VUDAUTOPRO2013Android Box

Notes: Any changes to the design and specifications are not recommended. Owner s Manual MAD11 Android Box R 2 Contents Chapter 1:Product and accessory---- -----------------------------------------3 Chapter 2:Technical specification--------------------------------------------3 Chapter 3:Remote control-----------------------------------------------------4 Chapter 4: Cable Installation and boot-------------------------------------6 Chapter 5:Introduction of the main interface------------------------------7 Chapter 6:Basic operation of the android system-- ---------------------- 8 Chapter 7:Application introduction-----------------------------------------12 Chapter 8:Common problems and treatment ---------------------- ----1 4 15 Enlarge narrow button:To enlarge or narrow thepicture. 7.4.2: tool bar introduction To enlarge or reduce the picture Slideshow : Press the left button of the fly mouse, enter the slideshow; Menu: Press the left button of the fly mouse, call out the menu options, as below picture: Share: analyse the browsing pictures ; Delete: delete the browsing photos ; More:View detailed information about the picture, set to trim, left rotate and right rotate Chapter 8: Common problems and treatment This chapter will introduce common problems and treatment of these for the Android Box Q1. What you should do if the box dies or the button has no response Press the power button of Remote control for 15 seconds, it will be powered off and the power light will be off and it will reset after press the power button of remote control Q2 .What to do if the Android TV box can not be opened properly or there is no screen output? Pls check as following steps: 1) Check if the light is on, if no light, check if the power is connected properly . 2) Check If there is signal output on the TV screen, if not, check if the audio cable is connected properly, and if the TV is set to the correct video channel outputs ( HDMI or CVBS output) 3) Remove SD card or removable hard disk or USB disk on the device. Plug in again when the boot normal. 4) Since the third-party software canbe installed, find out the conflicting software, pls delete them Q3:What to do if the movie can notplay properly? First check if themovie’s format is supportedby the android system, Next make sure thedevice operates properly.the unit and play the movie for verification. If still can not play, the format of the movie may not be supported by the device Q4:What to do if there is no internet on the main interface 1) Make sure the signal for wifi is workable 2) Make sure therouter is opened with DHCP , if not please set theIP address It is recommended to re-power 3)If you use a wireless card , make sure it is connectedwith wireless network, confirm the DHCP of therouter is opened, otherwise pls set the IP address. FCC statement This device complies with part 15 of the FCC Rules, Operation is subject to the following two conditions:(1)This device may not cause harmful interference, and (2) this device must accept any interference received, including interference that may cause undesired operation. This equipment has been tested and found to comply with the limits for a Class B digital device, Pursuant to Part 15 of the FCC Rules. These limits are designed to provide reasonable protection against harmful interference in a residential installation. -Reorient or relocate the receiving antenna. -Increase the separation between the equipment and receiver. -Connect the equipment into an outlet on a circuit different from that to which the receiver is connected. -Consult the dealer or an experienced radio/TV technician for help. FCC Caution: Any changes or modifications not expressly approved by the party responsible for compliance could void the user's authority to operate this equipment. Radiation Exposure Statement This equipment complies with FCC radiation exposure limits set forth for an uncontrolled environment ,This equipment should be installed and operated with minimum distance 20cm between the radiator & your body. 3 Chapter1:Product andaccessory Chapter 2: Technical specification This chapter will introduce the technical specification supported by the Android smart TV box. Technical specification of the smart Android TV box: --CPU: 1GHz ARM A9 Cortex+Mali-400 3D GPU; --RAM capacity: 1GB DDR3; --Software system: the smart Android 4.0 operating system, massive APK software can be installed from the internet; -- remote control, full new experience operating mode; --2 host USB port,1 SD port; --HDMI output / CVBS output/1 stereo out --Hardware accelerated, full HD 1080p video formats decode ; -- -- Built - in browser, support HTML5 site, simulation the iPa d video online play; -- Built - in file browser system; -- Built-in HD file playback , support MPEG1/2/4 , divx , H.264 , VC -1, ReaIVideo and etc. encodedvideo , support movies with suffix name like mkv , m2ts , ts , wmv , mp4 , 3gp , avi , dat , rm , ravb , wmv; -- Built-in lossless music playback software, supports APE, FLAC and MP3 music , support synchronous lyrics display ; 14 7.3:Music Player Introduction Through the file browser to select themusic file, select themovie player to open 7.3.1:Remote Control buttons 7.4:Picture Viewer Through the file browser to select the image file, select the movie player to open 7.4.1:Remote Control buttons Pause button: pause and play thefile Last an next button: Select the last andnext song Stop button: Exit pictures 1 Android smart Box 1 Remote control, 1 pair AAA batteries Built-in wifi asdd 1 1 PauseStopFastback Fast forwardPreviousNextRepeat 1 Filter box 1 AV out cable 1 AV cable 1 user manual Chapter3:Remote Control 13 Photo button: enter the"photo" in the file browser Web button : Open the browser The left button of themouse is to confirm, and right button to return 7.1.2: Features A.The file filter system provides a simple. and quick way to find the fil e. , except the video file suffix, no other files will bedisplayed. to allow user…

Text truncated - open the document above for the full version.

EXHIBIT B - EUT EXTERNAL PHOTOGRAPHS EUT – All View EUT – Top View EUT – Bottom View EUT – Left Side View EUT – Right Side View

EXHIBIT A - FCC ID LABELING AND LOCATION FCC ID Label Proposed FCC ID Label Location The label shown shall be permanently affixed at a conspicuous location on the device and be readily visible to the user at the time purchase (Labeling requirements per 2.925) Label Here

EXHIBIT B - EUT EXTERNAL PHOTOGRAPHS EUT – Back Cover Off View EUT – Uncover View Antenna EUT – All Cover Off View EUT – Wifi Module Off View EUT – Sub-board Off View EUT – Main Board Top View EUT – Main Board Bottom View EUT – Sub-board Top View EUT – Sub-board Bottom View EUT – Wifi Module Top View EUT – Wifi Module Bottom View EUT –Fuse Box Top View EUT – Fuse Box Bottom View EUT –Fuse Box Cover OffView EUT – Fuse Box Board Top View EUT – Fuse Box Bottom View

MAD11’s main IC is AM8726，AM8726 is a 1.2 GHz Amlogic dual core CPU, support: WIFI MODULE is MLK005A-RTL8188CUS-33. The Realtek RTL8188 is a highly integrated single-chip Wireless LAN (WLAN) USB 2.0 network interface controller compatible with the IEEE 802.11n specification，It combines a MAC, a 1T1R capable baseband, and RF in a single chip. The RTL8188SU-GR provides a complete solution for a high-performance wireless client.

Bay Area Compliance Laboratories Corp. (Dongguan) Report No.: R2DG130201005-00 FCC Part 15.247 Page 9 of 52 FCC §15.247 (i) & §1.1307 (b) (1) & §2.1091- MAXIMUM PERMISSIBLE EXPOSURE (MPE) Applicable Standard According to subpart 15.247(i)and subpart §1.1307(b)(1), systems operating under the provisions of this section shall be operated in a manner that ensures that the public is not exposed to radio frequency energy level in excess of the Commission’s guidelines. Limits for Maximum Permissible Exposure (MPE) (§1.1310, §2.1091) (B) Limits for General Population/Uncontrolled Exposure Frequency Range (MHz) Electric Field Strength (V/m) Magnetic Field Strength (A/m) Power Density (mW/cm 2 ) Averaging Time (minutes) 0.3–1.34 614 1.63 *(100) 30 1.34–30 824/f 2.19/f *(180/f²) 30 30–300 27.5 0.073 0.2 30 300–1500 / / f/1500 30 1500–100,000 / / 1.0 30 f = frequency in MHz; * = Plane-wave equivalent power density; According to §1.1310 and §2.1091 RF exposure is calculated. Calculated Formulary: Predication of MPE limit at a given distance S = PG/4πR² = power density (in appropriate units, e.g. mW/cm 2 ); P = power input to the antenna (in appropriate units, e.g., mW); G = power gain of the antenna in the direction of interest relative to an isotropic radiator, the power gain factor, is normally numeric gain; R = distance to the center of radiation of the antenna (appropriate units, e.g., cm); Calculated Data: Mode Frequency (MHz) Antenna Gain Conducted Power Evaluation Distance (cm) Power Density (mW/cm 2 ) MPE Limit (mW/cm 2 ) (dBi) (numeric)(dBm)(mW) 802.11b 2462 -2 0.63 17.4355.34 20 0.0069 1.0 802.11g 2437 -2 0.63 14.5 28.18 20 0.0035 1.0 802.11n ht20 2412 -2 0.63 13.7723.82 20 0.0030 1.0 802.11n ht40 2437 -2 0.63 13.4322.03 20 0.0028 1.0 Result: The device meet FCC MPE at 20 cm distance

A3 A 4 3 2 1 AB CD 12 3 4 D CB All rights reserved. Reproduction in whole or in part is prohibited without any written consent of the copyright owner. AUTOPRO 5 EF EF 5 POWER&MCUPOWER&MCU.SCH AM8726M3AM8726M3.SCH USB&AVOUTUSB&AVOUT.SCH MAD11 A3 FORM A 4 3 2 1 AB CD 12 3 4 D CB All rights reserved. Reproduction in whole or in part is prohibited without any written consent of the copyright owner. AUTOPRO 5 EF EF 5 3 2 1 4 U3 AL1117 3.3V GND +5V E24 220U/6.3V C20 104 C10 104 VCC3.3V D12 1N5819 E5 47U/16V 12 34 L110UH/2A E1 470U/35V C2104/50V C3 104/50V 1234 CON1 4PIN4.3 Q29014 R21 20K E2 100U/35V D31N4148 BATT ACC ACC D1 1N5822 R271K C1 104/50V PGND PGND BAT12V 12V L4 FB E6 47U/16V C12 104 C14 104 C16 104 C18 104 C19 104 GND USB5V L5 FB E15 10U/25V C30 104 C31 104 C32 104 C33 104 C34 104 GND USB3.3V GND VCC5V Q39014 R2420K D41N4148 C23104 ACC GND R25 20K ACC# VD1NC GND ACC_CTL E13 10U/25V L12100UH/0.5A D13 1N5819 R558.2K E26 100U/16V C27104 C45150P R612.4K GND DR 8 LPK 7 VCC 6 COM 5 SW-C 1 SW-E 2 TI 3 GND 4 UTC34063 U5 UTC34063 R471R +5V GND GND -5V L6 FB L2 100UH/2A D2 1N5822 E3 220U/6.3V E447U/16V C44104 V_IN 1 GND 3 ON/OFF 5 OUT 2 FB 4 GND 6 U1AP1501 ADJ R28 1K R35 220R R34 3K GND GND R23NC R20 39K R44 3.3R E747U/16V C29 104 -5VA C54 100P C21 104 R22NC FMANT C28 104 R50 33R 123 IR1HEG1838 MCU5V GND C48105 IR C53100P R51 33R IR_IN R48 560R D14RED +5V Y1 11.0592M C46 33P C47 33P GND E1710U/25V R54 8.2K D6 1N4148 GND MCU5V TXDRXD 1234 CON2NC RXDTXD MCU5VGND MCU5V GND IR_INIR_OUTMUTE R49 33R 5V_CTL R2 NC R3 NC 24SDA24SCL RST 1 RXD/P3.0 2 TXD/P3.1 3 XTAL2 4 XTAL1 5 INT0/P3.2/PWM8 6 INT1/P3.3/PWM9 7 P3.4/T0/PWM10 8 P3.5/T1/PWM11 9 VSS 10 P3.7/PWM12 11 P1.0/RXD1/PWM0 12 P1.1/TXD1/PWM1 13 P1.2/PWM2 14 P1.3/PWM3 15 P1.4/ADC0/PWM4 16 P1.5/ADC1/PWM5 17 P1.6/ADC2/PWM6 18 P1.7/ADC3/PWM7 19 VDD 20 U6HD8007 C26 104 C25 104 3 2 1 4 U4 NC GND E25 47U/16V C24 104 MCU5V VCC5V D111N5819 R43 3.3R C9104 S GD 1234 5678 U2 IRF7424 R40 30K Q49014 GND R41 4.7K 5V_CTL C7104 +5V GND C8104 AML RESET A0 1 A1 2 A2 3 GND 4 SDA 5 SCL 6 WP 7 VCC 8 U7NC GND 24SCL24SDA MCU5V R4 NC R5 NC ACC# GND IR_OUT L3FB E12 100U/16V C11 104 C13 104 C15 104 C17 104 GND AM_5V R46 6.8K Z33.3V D5 1N4148 GND 12V E14 10U/25V C22104 VCC_RTC D7 1N4148 R56 NC R57 NC UART_A_TXUART_A_RX MCU_TXDMCU_RXD VCC3.3V R109 10K R110 10K MCU5V R111 2.2R E28 47U/16V C4 104 C6 104 C75 104 GND V5V L11FB DVDD E9 10U/25V C37104 C38104 C39104 MAD11POWER&MCU A3 FORM A 4 3 2 1 AB CD 12 3 4 D CB All rights reserved. Reproduction in whole or in part is prohibited without any written consent of the copyright owner. AUTOPRO 5 EF EF 5 GND 1 GND 2 GND 3 GND 5 GND 4 GND 6 GND 7 GND 8 GND 9 GND 10 GND 11 G/Y/Y 12 R/Cr/Pr 13 B/Cb/Pb 14 CVBS 15 GND 16 AUDIO OUT L 17 AUDIO OUT R 18 GND 19 HPL 20 HPR 21 GND 22 MIC_BIAS 23 HP_MIC- 24 HP_MIC+ 25 MIC1N 26 MIC1P 27 GND 28 SD_D0_B 29 SD_D1_B 30 SD_D2_B 31 SD_D3_B 32 SD_CLK_B 33 GND 34 SD_CMD_B 35 CARD_DET 36 CARD_EN 37 UART_A_TX 38 UART_A_RX 39 UART_B_TX 40 UART_B_BX 41 I2C_SDA_A 42 I2C_SCK_A 43 I2C_SDA_B 44 I2C_SCK_B 45 RMII_RX_ERR 46 CLK50M 47 GND 48 RMII_CRS_DV 49 RMII_RXD1 50 RMII_RXD0 51 GND 52 RMII_TXEN 53 RMII_TXD1 54 RMII_TXD0 55 RMII_MDC 56 RMII_MDIO 57 CMDATA0 58 CMDATA1 59 CMDATA2 60 CMDATA3 61 CMDATA4 62 CMDATA5 63 CMDATA6 64 CMDATA7 65 CMHREF 66 CMVREF 67 CM_RST# 68 CMPCLK 69 GND 70 CMMCLK 71 GND 72 FEC_D0_A 73 FEC_D1_A 74 FEC_D2_A 75 FEC_D3_A 76 FEC_D4_A 77 FEC_D5_A 78 FEC_D6_A 79 FEC_D7_A 80 FEC_CLK_A 81 GND 82 FEC_SYNC_A 83 FEC_VALID_A 84 CM_PWDN2 85 CM_PWDN1 86 TOUCH_INT 87 HP_DET 88 DC_DET 89 CHGLED 90 GSEN_INT 91 LCD_PWR_EN# 92 GND 93 LCD_R2 94 LCD_R3 95 LCD_R4 96 LCD_R5 97 LCD_R6 98 LCD_R7 99 LCD_G2 100 LCD_G3 101 LCD_G4 102 LCD_G5 103 LCD_G6 104 LCD_G7 105 LCD_B2 106 LCD_B3 107 LCD_B4 108 LCD_B5 109 LCD_B6 110 LCD_B7 111 TCON_STH 112 TCON_STV 113 OEH 114 LCD_CLK 115 GND 116 XI 117 XO 118 CAP_TP_EN 119 SPK_MUTE 120 GPS_RSTN/COAXIAL 121 WIFI/BT_EN 122 USB_PWR_CTL 123 PWR_HOLD 124 PWR_KEY_DET 125 VCC_RTC 126 IR/MLCR 127 RESET_CPU 128 ID1 129 VBUS1 130 GND 131 DM1 132 DP1 133 GND 134 VBUS2 135 DM2 136 DP2 137 GND 138 BL_EN 139 BL_ADJ 140 GND 141 ADC_X+ 142 ADC_Y+ 143 ADC_X- 144 ADC_Y- 145 ADC_KEY 146 VBAT_DET 147 GND 148 LVDS_3P 149 LVDS_3N 150 LVDS_CKP 151 LVDS_CKN 152 LVDS_2P 153 LVDS_2N 154 LVDS_1P 155 LVDS_1N 156 LVDS_0P 157 LVDS_0N 158 HDMI_HPD 159 HDMI_SDA 160 HDMI_SCL 161 HDMI_CEC 162 GND 163 TXC- 164 TXC+ 165 TX0- 166 TX0+ 167 TX1- 168 TX1+ 169 TX2- 170 TX2+ 171 GND 172 PWR_EN 173 VCCX 174 VCCX 175 VCCX 176 VCCX 177 VCCX 178 VCCX 179 AM1 AM8726M3PCBA_1 GND ADC_KEYVBAT_DETHDMI_HPDHDMI_SDAHDMI_SCLHDMI_CECTXC-TXC+TX0-TX0+TX1+TX1-TX2-TX2+ AM_5V PWR_EN G/Y/Y R/Cr/Pr R/Cb/Cr CVBS AUD_OUTL AUD_OUTR SD_D0_B SD_D1_B SD_D2_B SD_D3_B SD_CLK_B SD_CMD_B CARD_DET CARD_EN UART_A_TX UART_A_RX I2C_SDA_A I2C_SCK_A HP_DETDC_DET SPK_MUTE IR_OUT AML_RESET ID1 VBUS1 DM1 DP1 VBUS2 DM2 DP2 R77 2.2K AM_5V VBUS2 R80 100R AML RESET AML_RESET CD/DAT3 1 CMD 2 VSS 3 VDD 4 CLK 5 VSS 6 DAT0 7 DAT1 8 DAT2 9 CD CD WP WP GND_1GND_2 JACK1 SD_PUSH_1 GND SD_D0_BSD_D1_BSD_D2_BSD_D3_BSD_CMD_B SD_CLK_B CARD_DET R58 22R SD_CLK R90 47K R9 NC CARD_EN VCC3.3V R8 NC 2 3 1 Q5 AO3401 C49105 CARD_3V3 R76 2.2K VBUS1 R62 10K GND DM1DP1 R84 0R R83 0R L7 FB +5V C35 104 E18 10U/25V 432156 USB1USB GND D1-D1+ R7 NC R66 10K VCC_RTC R85 100K R86 100K GND VCC3.3V R65 10K R63 10K R64 10K GND VCC3.3V R82 0R R6 NC ID1 GND D81N4148 MUTE R1 NC WIFI/BT_EN HDMI_SPDIF MAD11ADROID MODE Y3 24M A3 FORM A 4 3 2 1 AB CD 12 3 4 D CB All rights reserved. Reproduction in whole or in part is prohibited without any written consent of the copyright owner. AUTOPRO 5 EF EF 5 R301KR291K LOUTROUT E19 10U/25V R69 10K R68 10K GND C69 102 C68 102 R97 3.9K +- 56 7 84 U9B 4558 +- 32 1 84 U9A4558 R96 18K C56 100P R983.9K C55 100P R95 18K -5VA Q109015 R88 100K VCC5V E11 47U/16V R2620K GND D91N4148 D101N4148 E10 47U/16V GND Q99014 R31 1K Q8 9014 R32 1K GND MUTE GND R87100K C70 10P GND R89100K C71 10P V5V R7010K -5VAV5V R99 NC GND AUD_OUTRAUD_OUTL MUTE_ON Q79014 R42 4.7K Q119015 R36 220R R37 220R…

Text truncated - open the document above for the full version.

Note: This test report is prepared for the customer shown above and for the device described herein. It may not be duplicated or used in part without prior written consent from Bay Area Compliance Laboratories Corp. This report must not be used by the customer to claim product certification, approval, or endorsement by NVLAP*, or any agency of the Federal Government. * This report may contain data that are not covered by the NVLAP accreditation and shall be marked with an asterisk “★” (Rev.2) FCC PART 15.247 TEST REPORT For Shen Zhen Autopro Technology CO., LTD BLDG H2, Area A, HongFa Technology Industrial Zone, ShiYan Town, BaoAn District, ShenZhen, Guangdong, China Report Type: Original Report Product Type: Android Box Test En gineer: Ares Liu Re port Number: R2DG130201005-00A Re port Date: 2013-03-25 Reviewed By: Ivan Cao RF Leader Test Laboratory: Bay Area Compliance Laboratories Corp. (Dongguan) No.69 Pulongcun, Puxinhu Industrial Zone, Tangxia, Dongguan, Guangdong, China Tel: +86-769-86858888 Fax: +86-769-86858891 www.baclcorp.com.cn FCC ID: VUDAUTOPRO2013 Bay Area Compliance Laboratories Corp. (Dongguan) Report No.: R2DG130201005-00A FCC Part 15.247 Page 2 of 52 TABLE OF CONTENTS GENERAL INFORMATION ....................................................................................................................................... 4 PRODUCT DESCRIPTION FOR EQUIPMENT UNDER TEST (EUT) ..................................................................................... 4 OBJECTIVE ................................................................................................................................................................... 4 RELATED SUBMITTAL(S)/GRANT(S) ............................................................................................................................. 4 TEST METHODOLOGY .................................................................................................................................................. 4 TEST FACILITY ............................................................................................................................................................. 5 SYSTEM TEST CONFIGURATION .......................................................................................................................... 6 DESCRIPTION OF TEST CONFIGURATION ...................................................................................................................... 6 EUT EXERCISE SOFTWARE .......................................................................................................................................... 6 EQUIPMENT MODIFICATIONS ....................................................................................................................................... 6 SUPPORT EQUIPMENT LIST AND DETAILS .................................................................................................................... 7 EXTERNAL CABLE ........................................................................................................................................................ 7 BLOCK DIAGRAM OF TEST SETUP ................................................................................................................................ 7 SUMMARY OF TEST RESULTS ............................................................................................................................... 8 FCC §15.247 (i) & §1.1307 (b) (1) & §2.1091- MAXIMUM PERMISSIBLE EXPOSURE (MPE) .............................. 9 APPLICABLE STANDARD .............................................................................................................................................. 9 FCC §15.203 - ANTENNA REQUIREMENT ........................................................................................................... 10 APPLICABLE STANDARD ............................................................................................................................................ 10 ANTENNA CONNECTOR CONSTRUCTION .................................................................................................................... 10 FCC §15.209, §15.205 & §15.247(d) - SPURIOUS EMISSIONS ............................................................................. 11 APPLICABLE STANDARD ............................................................................................................................................ 11 MEASUREMENT UNCERTAINTY .................................................................................................................................. 11 EUT SETUP ................................................................................................................................................................ 11 EMI TEST RECEIVER & SPECTRUM ANALYZER SETUP .............................................................................................. 12 TEST PROCEDURE ...................................................................................................................................................... 12 CORRECTED AMPLITUDE & MARGIN CALCULATION ................................................................................................. 13 TEST EQUIPMENT LIST AND DETAILS ......................................................................................................................... 13 TEST RESULTS SUMMARY .......................................................................................................................................... 13 TEST DATA ................................................................................................................................................................ 13 FCC §15.247(a) (2) – 6 dB EMISSION BANDWIDTH ............................................................................................ 24 APPLICABLE STANDARD .............................................................................…

Text truncated - open the document above for the full version.

EXHIBIT C - TEST SETUP PHOTOGRAPHS Radiated Emissions Below 1G –Front View Radiated Emissions Below 1G ---Rear View Radiated Emissions Above 1G –Front View Radiated Emissions Above 1G –Rear View