SZ23360R49REMOTE CONTROL RECEIVER

FCC ID Label Sample for FCCID: SZ23360R49_ FCC ID: SZ23360R49 Made in China This device complies with Part 15 of the FCC Rules. Operation is subject to the following two conditions: (1) this device may not cause harmful interference, and (2) this device must accept any interference received, including interference that may cause undesired operation.

Golf Car FCC ID FCC ID# Rhino Mule

123456 A B C D 6 54321 D C B A TAT KEI ELECTRONIC IND. CO., LTD. DWG. No. Rev. Date : Size Model No.: Model Name: Drawn: Checked:Approved: Title: A/0 A FM-RD-20A PAGE : DOC. No: C12 470uF L3 6.8uH L2 0.3UH E1 ANT C19 4.7uF VO2 1 GND 2 SI 3 OSCI 4 OSCO 5 R 6 L 7 RDB 8 LDB 9 BLK 10 FOR 11 TB 12 VDD 13 VI1 14 VO1 15 VI2 16 IC1 RX2 C13 220uF D1 3V3 L1 2.2uH C2 10PF C1 5PF C4 473 C3 30PF C20 472 C5 0.1UF C9 103 C6 0.1UF C23 102 C8 0.1UF C21 470PF R1 330K R2 2K2 R4 3.9K R18 680R R19 2.2M R17 180R R20 2M2 R3 2K2 R28 24K R5 470R Q1 380 Q2 8050 Q11 9014 Q3 8050 Q10 9014 Q4 8050 Q13 8550 Q12 8550 1:12 RC GOLF TRUCK 2006-03-21 0E10821A EB- DWG-EB- R15 10K R16 10K C7 0.1UF M Main PCB(49.860MHz) D2 IN4148 R12 10K R13 10K R6 0.5/ 1/2W VDD VDD R21 100R R22 100R R27220K C24 1P 1 2 3 4 5 6 7 J1 TO OVER PCB TP M 9.6V C16 104J C15 104J C17 104J C18 104J 1 2 3 45 K1 RELAY-SPDT 1 2 3 45 K2 RELAY-SPDT M1 9.6V Q9 IRF2055N R25 1K C10 103 C11 103 R24 330R R26 0.022R/10W R23 2.2K D6 IN4001 D5 IN4001 D7 IN4007 C22 10uF/25V R7 47K R11 10K R9 1K C14 22uF Q5 8050 Q7 8550 V1 R8 47K R14 10K R101K Q6 8050 Q8 8550 V1 D4 IN4148 D3 IN4148 V1 V1 BT1 9.6V +9.6V S1 SW-SPST R12-1 10K

TIMCO ENGINEERING INC. 849 NW State Road 45 Newberry, Florida 32669 http://www.timcoengr.com 888.472.2424 F 352.472.2030 email: [email protected] APPLICANT: PLANET TOYS (HK) LTD. FCC ID: SZ23360R49 REPORT #: P\PLANET_SZ2\639ZUT6\639ZUT6TestReport.doc COVER SHEET Test Report Product Name: WIRELESS REMOTE CONTROL RECEIVER FCC ID: SZ23360R49 Applicant: PLANET TOYS (HK) LTD. 1107 CHINACHEM GOLDEN PLAZA 77 MODY ROAD, TSIMSHATSUI EAST KOWLOON HONG KONG Date Receipt: 5/4/2006 Date Tested: 5/23/2006 TIMCO ENGINEERING INC. 849 NW State Road 45 Newberry, Florida 32669 http://www.timcoengr.com 888.472.2424 F 352.472.2030 email: [email protected] APPLICANT: PLANET TOYS (HK) LTD. FCC ID: SZ23360R49 REPORT #: P\PLANET_SZ2\639ZUT6\639ZUT6TestReport.doc TABLE OF CONTENTS TABLE OF CONTENTS LIST APPLICANT: PLANET TOYS (HK) LTD. FCC ID: SZ23360R49 TEST REPORT CONTAINING: PAGE 1...............TEST EQUIPMENT LIST PAGE 2...............TEST PROCEDURES PAGE 3...............MODIFICATIONS PAGE 4...............RADIATION INTERFERENCE TEST DATA PAGE 5...............TEST SET UP PHOTO EXHIBITS CONTAINING: STATEMENT CONFIRMING MODIFICATION BLOCK DIAGRAM SCHEMATIC INSTRUCTION MANUAL LABEL SAMPLE LABEL LOCATION EXTERNAL PHOTOGRAPHS INTERNAL PHOTOGRAPHS CIRCUIT DESCRIPTION TEST SET UP PHOTOGRAPH TIMCO ENGINEERING INC. 849 NW State Road 45 Newberry, Florida 32669 http://www.timcoengr.com 888.472.2424 F 352.472.2030 email: [email protected] APPLICANT: PLANET TOYS (HK) LTD. FCC ID: SZ23360R49 REPORT #: P\PLANET_SZ2\639ZUT6\639ZUT6TestReport.doc Page 1 of 5 EMC Equipment List Device Manufacturer Model Serial Number Cal/Char Date Due Date 3/10-Meter OATS TEI N/A N/A Listed 3/27/04 3/26/07 3-Meter OATS TEI N/A N/A Listed 1/11/06 1/10/09 Antenna: Biconnical Eaton 94455-1 1057 CAL 12/12/05 12/12/07 Antenna: Biconnical Eaton 94455-1 1096 CAL 8/17/04 8/17/06 Antenna: Biconnical Electro- Metrics BIA-25 1171 CAL 4/29/05 4/29/07 Analyzer Blue Tower Quasi-Peak Adapter HP 85650A 2811A01279 CAL 4/13/05 4/13/07 Analyzer Blue Tower RF Preselector HP 85685A 2926A00983 CAL 9/5/05 9/5/07 Analyzer Blue Tower Spectrum Analyzer HP 8568B 2928A04729 2848A18049 CAL 4/13/05 4/13/07 LISN Electro- Metrics ANS-25/2 2604 CAL 8/27/04 8/27/06 LISN Electro- Metrics EM-7820 2682 CAL 4/28/05 4/28/07 Antenna: Log- Periodic Eaton 96005 1243 CAL 12/14/05 12/14/07 TIMCO ENGINEERING INC. 849 NW State Road 45 Newberry, Florida 32669 http://www.timcoengr.com 888.472.2424 F 352.472.2030 email: [email protected] APPLICANT: PLANET TOYS (HK) LTD. FCC ID: SZ23360R49 REPORT #: P\PLANET_SZ2\639ZUT6\639ZUT6TestReport.doc Page 2 of 5 TEST PROCEDURE GENERAL: This report shall NOT be reproduced except in full without the written approval of TIMCO ENGINEERING, INC. RADIATION INTERFERENCE: The test procedure used was ANSI STANDARD C63.4-2003 using a HEWLETT PACKARD spectrum analyzer with a preselector. The bandwidth of the spectrum analyzer was 100 kHZ with an appropriate sweep speed. The analyzer was calibrated in dB above a microvolt at the output of the antenna. The resolution bandwidth was 100KHZ and the video bandwidth was 300KHZ. The ambient temperature of the UUT was 80ºF with a humidity of 70%. FORMULA OF CONVERSION FACTORS: The Field Strength at 3m was established by adding the meter reading of the spectrum analyzer (which is set to read in units of dBuV) to the antenna correction factor supplied by the antenna manufacturer. The antenna correction factors are stated in terms of dB. The gain of the Preselector was accounted for in the Spectrum Analyzer Meter Reading. Example: Freq (MHz) METER READING + ACF = FS 33 20 dBuV + 10.36 dB = 30.36 dBuV/m @ 3m ANSI STANDARD C63.4-2003 10.1.7 MEASUREMENT PROCEDURES: The unit under test was placed on a table 80 cm high and with dimensions of 1m by 1.5m. The table used for radiated measurements is capable of continuous rotation. When an emission was found, the table was rotated to produce the maximum signal strength. At this point, the antenna was raised and lowered from 1m to 4m. The antenna was placed in both the horizontal and vertical planes. ANSI STANDARD C63.4-2003 12.1.1.1 SUPERREGENERATIVE RECEIVER: A Signal Generator was set to the unit under test operating frequency. An un-modulated continuous wave (CW) signal was radiated at the super-regenerative receiver operating frequency to cohere the characteristic broadband emissions from the receiver. TIMCO ENGINEERING INC. 849 NW State Road 45 Newberry, Florida 32669 http://www.timcoengr.com 888.472.2424 F 352.472.2030 email: [email protected] APPLICANT: PLANET TOYS (HK) LTD. FCC ID: SZ23360R49 REPORT #: P\PLANET_SZ2\639ZUT6\639ZUT6TestReport.doc Page 3 of 5 MODIFICATIONS: In order to get passing results the following modifications were required: Change the value of R1 to 330K. TIMCO ENGINEERING INC. 849 NW State Road 45 Newberry, Florida 32669 http://www.timcoengr.com 888.472.2424 F 352.472.2030 email: [email protected] APPLICANT: PLANET TOYS (HK) LTD. FCC ID: SZ23360R49 REPORT #: P\PLANET_SZ2\639ZUT6\639ZUT6TestReport.doc Page 4 of 5 APPLICANT: PLANET TOYS (HK) LTD. FCC ID: SZ23360R49 NAME OF TEST: RADIATION INTERFERENCE RULES PART NO.: 15.109 REQUIREMENTS: 30 to 88 MHz: 40.0 dBuV/M @ 3 METERS 88 to 216 MHz: 43.5 dBuV/M 216 to 960 MHz: 46.0 dBuV/M ABOVE 960 MHz: 54.0 dBuV/M TEST RESULTS: A search was made of the spectrum from 30 to 1000MHz and the measurements indicate that the unit DOES meet the FCC requirements. TEST DATA: Tuned Frequency MHz Emission Frequency MHz Meter Reading dBuV Ant. Polarity Coax Loss dB Correction Factor dB Field Strength dBuV/m Margin dB 49.9 45.83 22.6 H 0.48 11.20 34.28 5.72 49.9 46.00 29.1 V 0.48 10.30 39.88 0.12 49.9 48.62 25.1 H 0.49 11.20 36.79 3.21 49.9 48.68 28.5 V 0.49 10.84 39.83 0.17 49.9 51.37 26.0 V 0.50 11.29 37.79 2.21 49.9 51.38 25.4 H 0.50 11.20 37.10 2.90 49.9 52.99 25.7 H 0.51 11.20 37.41 2.59 49.9 53.07 27.8 V 0.51 11.53 39.84 0.16 49.9 54.61 24.4 H 0.52 11.20 36.12 3.88 49.9 54.67 27.5 V 0.52 11.75 39.77 0.23 49.9 55.91 20.9 H 0…

Text truncated - open the document above for the full version.