YGD-G2216CAR MEDIA PLAYER

1 2 3 4 56 ABCD 6 5 4 3 2 1 D CBA MCU(PANASONIC) TFT DRIVER MST776 7'' HANNSTAR TFT(60PIN interface) 7'' TOUCH SCREEN 128M FLASH (MX12845) (HY1262) 128M SDRAM 24C16 EEPROM 1.8V3.3V 5V TXDRXD BLUE TOOTH TV MODULE RADIO MODULE GPS MODULE NWD-N117 (TEF6624) (SHJ-6A) (FLC -MD-023E) 24C16 EEPROM DVD MPEG 8202TQ 64M SDRAM HY57V64 16M FLASHEN25T16 AUDIO PROCESSOR CD2312 AMP TB2929HQ DVD AUDIOGPS AUDIO IPOD AUX 74HC4052 TV AUDIOAUDIO L/R SPEAKER1SPEAKER2SPEAKER3SPEAKER4 AP1507 AP1507 +5V DVD LOADER DL-C30 AP1117AP1117 POWER JACK Y116MHZ Y227MHZ Y1 14.31818MHZ

深圳市华标电子科技有限公司 Bontek Compliance Testing Laboratory Ltd DATE: April 25, 2011 Dear TCB Section of Timco Engineering, Inc., Thank you for cooperation. I would like to submit FCC application of Sunbobo Digital CO.,Ltd; . FCC ID:YGD-G2216 by your TCB Approval today. Best Regards, Bontek Compliance Testing Laboratory Ltd. Tony Wu/General Manager

Sunbobo Digital CO.LTD; Block D,2/F,Victorious Factory Bldg.35 Tseuk Luk Street,San Po Kong,Kowloon,Hong Kong April 25, 2011 Federal Communications Commission Authorization and Evaluation Division 7435 Oakland Mills Road Columbia, MD 21046 FCC Application for FCC ID: YGD-G2216 To Whom it may Concern: This letter is to ascertain that Sunbobo Digital CO.LTD;Product has been the units used for conducting FCC compliance testing,the DoC part will be tested by FCC recognized test lab. Best regards Sincerely, Sunbobo Digital CO.LTD; Terry Sze(General manager)

Sunbobo Digital CO.LTD; FCC ID: YGD-G2216 POWER OF ATTORNEY April 25, 2011 Federal Communications Commission Authorization and Evaluation Division 7435 Oakland Mills Road Columbia, MD 21046 To Whom It May Concern: We, the undersigned, hereby authorize Bontek Compliance Testing Laboratory Ltd.(Tony Wu) on our behalf, to apply to the Federal Communications Commission on our equipment. Any and all acts carried out by Bontek Compliance Testing Laboratory Ltd. (Tony Wu) on our behalf shall have the same effect as acts of our own. This is to advise that we are in full compliance with the Anti-Drug Abuse Act.We, Sunbobo Digital CO.LTD;are not subject to a denial of federalbenefits pursuant to Section 5301 of the Anti-Drug Act of 1988, 21 USC853a, and no party to the application is subject to a denial of federal benefits pursuantto that section. Sincerely, Sunbobo Digital CO.LTD; Terry Sze (General manager)

External Photographs EUT – Fitting View EUT –Front View EUT –Rear View EUT –Remote control View

FCC ID Label Sample for FCC ID:YGD- G2216 FCC ID:YGD-G2216 Model: G2216 This device complies with Part 15 of the FCC Rules. Operation is subject to the following two conditions: (1) this device may not cause harmful interference, and (2) this device must accept any interference received, including interference that may cause undesired operation.

FCC ID Location FCC ID Location

Internal Photographs EUT – Internal View EUT - PCB View EUT - PCB View EUT - PCB View EUT - PCB View EUT - PCB View EUT - PCB View EUT - PCB View EUT - Screen View

Operation description First of all, power on the car media player ,then you can running bluetooth, waitting for the bluetooth connect to other device, you can use bluetooth earphonen to listen music.

2010/01/10 2010/01/10 Dgcai 2DIN DVD MAIN_SCH PART NO.DWN BY :CHECK BY :APPD. BY :SHEET OF FINISH :SCALE : REV. DATE : UNIT : MATERIAL :TITLE DATE DATE DATE 2DIN+SL_6.2"&7.0" PWR/MODE&SEL&GPS&WUTE PWR/MODE&SEL&GPS&WUTE PWR/MODE&SEL&GPS&WUTE SW3 MUTE SW4 EJ SW5 GPS （ SEL ） SW6 PREV SW7 NEXT SW8 VOL- SW9 VOL+ SW10 TFT_UP SW11 TFT_DN R1 10R R4 2K2 R5 3K3 R6 5K6 R7 8K2 R8 12K R9 18K R10 27K R11 47K R12 100K 3 EN- 2 GND 1 EN+ 5 SW 4 SW J2 ENCODE R25 10K R26 20K C208 103 C2 100P C3 100P SW1 ??? SW2 ??? SW12 ??? SW13 ??? SW14 ??? SW15 ??? SW16 ??? SW17 ??? SW18 ??? R2 10R R3 2K2 R13 3K3 R14 5K6 R15 8K2 R16 12K R17 18K R18 27K R19 47K R20 100K 3 EN- 2 GND 1 EN+ 5 SW 4 SW J1 ENCODE R21 10K R22 20K C1 103 C4 100P C5 100P KEY1(MCU_03PIN) VOL_AD(MCU_01PIN) KEY1(MCU_04PIN) VOL_AD(MCU_02PIN) 2010/03/09 2010/03/09 Dgcai 2DIN DVD MAIN_SCH PART NO.DWN BY :CHECK BY :APPD. BY :SHEET OF FINISH :SCALE : REV. DATE : UNIT : MATERIAL :TITLE DATE DATE DATE PWR/MODE T0 KB _R T0 KB _L SD CARD BOARD SW3 ??? SW4 ??? SW5??? SW6 ??? SW7 ??? SW8 ??? R1 3K R4 1K5 R5 3K3 R6 5K6 R7 10K R8 22K R9 47K 3 EN- 2 GND 1 EN+ 5 SW 4 SW EN1 ENCODE C208 103 R2 10R SW2 ??? SW1 ??? SW12 ??? SW13 ??? R3 10R R13 10K R14 22K R15 47K 3 EN- 2 GND 1 EN+ 5 SW 4 SW EN2 ENCODE C1 103 R24 5K6 SW20 ??? 13579 111315171921 246810121416182022 2423 CON01 CN22-0.5MM-C FPC-28-0.5MM_UP 13579 111315171921232527 246810121416182022242628 3029 CON02 CN28-0.5MM 12 MIC1 MIC R22 1K5 R23 3K3 13579 246810 1211 CN4 CN10-0.5MM-C FPC-28-0.5MM_UP R10 10R C2 105 R11 1K R12 1K R16 1K R17 1K R18 1K R19 1K R20 1K KA D1 LED-1 KA D2 LED-1 KA D3 LED-1 KA D4 LED-1 KA D5 LED-1 KA D6 LED-1 KA D7 LED-1 R25 1K KA D9 LED-1 R26 1K KA D10 LED-1 R27 1K KA D11 LED-1 R28 1K KA D12 LED-1 R29 1K KA D13 LED-1 KA D14 LED-1 R21 470R KA D8 LED-1 R30 470R KA D15 LED-1 13579 246810 1211 GPS_CN CN10-0.5MM-C FPC-28-0.5MM_UP 13579 246810 1211 DVD_CN CN10-0.5MM-C FPC-28-0.5MM_UP R31 10R 1234 USB1 USB-4P 123 IR1 IR-5V 13579 246810 1211 CN1 CN10-0.5MM-C FPC-28-0.5MM_UP 13579 246810 13 11 12 DVD_CARD1 SD-13P FPC-28-0.5MM_UP D16 LED-1 K0 K1 IR+5V IR EN+ EN- AUX_L AUX_R K0 PWR KLED_L G_D2 G_D3 G_CMD G_DET G_VDD G_CLK G_D0 G_D1 KLED_L USB+5V D- D+ D_D1 D_D0 D_CLK D_VDD D_DET D_CMD D_D3 D_D2 RST KLED_R K1 EN_B EN+ EN- D+ D- USB+5V MIC- MIC+ IR IR+5V AUX_R AUX_L PWR MIC+ MIC- MIC+MIC- IR IR+5V KLED_L KLED_R IR+5V G_D2 G_D3 G_CMD G_DET G_VDD G_CLK G_D0 G_D1 D_D2 D_CMDD_VDDD_D0 D_D1 DCLK D_DET D_D3 D+ D-USB+5V TitleSize Document Number Rev Date: Sheet of 1 MST045A-B01A 1.0 Power : Buck 7 A3 Tuesday, August 26, 2008 R12; 12V=>4.7K 5V=>100R A B C D 5 4 3 2 1 D C B A 1 2 3 4 5 D710V L3 FB120R R195.1K R7100R C151uF C18 1uF C11 100n C24 103 12 D8SS14 C29120P C250.1uF L14 FB120R ADJ IN 3 1 2 U2SO-263AP1084-ADJ C3100n D11 SS14 L15 15UH R12100R C16100n 2 2 1 1 3 3 D6BAV99 R109 20K L18 FB120R L35 22UH C1140.1uF C30102 3 FB 1 LX 2 GND 4 SD 5 IN U15 MP1541 C9 1uF C130.1uF L4 5.1R L61 FB120R 2 2 1 1 3 3 D10BAV99 R82.2K 12 C11510u-1206 L10 FB120R L13 FB120R C31 1uF R1551K MP2259 5 VIN 6 SW 2 GND 3 FB 4 ON/OFF 1 BS U14MP2259 R164.7K 2 2 1 1 3 3 D9BAV99 C20100n D515V C211uF D125V6 R150100K L17 FB120R R113.3K 2 2 1 1 3 3 D4BAV99 C26 1uF R9 0R L5 NC L12 FB120R 2 2 1 1 3 3 D3BAV99 C170.1uF C2100n R1739K L7 FB120R C80.1uF C270.1uF 12 EC14 SMD-D6.3X5.3 100U/16V 12 EC48 SMD-D6.3X5.3 100U/16V 12 EC15 SMD-D6.3X5.3 100U/16V 12 EC110 SMD-D6.3X5.3 100U/16V 12 C1010u-1206 12 C1910u-1206 12 C22 10u-1206 12 C12 10u-1206 VGL VGH VCC5V VCC5V VDDP VDDC_ADC AVDD_DPWM VDDC AVDD_DACAVDD50_PWM VCC5V VDDP_TCON VDDC VDD3_3V AVDD_PLLAVDD_ADC VDD50_PWM VCC5V VDD3_3V VCC5V VCC5V AVDD11V AVDD50_PWM FB1V SW SW 输入接口 DVD 倒车 AV GPS A B C D 5 4 3 2 1 D C B A 1 2 3 4 5 Monday, September 01, 2008 A3 RGB&VIDEO INPUT A 2 7 Maria_MST7910LA ORG of Sheet Date: Rev Document Number SizeTitle C38 47nF C6822pF C760.1uF R26 1K R37 75R R41 75R C570.1uF R25 1K C70 0.01uF R4475R R67 75R C71 0.01uF R40 0R R63 75R R36 0R R6875RR6075R C77 0.1uF C48 0.1uF R55 75R C67 0.01uF C4122PF C73 0.01uF R59 75R R62 0R C530.1uF R4375R C690.1uF R61 0R R65 75R C40 47nF C7222pF C4222PF R6475R R69 75R R39 75R R38 0R R4275R C4322PF C520.1uF 12 D47 EZJZ1V800AA R66 0R R5675R C39 47nF 12 D46 EZJZ1V800AA R823 0R R822 0R 1 1 TP1 1 1 TP2 1 1 TP4 1 1 TP5 1 1 TP6 1 1 TP7 1 1 TP8 12 EC12 SMD-D6.3X5.3 100U/16V 4948474645443730 9876 434241403938363534333231291413121110 5432 282726252423 1 222120191817161550 5152 CON1 CON50P-0.5MM 50PIN-0.5MM_DN GND GND GND VCC5V GNDGNDGND HSYNC1 VSYNC1 BINPGINPRINP CVBS1P SCINPSCINMSYINPSYINM CVBS2P CVBS_IN1+ VS_IN V_YV_Y B+R+R+ CVBS_IN2+ G+HS_IN V_CV_C MST_TXD MST_RXD B+ G+ R+ HS_IN VS_IN V_C V_Y CVBS_IN1+CVBS_IN2+ AUX_L1 AUX_R1 MST_RXD MST_TXD BT_RXD BT_TXD MIC+MIC-BT_R BT_L BT_POWER G_X+G_Y-G_X- G_Y+ SYS+5V END_B END_A RESET LAMP VCC5V VCC9V ISP_SCL&RXDISP_SDA&TXD SPI_WP TitleSize Document Number Rev Date: Sheet of 3 MST045A-B01A 1.0 Panel I/F 7 A3 Monday, September 01, 2008 10MHz GPS 来 ABC D 5 4 3 2 1 D CBA 1 2 3 4 5 4 1V 2.5V 3.05V 3.45V 4.3V 6.7V 7.55V 7.95V 8.5V 10V PVI07/AT07/AT056/AU07/CPT07 1 GND 2 VCC 3 VGL 4 VGH 5 STR 6 STL 7 CKV 8 U/D 9 OEV 10 VCOM 11 VCOM1 12 L/R 13 MOD 14 OEH 15 STHL 16 STHR 17 CPH3 18 CPH2 19 CPH1 20 VCC 21 GND 22 VR 23 VG 24 VB 25 AVDD 26 AVSS 2827 J2FPC26P-0.5MM-Header L30FB120R C1260.1uF 12 D38 EZJZ1V800AA C1230.1uF R127 1K + EC8C1206 10uF/16V R118 33R 12 D39 EZJZ1V800AA R138 4K7 C1271uF 12 D41 EZJZ1V800AA C125 C0603 102 32 1 Q52N3904 C1221uF R132 10K 1 IN 2 S1A 3 S2A 4 DA 5 S1B 6 S2B 7 DB 8 GND 9 DC 10 S2C 11 S1C 12 DD 13 S2D 14 S1D 16 VCC 15 EN U29 PT2328-XL L29 NC 1234 5678 RN24 33R 1234 5678 RN22 33R R12120K 1234 5678 RN21 33R 1234 5678 RN2 33RX4 1 3 2 Q4 SOT23-100 AO3401 E B C SOT-23 1 3 2 Q7 2N3904 R135100K R12018K 1234 CN17FPC_4P C121470p R117 33R C120470p C119470p 12 D40 EZJZ1V800AA 1 OUT1 2 IN1- 3 IN1+ 4 GND 5 IN2+ 6 IN2- 7 OUT2 8 V+ U11 OP3414 C1240.1uF C129 0.1uF R1282K E B C SOT-23 1 3 2 Q6 2N3904 R1291K R1361K2 R167 4K7 L31 FB120R R13310K R134470R 1234 5678 RN19 33R R124 4K7 1234 5678 RN20 33R 1234 5678 RN23 33R R1…

Text truncated - open the document above for the full version.

Test Report of FCC Part 15 C for FCC Certificate On Behalf of Sunbobo Digital CO.LTD; FCC ID: YGD-G2216 Product Description: Car Media Player Model No.: G2216 Supplementary Model No.: D2216(the difference of all models is apperance) Prepared for: Sunbobo Digital CO.LTD; Block D, 2/F,Victorious Factory Bldg.35 Tseuk Luk Street, San Po Kong, Kowloon, Hong Kong Prepared by: Bontek Compliance Testing Laboratory Ltd 1/F, Block East H-3, OCT Eastern Ind. Zone, Qiaocheng East Road, Nanshan, Shenzhen, China Tel: 86-755-86337020 Fax: 86-755-86337028 Report No.: BCT11DR-0460E Issue Date: April 25, 2011 Test Date: April 12~25, 2011 Test by: Reviewed By: Kendy Wang Tony Wu Report No.: BCT11DR-0460E Page 2 of 48 FCC ID: YGD-G2216 TABLE OF CONTENTS 1. GENERAL INFORMATION....................................................................................................................................4 1.1 PRODUCT DESCRIPTION FOR EQUIPMENT UNDER TEST (EUT).........................................................................4 1.2 RELATED SUBMITTAL(S) / GRANT (S)...................................................................................................................4 1.3 TEST METHODOLOGY...........................................................................................................................................4 1.4 TEST FACILITY......................................................................................................................................................5 2. SYSTEM TEST CONFIGURATION......................................................................................................................6 2.1 EUT CONFIGURATION..........................................................................................................................................6 2.2 EUT EXERCISE.....................................................................................................................................................6 2.3 GENERAL TEST PROCEDURES.............................................................................................................................6 2.4 LIST OF MEASURING EQUIPMENTS USED............................................................................................................7 3. SUMMARY OF TEST RESULTS...........................................................................................................................9 4 – DISTURBANCE VOLTAGE AT THE MAINS TERMINALS..........................................................................10 4.1 MEASUREMENT UNCERTAINTY...........................................................................................................................10 4.2 APPLICABLE STANDARD.....................................................................................................................................10 4.4 INSTRUMENT SETUP...........................................................................................................................................10 4.5 TEST PROCEDURE..............................................................................................................................................11 4.6 TEST RESULT......................................................................................................................................................11 5. TEST OF HOPPING CHANNEL BANDWIDTH................................................................................................14 5.1 APPLICABLE STANDARD.....................................................................................................................................14 5.2 EUT SETUP........................................................................................................................................................14 5.3 TEST EQUIPMENT LIST AND DETAILS.................................................................................................................14 5.4 TEST PROCEDURE..............................................................................................................................................14 5.5 TEST RESULT......................................................................................................................................................14 6. TEST OF HOPPING CHANNEL SEPARATION...............................................................................................18 6.1 APPLICABLE STANDARD.....................................................................................................................................18 6.2 EUT SETUP........................................................................................................................................................18 6.3 TEST EQUIPMENT LIST AND DETAILS.................................................................................................................18 6.4 TEST PROCEDURE..............................................................................................................................................18 6.5 TEST RESULT......................................................................................................................................................18 7. TEST OF NUMBER OF HOPPING FREQUENCY...........................................................................................22 7.1 APPLICABLE STANDARD.....................................................................................................................................22 7.2 EUT SETUP........................................................................................................................................................22 7.3 TEST EQUIPMENT LIST AND DETAILS.................................................................................................................22 7.4 TEST PROCEDURE...................................................................................................................…

Text truncated - open the document above for the full version.

TEST SETUP PHOTOGRAPHS Conducted Emission Radiated Emission