JWSLZ400RFLong Range 2-Way RF Laser Barcode Scanner

Table Of Contents Introduction .....................................................................................................2 Installation .......................................................................................................3 Configuring the RF Laser Reader .................................................................8 Radio Considerations....................................................................................24 Operating Instructions .................................................................................24 Accumulate Mode..........................................................................................25 Function/Control Key Support ....................................................................26 Troubleshooting.............................................................................................28 Changing Jumpers and Channels ................................................................32 Recharging the Batteries ..............................................................................34 Specifications for Code 39 ............................................................................35 Code 93 Specifications ..................................................................................38 Codabar Specifications .................................................................................39 Code 128 Specifications ................................................................................40 Interleaved 2 of 5 Code .................................................................................42 UPC Specifications ........................................................................................44 MSI/Plessey Specifications ...........................................................................48 Index...............................................................................................................50 1/06 1 The LZ400-RF and the B78 Base Station have been tested and found to comply with the limits for a Class A digital device, pursuant to Part 15 of the FCC Rules. These limits are designed to provide reasonable protection against harmful interference in a residential installation. This equipment generates, uses and can radiate radio frequency energy and, if not installed and used in accordance with the instructions, may cause harmful interference to radio communications. However, there is no guarantee that interference will not occur in a particular installation. If this equipment does cause harmful interference to radio or television reception, which can be determined by turning the equipment off and on, the user is encouraged to try to correct the interference by one or more of the following measures: • Reorient or relocate the receiving antenna. • Increase the separation between the equipment and receiver. • Connect the equipment into an outlet on a circuit different from that to which the receiver is connected. • Consult the dealer or an experienced radio/TV technician for help. Shielded cables and I/O cords must be used with this equipment to comply with the relevant FCC regulations. Changes or modifications not expressly approved in writing by Worth Data may void the user's authority to operate this equipment. This device complies with Part 15 of the FCC Rules. Operation is subject to the following two conditions: (1) this device may not cause harmful interference, and 2) this device must accept any interference received, including interference that may cause undesired operation. This device complies with RSS-210 of Industry Canada. Operation is subject to the following two conditions: 1) this device may not cause interference, and 2) this device must accept any interference, including interference that may cause undesired operation of the device. The laser used is a Class II Laser Product and has a 1.2 Milliwatts Output. To operate the laser scanner, aim the scanner at the bar code, and pull the trigger. The light source will turn off, once a successful scan has occurred or 2.5 seconds has elapsed, whichever is first. Do not look directly into the laser light source with the trigger depressed; avoid direct eye contact with the laser light source. 2 Introduction The Worth Data RF Lasers have the following features: 1) The LZ400-RF Laser Scanner for the USA and Canada. This laser has a range of 500 feet and has collision detect and retry logic built within. The LZ400-RF Laser communicates with the B78 Base Station. The Base Station communicates with a host PC through the USB port or a RS-232 Serial Port. Up to ten RF Lasers can communicate with one Base Station. 2) If you use the USB interface, data is transmitted as keyboard data. If you use the serial interface instead, serial data is transmitted to one of the computer's COM ports. 3) The USA RF Laser and Base operate in the 902MHz band. The laser and base radios operate by "frequency hopping" spread spectrum. The radios hop from one frequency to another every 400ms. The radio goes through 25 different frequencies and then repeats the sequence – all in the 902 MHz band at 15 milliwatts (10 dBm) of power. Different sequences define the channels. It is possible to have up to ten RF Lasers/Base Stations in the same area, providing each pair is on separate channels to avoid interference and general confusion. The RF Lasers can also operate in the same room as the 701 RF Terminal. 4) The R/F Lasers can read and discriminate between Code 39, Full ASCII Code 39, Interleaved 2 of 5, Codabar, Code 128, EAN-13, EAN-8, UPC- E, UPC-E1, UPC-A, MSI, LabelCode4, LabelCode5, Code 93 and Plessey. 5) The RF Lasers have a rechargeable lithium ion battery. The battery is recharged with an included 5v power supply. Recharge time on fully discharged batteries is 2 hours. 3 Installation Components of RF Laser Readers In the event the shipping box shows damage on arrival, please note the damage on the carrier's receipt log. The supp…

Text truncated - open the document above for the full version.

623 SWIFTST. • SANTACRUZ, CA 95060 • TELEPHONE: 831-458-9938 • FAX: 831-458-9964 • EMAIL: [email protected]

1 Helen Zhao Subject:FW: WORTHDATA INC., FCC ID: JWSLZ400RF, Assessment NO.: AN06T5407, Notice#1 From: Claire Hoque Sent: Thursday, January 19, 2006 5:40 PM To: Helen Zhao Cc: Michael Heckrotte; Chuck Cowden; Thu Chan Subject: answer: WORTHDATA INC., FCC ID: JWSLZ400RF, Assessment NO.: AN06T5407, Notice#1 Hi Helen, Here are the answers. Question #1: This is a hand-held device. But the test report does not indicate the device has ever been tested in three orthogonal planes. Please explain. <Claire>report is revised to include missing data. Question #2: Pease update the report in the following areas: a) In section 7.1.1, 7.1.2, 7.1.4, only test plots are provided, no final test data as well as limit shown in test result. b) In section 7.1.5, no test plots were provided. c) Page 27 of the test report shows a wrong plot. <Claire>report is revised. Question #3: The EUT photos show EUT is an RF laser scanner, without keyboard, but the user manual mentions: "The laser used is a Class II Laser Product and has a 1.2 Milliwatts Output. To operate the laser scanner, aim the top of the case at a bar code, and press the long green key on the keyboard of the R/F Terminal. " Please explain what is referred here as R/F terminal. <Claire>pls see updated manual. Question #4: This is for your information. The device works together with the base-station (AN06T5408). In future on Form 731, please indicate this, and provide the FCC ID that associates with this device. <Claire> OK. Thanks, Claire

PROPOSED FCC ID LABEL AND LOCATION WORTH DATA, INC. This device complies with Part 15 of the FCC Rules. Operation is subject to the following two conditions: (1) this device may not cause harmful interference, and (2) this device must accept any interference received, including interference that may cause undesired operation. FCC ID: JWSLZ400RF FCC ID LABEL

The JJB Series packs near the performance of a con- ventional monopole into an incredibly compact quarter- inch (7mm) diameter package. These antennas are ideal for any OEM application requiring a compact, cosmetically-attractive, low-cost antenna solution. The antenna features a through-hole feedline that can attach directly to a user’s PCB. Internal or external mounting is possible. Features Electrical Specifications Ultra-compact Very low cost Low VSWR Excellent performance Omni-directional pattern Easily concealed internally Suitable for internal or external applications Use with plastic* or metal enclosures ANT-916-JJB-xx DATA SHEET Product DimensionsDescription Plots 0.28” (7.0) Antenna Factor575 S.E. Ashley Place Grants Pass, OR 97526-3237 www.antennafactor.com 541-956-0931 (phone) 541-471-6251 (fax) Rev 08-09-05 AzimuthElevationTypical VSWR 270 90 180 0 -30dB -25dB -20dB -15dB -10dB - 5dB 0dB 5dB 10dB 270 90 180 0 -30dB -25dB -20dB -15dB -10dB - 5dB 0dB 5dB 10dB Coming Soon Coming Soon Coming Soon Coming Soon S11 SWR 1.877 CENTER 916.000MHz ST CENTER 916.000MHz RA SPAN 100.000MHz 1.586 * Requires proximity ground plane 0.69” (17.6) 0.34” (8.6) 0.08” (2.0) 0.35” (9.0) 0.22” (5.5) 0.57” (14.5) 0.22” (5.5) 0.06” (1.5) Center Freq. Bandwidth Wavelength VSWR Impedance Gain Connection 916MHz 30MHz 1/4-wave <2.0 typ. at center 50 ohms -1dBi est. Direct solder Electrical Specifications RA electrical specifications and plots measured on 1½” x 3½” reference ground plane Ordering Information ST electrical specifications and plots measured on 3½” x 3½” reference ground plane ANT-916-JJB-RA (Right-Angle) ANT-916-JJB-ST (Straight)

FCC CFR47 PART 15 SUBPART C CERTIFICATION TEST REPORT FOR LONG RANGE 2-WAY RF LASER BARCODE SCANNER MODEL NUMBER: LZ400-RF FCC ID: JWSLZ400RF REPORT NUMBER: 05U3728-3B ISSUE DATE: JANUARY 19, 2006 Prepared for WORTH DATA INCORPORATED 623 SWIFT STREET SANTA CRUZ, CA 95060, USA Prepared by COMPLIANCE CERTIFICATION SERVICES 561F MONTEREY ROAD MORGAN HILL, CA 95037, USA TEL: (408) 463-0885 FAX: (408) 463-0888 REPORT NO: 05U3728-3B DATE: JANUARY 19, 2006 EUT: LONG RANGE 2-WAY RF LASER BARCODE SCANNER FCC ID: JWSLZ400RF Page 2 of 52 COMPLIANCE CERTIFICATION SERVICES DOCUMENT NO: CCSUP4031A 561F MONTEREY ROAD, MORGAN HILL, CA 95037 USA TEL: (408) 463-0885 FAX: (408) 463-0888 This report shall not be reproduced except in full, without the written approval of CCS. Revision History Rev. Issue Date Revisions Revised By A 12/19/05 Initial Issue Thu B 01/19/06 Revised Sections 5.5 & 5.6 investigated with X,Y, & Z Positions Thu 01/19/06 Added Limit & Margin in Sections 7.1.1, 7.1.2, & 7.1.4 Thu 01/19/06 Revised Section 7.1.5 used with Peak Power Meter & Inserted the corrected plot on page 27 Thu REPORT NO: 05U3728-3B DATE: JANUARY 19, 2006 EUT: LONG RANGE 2-WAY RF LASER BARCODE SCANNER FCC ID: JWSLZ400RF Page 3 of 52 COMPLIANCE CERTIFICATION SERVICES DOCUMENT NO: CCSUP4031A 561F MONTEREY ROAD, MORGAN HILL, CA 95037 USA TEL: (408) 463-0885 FAX: (408) 463-0888 This report shall not be reproduced except in full, without the written approval of CCS. TABLE OF CONTENTS 1. ATTESTATION OF TEST RESULTS............................................................................................. 4 2. TEST METHODOLOGY .................................................................................................................. 5 3. FACILITIES AND ACCREDITATION .......................................................................................... 5 4. CALIBRATION AND UNCERTAINTY.......................................................................................... 5 4.1. MEASURING INSTRUMENT CALIBRATION ............................................................................. 5 4.2. MEASUREMENT UNCERTAINTY ............................................................................................... 5 5. EQUIPMENT UNDER TEST............................................................................................................6 5.1. DESCRIPTION OF EUT ..............................................................................................................6 5.2. MAXIMUM OUTPUT POWER .................................................................................................... 6 5.3. DESCRIPTION OF AVAILABLE ANTENNAS ............................................................................. 6 5.4. SOFTWARE AND FIRMWARE .................................................................................................... 6 5.5. WORST-CASE CONFIGURATION AND MODE......................................................................... 6 5.6. DESCRIPTION OF TEST SETUP ................................................................................................ 7 6. TEST AND MEASUREMENT EQUIPMENT ................................................................................ 9 7. LIMITS AND RESULTS ................................................................................................................. 10 7.1. ANTENNA PORT CHANNEL TESTS ......................................................................................... 10 7.1.1. 20 dB BANDWIDTH ......................................................................................................... 10 7.1.2. HOPPING FREQUENCY SEPARATION......................................................................... 14 7.1.3. NUMBER OF HOPPING CHANNELS ............................................................................. 16 7.1.4. AVERAGE TIME OF OCCUPANCY ............................................................................... 18 7.1.5. PEAK OUTPUT POWER .................................................................................................. 21 7.1.6. AVERAGE POWER........................................................................................................... 22 7.1.7. CONDUCTED SPURIOUS EMISSIONS.......................................................................... 23 7.2. RADIATED EMISSIONS.............................................................................................................32 7.2.1. TRANSMITTER RADIATED SPURIOUS EMISSIONS ................................................. 32 7.2.2. TRANSMITTER RADIATED EMISSIONS ABOVE 1 GHZ .......................................... 35 7.2.3. WORST-CASE RADIATED EMISSIONS BELOW 1 GHz ............................................. 36 7.3. POWERLINE CONDUCTED EMISSIONS ................................................................................ 44 8. SETUP PHOTOS .............................................................................................................................. 48 REPORT NO: 05U3728-3B DATE: JANUARY 19, 2006 EUT: LONG RANGE 2-WAY RF LASER BARCODE SCANNER FCC ID: JWSLZ400RF Page 4 of 52 COMPLIANCE CERTIFICATION SERVICES DOCUMENT NO: CCSUP4031A 561F MONTEREY ROAD, MORGAN HILL, CA 95037 USA TEL: (408) 463-0885 FAX: (408) 463-0888 This report shall not be reproduced except in full, without the written approval of CCS. 1. ATTESTATION OF TEST RESULTS COMPANY NAME: WORTH DATA, INC. 623 SWIFT ST. SANTA CRUZ, CA 95060 U.S.A EUT DESCRIPTION: LONG RANGE 2-WAY 900MHz RF LASER BARCODE SCANNER MODEL: LZ400-RF SERIAL NUMBER: 01631 DATE TESTED: NOVEMBER 14-17, 2005 APPLICABLE STANDARDS STANDARD TEST RESULTS FCC PART 15 SUBPART C NO NON-COMPLIANCE NOTED Compliance Certification Services, Inc. tested the above equipment in accordance with the requirements set forth in the above standards. The test results show that the equipment tested is capable of demonstrating compliance with the requirements as documented in this repo…

Text truncated - open the document above for the full version.

REPORT NO: 05U3728-3 DATE: DECEMBER 19, 2005 EUT: LONG RANGE 2-WAY RF LASER BARCODE SCANNER FCC ID: JWSLZ400RF Page 48 of 52 COMPLIANCE CERTIFICATION SERVICES DOCUMENT NO: CCSUP4031A 561F MONTEREY ROAD, MORGAN HILL, CA 95037 USA TEL: (408) 463-0885 FAX: (408) 463-0888 This report shall not be reproduced except in full, without the written approval of CCS. 8. SETUP PHOTOS ANTENNA PORT CONDUCTED RF MEASUREMENT SETUP ANTENNA PORT CONDUCTED PHOTO REPORT NO: 05U3728-3 DATE: DECEMBER 19, 2005 EUT: LONG RANGE 2-WAY RF LASER BARCODE SCANNER FCC ID: JWSLZ400RF Page 49 of 52 COMPLIANCE CERTIFICATION SERVICES DOCUMENT NO: CCSUP4031A 561F MONTEREY ROAD, MORGAN HILL, CA 95037 USA TEL: (408) 463-0885 FAX: (408) 463-0888 This report shall not be reproduced except in full, without the written approval of CCS. RADIATED RF MEASUREMENT SETUP RADIATED FRONT PHOTO REPORT NO: 05U3728-3 DATE: DECEMBER 19, 2005 EUT: LONG RANGE 2-WAY RF LASER BARCODE SCANNER FCC ID: JWSLZ400RF Page 50 of 52 COMPLIANCE CERTIFICATION SERVICES DOCUMENT NO: CCSUP4031A 561F MONTEREY ROAD, MORGAN HILL, CA 95037 USA TEL: (408) 463-0885 FAX: (408) 463-0888 This report shall not be reproduced except in full, without the written approval of CCS. RADIATED BACK PHOTO REPORT NO: 05U3728-3 DATE: DECEMBER 19, 2005 EUT: LONG RANGE 2-WAY RF LASER BARCODE SCANNER FCC ID: JWSLZ400RF Page 51 of 52 COMPLIANCE CERTIFICATION SERVICES DOCUMENT NO: CCSUP4031A 561F MONTEREY ROAD, MORGAN HILL, CA 95037 USA TEL: (408) 463-0885 FAX: (408) 463-0888 This report shall not be reproduced except in full, without the written approval of CCS. POWERLINE CONDUCTED EMISSIONS MEASUREMENT SETUP LINE CONDUCTED FRONT PHOTO REPORT NO: 05U3728-3 DATE: DECEMBER 19, 2005 EUT: LONG RANGE 2-WAY RF LASER BARCODE SCANNER FCC ID: JWSLZ400RF Page 52 of 52 COMPLIANCE CERTIFICATION SERVICES DOCUMENT NO: CCSUP4031A 561F MONTEREY ROAD, MORGAN HILL, CA 95037 USA TEL: (408) 463-0885 FAX: (408) 463-0888 This report shall not be reproduced except in full, without the written approval of CCS. END OF REPORT LINE CONDUCTED BACK PHOTO