PAV9501CLAiTrip

FM Transmitter BLOCK DIAGRAM 9501-TRIPCBL Regulator FM Modulator DC +12V Audio Signal Channel select +5V Crystal (7.6MHz)

       

FBRP5178 Appendix B PHOTOS OF EUT
       

FBRP5178 Appendix B: 1 of 3 PHOTO OF EUT Model : 9501-TRIPCBL Front View of EUT Rear View of EUT
       

FBRP5178 Appendix B: 2 of 3 PHOTO OF EUT Model : 9501-TRIPCBL Inside View of EUT Full View of Case
       

FBRP5178 Appendix B: 3 of 3 PHOTO OF EUT Model : 9501-TRIPCBL Full View of Component Side Full View of Solder Side 7.6MHz

       

FBRP5178 Appendix A: 1 of 2 Label Photo Full View Label of EUT Label FCC ID:PAV9501 This device complies with part 15 of the FCC Rules. Operation is subject to the following two conditions: (1) This device may not cause harmful interference. And (2) this device must accept any interference that may cause undesired operation.
       

FBRP5178 Appendix A: 2 of 2 PHOTOS OF RADIATED EMISSION TEST Model: 9501-TRIPCBL Front View Rear View

       

FBRP5178 Appendix B PHOTOS OF EUT
       

FBRP5178 Appendix B: 1 of 3 PHOTO OF EUT Model : 9501-TRIPCBL Front View of EUT Rear View of EUT
       

FBRP5178 Appendix B: 2 of 3 PHOTO OF EUT Model : 9501-TRIPCBL Inside View of EUT Full View of Case
       

FBRP5178 Appendix B: 3 of 3 PHOTO OF EUT Model : 9501-TRIPCBL Full View of Component Side Full View of Solder Side 7.6MHz

Operational description of 9501-TRIPCBL This Unit is a Wide-Band-FM modulator, with four selectable output frequencies (88.1MHz and 107.9MHz) which is selected by four-position dip switch and install in car for listening the music (such as MP3) or others via car’s radio. Operating process: 1. Connect audio signal (may be com from MP3) to the audio input port of 9501-TRIPCBL. 2. Select the desired frequency channel via dip switch. Power on the 9501-TRIPCBL. 3. 9501-TRIPCBL will radiate the RF signal (WFM modulated signal) to the air in selected frequency channel. 4. Tune the frequency of the car radio to the desired frequency. Car radio will receive the audio signal as the signal send to 9501-TRIPCBL if car’s radio select the same frequency channel. Power Requirement: This unit is operated with DC 3V (2AAA UM-4 size battery). This 3V voltage is step up to 5V DC for the operation of main IC chip (ROHM BH1418FV). Main Chip 1:. This unit uses a ROHM BH1418FV (U6) with 7.6MHz crystal frequency simple configuration. The BH1418FV is a FM stereo transmitter IC that transmits stereo composite signals and a FM transmitter for broadcasting a FM signal on the air. The FM output frequency is controlled by 2 wire (pin 19 data and ping 18 clock) control by micro controller (P89LPC915FDH). The FM output pin is pin 12. FM signal pass through a Filter to reduce the harmonic noise, then a class A amplifier to drive a internal antenna which is printed on P.C.B. The stereo modulator generates a composite signal which consists of the MAIN, SUB, and pilot signal from a internal 38KHz oscillator. The FM transmitter radiates FM wave on the air by modulating the carrier signal with a composite signal. The transmission frequency is stable because it has a PLL system FM transmitter circuit. Frequency is set for North America.

1 2 34 ABCD 4 3 2 1 D CBA Title Number Revision Size A Date: 2-Dec-2005 Sheet of File: C:\Design Files2\P616-LCDiTrip\P616- LCDiTrip r3d\P616-LCDiTrip r3d.ddb Drawn By: GND GND +3.3Vd +3.3Vd +3.3Vd +3.3Va +3.3Va +3.3Va +Vcc +Vcc +Vcc Project Number: P616 - LCDiTrip Design P616 3D 1 of 7R. Riffert R. Riffert Confidential PCB1PCB Pick n Place PCBASSEM1 PCB ASSEMBLY PP1Plastic Parts Boxing1Packaging Left1Right1AGND 123456 J2CN6 123 J1CN3 GND +3.3Va PWR EN +3.3Vd +5V +12V P616-Power SupplyP616-Power Supply.Sch GND+3.3Vd Enable PWR EN LED SDA SCL FWGND P616-Micro and SwitchesP616-Micro and Switches.Sch SDA SCL LED GND+3.3Vd P616-LCD and DriverP616-LCD and Driver.Sch Left1 Right1 GND+5V Left2 Right2 AGND P616-Audio FilterP616-Audio Filter.Sch Left2 Right2 GND+3.3VaSDASCLEnable RF Out RFGND P616-FM Stereo TransmitterP616-FM Stereo Transmitter.Sch +12VGNDRF ANT1 RFGND1GND+12V GND RF ANT1 RFGND1 RF Out RFGND P616-RF Output NetworkP616-RF Output Network.Sch Note: "NC" componants have been added in the even the main parts are not available. 1 2 34 ABCD 4 3 2 1 D CBA Title Number Revision Size A Date: 2-Dec-2005 Sheet of File: C:\Design Files2\P616-LCDiTrip\P616- LCDiTrip r3d\P616-LCDiTrip r3d.ddb Drawn By: L2 100uH PWR EN C162.2uF GND GND +3.3Va +3.3Va PWR EN Project Number: P616 - LCDiTrip Power Supply P616 3D 2 of 7R. Riffert R. Riffert Confidential +3.3Va R7NC +3.3Vd C40.01uF Digital Power C152.2uF R1210 +3.3Vd +3.3Vd D2BAV99 L1 100uH R1712KR1610K +12V +5V +5V +12V +12V +5V C200.1uF C210.1uF Vin 1 Vout 2 Vout 3 Adj 4 NC 5 Vout 6 Vout 7 NC 8 U2LM317LM C180.1uF +5V R27220 R26390 C241.0uF +5V R8NC C192.2uF C3210uF C3410uF C1722uF C110uF C20.01uF R28100K D1ZLLS400T SW 1 BST 2 Rcl 3 RTN 4 FB 5 Ron 6 Vcc 7 Vin 8 U1LM5007MM R131.0 R1100K C50.01uF C30.1uF Vout = +5.5V @ 40 +-10mA's C14NC 1 2 34 ABCD 4 3 2 1 D CBA Title Number Revision Size A Date: 2-Dec-2005 Sheet of File: C:\Design Files2\P616-LCDiTrip\P616- LCDiTrip r3d\P616-LCDiTrip r3d.ddb Drawn By: GND GND +3.3Vd +3.3Vd +3.3Vd +3.3Vd C22 0.1uF Enable Enable FM Transmitter R2100K R3100K R1810KR1910K C6 0.01uF C7 0.01uF R2010KR4100K +3.3Vd PWR EN PWR EN Project Number: P616 - LCDiTrip Micro and Switches P616 3D 3 of 7R. Riffert R. Riffert Confidential LED SDA SCL SCLSDA CIN2B/KBI1/AD10/P0.1 1 KBI0/CMP2/P0.0 2 RST/P1.5 3 Vss 4 INT1/P1.4 5 SDA/INT0/P1.3 6 SCL/T0/P1.2 7 P1.1/RXD 8 P1.0/TXD 9 Vdd 10 P0.5/CMPREF/KBI5/CLKIN 11 P0.4/CIN1A/KBI4/AD13/DAC1 12 P0.3/CIN1B/KBI3/AD12 13 P0.2/CIN2A/KBI2/AD11 14 U3P89LPC915FDH S1 SW SPST S3 SW SPST S2 SW SPST Up or DownDown or Up Select 1 2 34 ABCD 4 3 2 1 D CBA Title Number Revision Size A Date: 2-Dec-2005 Sheet of File: C:\Design Files2\P616-LCDiTrip\P616- LCDiTrip r3d\P616-LCDiTrip r3d.ddb Drawn By: +3.3Vd C80.01uF R5100K R6100K +3.3Vd SDA SCL Project Number: P616 - LCDiTrip LCD and Driver P616 3D 4 of 7R. Riffert R. Riffert Confidential +3.3Vd R3747 LED GND GND S1 2 S2 1 S3 28 S4 27 S5 26 S6 25 S7 24 S8 23 S9 22 S10 21 S17 20 S18 19 S19 18 S20 17 S21 16 S22 15 S23 14 S24 13 S25 12 S26 11 S27 10 SDA 9 SCL 8 Vdd 5 A0/OSC 6 A2/BP2 4 Vss 7 BP1 3 U4OM8577 C35680pF R381.0M +3.3Vd +3.3Vd +3.3Vd LED US/H 1 INTL/1F 4 1E/1G 3 1D/1C 2 1A/1B 5 LX/3F 12 2E/2G 7 2D/2C 6 2A/2B 9 DP/2F 8 3E/3G 11 3D/3C 10 3A/3B 13 DX/-- 14 COM1/-- 15 --/COM2 16 LED- 17 LED+ 18 D4LCD-GZ0401B8 1 2 34 ABCD 4 3 2 1 D CBA Title Number Revision Size A Date: 2-Dec-2005 Sheet of File: C:\Design Files2\P616-LCDiTrip\P616- LCDiTrip r3d\P616-LCDiTrip r3d.ddb Drawn By: +5V C90.01uF R2110K C4210uF Left1 Right1 GND Left1Right1 GND +5V +5V +5V Project Number: P616 - LCDiTrip FM Audio Filter P616 3D 5 of 7R. Riffert R. Riffert Confidential - 2 + 3 1 84 U5ALMV358M - 6 + 5 7 U5BLMV358M R4020K R2210K R3920K R4120K R4220K C251.0uFC271.0uF C261.0uFC281.0uF AGND SGND C38330pFC37330pF Left2 Right2 Left2Right2 AGND R1410 C400.0 R9NC C36680pF R64NCR65NC R66NC 1 2 34 ABCD 4 3 2 1 D CBA Title Number Revision Size A4 Date: 2-Dec-2005 Sheet of File: C:\Design Files2\P616-LCDiTrip\P616-LCDiTrip r3d\P616-LCDiTrip r3d.ddb Drawn By: C533300pF C60150pF C54 3300pF C61 150pF C291.0uF C301.0uF C6722pF C6822pF C31 1.0uF C4410uF Q12SD2142K + C3333uFC65 0.047uF R56100 R571K R243.3K R503.3K R4320K +3.3Va R2310K C57100pF C39330pF C4310uF C100.01uF C64 1000pF C69NC/5.0pF C62150pF L347nH R2510K R446.8K R4710K R49270 R4610K R48270 R514.7K SDASCLEnable R-ch Input 1 Pre-Emphasis TC 2 LPF TC 3 Filter 4 Composite Sig. Out 5 GND 6 Vcc 8 PLL Phase Det. Out 7 RF Osc. 10 RF GND 11 RF Output 12 PLL Vcc 13 XTAL Osc. 14 CLOCK 18 XTAL Osc. 15 Chip Enable 17 DATA 19 Audio Muting 20 Pre-Emphasis TC 23 Pilot Sig. Adj. 21 LPF TC 22 L-ch Input 24 N.C. 9 N.C. 16 U6BH1418FV D3BB200 +3.3Va +3.3Va C230.0 Left2Right2 C110.01uF Left2 Right2 GND Left2Right2GND +3.3Va +3.3Va +3.3Va SDASCL Enable Project Number: P616 - LCDiTrip FM Stereo Transmitter P616 3D 6 of 7R. Riffert R. Riffert Confidential R456.8K C63NC R320.0 R310.0 C46NC R300.0 C41NC C48NC C47NC R33NC R290.0 R1510 R53100 R55100 R54100 RFGND C52 3300pF C51 3300pF RF Out RFGND RF Out R58270 C56 1000pF C5922uF C4522uF C6622pF C550.01uF XTAL17.600MHz 1 2 34 ABCD 4 3 2 1 D CBA Title Number Revision Size A Date: 2-Dec-2005 Sheet of File: C:\Design Files2\P616-LCDiTrip\P616- LCDiTrip r3d\P616-LCDiTrip r3d.ddb Drawn By: C13100pF L6NC ANT1ANTENNA(PCB) GND GND Project Number: P616 - LCDiTrip FM Stereo Transmitter P616 3D 7 of 7R. Riffert R. Riffert Confidential C12NC R350.0 R10NC R11NC L4 220nH L5 220nH C7215pF C7315pF C7415pF C7515pF RF ANT1RFGND1 RFGND RF Out R340.0 RF Ant L747nHL847nH C760.01uFC770.01uF RFGND RFGND1RF ANT1

HomeTek Technology (Chang-An) Inc.












































 
 APPLICANT : GRIFFIN TECHNOLOGY CO. ADDRESS : 1619 Elm. Hill Pike, Nashville, TN. 37210 USA EUT : CLAiTrip MODEL NO. : 9501-TRIPCBL FCC ID : PAV9501 Under Part 15, SUBPART B AND SUBPART C. CLASS B Certification MEASUREMENT PROCEDURE USED FCC RULES AND FCC / ANSI C63.4-2003 PREPARED BY : HomeTek Technology (Chang-An) Inc. South of Shatou Industry District, Chang-An Town, DongGuan City, GuangDong, China Report # : FBRP5178
ADDRESS: South of Shatou Industry District, Chang-An Town, DongGuan City, GuangDong, China PHONE : 86-769-85303005 FAX : 86-769-85303006
E - mail :
[email protected]
       


FBRP5178 Page : 1 of 17 TABLE OF CONTENTS.................................................................................................................................. 1 GENERAL INFORMATION ................................................................................................................................... 2 MODIFICATION LIST ............................................................................................................................................ 4 CONDUCTED POWER LINE TEST....................................................................................................................... 5 1 TEST PROCEDURE ..................................................................................................................................... 5 2 RESULT OF CONDUCTED EMISSION TEST ............................................................................................. 5 RADIATED EMISSION TEST ................................................................................................................................ 6 1 TEST INSTRUMENTS & FACILITIES......................................................................................................... 6 2 EUT OPERATING CONDITION .................................................................................................................. 7 3 TEST SETUP ................................................................................................................................................ 8 4 CONFIGURATION OF THE EUT ................................................................................................................. 9 5 TEST PROCEDURE ................................................................................................................................... 11 6 LIMIT OF RADIATED EMISSION CLASS B ............................................................................................. 12 7 RESULT OF RADIATED EMISSION TEST ............................................................................................... 12 8 RADIATED EMISSION TEST DATA (PAGE 1)......................................................................................... 13 9 RADIATED EMISSION TEST DATA (PAGE 2)......................................................................................... 14 10 RADIATED EMISSION TEST DATA (PAGE 3)......................................................................................... 15 11 RADIATED EMISSION TEST DATA (PAGE 4)......................................................................................... 16 PHOTO OF FCC ID LABEL ................................................................................................................................. 17 APPENDIX A PHOTOS OF TEST CONFIGURATION APPENDIX B PHOTOS OF EUT APPENDIX C PLOT OF OCCUPIED BANDWIDTH
       
  FBRP5178 Page : 2 of 17 GENERAL INFORMATION 1 APPLICANT : GRIFFIN TECHNOLOGY CO. 2 ADDRESS : 1619 Elm. Hill Pike, Nashville, TN. 37210 USA 3 MANUFACTURER : GRIFFIN TECHNOLOGY CO. 4 ADDRESS : 1619 Elm. Hill Pike, Nashville, TN. 37210 USA 5 DESCRIPTION OF EUT : EUT : CLAiTrip FCC ID : PAV9501 Model Number : 9501-TRIPCBL Serial # : N/A
       




FBRP5178 Page : 3 of 18 6 FEATURES OF EUT : Dimension : h=12.5mm,w=26mm l=72mm,total length=85cm Weight : 0.6 OZ. Antenna : Built-in Power : Provided by 12 Volt Cigarette lighter Frequencies : 88.1,107.9MHz Oscillator : High stability crystal, phase-lock control Frequency response : 50Hz to15KHz Signal Distortion : <3%[F=75KHz,f=1KHz] Operating range : 10-30 ft 7 TEST MODE : The EUT were investigated with two operation modes shown as below : (1) FM 88.1MHz mode; (2) FM107.9MHz mode The test mode of (1) FM 88.1MHz is worst case, and the final test data were shown in this test report.
       
  FBRP5178 Page : 4 of 17 MODIFICATION LIST THE FOLLOWING ACCESSORIES WERE ADDED TO THE EUT DURING TESTING : NO MODIFICATION BY HOMETEK TECHNOLOGY(Chang-An) INC.
       
  FBRP5178 Page : 5 of 17 CONDUCTED POWER LINE TEST 1 TEST PROCEDURE According to ANSI C63.4 – 2003. 2 RESULT OF CONDUCTED EMISSION TEST N/A (Conducted Power Line Test is not applicable to this EUT (Model :9501-TRIPCBL).
       
  FBRP5178 Page : 6 of 17 RADIATED EMISSION TEST 1 TEST INSTRUMENTS & FACILITIES The following test Instruments was used during the radiated emission test : Item Instruments /facilities Specification Manufacturer Model # / S/N# Date of Cal. 1 OPEN AREA TEST SITE
OATS 1 SEP/2005 2 EMI TEST RECEIVER 20Hz ~ 26.5GHz ROHDE & SCHWARZ 845636/007 SEP/2005 3 PRE- AMPLIFIER 9KHz ~ 1300MHz HEWLETT PACKARD 8447D 1937A02095 SEP/2005 4 BICONICAL/LOG BROADBAND ANTENNA 25MHz ~ 2GHz ANTENNA RESEACH LPB2520/A 1095 OCT/2005 5 Attenuation 50
/6dB JYE BAO FAT-N (M-F) 001 SEP/2005 6 Cable 10m SUHNER RG214/U OS3-003 SEP/2005 7 Cable 14m BELDEN 9913 OS3-001 SEP/2005 8 EMI 32 (software) N/A AUDIX 19991013-0923 N/A Note : Items 1 ~ 7 were calibrated within period of 1 year.
       
  FBRP5178 Page : 7 of 17 2 EUT OPERATING CONDITION 2.1 Confi…

Text truncated - open the document above for the full version.

       

FBRP5178 Appendix A: 2 of 2 PHOTOS OF RADIATED EMISSION TEST Model: 9501-TRIPCBL Front View Rear View