XM5-SM2144N2BIOWIFI MODULE

Connect One Ltd. 20 Atir Yeda Street Kfar Saba 44643, Israel Phone: +972-9-766- 0456 Fax: +972-9-766-0461 Email: [email protected] www.connectone.com Pub. No. 11-4400-03, Copyright © Connect One, 2008-2011. All rights reserved. WiReach BK Data Sheet Ver. 1.30 WiReach BK WiReach BK Data Sheet ii Information provided by Connect One Ltd. is believed to be accurate and reliable. However, Connect One assumes no responsibility for its use, nor any infringement of patents or other rights of third parties, which may result from its use. No license is granted by implication or otherwise under any patent rights of Connect One other than for circuitry embodied in Connect One’s products. Connect One reserves the right to change circuitry at any time without notice. This document is subject to change without notice. The software described in this document is furnished under a license agreement and may be used or copied only in accordance with the terms of such a license agreement. It is forbidden by law to copy the software on any medium except as specifically allowed in the license agreement. No part of this document may be reproduced or transmitted in any form or by any means, electronic or mechanical, including but not limited to photocopying, recording, transmitting via fax and/or modem devices, scanning, and/or information storage and retrieval systems for any purpose without the express written consent of Connect One. WARNING: THE WiReach BK IS AN RF MODULE INTENDED FOR EMBEDDING IN A HOST DEVICE. LOCAL RELEVANT RF REGULATIONS SUCH AS ALLOWED FREQUENCIES AND USAGE IN COMMERCIAL FLIGHTS MUST BE OBSERVED. SAFETY INSTRUCTIONS MUST BE INCLUDED IN THE MANUALS OF THE HOST DEVICE. CONNECT ONE ASSUMES NO LIABILITY FOR CUSTOMER FAILURE TO COMPLY WITH THESE PRECAUTIONS. iChip, WiReach BK, IP Communication Controller, SerialNET, AT+i and Connect One are trademarks of Connect One Ltd. Copyright  2008 – 2011 Connect One Ltd. All rights reserved. Connect One Revision History WiReach BK Data Sheet iii Revision History 11-4400-03 Version Date Description 1.00 August 2010 Initial preliminary version 1.10 August 2010 Updated Mechanical Dimensions 1.15 August 2010 Misc. Updates 1.20 August 2010 Formatting 1.30 February 2011 Added FCC Notices Connect One Contents WiReach BK Data Sheet iv Contents 1 Introduction ....................................................................................................................... 1-1 1.1 General Description ..................................................................................................... 1-1 1.2 Hardware Description ................................................................................................... 1-1 1.3 Performance Specifications ......................................................................................... 1-1 2 Features ............................................................................................................................. 2-1 2.1 Security ........................................................................................................................ 2-1 2.2 Protocols ...................................................................................................................... 2-1 2.3 Additional Features ...................................................................................................... 2-1 3 Typical Applications ........................................................................................................ 3-1 4 Connector Pin Description .............................................................................................. 4-1 4.1 Pin Numbers ................................................................................................................. 4-1 4.2 Pin Functional Description ........................................................................................... 4-2 5 Interfaces ........................................................................................................................... 5-1 5.1 Serial Interface ............................................................................................................. 5-1 5.2 USB Interface ............................................................................................................... 5-1 6 Electrical Specifications .................................................................................................. 6-1 6.1 Absolute Maximum Ratings ......................................................................................... 6-1 6.2 DC Operating Characteristics ...................................................................................... 6-1 6.3 Tx Specifications .......................................................................................................... 6-2 6.4 Rx Specifications .......................................................................................................... 6-2 7 Mechanical Dimensions ................................................................................................... 7-1 8 Ordering Information ....................................................................................................... 8-2 9 Internet Protocol Compliance ......................................................................................... 9-3 Connect One Figures WiReach BK Data Sheet v Figures Figure ‎4-1: Pin-out for WiReach BK .......................................................................................... 4-1 Figure‎7-1: Mechanical Dimensions .......................................................................................... 7-1 Connect One Tables WiReach BK Data Sheet vi Tables Table 4-1: Connector Signal Description ................................................................................. 4-2 Table 6-1: Absolute Maximum Ratings..................................................................................... 6-1 Table 6-2: DC Operating Characteristics....…

Text truncated - open the document above for the full version.

9 mm 9 mm Model iW-SM2144N2BIO FCC ID: XM5-SM2144N2BIO IC ID : 8516A-SM2144N2BIO Part Number IC Canada number FCC ID number

Connect One Introduction WiReach BK Data Sheet 1-1 1 Introduction 1.1 General Description WiReach BK is a secure serial-to-Wireless LAN device server module that also acts as a bridge to connect serial devices to 802.11b/g Wireless LANs. It includes the iChip ™ CO2144 IP Communication Controller ™ chip and Marvell 88W8686 WiFi chipset. It is packaged in RoHS-compliant ultra-slim form factor and uses an industry standard pin-out. WiReach BK offers much more than many other device servers on the market. It acts as a security gap between the application and the network; supports up to 10 simultaneous TCP/UDP sockets; two listening sockets; a web server with two websites; SMTP and POP3 clients; MIME attachments; FTP and TELNET clients, and SerialNET ™ mode for serial-to-IP bridging. WiReach BK supports the SSL3/TLS1 protocol for secure sockets, HTTPS and FTPS, WEP, WPA and WPA2 WiFi encryption. WiReach BK minimizes the need to redesign the host device hardware. It easily inserts into headers on the host PCB and connects to an external antenna. Minimal or no software configuration is needed for WiReach BK to access the Wireless LAN. Connect One’s high-level AT+i ™ API eliminates the need to add WiFi drivers, security and networking protocols and tasks to the host application. The AT+i SerialNET operating mode offers a true plug-and-play mode that eliminates any changes to the host application. WiReach BK firmware – the IP stack and Internet configuration parameters – are stored in an external flash memory. The module is power-efficient: the core operates at 1.2V, while I/Os operate at 3.3V. Power Save mode further reduces power consumption. 1.2 Hardware Description  Size: 46.2 x 25.4 x 5.0 mm  (46.2 x 25.4 x 6mm with shielding option)  Core CPU: 32-bit RISC ARM7TDMI, low- leakage, 0.13 micron, running at 48MHz  Operating Voltage: +3.58V+/-5%  Operating Humidity: 90% maximum (non-condensing)  Operating Temperature Range: -20° to 75°C (-4° to 167°F)  Power Consumption: Transmit – 250mA @16dbm 235mA @12dbm (typical) Receive – 190mA (typical) Power Save mode – 8mA  RF Connector: U.FL of Hirose  Connector: Low profile 70 pin (Molex #53748-0708)  Host Interface: TTL Serial and USB device.  RoHS-compliant; lead-free 1.3 Performance Specifications  Host Data Rate: up to 3Mbps in serial mode  Serial Data Format (AT+i mode): Asynchronous character; binary; 8 data bits; no parity; 1 stop bit  SerialNET mode: Asynchronous character; binary; 7 or 8 data bits; odd, even, or no parity; 1 stop bit  Flow Control: Hardware (-RTS, -CTS) and software flow control.

Test Report E102773.00 ConnectOne Ltd. Page 1 of 122 FCC ACC M Ver 1.1 05Mayl 2000 DATE: 01 February 2011 I.T.L. (PRODUCT TESTING) LTD. FCC Radio Test Report for ConnectOne Ltd. Equipment under test: WiFi Module iW-SM2144N2BIO Written by: _____________________________ D. Shidlowsky, Documentation Approved by: _____________________________ A. Sharabi, Test Engineer Approved by: _____________________________ I. Raz, EMC Laboratory Manager This report must not be reproduced, except in full, without the written permission of I.T.L. (Product Testing) Ltd. This report relates only to items tested. Test Report E102773.00 ConnectOne Ltd. Page 2 of 122 FCC ACC M Ver 1.1 05Mayl 2000 Measurement/Technical Report for ConnectOne Ltd. WiFi Module iW-SM2144N2BIO FCC ID: XM5-SM2144N2BIO IC: 8516A-SM2144N2BIO This report concerns: Original Grant: X Class I Change: Class II Change: Equipment type: Digital Transmission System Limits used: 47CFR15 Section 15.247 Measurement procedure used is ANSI C63.4-2003. Application for Certification Applicant for this device: prepared by: (different from "prepared by") Ishaishou Raz Avi Provizor ITL (Product Testing) Ltd. ConnectOne Ltd. Kfar Bin Nun 20 Atir Yeda St. D.N. Shimshon 99780 Kfar Saba 4463 Israel Israel e-mail [email protected] Tel: + 972 - 9 - 766 - 0456 Fax: + 972 - 9 – 766 - 0461 e-mail: [email protected] TABLE OF CONTENTS 1. GENERAL INFORMATION ------------------------------------------------------------------------------- 5 1.1 Administrative Information ................................................................................. 5 1.2 List of Accreditations ......................................................................................... 6 1.3 Product Description ........................................................................................... 7 1.4 Test Methodology .............................................................................................. 7 1.5 Test Facility ....................................................................................................... 7 1.6 Measurement Uncertainty ................................................................................. 8 2. SYSTEM TEST CONFIGURATION --------------------------------------------------------------------- 9 2.1 Justification ........................................................................................................ 9 2.2 EUT Exercise Software ..................................................................................... 9 2.3 Special Accessories .......................................................................................... 9 2.4 Equipment Modifications ................................................................................... 9 2.5 Configuration of Tested System ...................................................................... 10 3. CONDUCTED AND RADIATED MEASUREMENT TEST SET-UP PHOTOS --------------11 4. 6 DB MINIMUM BANDWIDTH --------------------------------------------------------------------------12 4.1 Test procedure ................................................................................................ 12 4.2 Results table .................................................................................................... 19 4.3 Test Equipment Used. ..................................................................................... 20 5. 26 DB MINIMUM BANDWIDTH ------------------------------------------------------------------------21 5.1 Test procedure ................................................................................................ 21 5.2 Results table .................................................................................................... 28 5.3 Test Equipment Used. ..................................................................................... 29 6. MAXIMUM TRANSMITTED PEAK POWER OUTPUT -------------------------------------------30 6.1 Test procedure ................................................................................................ 30 6.2 Results table .................................................................................................... 37 6.3 Test Equipment Used. ..................................................................................... 38 7. PEAK POWER OUTPUT OUT OF 2400-2483.5 MHZ BAND ----------------------------------39 7.1 Test procedure ................................................................................................ 39 7.2 Results table .................................................................................................... 82 7.3 Test Equipment Used. ..................................................................................... 83 8. BAND EDGE SPECTRUM -------------------------------------------------------------------------------84 8.1 Test procedure ................................................................................................ 84 8.2 Results table .................................................................................................... 89 8.3 Test Equipment Used. ..................................................................................... 90 9. RADIATED EMISSION, 9 KHZ – 30 MHZ -----------------------------------------------------------91 9.1 Test Specification ............................................................................................ 91 9.2 Test Procedure ................................................................................................ 91 9.3 Measured Data ................................................................................................ 91 9.4 Test Instrumentation Used, Radiated Measurements .................................... 92 9.5 Field Strength Calculation ............................................................................... 92 10. RADIATED EMISSION 30 – 25000 MHZ ------------------------------------------------------------93 10.1 Test Specification ..............…

Text truncated - open the document above for the full version.