ZJD-ARV5403FLLTEIPC

Revision: 1.3 1 Revision Description Date 1.0 Release 2010/08/07 1.1 Add 4G LTE describe 2012/10/9 1.2 Modify AR-V5403FL to AR-V5403FLAT-LTE 2012/10/16 1.3 Contents modify by FCC(TCB) submission required. 2012/10/18 AR-V5403FLAT-LTEAT-LTE Installation Guide Revision: 1.3 2 Contents 1Introduction to AR-V5403FLAT-LTE ............................................ 3 1.1Specifications ........................................................................................... 3 1.2Packing List .............................................................................................. 3 2Procedure of Assembly/Disassembly ......................................... 9 2.12.5” Hard Disk Installation .................................................................... 9 2.2Accessory (CF card, 4G LTE, GPS, Wi-Fi Bluetooth, SIM Card, Outline bracket) Installation ......................................................................... 14  2.3GPS/4G LTE/WiFi-Bluetooth Modules Installation ....................... 17 3Appendix ............................................................................................ 19 4Introductions of AR-B5403 .......................................................... 21 4.1 Features ....................................................................................................... 21 4.3 Block Diagram ........................................................................................... 25 5 Hardware’s Information ................................................................... 26 5.1 Locations ..................................................................................................... 26 5.2 Connector and Jumper Setting Table.................................................. 30 6 BIOS Setting ....................................................................................... 39 6.1 Main Setup .................................................................................................. 40 6.2 Advanced Chipset Setup ........................................................................ 42 6.3 PnP/PCI Setup ............................................................................................ 44 6.4 Peripherals Setup ..................................................................................... 45 6.5 PC Health Setup ........................................................................................ 47 6.6 Boot Setup .................................................................................................. 48 6.7 Exit Setup .................................................................................................... 49 7 FCC Warning statement .................................................................. 51 7.1.FCC Part 15.21 information for user ................................................ 51 7.2.For mobile devices without co-location condition ...................... 51 7.3.Information for OEM integrator ......................................................... 51 Revision: 1.3 3 1 Introduction to AR-V5403FLAT-LTE AR-V5403FLAT-LTEAT-LTE is a Fan-less system product mainly for vehicles industry PC applications. With powerful Intel CPU core & diverse memory card extension (according to CF card, SO-DIM), AR-V5403FLAT-LTE can satisfy the users requirements in any vehicles industry applications environment, especially in vehicles computer fields. AR-V5403FLAT-LTE has diverse physical interface in the front panel, such as GPIO’s terminal, 2*(10/100/1000Base-T) LANs, VGA connectors, build-in LEDs, 4 USB Ports, 2 COM ports, SIM card functions and FUSE, ATX Power Switch &Remote Switch/ Microphone/Speaker, DC inlet. In addition, the system provides the capacity for extending I/O device by options adding GPS/4G LTE/WiFi Bluetooth depends on users needs. 1.1 Specifications Item Description System AR-V5403FLAT-LTE CPU Board AR-B5403 series System Dimensions (uncluding bracket) 285x190x67(mm) 1.2 Packing List DescriptionQuantity AR-V5403FLAT-LTE 1 Terminal block (Plug-DC connecter) 1 Terminal block (Plug-GPIO connecter) 1 Wall Mount Bracket(Including label for isolation ) 2 Compact Disk 1 KB/MS Y Cable 1 Remote Switch Cable 1 2.5”HDD Bracket (Screws-4PCS) 1 Antenna for GPS external cable (Option) 1 Antenna for 4G LTE external cable (Option) 1 Antenna for Wi-Fi + Bluetooth external cable (Option) 1 Fuse 7.5A for 24V vehicles 1 Revision: 1.3 4 System Dissection (1) Dimensions Revision: 1.3 5 (2) Front Panel “I/O” Storage Power-on statusSpeaker/Mic/Remote COM1/COM2 LAN1/LAN2 VGACF Card/HDD&POWER LED Fuse Power Switch USBDC Inlet Antenna Inlet GPIO Revision: 1.3 6 (3) System Configuration 1 23 45 6 7 9 8 10 13 Revision: 1.3 7 11 12 14 15 Revision: 1.3 8 Item Description Quantity 1 Upper Cover 1 2 Bottom Case 1 3 Thermal Module 1 4 Mounting Bracket 2 5 CF Card Bracket 1 6 Mother board + GPIO board 1 7 HDD/SSD Module 1 8 GPS Module 1 94G LTE Module 1 10 Wi-Fi Module 1 11 DDRII Lid 1 12 Hook modules of bracket 4 13 Antennas of GPS/4G LTE/WiFi 1 14 Fuse 7A for 12V vehicles (default value) 1 15 SIM Card cover 1 Revision: 1.3 9 2 Procedure of Assembly/Disassembly 2.1 2.5” Hard Disk Installation The following instructions will guide you to install HDD step-by-step: 1. Remove the terminal plug from the AR-V5403FLAT-LTE. 2. Unfasten the screws from storage plate of AR-V5403FLAT-LTE. Unfasten the screw!! Unfasten the screw!! Remove the external power adapter!! Revision: 1.3 10 3. Pulled the storage plate by below photo direction. 4. Inserted the storage device into the HDD plater. 5. Place HDD module back into the case. Install the storage device on the HDD plater with four Pulled Push it! Install the storage device. Caution! Check the Direction is correct. Revision: 1.3 11 6. Fix HDD module to the chassis by two screws. Push!!Put HDD module back into the chassis. Fasten the screws!! Revision: 1.3 12 7. Slide the top cover into or take off the bottom chassis. Pay attention to make su…

Text truncated - open the document above for the full version.

Ebwje!Xboh Ebwje!Xboh

˹̂̅ʳ˥ ̇ʳ̀̂˷̈˿˸ʳ̂́˿̌ ˇˁʳʳʳ˧̈́˸ʳ˨̃ʳˣ̅̂˶˸˷̈̅˸

Compliance Certification Services Inc. Report No.: T120917W01 Date of Issue: September 27, 2012 A1 - 1 / 25 Rev. 00 APPENDIX 1 - PHOTOGRAPHS OF EUT EXTERNAL PHOTOGRAPHS OF EUT Compliance Certification Services Inc. Report No.: T120917W01 Date of Issue: September 27, 2012 A1 - 2 Rev. 00 Compliance Certification Services Inc. Report No.: T120917W01 Date of Issue: September 27, 2012 A1 - 3 Rev. 00 Monopole Antenna for WLAN & WWAN Compliance Certification Services Inc. Report No.: T120917W01 Date of Issue: September 27, 2012 A1 - 4 Rev. 00 Dipole Antenna for BT Compliance Certification Services Inc. Report No.: T120917W01 Date of Issue: September 27, 2012 A1 - 5 Rev. 00 Compliance Certification Services Inc. Report No.: T120917W01 Date of Issue: September 27, 2012 A1 - 6 Rev. 00 Compliance Certification Services Inc. Report No.: T120917W01 Date of Issue: September 27, 2012 A1 - 7 Rev. 00

Compliance Certification Services Inc. Report No.: T120917W01 Date of Issue: September 27, 2012 A1 - 8 Rev. 00 INTERNAL PHOTOGRAPHS OF EUT Compliance Certification Services Inc. Report No.: T120917W01 Date of Issue: September 27, 2012 A1 - 9 Rev. 00 Compliance Certification Services Inc. Report No.: T120917W01 Date of Issue: September 27, 2012 A1 - 10 Rev. 00 Compliance Certification Services Inc. Report No.: T120917W01 Date of Issue: September 27, 2012 A1 - 11 Rev. 00 Compliance Certification Services Inc. Report No.: T120917W01 Date of Issue: September 27, 2012 A1 - 12 Rev. 00 Compliance Certification Services Inc. Report No.: T120917W01 Date of Issue: September 27, 2012 A1 - 13 Rev. 00 Compliance Certification Services Inc. Report No.: T120917W01 Date of Issue: September 27, 2012 A1 - 14 Rev. 00 Compliance Certification Services Inc. Report No.: T120917W01 Date of Issue: September 27, 2012 A1 - 15 Rev. 00 BT Module Compliance Certification Services Inc. Report No.: T120917W01 Date of Issue: September 27, 2012 A1 - 16 Rev. 00 Compliance Certification Services Inc. Report No.: T120917W01 Date of Issue: September 27, 2012 A1 - 17 Rev. 00 WLAN Module Compliance Certification Services Inc. Report No.: T120917W01 Date of Issue: September 27, 2012 A1 - 18 Rev. 00 Compliance Certification Services Inc. Report No.: T120917W01 Date of Issue: September 27, 2012 A1 - 19 Rev. 00 WWAN Module Compliance Certification Services Inc. Report No.: T120917W01 Date of Issue: September 27, 2012 A1 - 20 Rev. 00 Compliance Certification Services Inc. Report No.: T120917W01 Date of Issue: September 27, 2012 A1 - 21 Rev. 00 Compliance Certification Services Inc. Report No.: T120917W01 Date of Issue: September 27, 2012 A1 - 22 Rev. 00 Compliance Certification Services Inc. Report No.: T120917W01 Date of Issue: September 27, 2012 A1 - 23 Rev. 00 GPS Module Compliance Certification Services Inc. Report No.: T120917W01 Date of Issue: September 27, 2012 A1 - 24 Rev. 00 Compliance Certification Services Inc. Report No.: T120917W01 Date of Issue: September 27, 2012 A1 - 25 Rev. 00

Compliance Certification Services Inc. FCC ID: ZJD-ARV5403FLLTE Report No.: T120917W01-RP4 Page 86 Rev. 00 APPENDIX I RADIO FREQUENCY EXPOSURE LIMIT According to §15.247(i), systems operating under the provisions of this section shall be operated in a manner that ensures that the public is not exposed to radio frequency energy levels in excess of the Commission's guidelines. See § 1.1307(b)(1) of this chapter. EUT Specification EUT IPC Frequency band (Operating) WLAN: 2.412GHz ~ 2.462GHz WLAN: 5.18GHz ~ 5.32GHz / 5.50GHz ~ 5.70GHz WLAN: 5.745GHz ~ 5.825GHz Others Device category Portable (<20cm separation) Mobile (>20cm separation) Others Exposure classification Occupational/Controlled exposure (S = 5mW/cm 2 ) General Population/Uncontrolled exposure (S=1mW/cm 2 ) Antenna diversity Single antenna Multiple antennas Tx diversity Rx diversity Tx/Rx diversity Max. output power IEEE 802.11b mode: 17.91 dBm (61.8016mW) IEEE 802.11g mode: 17.60 dBm (57.5440mW) IEEE 802.11n HT 20 MHz mode: 17.57 dBm (57.1479mW) IEEE 802.11n HT 40 MHz mode: 16.88 dBm (48.7528mW) Antenna gain (Max) 5 dBi (Numeric gain: 3.16) Evaluation applied MPE Evaluation* SAR Evaluation N/A Remark: The maximum output power is 17.91 dBm (61.8016mW) at 2442MHz (with 3.16 numeric antenna gain.) TEST RESULTS No non-compliance noted. MPE EVALUATION No non-compliance noted. Compliance Certification Services Inc. FCC ID: ZJD-ARV5403FLLTE Report No.: T120917W01-RP4 Page 87 Rev. 00 Calculation Given d GP E ×× = 30 & 3770 2 E S = Where E = Field strength in Volts / meter P = Power in Watts G = Numeric antenna gain d = Distance in meters S = Power density in milliwatts / square centimeter Combining equations and re-arranging the terms to express the distance as a function of the remaining variables yields: 2 3770 30 d GP S ×× = Changing to units of mW and cm, using: P (mW) = P (W) / 1000 and d (cm) = d(m) / 100 Yields () () 2 2 0796.0 100/3770 1000/30 d GP d GP S × ×= × ×× = Equation 1 Where d = Distance in cm P = Power in mW G = Numeric antenna gain S = Power density in mW / cm 2 Maximum Permissible Exposure Substituting the MPE safe distance using d = 20 cm into Equation 1: Yields GPS××=000199.0 Where P = Power in mW G = Numeric antenna gain S = Power density in mW / cm 2 Compliance Certification Services Inc. FCC ID: ZJD-ARV5403FLLTE Report No.: T120917W01-RP4 Page 88 Rev. 00 IEEE 802.11b mode: EUT output power = 61.8016mW Numeric Antenna gain = 3.16 Æ Power density = 0.03886 mW / cm2 IEEE 802.11g mode: EUT output power = 57.5440 mW Numeric Antenna gain = 3.16 Æ Power density = 0.03619 mW / cm2 IEEE 802.11n HT 20 MHz mode: EUT output power = 57.1479 mW Numeric Antenna gain = 3.16 Æ Power density =0.03594 mW / cm2 IEEE 802.11n HT 40 MHz mode: EUT output power = 48.7528mW Numeric Antenna gain = 3.16 Æ Power density = 0.03066 mW / cm2 (For mobile or fixed location transmitters, the maximum power density is 1.0 mW/cm 2 even if the calculation indicates that the power density would be larger.)

Compliance Certification Services Inc. FCC ID: ZJD-ARV5403FLLTE Report No.: T120917W01-RP4 Note: This report shall not be reproduced except in full, without the written approval of Compliance Certification Services Inc. This document may be altered or revised by Compliance Certification Services Inc. personnel only, and shall be noted in the revision section of the document. Page 1 / 90 Rev. 00 FCC 47 CFR PART 15 SUBPART C TEST REPORT For IPC Model: AR-V5403FLAT-LTE Trade Name: Acrosser Issued to Acrosser Technology Co., LTD. 10F., No. 12, Lane 609, Sec. 5, Chongsin Rd., Sanchong Dist., New Taipei City 241, Taiwan, R.O.C. Issued by Compliance Certification Services Inc. No.11, Wu-Gong 6th Rd., Wugu Industrial Park, New Taipei City 248, Taiwan (R.O.C.) http://www.ccsrf.com [email protected] Issued Date: September 29, 2012 Compliance Certification Services Inc. FCC ID: ZJD-ARV5403FLLTE Report No.: T120917W01-RP4 Page 2 Rev. 00 Revision History Rev. Issue Date Revisions Effect Page Revised By 00 September 29, 2012 Initial Issue ALL Eunice Shen Compliance Certification Services Inc. FCC ID: ZJD-ARV5403FLLTE Report No.: T120917W01-RP4 Page 3 Rev. 00 TABLE OF CONTENTS 1. TEST RESULT CERTIFICATION....................................................................................................4 2. EUT DESCRIPTION ...........................................................................................................................5 3. TEST METHODOLOGY ....................................................................................................................6 3.1 EUT CONFIGURATION........................................................................................................................6 3.2 EUT EXERCISE....................................................................................................................................6 3.3 GENERAL TEST PROCEDURES.............................................................................................................6 3.4 FCC PART 15.205 RESTRICTED BANDS OF OPERATIONS.........................................................7 3.5 DESCRIPTION OF TEST MODES...........................................................................................................8 4. INSTRUMENT CALIBRATION........................................................................................................9 4.1 MEASURING INSTRUMENT CALIBRATION......................................................................................9 4.2 MEASUREMENT EQUIPMENT USED .......................................................................................10 4.3 MEASUREMENT UNCERTAINTY .............................................................................................11 5. FACILITIES AND ACCREDITATIONS ........................................................................................12 5.1 FACILITIES .......................................................................................................................................12 5.2 EQUIPMENT......................................................................................................................................12 5.3 TABLE OF ACCREDITATIONS AND LISTINGS.....................................................................................13 6. SETUP OF EQUIPMENT UNDER TEST .......................................................................................14 6.1 SETUP CONFIGURATION OF EUT.......................................................................................................14 6.2 SUPPORT EQUIPMENT ...............................................................................................................14 7. FCC PART 15.247 REQUIREMENTS.............................................................................................15 7.1 6DB BANDWIDTH.............................................................................................................................15 7.2 PEAK POWER....................................................................................................................................23 7.3 BAND EDGES MEASUREMENT ................................................................................................31 7.4 PEAK POWER SPECTRAL DENSITY....................................................................................................53 7.5 SPURIOUS EMISSIONS.................................................................................................................61 7.6 RADIATED EMISSIONS ..............................................................................................................68 7.7 POWERLINE CONDUCTED EMISSIONS...............................................................................................85 APPENDIX I RADIO FREQUENCY EXPOSURE ...............................................................................86 APPENDIX II PHOTOGRAPHS OF TEST SETUP .............................................................................89 APPENDIX 1 - PHOTOGRAPHS OF EUT Compliance Certification Services Inc. FCC ID: ZJD-ARV5403FLLTE Report No.: T120917W01-RP4 Page 4 Rev. 00 1. TEST RESULT CERTIFICATION Applicant: Acrosser Technology Co., LTD. 10F., No. 12, Lane 609, Sec. 5, Chongsin Rd., Sanchong Dist., New Taipei City 241, Taiwan, R.O.C. Equipment Under Test: IPC Tr a d e N a m e : Acrosser Model: AR-V5403FLAT-LTE Date of Test: September 22 ~ 27, 2012 APPLICABLE STANDARDS STANDARD TEST RESULT FCC 47 CFR Part 15 Subpart C No non-compliance noted We hereby certify that: The above equipment was tested by Compliance Certification Services Inc. The test data, data evaluation, test procedures, and equipment configurations shown in this report were made in accordance with the procedures given in ANSI C63.4: 2003 and the energy emitted by the sample EUT tested as described in this report is in compliance with the requirements of FCC Rules Part 15.207, 15.209, 15.247. The test results …

Text truncated - open the document above for the full version.

Compliance Certification Services Inc. FCC ID: ZJD-ARV5403FLLTE Report No.: T120917W01-RP4 Page 89 Rev. 00 APPENDIX II PHOTOGRAPHS OF TEST SETUP Conducted Emissions Setup Photos Compliance Certification Services Inc. FCC ID: ZJD-ARV5403FLLTE Report No.: T120917W01-RP4 Page 90 Rev. 00 Radiated Emissions Setup Photos