WAZSKE13401Keyless System LFU

【 Confidential 】 The following contents are described in Owners Manual of the vehicle. In Canada, it is described in English and French. FCC WARNING Changes or modifications not expressly approved by the party responsible for compliance could void the user’s authority to operate the equipment. FCC/IC This device complies with Part 15 of FCC Rules and Industry Canada licence-exempt RSS standard(s). Operation is subject to the following two conditions: (1) this device may not cause interference, and (2) this device must accept any interference, including interference that may cause undesired operation of this device. Le présent appareil est conforme aux la Partie 15 des règles de la FCC et CNR d'Industrie Canada applicables aux appareils radio exempts de licence. L'exploitation est autorisée aux deux conditions suivantes: (1) l'appareil ne doit pas produire de brouillage, et (2) l'utilisateur de l'appareil doit accepter tout brouillage radioélectrique subi, même si le brouillage est susceptible d'en compromettre le fonctionnement. Users manual FCC&IC.xls

【 Confidential 】 LF Antenna － A/B TOP RIGHT LEFT FACE BACK BOTTOM Keyless System (LF Antenna) PHOTO_6_LF Antenna-A&B(Handle).xls

【 Confidential 】 LF Antenna － C ～ F TOP LEFT FACE RIGHT BACK BOTTOM Keyless System (LF Antenna) PHOTO_6_LF Antenna-C～F.xls

【 Confidential 】 Model ： SKE134-01 FACE LEFT TOP RIGHT BOTTOM BACK Keyless System (LFU) PHOTO_6_LFU_SKE13401.xls

【 Confidenrial 】 Model ： SKE134-01 Label display * ＊ There is no sufficient space and this product will be installed in the vehicle, therefore labelling requirement will be described in the users manual. Keyless System LFU Label Label FCC ID：W AZSKE13401 IC ：662F-SKE13401 Mode l：SKE134-01 MITSUBISHI ELECTRIC CORPORATION Label_LFU_SKE13401_fcc.xls

【 Confidential 】 LF Antenna －A/B Keyless System (LF Antenna) PHOTO_PCB_ASSY_LF Antenna-A&B(Handle).xls

【 Confidential 】 LF Antenna － C ～ F FACE BACK Keyless System (LF Antenna) PHOTO_PCB_ASSY_LF Antenna-C～F.xls

【 Confidential 】 PHOTO_PCB_ASSY_LFU_SKE13401.xls Model ： SKE134-01 FACE BACK Keyless System (LFU)

Test report No. : 31BE0219-HO-04-A-R1 Page : 2 of 26 Issued date : March 22, 2011 Revised date : March 29, 2011 FCC ID : WAZSKE13401 UL Japan, Inc. Head Office EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8116 Facsimile : +81 596 24 8124 CONTENTS PAGE SECTION 1: Customer information ..................................................................................................... 3 SECTION 2: Equipment under test (E.U.T.) ........................................................................................ 3 SECTION 3: Test specification, procedures & results ........................................................................ 4 SECTION 4: Operation of E.U.T. during testing ................................................................................. 7 SECTION 5: Radiated emission (Fundamental and Spurious Emission) .......................................... 9 SECTION 6: -26dB Bandwidth ............................................................................................................ 11 SECTION 7: 99% Occupied Bandwidth ............................................................................................. 11 APPENDIX 1: Photographs of test setup ............................................................................................ 12 Radiated Emission ............................................................................................................................. 12 Worst Case Position .......................................................................................................................... 14 APPENDIX 2: Data of EMI test........................................................................................................... 17 Radiated Emission below 30MHz (Fundamental and Spurious Emission) ................................. 17 -26dB Bandwidth and 99% Occupied Bandwidth ......................................................................... 23 APPENDIX 3: Test instruments .......................................................................................................... 26 Test report No. : 31BE0219-HO-04-A-R1 Page : 3 of 26 Issued date : March 22, 2011 Revised date : March 29, 2011 FCC ID : WAZSKE13401 UL Japan, Inc. Head Office EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8116 Facsimile : +81 596 24 8124 SECTION 1: Customer information Company Name : Mitsubishi Electric Corporation Himeji works Address : 840 Chiyoda-machi Himeji Hyogo, 670-8677, Japan Telephone Number : +81-79-298-8994 Facsimile Number : +81-79-298-9929 Contact Person : Toshio Koga SECTION 2: Equipment under test (E.U.T.) 2.1 Identification of E.U.T. Type of Equipment : Keyless System LFU Model No. : SKE134-01 Serial No. : Refer to Clause 4.2 Rating : DC 12.0V Receipt Date of Sample : February 1, 2011 Country of Mass-production : Japan Condition of EUT : Production prototype (Not for Sale: This sample is equivalent to mass-produced items.) Modification of EUT : No Modification by the test lab 2.2 Product Description Model No: SKE134-01 (referred to as the EUT in this report) is the Keyless System LFU. Feature of EUT The Keyless Entry System installed in vehicles. The lock or unlock of the door push the switch on the door, the transmitter starts communication between LF control unit(LFU) and a receiver and opens and closes the key of the door, and the engine start is possible. It can also lock or unlock the doors by operating the button on the transmitter. General Specification Clock frequency in the system : (CPU) 16MHz, (LF IC) 8MHz Radio Specification Radio Type : Transmitter Frequency of Operation : 125kHz Modulation : ASK Method of Frequency Genenration : Crystal Antenna type : Inductive Duty Cycle : Very Low Operating temperature range : -40 to +85 deg. C Test report No. : 31BE0219-HO-04-A-R1 Page : 4 of 26 Issued date : March 22, 2011 Revised date : March 29, 2011 FCC ID : WAZSKE13401 UL Japan, Inc. Head Office EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8116 Facsimile : +81 596 24 8124 SECTION 3: Test specification, procedures & results 3.1 Test Specification Test Specification : FCC Part 15 Subpart C: 2010, final revised on December 6, 2010 and effective January 5, 2011 Title : FCC 47CFR Part15 Radio Frequency Device Subpart C Intentional Radiators Section 15.209 Radiated emission limits, general requirements Test report No. : 31BE0219-HO-04-A-R1 Page : 5 of 26 Issued date : March 22, 2011 Revised date : March 29, 2011 FCC ID : WAZSKE13401 UL Japan, Inc. Head Office EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8116 Facsimile : +81 596 24 8124 3.2 Procedures and results No. Item Test Procedure Specification RemarksDeviation Worst marginResults 1 Conducted Emission <FCC> ANSI C63.4:2003 7. AC powerline conducted emission measurements <IC> RSS-Gen 7.2.4 <FCC> Section 15.207 <IC> RSS-Gen 7.2.4 - N/A *1) N/A N/A 2 Electric Field Strength of Fundamental Emission <FCC> ANSI C63.4:2003 13. Measurement of intentional radiators <IC> RSS-Gen 4.8, 4.11 <FCC> Section 15.209 <IC> RSS-210 2.5.1 RSS-Gen 7.2.5 Radiated N/A 10.7dB 0.12500MHz, AV (Antenna A) Complied 3 Electric Field Strength of Spurious Emission <FCC> ANSI C63.4:2003 13. Measurement of intentional radiators <IC> RSS-Gen 4.9, 4.11 <FCC> Section 15.209 <IC> RSS-210 2.5.1 RSS-Gen 7.2.5 Radiated N/A 18.6dB 208.421MHz, QP, Vertical (Antenna F) Complied 4 -26dB Bandwidth <FCC> ANSI C63.4:2003 13. Measurement of intentional radiators <IC> - <FCC> Reference data <IC> - Radiated N/A N/A N/A Note: UL Japan, Inc.’s EMI Work Procedures No.QPM05 and QPM15. *1) The test is not applicable since the EUT is not the device that is designed to be connected to the public utility (AC) power line. FCC 15.31 (e) This test was performed with the New Battery (DC 12.0V) and the constant voltage was supplied to this EUT during the tests. Therefore, this EUT c…

Text truncated - open the document above for the full version.

Test report No. : 31BE0219-HO-04-A-R1 Page : 17 of 26 Issued date : March 22, 2011 Revised date : March 29, 2011 FCC ID : WAZSKE13401 UL Japan, Inc. Head Office EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8116 Facsimile : +81 596 24 8124 APPENDIX 2: Data of EMI test Radiated Emission below 30MHz (Fundamental and Spurious Emission) Antenna A DATA OF RADIATED EMISSION TEST UL Japan, Inc. Head Office EMC Lab. No.4 Semi Anechoic Chamber Date : 2011/02/02 Company : MITSUBISHI ELECTRIC CORPORATION HIME Report No. : 31BE0219-HO-04 Kind of EUT : Keyless System(LFU) Power : DC 3.0V Model No. : SKE134-01 Temp./ Humi. : 21deg. C. /31% Serial No. : 001 Engineer : Kazuya Yoshioka Mode / Remarks : Tx 125kHz AntennaA Worst Axis(ECU:X-axis Antenna:X-axis) LIMIT : FCC15.209(a) 3m, 9-90kHz:PK, 110-490kHz:PK, other:QP FCC15.209(a) 3m, 9-90kHz:AV, 110-490kHz:AV, other:QP CHART: WITH FACTOR , ANT TYPE: LOOP , Except for the data below : adequate margin data below the limits. CALCULATION : RESULT[dBuV] = READING[dBuV] + ANT FACTOR[dB] + LOSS[dB]( CABLE + ATTEN.- AMP.) Frequency[Hz] [dBuV/m]<< QP/AV/PEAK DATA >> 90 deg:C 45 deg:B 0 deg:A 30M.01M.02M.03M.05M.07M.1M.2M.3M.5M.7M1M2M3M5M7M10M20M 0 10 20 30 40 50 60 70 80 90 100 110 120 130 140 150 Freq.Reading DET Ant.FacLossGainResultLimitMarginAntennaTable Comment Freq.Reading DET Ant.FacLossGainResultLimitMarginAntennaTable Comment [MHz][dBuV] DET [dB/m][dB][dB][dBuV/m][dBuV/m][dB][deg][deg] Comment 0.12500112.1PEAK20.15.932.1106.0125.719.745B335 0.12500108.1PEAK20.15.932.1102.0125.723.790C282 0.12500112.9PEAK20.15.932.1106.8125.718.90A359Worst 0.12500112.1PEAK20.15.932.1106.0125.719.7135A28 0.12500100.4AV20.15.932.194.3105.711.4135A28 0.1250096.3AV20.15.932.190.2105.715.590C282 0.12500100.3AV20.15.932.194.2105.711.545B335 0.12500101.1AV20.15.932.195.0105.710.70A359Worst 0.12500104.9PEAK20.15.932.198.8125.726.90A359Hori 0.1250093.2AV20.15.932.187.1105.718.60A359Hori 0.2506129.4PEAK20.06.00.055.4119.664.20A359 0.2506110.8AV20.06.00.036.899.662.80A359 0.3757425.5PEAK19.96.00.051.4116.164.70A359 0.375744.6AV19.96.00.030.596.165.60A359 0.5009815.4QP19.96.00.041.373.632.30A359 0.626199.3QP19.96.00.035.271.736.50A359 0.750001.8QP19.96.00.027.770.142.40A358 1.000001.1QP19.96.00.027.067.640.60A359 1.125000.9QP19.96.10.026.966.539.60A357 1.250001.0QP19.96.10.027.065.638.60A359 *The limit is rounded down to one decimal place. *The test result is rounded off to one or two decimal places, so some differences might be observed. RH Test report No. : 31BE0219-HO-04-A-R1 Page : 18 of 26 Issued date : March 22, 2011 Revised date : March 29, 2011 FCC ID : WAZSKE13401 UL Japan, Inc. Head Office EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8116 Facsimile : +81 596 24 8124 Radiated Emission above 30MHz (Spurious Emission) Antenna A DATA OF RADIATED EMISSION TEST UL Japan, Inc. Head Office EMC Lab. No.4 Semi Anechoic Chamber Date : 2011/02/03 Company : MITSUBISHI ELECTRIC CORPORATION HIME Report No. : 31BE0219-HO-04 Kind of EUT : Keyless System (LFU) Power : DC 3.0V Model No. : SKE134-01 Temp. / Humi. : 24deg.C / 34% Serial No. : 001 Engineer : Hiroyuki Furutaka Mode / Remarks : Tx 125kHz AntA Worst Axis(ECU Hori:Y Vert:Y , Ant Hori:Z, Vert:Z) LIMIT : FCC15.209 3m, below 1GHz:QP, above 1GHz:PK All other spurious emissions were less than 20dB for the limit. CHART:WITH FACTOR ANT TYPE: -30MHz:LOOP, 30-300MHz:BICONICAL, 300MHz-1000MHz:LOGPERIODIC, 1000MHz-:HORN CALCULATION:RESULT = READING + ANT FACTOR + LOSS(CABLE+ATTEN.) - GAIN(AMP) Frequency[Hz] [dBuV/m]<< QP DATA >> Horizontal Vertical Horizontal Vertical 30M1G50M70M100M200M300M500M700M 0 10 20 30 40 50 60 70 80 FrequencyReading DET AntennaLoss& LevelAngleHeight Polar. LimitMargin Comment FrequencyReading DETFactorGain LevelAngleHeight Polar. LimitMargin Comment [MHz][dBuV] DET [dB/m][dB][dBuV/m][Deg][cm] Polar. [dBuV/m][dB] Comment 128.26130.1QP13.7-23.620.21100Vert.43.523.3 128.26129.7QP13.7-23.619.8148243Hori.43.523.7 144.29426.0QP14.8-23.517.3118223Hori.43.526.2 176.36128.7QP16.0-23.221.5184100Vert.43.522.0 200.40829.5QP16.7-23.023.2201100Vert.43.520.3 200.40924.5QP16.7-23.018.227249Hori.43.525.3 208.42326.7QP16.8-22.920.640236Hori.43.522.9 208.42329.5QP16.8-22.923.4195100Vert.43.520.1 216.43626.7QP16.9-22.920.730226Hori.46.025.3 216.43930.2QP16.9-22.924.2357100Vert.46.021.8 224.45728.4QP17.0-22.822.63100Vert.46.023.4 224.45726.2QP17.0-22.820.4306224Hori.46.025.6 *The limit is rounded down to one decimal place. *The test result is rounded off to one or two decimal places, so some differences might be observed. Antenna A Worst Axis (ECU Hori: Y Vert: Y, Ant Hori: Z, Vert: Z) RH Test report No. : 31BE0219-HO-04-A-R1 Page : 19 of 26 Issued date : March 22, 2011 Revised date : March 29, 2011 FCC ID : WAZSKE13401 UL Japan, Inc. Head Office EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8116 Facsimile : +81 596 24 8124 Radiated Emission below 30MHz (Spurious Emission) Antenna C DATA OF RADIATED EMISSION TEST UL Japan, Inc. Head Office EMC Lab. No.4 Semi Anechoic Chamber Date : 2011/02/02 Company : MITSUBISHI ELECTRIC CORPORATION HIME Report No. : 31BE0219-HO-04 Kind of EUT : Keyless System(LFU) Power : DC 3.0V Model No. : SKE134-01 Temp./ Humi. : 21deg. C. /31% Serial No. : 001 Engineer : Kazuya Yoshioka Mode / Remarks : Tx 125kHz AntennaC Worst Axis(ECU:X-axis Antenna:X-axis) LIMIT : FCC15.209(a) 3m, 9-90kHz:PK, 110-490kHz:PK, other:QP FCC15.209(a) 3m, 9-90kHz:AV, 110-490kHz:AV, other:QP CHART: WITH FACTOR , ANT TYPE: LOOP , Except for the data below : adequate margin data below the limits. CALCULATION : RESULT[dBuV] = READING[dBuV] + ANT FACTOR[dB] + LOSS[dB]( CABLE + ATTEN.- AMP.) Frequency[Hz] [dBuV/m]<< QP/AV/PEAK DATA >> 90 deg:C 45 deg:B 0 deg:A 30M.01M.02M.03M.05M.07M.1M.2M.3M.5M.7M1M2M3M5M7M10M20M 0 10 20 30 40 50 60 70 80 90 100 110 120 130 140 150 Freq.Reading DET Ant.FacLossGainResultLimitMarginAntennaTable …

Text truncated - open the document above for the full version.

Test report No. : 31BE0219-HO-04-A-R1 Page : 12 of 26 Issued date : March 22, 2011 Revised date : March 29, 2011 FCC ID : WAZSKE13401 UL Japan, Inc. Head Office EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8116 Facsimile : +81 596 24 8124 APPENDIX 1: Photographs of test setup Radiated Emission Antenna A Photo 1 Photo 2 Test report No. : 31BE0219-HO-04-A-R1 Page : 13 of 26 Issued date : March 22, 2011 Revised date : March 29, 2011 FCC ID : WAZSKE13401 UL Japan, Inc. Head Office EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8116 Facsimile : +81 596 24 8124 Radiated Emission Antenna C and F Photo 1 Photo 2 Test report No. : 31BE0219-HO-04-A-R1 Page : 14 of 26 Issued date : March 22, 2011 Revised date : March 29, 2011 FCC ID : WAZSKE13401 UL Japan, Inc. Head Office EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8116 Facsimile : +81 596 24 8124 Worst Case Position Antenna A Below 30MHz:X-axis Above 30MHz(Hori:Z-axis /Vert:Z-axis) Antenna C Below 30MHz:X-axis Above 30MHz(Hori:X-axis /Vert:X-axis) X-axis X-axis Y-axis Y-axis Z-axis Z-axis Test report No. : 31BE0219-HO-04-A-R1 Page : 15 of 26 Issued date : March 22, 2011 Revised date : March 29, 2011 FCC ID : WAZSKE13401 UL Japan, Inc. Head Office EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8116 Facsimile : +81 596 24 8124 Worst Case Position Antenna F Below 30MHz:X-axis Above 30MHz(Hori:Z-axis /Vert:Z-axis) ECU Below 30MHz:X-axis Above 30MHz(Hori:Y-axis /Vert:Y-axis) X-axis X-axis Y-axis Y-axis Z-axis Z-axis Test report No. : 31BE0219-HO-04-A-R1 Page : 16 of 26 Issued date : March 22, 2011 Revised date : March 29, 2011 FCC ID : WAZSKE13401 UL Japan, Inc. Head Office EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8116 Facsimile : +81 596 24 8124 4.2 Configuration and peripherals * Cabling and setup were taken into consideration and test data was taken under worse case conditions. Description of EUT and Support equipment No. Item Model number Serial number Manufacturer Remarks A Keyless System LFU SKE134-01 20110131-L1 Mitsubishi Electric Corporation Himeji works EUT B LF Antenna - Ant A - EUT C LF Antenna - Ant B - EUT D LF Antenna - Ant C Mitsubishi Electric Corporation Himeji works EUT E LF Antenna - Ant D Mitsubishi Electric Corporation Himeji works EUT F LF Antenna - Ant E Mitsubishi Electric Corporation Himeji works EUT G LF Antenna - Ant F Mitsubishi Electric Corporation Himeji works EUT H SW Box 1 - - Mitsubishi Electric Corporation Himeji works - List of cables used No. Name Length (m) Shield Remark Cable Connector 1 Antenna Cable 1.5 Unshielded Unshielded - 2 Antenna Cable 1.5 Unshielded Unshielded - 3 Antenna Cable 1.3 Unshielded Unshielded - 4 Antenna Cable 1.3 Unshielded Unshielded - 5 Antenna Cable 1.3 Unshielded Unshielded - 6 Antenna Cable 1.3 Unshielded Unshielded - 7 Signal Cable 0.9 Unshielded Unshielded - 8 DC Cable 1.3 Unshielded Unshielded - A DC12.0V C B D E F G H 7 6 5 1 2 3 4 8