XFU-18531002Essential Insight.mesh, wSIM and Repeater

Part Number 185302-01 Rev. D (04/12) Bently Nevada* Asset Condition Monitoring Installation and Maintenance Essential Insight.mesh * Wireless System Essential Insight.mesh Installation and Maintenance Manual ii © 2009-2012 Bently Nevada, Inc. All rights reserved. The information contained in this document is subject to change without notice. * Denotes trademark of Bently Nevada, Inc., a wholly owned subsidiary of General Electric Company. Bently Nevada, Essential Insight.mesh, System 1, Trendmaster, wSIM The following are trademarks of the legal entities cited: Unistrut ® is a registered trademark of Unistrut International Corporation in the United States and/or other countries. Printed in USA. Uncontrolled when transmitted electronically Contact Information The following contact information is provided for those times when the local representative cannot be contacted: Mailing Address 1631 Bently Parkway South Minden, Nevada USA 89423 USA Telephone 1.775.782.3611 1.800.227.5514 Fax 1.775.215.2873 Internet http://www.ge-msc.com/bently Essential Insight.mesh Installation and Maintenance Manual iii Additional Information Notice: This manual does not contain all the information required to operate and maintain the product. Refer to the following manuals for other required information. 200150, 200155, and 200157 Accelerometer Installation Guide (Part Number 164985-01) 200125 Trendmaster* 2000 Thermocouple (Part Number 149558-01) ISA100 Gateway Manufacturer Manual (as applicable) Product Disposal Statement Customers and third parties, who are not member states of the European Union, who are in control of the product at the end of its life or at the end of its use, are solely responsible for the proper disposal of the product. No person, firm, corporation, association or agency that is in control of product shall dispose of it in a manner that is in violation of any applicable federal, state, local or international law. Bently Nevada, Inc. is not responsible for the disposal of the product at the end of its life or at the end of its use. Essential Insight.mesh Installation and Maintenance Manual iv Contents 1. Introduction ...................................................... 7 2. Components ...................................................... 9 2.1 Wireless Sensor Interface Module Devices (wSIM Devices) ......................................................................................................... 9 2.2 Repeater ...................................................................................... 13 2.3 Manager Gateway .................................................................. 16 2.3.1 ISA100 Gateway ............................................................ 16 2.3.2 BN Protocol Manager Gateway .............................. 17 2.4 Power Modules ......................................................................... 20 2.4.1 Battery Power Modules .............................................. 20 2.4.2 External Power Module for Safe Areas ............... 22 2.5 Energy Harvesters .................................................................. 23 2.5.1 Vibration Energy Harvesters .................................... 23 2.6 Transducers ............................................................................... 24 2.7 Cables and Connectors ........................................................ 25 2.8 Mounting Hardware .............................................................. 26 3. Planning Network Installation .................... 29 3.1 Designing the Layout ............................................................ 33 4. Commissioning/Provisioning ...................... 35 4.1 Commissioning BN Protocol Devices ............................. 35 4.1.1 Attach Power Modules to wSIM Devices and Repeaters .............................................................................................. 35 4.1.2 Setup the Manager Gateway .................................. 36 4.1.3 Configure the Network ID ......................................... 38 4.1.4 Configure the Join Key ............................................... 39 4.1.5 Commission wSIM Devices and Repeaters ....... 40 4.1.6 Verify Operation ............................................................. 43 4.2 Provisioning ISA100 Devices .............................................. 43 Essential Insight.mesh Installation and Maintenance Manual v 5. Installing Hardware ...................................... 45 5.1 Installing the Manager Gateway ..................................... 45 5.1.1 Rack-Mount Manager Gateway ............................ 46 5.1.2 ISA100 Manager Gateway ........................................ 47 5.2 Installing a wSIM Device or Repeater ............................ 48 5.2.1 Choosing a Mounting Location .............................. 48 5.2.2 Mount a wSIM Device or Repeater ....................... 50 5.2.3 Mount a node to a Hex Mounting Base ............. 54 5.2.4 Connecting Transducers to wSIM Devices ....... 55 5.2.5 Transducer Field Termination ................................. 56 5.3 Installing a Vibration Energy Harvester ....................... 57 5.3.1 Finding the Right Location ....................................... 57 5.3.2 Mounting a Vibration Energy Harvester ............ 58 5.3.3 Connecting to a wSIM Device or Repeater ....... 58 6. Configuring Essential Insight.mesh in System 1 Software ................................................... 61 6.1 Configure the Plant Network ............................................. 61 6.1.1 BN Protocol ...................................................................... 61 6.1.2 ISA100 Protocol ............................................................. 62 6.2 Configure Essential Insight.mesh Network ................. 62 6.3 Data collection considerations ......................................... 64 6.3.1 Static Data ....................................................................... 64 6.3.2 Fast Static Data .................…

Text truncated - open the document above for the full version.

This report contains a total of 67 pages and may be reproduced in full only. Partial reproduction may only be done with the written consent of CKC Laboratories, Inc. Bently Nevada, Inc. ADDENDUM TEST REPORT TO 92362-12B EI.mesh Repeater, 185350-01 EI.mesh wSIM, 185310-01 Tested To The Following Standards: FCC Part 15 Subpart C Sections 15.207, 15.247 and RSS 210 Issue 8 Report No.: 92362-12C Date of issue: July 13, 2012 This test report bears the accreditation symbol indicating that the testing performed herein meets the test and reporting requirements of ISO/IEC 17025 under the applicable scope of EMC testing for CKC Laboratories, Inc. We strive to create long-term, trust based relationships by providing sound, adaptive, customer first testing services. We embrace each of our customers’ unique EMC challenges, not as an interruption to set processes, but rather as the reason we are in business. Page 2 of 67 Report No.: 92362-12C TABLE OF CONTENTS Administrative Information .......................................................................................................................... 3 Test Report Information ............................................................................................................................................ 3 Revision History ......................................................................................................................................................... 3 Report Authorization ................................................................................................................................................. 3 Test Facility Information ............................................................................................................................................ 4 Site Registration & Accreditation Information .......................................................................................................... 4 Summary of Results ................................................................................................................................................... 5 Conditions During Testing.......................................................................................................................................... 5 Equipment Under Test ............................................................................................................................................... 6 Peripheral Devices ..................................................................................................................................................... 6 FCC Part 15 Subpart C ................................................................................................................................... 7 15.207 AC Conducted Emissions ................................................................................................................................ 7 15.209 Radiated Emissions ...................................................................................................................................... 15 15.247(b) RF Power Output ..................................................................................................................................... 32 -6dB Occupied Bandwidth ....................................................................................................................................... 38 15.247(d) Bandedge ................................................................................................................................................ 44 15.247(e) Power Spectral Density ........................................................................................................................... 52 RSS-210 ....................................................................................................................................................... 59 99 % Bandwidth ....................................................................................................................................................... 59 Supplemental Information .......................................................................................................................... 66 Measurement Uncertainty ...................................................................................................................................... 66 Emissions Test Details .............................................................................................................................................. 66 Page 3 of 67 Report No.: 92362-12C ADMINISTRATIVE INFORMATION Test Report Information REPORT PREPARED FOR: REPORT PREPARED BY: Bently Nevada, Inc. 1631 Bently Parkway South Minden, NV 89423 Joyce Walker CKC Laboratories, Inc. 5046 Sierra Pines Drive Mariposa, CA 95338 Representative: Dwayne Folden Project Number: 92362 Customer Reference Number: 1010054595 DATE OF EQUIPMENT RECEIPT: October 12, 2011 DATE(S) OF TESTING: October 12-September 29, 2011 Revision History Original: Testing of the EI.mesh Repeater, 185350-01 & EI.mesh wSIM, 185310-01 to FCC Part 15 Subpart C Sections 15.207, 15.247 and RSS 210 Issue 8. Addendum A: To correct the RF Power Output results. Addendum B: To include a statement to the RF Power Output section concerning 15.31(e) requirements. Addendum C: Spurious emissions (15.209) data sheets, Bandedge and PSD data sheets were replaced with corrected data sheets. Report Authorization The test data contained in this report documents the observed testing parameters pertaining to and are relevant for only the sample equipment tested in the agreed upon operational mode(s) and configuration(s) as identified herein. Compliance assessment remains the client’s responsibility. This report may not be used to claim product endorsement by A2LA or any government agencies. This test report has been authorized for release under quality control from CKC Laboratories, Inc. Steve Behm Director of Quality Ass…

Text truncated - open the document above for the full version.

REPEATER LOW FREQUENCY REPEATER LOW FREQUENCY REPEATER HIGH FREQUENCY REPEATER HIGH FREQUENCY WSIM LOW FREQUENCY WSIM LOW FREQUENCY WSIM HIGH FREQUENCY WSIM HIGH FREQUENCY WSIM HIGH FREQUENCY