PZWDWBT005Bluetooth Module

Information to user DWBT005 (DWBT004) is installed in the handy terminal, so DWBT005 (DWBT004) has no user’s manual. FCC user’s manual requirements that are FCC rule Part 15.21 and 15.105 are described on user’s manual of the handy terminals. US and Canada Regulations This device complies with Part 15 of FCC rules, Canada ICES-003 and RSS-210 Rules. Operation is subject to the following two conditions: (1) this device may not cause harmful interference, and (2) this device must accept any interference received, including interference that may cause undesired operation. NOTE : This equipment has been tested and found to comply with the limits for a Class A digital device, pursuant to Part 15 of the FCC Rules. These limits are designed to provide reasonable protection against harmful interference when the equipment is operated in a commercial environment. This equipment generates, uses, and can radiate radio frequency energy and, if no t installed and used on accordance with the instruction manual, may cause harmful interference to radio communications. Operation of this equipment in a residential area is likely to cause harmful interference in which case the user will be required to correct the interference at his own expense. NOTE : This Class A digital device apparatus complies with Canadian ICES-003. Cet appareil numérique de la classe A est conforme à la norme NMB-003 du Canada. FCC WARNING : Changes or modifications not expressly approved by the party responsible fo r compliance could void the user’s authority to operate the equipment. CAUTION : Radio Frequency Radiation Exposure This equipment complies with FCC radiation exposure limits set forth for uncontrolled equipment and meets the FCC radio frequency (RF) Exposure Guidelines in Supplement C to OET65. This equipment has very low levels of RF energy that it is deemed to comply without testing of specific absorption ratio (SAR). Co-location : Bluetooth Board(FCC ID:PZWDWBT005) and KCS(FCC ID:PZWKCS) installed in this Barcode Handy Terminal must not be co-located or operated in conjunction with any other antenna or transmitter.

Denso Wave Corporation FCC ID: PZWDWBT005 External Photos Bluetooth Board Other Part RF Shield Bluetooth Board (Component Side) Bluetooth Board Other Part Bluetooth Board (Solder Side) Denso Wave Corporation FCC ID: PZWDWBT005 Bluetooth Module IC Bluetooth Module IC

Marking Layout and Location Marking Location on the Bluetooth Board FCC ID and IC ID label location Rating plate Marking Layout on the Bluetooth Board Fig. Label layout of DWBT005 FCC ID : PZWDWBT005 IC : 1551C-DWBT005 N661 Fig. Rating plate of DWBT004 004NYCA0207 S/N : DWBT004 R Fig. Rating plate of DWBT005 004NYCA0207 S/N : DWBT005 R

Denso Wave Corporation FCC ID: PZWDWBT005 Internal Photos Front of Bluetooth Module IC without RF Shield Rear of Bluetooth Module IC

Test report No. : 25HE0109-HO-3 Page : 2 of 44 Issued date : May 11, 2005 Revised date : May 19, 2005 FCC ID : PZWDWBT005 UL Apex Co., Ltd. Head Office EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8116 Facsimile : +81 596 24 8124 MF060b(10.04.03) CONTENTS PAGE SECTION 1: Client information .................................................................................................................... 3 SECTION 2: Equipment under test (E.U.T.)................................................................................................ 3 SECTION 3: Test specification, procedures & results ................................................................................ 4 SECTION 4: Operation of E.U.T. during testing ......................................................................................... 7 SECTION 5: Conducted Emission................................................................................................................. 8 SECTION 6: Spurious Emission .................................................................................................................... 9 SECTION 7: Carrier Frequency Separation .............................................................................................. 10 SECTION 8: Number of Hopping Frequency ............................................................................................ 10 SECTION 9: Dwell time ............................................................................................................................... 10 APPENDIX 1: Photographs of test setup .................................................................................................... 11 Conducted Emission............................................................................................................................................... 11 Spurious Emission (Radiated) ...............................................................................................................................12 Worst Case Position (Y-axis:Horizontal / Z-axis:Vertical) .................................................................................14 APPENDIX 2:Test instruments .................................................................................................................... 15 APPENDIX 3: Data of EMI test.................................................................................................................... 16 Conducted Emission...............................................................................................................................................16 Carrier Frequency Separation ..............................................................................................................................20 20dB Bandwidth .....................................................................................................................................................22 Number of Hopping Frequency ............................................................................................................................24 Dwell time ...............................................................................................................................................................26 Maximum Peak Output Power .............................................................................................................................29 Radiated Spurious Emission..................................................................................................................................31 Conducted Spurious Emission ..............................................................................................................................39 99% Occupied Bandwidth .....................................................................................................................................43 Test report No. : 25HE0109-HO-3 Page : 3 of 44 Issued date : May 11, 2005 Revised date : May 19, 2005 FCC ID : PZWDWBT005 UL Apex Co., Ltd. Head Office EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8116 Facsimile : +81 596 24 8124 MF060b(10.04.03) SECTION 1: Client information Company Name : DENSO WAVE INCORPORATED Address : 1-1, Showa-cho, Kariya-shi, Aichi-ken 448-8661 Japan Telephone Number : +81-566-61-3816 Facsimile Number : +81-566-25-4741 Contact Person : Hiroshi Hayami SECTION 2: Equipment under test (E.U.T.) 2.1 Identification of E.U.T. Type of Equipment : Bluetooth Board Model No. : DWBT005 Serial No. : 00037A2287D4 00037A2287AE Country of Manufacture : Japan Receipt Date of Sample : March 22,2005 Condition of EUT : Production prototype (Not for Sale: This sample is equivalent to mass-produced items.) 2.2 Product Description Model No: DWBT005 is the Bluetooth Board based on Bluetooth Specification 1.2. This EUT is installed in barcode scanner with IEEE802.11b Wireless LAN function made of DENSO WAVE INCORPORATED (M/N: KCS). RF specification is accordance with Bluetooth. The clock frequency of EUT is 16MHz. Series model: DWBT004 , the difference between DWBT004 and DWBT005 is the length of antenna cable. The test result has no difference in electromagnetic factor. Equipment Type : Transceiver Frequency operation : 2402-2480MHz Type of modulation : FHSS Channel spacing : 1MHz Mode of operation : Duplex Antenna Type : Inverted-F type multi layer antenna Antenna Gain : 2.02dBi Antenna connector Type : Coaxial Connector with Switch SWD Type Method of Frequency Generation : Crystal Power Supply : DC3.0-3.6V FCC 15.31 (e) This EUT provides stable voltage(DC3.3V) from Host, and it is constantly converted into and provided with DC1.8V for the Operational voltage within RF Module regardless of input voltage. Therefore, this EUT complies with the requirement. FCC Part 15.203 Antenna requirement EUT has a particular antenna connector. Therefore, the equipment complies with the antenna requirement of…

Text truncated - open the document above for the full version.

Test report No. : 25HE0109-HO-3 Page : 11 of 44 Issued date : May 11, 2005 Revised date : May 19, 2005 FCC ID : PZWDWBT005 UL Apex Co., Ltd. Head Office EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8116 Facsimile : +81 596 24 8124 MF060b(10.04.03) APPENDIX 1: Photographs of test setup Conducted Emission Front Rear Test report No. : 25HE0109-HO-3 Page : 12 of 44 Issued date : May 11, 2005 Revised date : May 19, 2005 FCC ID : PZWDWBT005 UL Apex Co., Ltd. Head Office EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8116 Facsimile : +81 596 24 8124 MF060b(10.04.03) Spurious Emission (Radiated) Front Rear Test report No. : 25HE0109-HO-3 Page : 13 of 44 Issued date : May 11, 2005 Revised date : May 19, 2005 FCC ID : PZWDWBT005 UL Apex Co., Ltd. Head Office EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8116 Facsimile : +81 596 24 8124 MF060b(10.04.03) Wireless LAN Adapter and Bluetooth Board Bluetooth Board (DWBT005) Stand alone Antenna for Wireless LAN Wireless LAN Module FCC ID: PZWKCS (Already granted) Bluetooth Board (DWBT005) Stand alone Wireless LAN Module FCC ID: PZWKCS (Already granted) Test report No. : 25HE0109-HO-3 Page : 14 of 44 Issued date : May 11, 2005 Revised date : May 19, 2005 FCC ID : PZWDWBT005 UL Apex Co., Ltd. Head Office EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8116 Facsimile : +81 596 24 8124 MF060b(10.04.03) Worst Case Position (Y-axis:Horizontal / Z-axis:Vertical) X-axis Y-axis Z-axis