SO 14 5 6 4 U5C 4070 SO 14 8 9 10 C22 100 nF 0805 1 2 R45 1M 0805 12 R46 22K 0805 1 2 R47 10K 0805 1 2 C25 10u F /1 6V CAP10 0RP 1 2 R51 11K 0805 12 R52 7K 5 0805 12 R53 10K 0805 12 C28 10 nF 0805 1 2 C31 100 nF 0805 1 2 R54 7K 5 0805 12 R55 11K 0805 12 C32 10 nF 0805 1 2 C33 1nF 0805 1 2 R57 1K 0805 12 R58 51K 0805 12 U4A 4013 SO 14 D 5 CLK 3 Q 1 Q 2 S 6 R 4 U5E 4070 SO 14 14 7 U4C 4013 SO 14 GND 7 V CC 14 U6 T A 311 03F SSO P24 FIL2OU T 1 F I L2I N 2 FIL1OU T 3 F I L1I N 4 CO M POU T 5 IN2 6 CRECT 7 CNF 8 M ICO UT 9 MI CNF 10 MICIN 11 GND 12 VREF 13 THROUGH 14 EXPMUT E 15 COM PMUT E 16 RO2 17 RO1 18 RIN 19 EXPO UT 20 ERECT 21 PREOU T 22 PRENF 23 VCC 24 C29 220 pF 0805 1 2 C30 220 pF 0805 1 2 R41 5K 1 0805 1 2 R62 10K 0805 12 + - U2D LM 324 SO 14 12 13 14 C12 100 nF 0805 1 2 C13 10u F /1 6V CAP10 0RP 1 2 C26 10u F /1 6V CAP10 0RP 1 2 R64 51 0K 0805 12 TP7 TP TP 1 1 TP8 TP TP 1 1 TP9 TP TP 1 1 TP12 TP TP 1 1 TP13 TP TP 1 1 TP14 TP TP 1 1 TP15 TP TP 1 1 TP16 TP TP 1 1 R1 15 0R 0805 12 R1 17 10K 0805 1 2 R40 7K 5 0805 1 2 C23 NA 0805 1 2 R63 75K 0805 12 R56 5K 1 0805 12 R1 20 10K 0805 1 2 R1 21 10K 0805 1 2 TP35 TP TP 1 1 TP10 TP TP 1 1 TP11 TP TP 1 1 R1 25 10 0K 0805 1 2 R1 26 10 0K 0805 12 R1 27 10K 0805 1 2 R1 28 10K 0805 1 2 R1 29 10 0K 0805 1 2 Q27 M MB T 39 06 SO T 23 1 2 3 Q28 M MB T 39 04 SO T 23 1 2 3 Q23 NA SO T 23 1 2 3 Q22 NA SO T 23 1 2 3 R1 18 NA 0805 1 2 R1 19 NA 0805 1 2 C54 NA 0805 1 2 C18 3n 3F 0805 1 2 C53 10u F /1 6V CAP10 0RP 1 2 R50 1K 0805 1 2 R1 16 NA 0805 1 2 C52 NA CAP10 0RP 1 2 R48 75K 0805 1 2 C24 1NF 0805 1 2 R44 51K 0805 1 2 R61 20 0K 0805 12 R49 22K 0805 1 2 C27 2u2 F /1 6V CAP10 0RP 1 2 D9 DIO DE LL34 21 D10 DIO DE LL34 2 1 AGND RXDAT A RXCLK MIC MI COFF TXDAT A PANA AUDRX AUDI O AUDT X AUDOF F MC U . SC H CONTROLLER CR EATO R LTD CO NFID ENTI AL B 67Sunday , July 16, 2000 Ti tle SizeDocu ment NumberR ev Dat e:Sheet of PD I G RC 0LDT SW AR M _L RC 1_CDSW AR M_ R SW LEG _ L SW LEG_ R RXCLK0RXCLKPD I G OSC 2OSC 1 RC 4R XDATADGN D DGN D SW LEG_ L0SW LEG _ L RST RC 6 SW LEG_ RRC 0PWRAUDOF FRC 7 OPTION1SW AR M_ RR C 1AOF F OPTION2SW AR M _LR C 2A U D OF FB AT OPTION3SW LEG_ L0R C 3_ R XE N OPTION4OUTE RRC 4M ICOF F LE2RC 5LEDEY E INNERLE1RC 6_TXEN DGN DRXCLK0RC 7PW R_MO TO PTION 2 OSC 1PD I GOPTION3 OSC 2DGN DDGN DPD IG RC 0RC 7LE1DGN D RC 1RC 6 RC 2RC 5 RC 3RC 4 MOTN U RC 0MOTNUMOTPU RC 1MOTPUPW R_MO T RC 2AUDOF F RC 3TXDATAAOF F BATPD IGRC 4GENERATORGENERATOR RC 5R FDATATXDATA RC 6RFC LKMICOF F RC 7RFC ER FDA TA RFC LK DGN DPD IGRFC E LE2DGN D_TXEN _RXEN LEDEY E OPTION1OPTION4PWRAUDOF F OUTE R INNER _CD LDT RXDATA RXCLK SW AR M _L DGN DDGN DSW AR M_ R SW LEG _ L SW LEG_ R RST PD I G DGN D C47 47pF 0805 1 2 C48 47pF 0805 1 2 C49 100 nF 0805 1 2 R79 100K 0805 1 2 R80 100K 0805 1 2 R81 100K 0805 1 2 R87 10K 0805 12 R84 10K 0805 12 R88 10K 0805 12 U10 74HC373 SO20W LE 11 D0 3 D1 4 D2 7 D3 8 D4 13 D5 14 D6 17 D7 18 OE 1 Q0 2 Q1 5 Q2 6 Q3 9 Q4 12 Q5 15 Q6 16 Q7 19 VC C 20 GN D 10 U11 74HC373 SO20W LE 11 D0 3 D1 4 D2 7 D3 8 D4 13 D5 14 D6 17 D7 18 OE 1 Q0 2 Q1 5 Q2 6 Q3 9 Q4 12 Q5 15 Q6 16 Q7 19 VC C 20…

Text truncated - open the document above for the full version.

FCC ID C44TCE2098TOYS Electrical (EMC) Test Report E37111.00Team Concepts Electronics Ltd. Page 1 of 39 FCC DOC M Ver 1.12 04 April 2000 DATE: 16 July 2000 I.T.L. (PRODUCT TESTING) LTD. EMC Test for Team Concepts Electronics Ltd. Equipment under test: Computerized Analog Toy 900M VER. 5.2 (Analog Toy) Approved by:_____________________________ Y. Mordukhovitch , Test Engineer Approved by:_____________________________ I. Raz, EMC Laboratory Manager This report must not be reproduced, except in full, without the written permission of I.T.L. (Product Testing) Ltd. This report relates only to items tested. . FCC ID C44TCE2098TOYS Test Report E37111.00Team Concepts Electronics Ltd. Page 2 of 39 FCC DOC M Ver 1.12 04 April 2000 Measurement/Technical Report for Team Concepts Electronics Ltd. Equipment under test: Computerized Analog Toy M/N 900M VER 5.2 FCC ID: C44TCE2098TOYS DATE: 18 July 2000 This report concerns:Original Grant x Class II change ___ Class B verification Class A verification Class I change ____ Equipment type: Radio Telemetry Transmitter Request Issue of Grant: x Immediately upon completion of review Limits used: CISPR 22 Part 15 x Measurement procedure used is ANSI C63.4-1992. Application for Certification Applicant for this device: prepared by:(different from "prepared by") Application for Certification Applicant for this device: prepared by:(different from "prepared by") Ishaiahou Raz ITL (Product Testing) Ltd.Team Concepts Electronics Ltd POB 2115/F Yan Hing Centre Or Yehuda 602519-13 Wong Chuk Yeung Street IsraelFo Tan, Shatin Tel: 972-3-533 9022N.T. Hong Kong Fax: 972-3-533 9019Tel: 852 2697 8138 Fax: 852 2691 0405 FCC ID C44TCE2098TOYS Test Report E37111.00Team Concepts Electronics Ltd. Page 3 of 39 FCC DOC M Ver 1.12 04 April 2000 TABLE OF CONTENTS 1.GENERAL INFORMATION -----------------------------------------------------------------------------4 1.1Product Description.................................................................................... 4 1.2Test Methodology...................................................................................... 4 1.3Test Facility............................................................................................... 4 1.4Measurement Uncertainty ........................................................................... 4 2.PRODUCT LABELING----------------------------------------------------------------------------------5 3.SYSTEM TEST CONFIGURATION-------------------------------------------------------------------6 3.1Justification................................................................................................ 6 3.2EUT Exercise Software .............................................................................. 6 3.3Special Accessories ................................................................................... 6 3.4Equipment Modifications ............................................................................. 6 3.5Configuration of Tested System .................................................................. 6 4.BLOCK DIAGRAM ---------------------------------------------------------------------------------------7 4.1Schematic Block/Connection Diagram.......................................................... 7 5.RADIATED EMISSION DATA --------------------------------------------------------------------------8 5.1Radiated Emission ..................................................................................... 8 5.2Measured Data.......................................................................................... 8 5.3Test Instrumentation Used, Radiated Measurements .................................. 13 5.4Field Strength Calculation ......................................................................... 14 6.RADIATED EMISSION DATA ------------------------------------------------------------------------ 15 6.1Radiated Emission Above 1 GHz............................................................... 15 6.2Test Data ................................................................................................ 15 6.3Test Instruments used, Radiated Measurement Above 1 GHZ ..................... 24 6.4Field Strength Calculation ......................................................................... 25 7.PHOTOGRAPHS OF TESTED E.U.T. ------------------------------------------------------------- 26 8.SIGNATURES OF THE E.U.T'S TEST ENGINEERS ------------------------------------------- 33 9.APPENDIX A - CORRECTION FACTORS--------------------------------------------------------- 34 9.1Correction factors for CABLE................................................................... 34 9.2Correction factors for CABLE................................................................... 35 9.3Correction factors for LOG PERIODIC ANTENNA ..................................... 36 9.4Correction factors for BICONICAL ANTENNA............................................. 37 9.5Correction factors for BICONICAL ANTENNA Type 3109............................ 38 9.6Correction factors for BICONICAL ANTENNA Type 3109............................ 39 9.7Correction factors for SAS ANTENNA, 3 meter range................................. 40 FCC ID C44TCE2098TOYS Test Report E37111.00Team Concepts Electronics Ltd. Page 4 of 39 FCC DOC M Ver 1.12 04 April 2000 1. General Information 1.1 Product Description This document describes the “Smart Alex” system operation. The product includes a transmitter operating between 925.3 MHz to 927.05MHz and a receiver operating between 902.8MHz to 904.55MHz This is an inteligent interactive toy, designed especially for interactive games and educational programs with kids of all ages. The toy has the appearance of a book, an inteligent book, with a face, eyes, mouth, legs and hands. The toy is connected to PC via an RF link so that it is completely mobile within the home surrounding range. This toy has full voice capabilities in both way, thus being interactive, it can talk w…

Text truncated - open the document above for the full version.

Analog Toy Test Setup Photos Radiated Emissions Front View Radiated Emissions Side View