EROSTRFGWXGATEWAY

This document was prepared and written by the Technical Documentation department at: Crestron Electronics, Inc. 15 Volvo Drive Rockleigh, NJ 07647 1-888-CRESTRON Crestron STRFGWX Two-Way RF Transceiver Operations Guide - DOC. 5811A Contents •• i Contents Two-Way RF Transceiver: STRFGWX 1 Description 1 Functional Description 1 Physical Description 1 Leading Specifications 4 Setup 6 Network Wiring 6 Preparation for Use 7 Identity Codes 7 Firmware Upgrade 9 Programming with SIMPL Windows 12 Configure STRFGWX Program 12 Example Program 13 Problem Solving 13 Troubleshooting 13 Further Inquiries 14 Future Updates 15 Future Firmware Upgrades 15 Return and Warranty Policies 16 Merchandise Returns / Repair Service 16 Crestron Limited Warranty 16 Crestron STRFGWX Two-Way RF Transceiver Operations Guide - DOC. 5811A Two-Way RF Transceiver: STRFGWX •• 1 Two-Way RF Transceiver: STRFGWX Description Functional Description The STRFGWX is a two-way radio frequency (RF) gateway/transceiver that communicates with Crestron’s wireless STX-1550C 2-Way RF Compact Color and STX-1550CW Wall Mount 2-Way RF Compact Color Touchpanels. The STRFGWX receives RF signals from one or more touchpanels (sold separately) and translates the signals into commands for transmission over the Crestron remote control system (herein referred to as the Cresnet system). Feedback signals from the Cresnet system are transmitted from the STRFGWX to the touchpanel(s) for real- time confirmation of commands. Up to 15 touchpanels can communicate with one STRFGWX and, if more touchpanels are needed, more STRFGWXs may be added to the control system. The RF signals can travel from a minimum of three feet up to a maximum of 50 - 75 feet. Additional range can be obtained by using multiple STRFGWX units distributed throughout any particular area or installation. The location of the STRFGWX and the orientation of the antenna are important factors in the RF performance. With the unit located outside of any metal enclosures and the antenna positioned horizontally, pointing straight out of the unit, adjust the antenna to achieve the best range. The range of the unit is also dependent on its placement and the construction of the building in which it is used. Included with the STRFGWX is a 4-pin connector plug to connect to other Cresnet system devices. Also included is an external power pack (PW-1205 for domestic use or PWI-1210 for international use). Physical Description The STRFGWX, shown on the next page, is housed in a black enclosure with silk- screened labels on the front and rear panels. On the front of the unit are five light- emitting diodes (LEDs) for indicating the unit’s status and the RF antenna (not shown for clarity). All other connections are made on the back of the unit. There are four rubber feet on the base of the unit for stability and to prevent slippage. Two-Way RF Transceiver Crestron STRFGWX 2 •• Two-Way RF Transceiver: STRFGWX Operations Guide - DOC. 5811A STRFGWX Physical Views RF GATEWAY - 2 WAYRF GATEWAY - 2 WAY PWRNETRxSIG RF Tx STRFGWXSTRFGWX ANTENNA 24 NET GZY NETNET .5A 12VDC 1.70 in (4.32 cm) 6.32 in (16.06 cm) 7.07 in (17.95 cm) CRESTRONCRESTRON CRESTRON ELECTRONICS INC. ROCKLEIGH, N.J. 07647 USACRESTRON ELECTRONICS INC. ROCKLEIGH, N.J. 07647 USA STRFGWX Ports The rear panel of the STRFGWX contains the port for operating power and three Cresnet ports. Each has a silk-screened label. Refer to the diagram below and the following descriptions. STRFGWX Rear Panel Ports 24 NET GZY NETNET .5A 12VDC CRESTRON ELECTRONICS INC. ROCKLEIGH, N.J. 07647 USACRESTRON ELECTRONICS INC. ROCKLEIGH, N.J. 07647 USA Crestron STRFGWX Two-Way RF Transceiver Operations Guide - DOC. 5811A Two-Way RF Transceiver: STRFGWX •• 3 12 VDC .5 A This direct current (DC) power socket connector is used to supply power via the external power pack. Crestron recommends specific power packs for its devices. The supplied power pack for the STRFGWX is Crestron part number PW-1205 (PWI- 1210 for international use). If a power pack other than this Crestron model is obtained, verify that it meets the required specifications and polarity as shown after this paragraph. Power Pack Specifications CRESTRON POWER PACKINPUT SPECSOUTPUT SPECS PW-1205120VAC~60 hertz (Hz)12VDC .5A PWI-1210230VAC~50Hz12VDC 1A Power Pack Output Connector Polarity NET (Modular Cresnet) These two 6-pin, 6-position RJ11 modular jacks are used to connect the STRFGWX to modular devices in the Cresnet system. Two NET ports are available so that network units can be daisy-chained together. NOTE: Most 6-conductor telephone cables are wired in a crisscross fashion and are not compatible with Crestron equipment. NOTE: All NET connectors, the two modular and the four-wire, can be used simultaneously. NET (Four-Wire Cresnet) This 4-pin connector is used to connect the STRFGWX to other four-wire devices in the Cresnet system. STRFGWX Indicators There are five LED indicators located on the front panel of the STRFGWX. Refer to the diagram below and the descriptions on the next page. The front panel also has a connector where the supplied antenna is attached. The antenna transmits and receives the touchpanel RF signals. STRFGWX Indicators RF GATEWAY - 2 WAYRF GATEWAY - 2 WAY PWRNETRxSIG RF Tx STRFGWXSTRFGWX ANTENNA CRESTRONCRESTRON Two-Way RF Transceiver Crestron STRFGWX 4 •• Two-Way RF Transceiver: STRFGWX Operations Guide - DOC. 5811A PWR This LED (green) illuminates when power is supplied to the STRFGWX. NET This LED (yellow) illuminates when communication with the Cresnet system and the STRFGWX is established. Illumination indicates that the SIMPL program currently loaded has a network device defined at the same NET ID code as the STRFGWX. RF These three red LEDs monitor the RF communications of the STRFGWX. The SIG LED illuminates when the STRFGWX is in communication with a touchpanel. If multiple units have been installed to expand the roaming capabilities of a touchpanel, the SIG LED of the STRFGWX …

Text truncated - open the document above for the full version.

STRFGWX The STRFGWX is a two-way radio frequency (RF) gateway/transceiver that communicates with Crestron’s wireless STX-1550C 2-Way RF Compact Color Touchpanels. The STRFGWX receives RF signals from touchpanels and translates the signals into commands for transmission over the Crestron remote control system. Feedback signals from the Cresnet system are transmitted from the STRFGWX to the touchpanel for real-time confirmation of commands.

C:\WINDOWS\Desktop\PA05731-1.out9/18/01 12:45PM Page: 1 CRESTRON ELECTRONICS, INC. Memo: Please forward printout to clifford Indented Bill of Material Report (Report Parameters) ------------------------------------------------------------------------------------------------------- System-Date: Tue Sep 18 11:12:09 2001 Database Name: /u/titanuat/dg008crtn/g008crtn User Id: clifford Terminal Id: yp45 Function name: indented.bom Parameter list = Parameter Output: to /usr/clifford/PA05731-1.out Report Output: to /usr/clifford/PA05731-1.out Item Group List: * Revision Type: REG Item Number: PA05731-1 To: PA05731-1 Buyer/Planner List: * Effective Date: 09/18/2001 Parent Item Quantity: 1 CRESTRON ELECTRONICS, INC. Indented Bill of Material Report ------------------------------------------------------------------------------------------------------- Item Number: PA05731-1 PCB ASSY, RF GATEWAY FOR Quantity: 1 UO 2 WAY 1550'S Batch-size: 1 Effective: 01/25/01 Expiration: 12/31/49 Revision ID: I - ECN 2097/TCR1810 Drawing ID: P Buyer/Planner: Item Group: Drawing ID-2: S ------------------------------------------------------------------------------------------------------- Qty/ By- Level Bom-seq Component Description Ext-Qty UOM Ph Pro 1.................. 5 PB05731-1 PCB RF GATEWAY FOR 1 EA N N 2 WAY 1550'S 1.................. 10 CFRDL121-1 CAP, ELECT, 120UF, 16V, 20%, 2 EA N N RDL, 2.5MMLS,6.3X11MM,LOW IMPD Memo: SECURE TO PCB W/ AHSI- C44,C45 1.................. 15 CFRDL560-2 CAP, ELECT, 56UF, 50V, 20%, 2 EA N N RDL,2.5MMLS, 6.3X15MM,LOW IMPD Memo: SECURE TO PCB W/ AHSI- C12,C43 1.................. 20 CFSMC050-1 CAP, CER, 5PF, 50V, 0805, COG, 1 EA N N 5%, SM C1 1.................. 25 CFSMC100-1 CAP, CER, 10PF, 50V, 0805, 3 EA N N COG, 5%, SM C:\WINDOWS\Desktop\PA05731-1.out9/18/01 12:45PM Page: 2 C2,C3,C4 1.................. 30 CFSMC101-3 CAP, CER, 100PF, 50V, 0805, 3 EA N N COG, 5%, SM C34,C88,C93 1.................. 31 CFSMC102-2 CAP, CER, 1000PF, 50V, 0805, 1 EA N N X7R, 5%, SM C25 1.................. 35 CFSMC103-3 CAP, CER, 0.01UF, 50V, 0805, 3 EA N N X7R, 5%, SM C5,C30,C39 1.................. 40 CFSMC104-2 CAP, CER, 0.1UF, 50V, 1206, 16 EA N N X7R, 10%, SM C6,C8,C9,C11,C16-C24,C27,C28,C36 1.................. 45 CFSMC105-1 CAP, CER, 1.0UF, 16V, 0805, 1 EA N N Y5V, +80/-20%, SM C40 1.................. 46 CFSMC150-1 CAP, CER, 15PF, 50V, 0805, 2 EA N N COG, 5%, SM C31,C46 1.................. 50 CFSMC220-1 CAP, CER, 22PF, 50V, 0805, 2 EA N N COG, 5%, SM C37,C38 1.................. 51 CFSMC222-2 CAP, CER, 2200PF, 50V, 0805, 1 EA N N X7R, 10%, SM C49 1.................. 55 CFSMC223-3 CAP, CER, 22000PF, 50V, 0805, 1 EA N N X7R, 10%, SM C32 1.................. 60 CFSMC3R3-2 CAP, CER, 3.3PF, 50V, 0805, 2 EA N N COG, 5%, SM C42,C50 1.................. 61 CFSMC471-1 CAP, CER, 470PF, 50V, 0805, 9 EA N N COG, 5%, SM C13-C15,C48,C89,C91,C94-C96 1.................. 62 CFSMC472-1 CAP, CER, 4700PF, 50V, 0805, 1 EA N N X7R, 5%, SM C33 1.................. 65 CFSMC473-1 CAP, CER, 47000PF, 50V, 1206, 1 EA N N X7R, 10%, SM C7 1.................. 70 CFSMC475-2 CAP, CER, 4.7UF, 16V, 1206, 1 EA N N Y5V, +80% -20%, SM C41 1.................. 71 CFSMC5R1-3 CAP, CER, 5.1PF, 50V, 0805, 1 EA N N COG, 0.025PF, SM C47 C:\WINDOWS\Desktop\PA05731-1.out9/18/01 12:45PM Page: 3 1.................. 75 CFSMT105-3 CAP, TANT, 1UF, 20V, 3216, 2 EA N N 10%, SM C26,C29 1.................. 80 CFSMT106-3 CAP, TANT, 10UF, 10V, 3528, 2 EA N N 10%, SM C35,C51 1.................. 85 CFSMT474-1 CAP, TANT, 0.47UF, 25V, 3216, 1 EA N N 10%, SM C10 1.................. 90 DIAXZ-1N4752A-1 DIODE, AXL, 1N4752A, ZENER, 1 EA N N DO-41, 33V, 1 WATT Z6 1.................. 95 DISMG-4002-1 DIODE, SM, 4002, GENERAL, 100V 1 EA N N DL-41 D3 1.................. 100 DISMS-SS14-1 DIODE, SCHOTTKY PRV=40V, Io= 3 EA N N 1A,Ifsm=30A,Vfm=500mV,DO-214AC D1,D2,D4 1.................. 105 DISMT-SMBJ33A-1 DIODE, SM, TRANS SUP, 33.0VWM, 1 EA N N 600W, 5%, UNIDIRECT, DO-214AA Z1 1.................. 110 DISMT-SMBJ8CA-1 DIODE, SM, TRANS SUP, 8.0VWM, 2 EA N N 600W, 5%, BI-DIRECT, DO-214AA Z2,Z3 1.................. 111 DISMW-1N914-1 DIODE, SM, 1N914, SWITCHING, 1 EA N N SOT-23 D18 1.................. 115 DKMS-TR3002-1 XCVR, HYBRID, 418.00MHZ, 3V, 1 EA N N 0.43"LX0.38"WX0.08"H, SM-20L U13 1.................. 120 FBSM-2 F BEAD, 600R MIN IMPD, 3.2LX 6 EA N N 1.6W MM, SM L2.L3,L7,L8,L10,L11 1.................. 125 FUTHAR10-1 FUSE, 100MA, RESET, 0.29"WX 2 EA N N 0.5"H, 0.2"LS, TH, 7.5 OHMS R9,R10 1.................. 130 ISTH32PLCC-1 IC SKT, 32PIN, PLCC, TH 2 EA N N U6,U9 1.................. 135 IPIM2839-1 IC, PROG, AM29F010-120JC, 2839 1 EA N N 32 PLCC, SKT MNT U6 2................. 5 ICIMF-AM29F010-120-1 IC, FLASH PROM, SECTOR ERASE, 1 EA N N 128KX8, 32PLCC, 120NS C:\WINDOWS\Desktop\PA05731-1.out9/18/01 12:45PM Page: 4 2................. 10 SFXM2839-1 SOFTWARE, PROM, ZA11282 1 EA N N 1.................. 140 IPIM2840-1 IC, PROG, AM29F010-120JC, 2840 1 EA N N 32 PLCC, SKT MNT U9 2................. 5 ICIMF-AM29F010-120-1 IC, FLASH PROM, SECTOR ERASE, 1 EA N N 128KX8, 32PLCC, 120NS 2................. 10 SFXM2840-1 SOFTWARE, PROM, ZA11282 1 EA N N 1.................. 145 ISTH20DIP-1 IC SKT, 20PIN, DIP, TH, 0.3"RS 1 EA N N U12 1.................. 150 IPIM2319-1 IC, PROG, PALCE16V8H-10PC/4, 1 EA N N 2319, 2OPIN DIP U12 2................. 5 ICIMP-PALCE16V8H-1-2 IC, PROG LOGIC, CMOS, 10NS, 0 EA N N 20PIN DIP, SKT MNT 2................. 10 SFXM2319-1 SOFTWARE,PROM,ZA11046,ZA11282 0 EA N N ZA11308 1.................. 154 ICSMA-ITT002AB-1 IC, ANALOG, SPDT RF SWITCH, 2 EA N N SOIC-8, SM U5,U24 1.................. 155 ICSMD-MAX483CSA-1 IC, DIGITAL, RS-485/422 XCVR, 1 EA N N SO-8, SM U4 1.................. 160 ICSME-NM93C46AM8-1 IC,EEPROM,CMOS,3-WIRE,1k-BIT, 1 EA N N X8/X16,4.5-5.5V,1MHz,SO-8,SM U3 1.................. 165 ICSMM-MC68340PV16-1 IC, MICRO PROC, 32BIT, 144PIN, 1 EA N N PLASTIC QFP, SM U1 1.................. 170 IPSM2841-1 IC, PROG, PIC16F876-20/SO, 1 EA N N 2841, SOIC-28, SM U15 2.....…

Text truncated - open the document above for the full version.

01-0548 Pg 1 TABLE OF CONTENTS SubjectParagraphPage No. Abstract1.02 References2.03 Administrative Information3.04 Test Program Outline4.05 General Test Information5.06 NumberNumber Enclosuresof Pages of Photos (1)Test Equipment List2- (2)Radiated Emission, Intentional Radiator,71 30 MHz to 10 GHz (3)Occupied Bandwidth21 (4)Conducted Emission, 450 kHz to 30 MHz31 (5)A2LA Scope of Accreditation2- 01-0548 Pg 2 1.0 ABSTRACT This report details the results of the FCC Code of Federal Regulations, 47 CFR, Part 15, Sub-Part B and Sub-Part C testing on one Gateway, Model No. STRFGWX, Serial No. C568212, manufactured by Crestron Electronics, Inc. operated with one Power Pack with AC Adapter, Model No. D7-10-01, manufactured by Candor, Inc. The Gateway and the Power Pack with AC Adapter were found to be in compliance with the radiated portions of the FCC Code of Federal Regulations, 47 CFR, Part 15, Sub-Part B for Class B equipment. The Gateway and the Power Pack with AC Adapter were found to be in compliance with the radiated portions of the FCC Code of Federal Regulations, 47 CFR, Part 15, Sub-Part C. The Gateway and the Power Pack with AC Adapter were found to be in compliance with the conducted portions of the FCC Code of Federal Regulations, 47 CFR, Part 15, Sub-Part B, specification limits Class B. The Gateway and the Power Pack with AC Adapter were found to be in compliance with the conducted portions of the FCC Code of Federal Regulations, 47 CFR, Part 15, Sub-Part C. Detailed test results can be observed in Enclosures 2, 3, and 4 of this report. The test results recorded in this report relate only to those items tested. This report shall not be reproduced, except in full, without the written approval of Dayton T. Brown, Inc. 01-0548 Pg 3 2.0 REFERENCES (a) Customer Purchase Order No.:42840 (b)Dayton T. Brown, Inc. Job No.:402394-01-000 (c)Test Specifications:Code of Federal Regulations, 47 CFR, Part 15, Sub-Part C Code of Federal Regulations, 47 CFR, Part 15, Sub-Part B, Class B (d)Test Procedure:American National Standard for Methods of Measurement of Radio-Noise Emissions from Low-Voltage Electrical and Electronic Equipment in the Range of 9 kHz to 40 GHz, ANSI C63.4-1992, dated 17 July 1992 01-0548 Pg 4 3.0 ADMINISTRATIVE INFORMATION Customer:Crestron Electronics, Inc. 15 Volvo Drive Rockleigh, NJ 07647 Test Items:Gateway, Model No. STRFGWX, Serial No. C568212, manufactured by Crestron Electronics, Inc. operated with one Power Pack with AC Adapter, Model No. D7-10-01, manufactured by Candor, Inc. Quantity Received:One of Each Test Start Date:16 August 2001 Test Completion Date:17 August 2001 Disposition of Test Items:The test samples were returned to Crestron Electronics, Inc. on 17 August 2001. 01-0548 Pg 5 4.0 TEST PROGRAM OUTLINE Description of Test MethodResults Radiated Emission, Intentional Radiator,Met the specification requirements. 30 MHz to 10 GHz Occupied BandwidthMet the specification requirements. Conducted Emission, 450 kHz to 30 MHzMet the specification requirements. 01-0548 Pg 6 5.0 GENERAL TEST INFORMATION Setup For the radiated emission test, in the frequency range of 30 to 1000 MHz, the test sample was set up in a climate controlled open field site that measures 44 feet long by 24 feet wide by 24 feet high. For the radiated emission test, in the frequency range of 1 to 10 GHz, the test sample was set up in an anechoic chamber that measures 20 feet wide by 20 feet long by 12 feet high. For the conducted emission test, the test sample was set up within a shielded enclosure which is 20 feet wide by 20 feet long by 12 feet high. All lines carrying power into the shielded enclosure passed through RF suppression filters suitably bonded to the enclosure and capable of 100-dB attenuation over a spectrum of 14 kHz to 10,000 MHz. Unit Operation: Operational Mode Tested - Transmit Mode - The Gateway was transmitting at 418.140 MHz. 01-0548 Enclosure 1 Test Equipment List Test equipment utilized for the program reported herein was within its assigned interval of calibration.Details are on file at Dayton T. Brown, Inc. and will be made available upon request. EQUIPMENT SERIAL CALIBRATION TEST ITEM MANUFACTURER DTB NO. CHARACTERISTIC MODEL NO. DUE DATE CE 20-Foot RG-214 Pasternack 7-9 DC - 1.0 GHz RG214/U 9 7/2/2002 BNC Cable ±1.0 dB RE Cable Dayton T. Brown, Inc. 7-17 DC – 1 GHz 30 Ft - 1/27/2002 ±6 dB RE SMA Cable Insulated Wire, Inc. 7-26 1 – 22 GHz 2505 26 2/24/2002 RE Cable Insulated Wire, Inc. 7-30 900 MHz – 6.5 GHz - 30 3/3/2002 RE BiLog Antenna Chase-York 27-1 30 - 2000 MHz CBL 6112 2055 2/10/2002 RE/OCB Double Ridge Electro-Mechanics Co. 27-41 200 - 2000 MHz 3106 2036 2/24/2002 Waveguide Antenna RE Double Ridge Electro-Mechanics Co. 27-55 1.0 - 18 GHz 3115 2072 12/8/2002 Waveguide Antenna RE Interference Analyzer Electro-Metrics 65-203 9 kHz - 1.0 GHz EMC-30 44137 11/25/2001 Mk IV CE Interference Analyzer Electro-Metrics 65-206 9 kHz - 1.0 GHz EMC-30 44162 10/7/2001 Mk IV RE Preamplifier Hewlett-Packard 71-11 1 - 26.5 GHz 8449B 3008A- 9/29/2002 30 dB Gain 00284 CE Line Impedance Solar Electronics 73-92 10 kHz - 30 MHz 9252-50-R- 951302 10/14/2001 Stabilization Network 50 μ h, 24 Amps 24-BNC Dual LISN CE Screen Room Ace Engineering - 20 ft x 20 ft - Screen - and Machine Company 10 ft High Room 1 01-0548 Enc 1 Pg 1 Test equipment utilized for the program reported herein was within its assigned interval of calibration.Details are on file at Dayton T. Brown, Inc. and will be made available upon request. EQUIPMENT SERIAL CALIBRATION TEST ITEM MANUFACTURER DTB NO. CHARACTERISTIC MODEL NO. DUE DATE RE Anechoic Facility Rayproof - 20 ft x 20 ft - Solid - 12 ft High Room 1 RE FCC Facility Dayton T. Brown, Inc. - 44 ft x 24 ft - FCC - 24 ft High Site RE/OCB Spectrum Analyzer Hewlett-Packard 376636A 9 kHz - 26.5 GHz 8563E 3635A- 1/12/2002 05798 01-0548 Enc 1 Pg 2 01-0548 Enclosure 2 Radiated Emission, Intentional Radiator, 30 MHz to 10 GHz 01-0548 Enc 2 Pg 1 RADIATED EMISSION, INTEN…

Text truncated - open the document above for the full version.