APB55790-02A1XToy Playset W/ RFID Locating & Recognition Device

SW1 Trapdoor Detect SW2 Drawbridge Detect SW3 Overrice Button SW4 1 1 2 2 MG1FN130-AL45-14150 55790 HE-Man castle Grayskul 00 16 OHMSPEAKER Oscillator Antenna1 Antenna2 Receiver Amplifier Amplifier Power Drive Circuit Regulator Reset Battery 4 x AA Amplifier PA0PA2PB4 PA3AUDO PA1 PB2PB1PB3PB6 VDD ROSC PB0PB7 BLOCK DIAGRAM #55790 PCB NO : 55790-003-0010 ( main pcb ) VCC Contoller IC HT84072 M Speaker ANT Driver LED Moter Tag Code Voltage 55790-003-0020 ( bond board ) 55790-003-0050 ( reader pcb ) LED X 4 55790-003-0080 ( led pcb )

PROPOSED FCC ID LABEL AND LOCATION MATTEL MT. LAUREL This device complies with Part 15 of the FCC Rules. Operation is subject to the following two conditions: (1) this device may not cause harmful interference, and (2) this device must accept any interference received, including interference that may cause undesired operation. FCC ID: APB55790-02A1X FCC ID LABEL

HT6720 13.56MHz RFID Transponder Block Diagram Rev. 0.011May 16, 2001 Features · Wide range operating voltage · Batteryless RF transponder · Data transmission in read-only operation · Max. of 64-bits customer programmable data · 16-bits CRC error detection code · OTP data memory · Very low operating current (4mA@V DD =3V) · 13.56MHz carrier frequency · Output data baud rate: 4.5kbps (Typ.) · PWM/ASK modulation · Built-in voltage limiter Applications · Interactive leisure products · Security system · Access control · Anti-counterfeit devices · Material management · Animal management · Personnel working time record · Car park monitoring system General Description The HT6720 is an RF transponder IC with 13.56MHz RF carrier, which provides a low cost batteryless tran - sponder solution when combined with an external in - ductor. The inductor and internal capacitor form an LC tank which induce voltage from the radiated 13.56MHz carrier signal generated from the reader antenna. HT6720 has a built-in low power RC oscillator which is activated if the induced carrier field strength is high enough to supply the operating current and the re- sponse signal (pre-programmed in the OTP memory) is serially transmitted out. The response data is transmit- ted using PWM/ASK modulation. Modulation of 13.56MHz is accomplished by damping the LC tank with a fixed baud rate. The transmission information is stored in a 96 bits one time programmable memory OTP, with a 16-bit CRC code (up to 64 bits reserved for customer). The effective detection range for a small sized antenna is 2cm~10cm which is dependent on antenna format & reader design. The larger the antenna loop used the longer the detec- tion range. It is advisable to use larger antenna to attain a 15 cm detection range. Implementing Holtek¢s advanced OTP and low power technology, HT6720 offers a very cost effective solution for RF contactless detection system. A code area of 64-bits (max.) wide is provided so cus- tomers can program the device using the specified pro - grammer supplied by Holtek. The pre-programmed ICs are also available upon customer¢s request. VPA CLK HF2 HF1 VDD VSS PWM/ASK Modulator Shift Register Data EPROM System Clock Generator VCC Limiter and RF Limiter Frequency Driver f/4 Data Processing Power ON Reset Test and EPROM Programming Control Pad Assignment Chip size: 925 ́1040 (mm) 2 * The IC substrate should be connected to VSS in the PCB layout artwork. Pad Coordinates Unit:mm Pad No.XYPad No.XY 1 -256.65 357.344228.70 -361.37 2 -256.65-361.99 5219.80338.59 396.10 -378.15 688.89332.15 Pad Description Pad No. Pad NameI/O Internal Connection Description 1HF2I/OCMOS Connect to an antenna coil for normal operation. Open for data program- ming. 2HF1I/OCMOS Connect to an antenna coil for normal operation. Data I/O for program- ming. 3VSS ¾¾ Negative power supply. 4CLKICMOSOpen for normal operation. Clock input for programming. 5VPAI ¾ Open for normal operation. High voltage supplies input for programming. 6VDD ¾¾ Open for normal operation. +5V supply input for programming. Absolute Maximum Ratings Supply Voltage (VDD) ...............................................6V Storage Temperature ...........................-50°Cto125°C Supply Voltage (VPA) ..........................................13.5V Operating Temperature ..............................0°Cto70°C Input Voltage .............................V SS -0 . 3V to V DD +0.3V Note: These are stress ratings only. Stresses exceeding the range specified under²Absolute Maximum Ratings²may cause substantial damage to the device. Functional operation of this device at other conditions beyond those listed in the specification is not implied and prolonged exposure to extreme conditions may affect device reliabil - ity. HT6720 Rev. 0.012May 16, 2001 (0,0) 1 2 3 4 5 6 HF1 VSS CLK HF2 VDD VPA Electrical Characteristics SymbolParameter Test Conditions Min.Typ.Max.Unit V DD Conditions V DD Operating Voltage ¾ V DD pad voltage 2.4 ¾ 6.5V I dd Operating Current 3V ¾¾ 4 ¾mA 5VVoltage limiter not started ¾ 10 ¾mA R m Modulation Resistance5V ¾¾ 320 ¾W V LCL LC Input Limiter Voltage ¾¾¾ 6.5 ¾ V B R Output Data Baud Rate 3V V DD vs V SS ¾ 4 ¾ Kbps 5V V DD vs V SS ¾ 5.5 ¾ Kbps HT6720 Rev. 0.013May 16, 2001 Functional Description Operation Concept The reader transmits a 13.56MHz carrier signal from its antenna, the LC tank on the transponder side converts the carrier energy to voltage form and supply to the tran - sponder chip with an internal pump circuit. If the induced energy is high enough, the pumped voltage reaches the break-in voltage of the internal RC-oscillator, the tran - sponder is actuated to transmit its internal data serially by means of damping the LC tank. The reader receiving the transponder¢s data by means of detecting the energy variation on its own antenna, and recognize the information with a microcontroller. The HT6720 has a built-in internal Voltage Limiter to prevent excess power supply and RF levels induced by the LC tank from damaging the device or causing the device to function abnormally. A total of 96 bits of OTP memory space is provided, from which 64 bits wide are customer programmable, which can be programmed using the specified programmer supplied by Holtek. The pre-programmed ICs are also available upon customer¢s request. HT6720 RF osc & Controller Energy Data Transponder Reader Timing & Code Package HT6720 Rev. 0.014May 16, 2001 Code Package A total of 96 bits information can be stored in the HT6720, from which 64 bits are customer programma - ble. Preamble: Preamble of data, 0000H. Agent ID: This 8-bit wide code is not customer program - mable and is supplied together with the data writer after registering to Holtek. The writer generates the code au - tomatically. Customer ID: This area is for the Agent, for example used to store current number of customer. Category ID: Can be used to store the application field information code. Product ID: Storing the contents of the user…

Text truncated - open the document above for the full version.

1 2 3 4 5 6 ABCD 6 5 4 3 2 1 D CBA Title Number Revision Size C Date: 30-Apr-2002 Sheet of File: \\..\55790Main V15.sch Drawn By: SW1 Trapdoor Detect SW2 Drawbridge Detect SW3 Overrice Button C290.1uF Q18 8050 SP1 R251.5K R27100 SW4 R28 3.3K Q13 9014 R301.5K Q14 9014 R371K R31 39 Q268550 Q27 8550 R32 39 Q288550 Q7 8050 Q8 8050 1 1 2 2 M1 FN130-AL45-14150 C32 0.1uF C31 0.1uF D4 1N4001 D5 1N4001 D6 1N4001 D7 1N4001 55790 HE-Man castle Grayskul 15 C28 0.1uF R38 220K VDD ROSC 33 PB6PB3PB0PB4PB1PB2 AUD1 PA0PA2PA3PB7PB5PA1 VSS U1 HT84072 Q108050 Q259014 L56.8uH L6 6.8uH VCC VCC PA1 VDD BAT2 4X"AA" VCC VCC Holtek R14 2.2K R1610K R12 560K R18 3K R17 100K C210.01uF R13 10KR15 10K C19200pF C20 0.1uF 32 1 84 IC1A HT82V732 56 7 IC1B HT82V732 R5 56K R9 150 C13 100pF Q3 2SC945 R4 200K C1627P Y1 13.56MHZ PA1 C3 240P C5 VC30pF L1 C7 0.1uF FR1 Q18550 R191K D91N4148 C1410P C156P Q42SC945 R8430 C9 220uF Q52N4401 R1056 + C18 220uF R722 R11 1K VReader C3318pF D13 IN4148 D12 IN4148 C34102 R443.3K VReader VReg 16 ohms 2-1/4"paper 3 3 C4 240P C6 VC 30pF L2 C8 0.1uF FR2 Q28550 R20 1K D10 1N4148 L4 2.7uH VReader Reader2 PCBA ( drawbridge) Reader1 PCBA (trapdoor) C3010uF R41 1.5K D141N4148 D15 1N4148 PB1 PB2 D3 1N4001 R40 1K + C24220uF R39 4.7 Q29 9014C R2110K R2310K VDD C37 0.1uF C12 0.1uF R2 1K R1 1K R36 10 C10 100uF VReader VReader C11 0.1uF D1 1N4148 D21N4148 C2 0.1uF C1 0.1uF R5147K R54 47K R55100 PB2 PB1 R52100 C404.7P R5347K R451K Q30 9015 C38 470uF R46100 R2210K Q15 9015 R421K VDD VDD R47100 Q319014 R56200 LED2RED LED4AMBER LED3AMBER LED1RED C42 220uF B4 B4

ELECTROMAGNETIC EMISSIONS COMPLIANCE REPORT CERTIFICATION TO FCC PART 15 REQUIREMENTS for INTENTIONAL RADIATOR TOY PLAYSET WITH AN RFID LOCATING & RECOGNITION DEVICE MODEL NO: 55790 BRAND NAME: HE-MAN CASTLE GRAYSKULL FCC ID NO: APB55790-02A1X REPORT NO: 02U1323-1 ISSUE DATE: JUNE 4, 2002 Prepared for MATTEL, INC 333 CONTINENTAL BLVD. EL SEGUNDO, CA 90245 USA Prepared by COMPLIANCE CERTIFICATION SERVICES 561F MONTEREY ROAD MORGAN HILL, CA 95037, USA TEL: (408) 463-0885 FAX: (408) 463-0888 REPORT NO: 02U1323-1 FCC ID: APB55790-02A1X DATE: JUNE 4, 2002 EUT: TOY PLAYSET WITH AN RFID LOCATING & RECOGNITION DEVICE COMPLIANCE CERTIFICATION SERVICES, INC. CCS DOCUMENT NO:CCSUP4022B 561F MONTEREY ROAD, MORGAN HILL, CA 95037, USA TEL:(408)463-0885 FAX:(408)463-0888 This report shall not be reproduced except in full, without the written approval of CCS. This document may be altered or revised by Compliance Certification Services personnel only, and shall be noted in the revision section of the document. TABLE OF CONTENTS 1. VERIFICATION OF COMPLIANCE...............................................................................3 2. PRODUCT DESCRIPTION................................................................................................4 3. TEST FACILITY..................................................................................................................4 4. MEASUREMENT STANDARDS.......................................................................................4 5. MEASUREMENT EQUIPMENT USED...........................................................................5 6. POWERLINE RFI LIMIT...................................................................................................5 7. RADIATED EMISSION LIMITS.......................................................................................5 8. FREQUENCY STABILITY LIMITS.................................................................................5 9. EQUIPMENT MODIFICATION........................................................................................6 10. TEST PROCEDURE AND RESULT.............................................................................6 10.1 RADIATED EMISSION TEST PROCEDURE AND RESULT......................................................6 10.2 FREQUENCY STABILITY TEST PROCEDURE AND RESULT................................................10 REPORT NO: 02U1323-1 FCC ID: APB55790-02A1X DATE: JUNE 4, 2002 EUT: TOY PLAYSET WITH AN RFID LOCATING & RECOGNITION DEVICE Page 3 of 11 COMPLIANCE CERTIFICATION SERVICES, INC. CCS DOCUMENT NO:CCSUP4022B 561F MONTEREY ROAD, MORGAN HILL, CA 95037, USA TEL:(408)463-0885 FAX:(408)463-0888 This report shall not be reproduced except in full, without the written approval of CCS. This document may be altered or revised by Compliance Certification Services personnel only, and shall be noted in the revision section of the document. 1. VERIFICATION OF COMPLIANCE COMPANY NAME : MATTEL, INC. 333 CONTINENTAL BLVD. EL SEGUNDO, CA 90245 USA CONTACT PERSON : JIM ZIELINSKI TELEPHONE NO. : 310-252-3955 EUT DESCRIPTION : TOY PLAYSET WITH AN RFID LOCATING & RECOGNITION DEVICE MODEL NAME/NUMBER : 55790 BRAND NAME : HE-MAN CASTLE GRAYSKULL SERIAL NUMBER : N/A FCC ID : APB55790-02A1X DATE TESTED : 5/30/2002, 5/31/2002 REPORT NUMBER : 02U1323-1 EQUIPMENT TYPE 13.56 MHz TRANSCEIVER MEASUREMENT PROCEDURE ANSI 63.4 / 1992 LIMIT TYPE CERTIFICATION FCC RULE CFR 47, PART 15.225 The above equipment was tested by Compliance Engineering Services, Inc. for compliance with the requirements set forth in CFR 47, PART 15. This said equipment in the configuration described in this report shows that maximum emission levels emanating from equipment are within the compliance requirements. Warning : This document reports conditions under which testing was conducted and results of tests performed. This document may not be altered or revised in any way unless done so by Compliance Certification Services and all revisions are duly noted in the revisions section. Any alteration of this document not carried out by Compliance Certification will constitute fraud and shall nullify the document. Tested By: Approved & Released For CCS By: FRANK IBRAHIM THU CHAN EMC ENGINEER SENIOR EMC ENGINEER COMPLIANCE CERTIFICATION SERVICES COMPLIANCE CERTIFICATION SERVICES REPORT NO: 02U1323-1 FCC ID: APB55790-02A1X DATE: JUNE 4, 2002 EUT: TOY PLAYSET WITH AN RFID LOCATING & RECOGNITION DEVICE Page 4 of 11 COMPLIANCE CERTIFICATION SERVICES, INC. CCS DOCUMENT NO:CCSUP4022B 561F MONTEREY ROAD, MORGAN HILL, CA 95037, USA TEL:(408)463-0885 FAX:(408)463-0888 This report shall not be reproduced except in full, without the written approval of CCS. This document may be altered or revised by Compliance Certification Services personnel only, and shall be noted in the revision section of the document. 2. PRODUCT DESCRIPTION CHASSIS TYPE PLASTIC Fundamental Frequency 13.56 MHz Power Source FOUR 1.5 VDC BATTERIES Tyep of Transmission DATA CONTINUOUS Type of Modulation AMPLITUDE Channel Bandwidth & Number of Channels 1 Antenna Requirement EMBEDDED Power Requirement 4 “AA” BATTERIES Describe Intended Use TOY Local Osc. 13.56 MHz 3. TEST FACILITY The 3/10/30 meter open area test site and conducted measurement facility used to collect the radiated data is located at 561F Monterey Road, Morgan Hill, California, U.S.A. A detailed description of the test facility was submitted to the Commission on May 27,1994. 4. MEASUREMENT STANDARDS The site is constructed and calibrated in conformance with the requirements of ANSI C63.4/1992. REPORT NO: 02U1323-1 FCC ID: APB55790-02A1X DATE: JUNE 4, 2002 EUT: TOY PLAYSET WITH AN RFID LOCATING & RECOGNITION DEVICE Page 5 of 11 COMPLIANCE CERTIFICATION SERVICES, INC. CCS DOCUMENT NO:CCSUP4022B 561F MONTEREY ROAD, MORGAN HILL, CA 95037, USA TEL:(408)463-0885 FAX:(408)463-0888 This report shall not be reproduced except in full, without the written approval of CCS. This document may be altered or revi…

Text truncated - open the document above for the full version.

REPORT NO: 02U1323-1 FCC ID: APB55790-02A1X DATE: JUNE 4, 2002 EUT: TOY PLAYSET WITH AN RFID LOCATING & RECOGNITION DEVICE Page 8 of 11 COMPLIANCE CERTIFICATION SERVICES, INC. CCS DOCUMENT NO:CCSUP4022B 561F MONTEREY ROAD, MORGAN HILL, CA 95037, USA TEL:(408)463-0885 FAX:(408)463-0888 This report shall not be reproduced except in full, without the written approval of CCS. This document may be altered or revised by Compliance Certification Services personnel only, and shall be noted in the revision section of the document. Radiated Emissions for freq < 30 MHz Setup Photos: REPORT NO: 02U1323-1 FCC ID: APB55790-02A1X DATE: JUNE 4, 2002 EUT: TOY PLAYSET WITH AN RFID LOCATING & RECOGNITION DEVICE Page 9 of 11 COMPLIANCE CERTIFICATION SERVICES, INC. CCS DOCUMENT NO:CCSUP4022B 561F MONTEREY ROAD, MORGAN HILL, CA 95037, USA TEL:(408)463-0885 FAX:(408)463-0888 This report shall not be reproduced except in full, without the written approval of CCS. This document may be altered or revised by Compliance Certification Services personnel only, and shall be noted in the revision section of the document. Radiated Emissions for freq > 30 MHz Setup Photos: REPORT NO: 02U1323-1 FCC ID: APB55790-02A1X DATE: JUNE 4, 2002 EUT: TOY PLAYSET WITH AN RFID LOCATING & RECOGNITION DEVICE Page 11 of 11 COMPLIANCE CERTIFICATION SERVICES, INC. CCS DOCUMENT NO:CCSUP4022B 561F MONTEREY ROAD, MORGAN HILL, CA 95037, USA TEL:(408)463-0885 FAX:(408)463-0888 This report shall not be reproduced except in full, without the written approval of CCS. This document may be altered or revised by Compliance Certification Services personnel only, and shall be noted in the revision section of the document. Frequency Stability Setup Photos: END OF REPORT