AZ492FT6002Bluetooth Module

Motorola Solutions Inc. April 03, 2012 To Whom It May Concern: FCC ID: AZ492FT6002 IC: 109U-92FT6002 FCC § 15.19 Labelling Requirements This device complies with part 15 of the FCC Rules and Industry Canada license- exempt RSS standard(s). Operation is subject to the following two conditions: (1) This device may not cause harmful interference, and (2) This device must accept any interference received, including interference that may cause undesired operation. FCC § 15.21 Information to User Changes or modifications not expressly approved by the party responsible for compliance could void the user’s authority to operate the equipment. INDUSTRY CANADA Statements Le présent appareil est conforme aux CNR d'Industrie Canada applicables aux appareils radio exempts de licence. L'exploitation est autorisée aux deux conditions suivantes : (1) l'appareil ne doit pas produire de brouillage, et (2) l'utilisateur de l'appareil doit accepter tout brouillage radioélectrique subi, même si le brouillage est susceptible d'en compromettre le fonctionnement. The above mentioned statements and paragraphs will be placed in a prominent location in the final user manual. Sincerely, Signed Above Mike Ramnath Motorola Solutions Inc 8000 West Sunrise Blvd, Plantation, Florida 33322 United States Tel Number: 954-723-5793 Email address: [email protected]

O2 BT Board Assembly 1. Plug the Bluetooth flex into the Bluetooth PCB, and insert the Bluetooth PCB into the front housing assembly. 2. place, and to align the board with the guide pin on the front housing the guide pin on the front housing assembly.3. Plug the Bluetooth flex into the main 4. Using a Torx T10 screwdriver, fasten the remaining three PCB screws following the sequence

To whom it may concern Motorola Solutions Inc 3 rd April 2012 Michael Ramnath 8000 West Sunrise Blvd Plantation. Fl 33322 U.S.A Authorization Letter for FCC / IC certification The company 7 layers AG has been contracted by Motorola Solutions Inc to obtain “FCC and IC certification” for the following electronic component manufactured and/or released by Motorola Solutions Inc: i. O2 Bluetooth Module FCC ID: AZ492FT6002 IC: 109U‐92FT6002 ii. O7 Bluetooth Module FCC ID: AZ492FT6007 IC: 109U‐92FT6007 The following persons at 7 layers AG will be authorized: - Carsten Steinroeder - Thomas Hirschfeld - Torsten Lohoff Unless future correspondence from Motorola Solutions Inc directs otherwise, please extend your full cooperation to 7 layers regarding matters to the above mentioned products for the period beginning 11 April 2012 through end of the project date. Thank you. (Signed above) Motorola Solutions Inc

7 layers AG Borsigstr.11 40880 Ratingen Germany Attn: Reviewing Engineer Federal Communications Commission 7435 Oakland Mills Road Columbia, MD 21046 CONFIDENTIALITY REQUEST FOR “O2” FCC-ID: AZ492FT6002 Sirs, In accordance with FCC Rule Section 0.457 and 0.459 of CFR 47, 7 layers AG (authorized by Continental Automotive GmbH) hereby requests the following documentation as Long-term confidential: - Schematic diagrams - Block diagrams - Operational Description Short-term confidential (until 01. June 2012): - Internal Photos - Test Setup Photos - User Manual / Integration Manual These documents contain detailed system and equipment description and related information about the product, which Flextronics International GmbH considers to be proprietary. This information should never get into the possession of competitors, which would be harmful for our business. Do not hesitate to contact me if you have any additional questions. Carsten Steinroeder Ratingen, 11/04/2012

Registergerichth registered in:Vorstandh Board of Directors:7 layers AG, Borsigstrasse 11 Ratingen, HRB 3264Dr. Wolfgang Dahm40880 Ratingen, Germany AufsichtsratsvorsitzendehDr. Hans-Jürgen MeckelburgPhone: +49 (0) 2102 749 0 Chairman of the Supervisory Board:Fax: +49 (0) 2102 749 350 Dr. Sabine Grobeckerwww.7Layers.com Carsten Steinroeder 17 April 2012 Phone +49 (0) 2102 749 331 Fax +49 (0) 2102 749 350 Email: [email protected] request for a limited modular approval - FCC ID: AZ492FT6002 Dear Application Examiner, the module “O2” is seeking FCC authorization as a limited modular transmitter. The requirement of the FCC part 15.212 are met. The following requirements are fulfilled: 1. The modular transmitter must have its own RF shielding The radio portion of the module has its own RF shielding. 2. The modular transmitter must have buffered modulation/data inputs The module has a memory management unit inside of the IC. It buffers the data inputs. 3. The modular transmitter must have its own power supply regulation The IC contains an own voltage regulation. In case of changes in the supply voltage VCC (for example caused by temperature changes or other effects), the internal voltage will be stabilized. 4. The modular transmitter must comply with the antenna requirements of Section 15.203 and 15.204c The transmitter has been tested with integral antenna. The antenna requirements of section 15.203 and 15.204c are fulfilled. 5. The modular transmitter must be tested in a stand-alone configuration The EUT was tested in a stand-alone configuration with integral antenna. FCC Federal Communications Commission - 2 - 6. The modular transmitter must be labelled with its own FCC ID number The Module is labelled with its own FCC ID (printed on the PCB). 7. The modular transmitter must comply with any specific rule or operating requirements applicable to the transmitter and the manufacturer must provide adequate instructions along with the module to explain any such requirements. The module is limited OEM integration and may only be connected to battery power. Connection to AC Mains is not allowed. 8. The modular transmitter must comply with any applicable RF exposure requirements. The device is exempted from RF exposure requirements, because the Output Power is below the RF exposure limit. See Test Report. Please contact us if you have any additional questions. Best Regards, Carsten Steinroeder Project Manager 7layers AG

EXTERNAL PHOTOS

Americas Subscriber Product Design Center O2 FCC/IC ID Label Artwork Contents IC Model: PMHN4193A FCC ID: AZ492FT6002 IC: 109U ‐ 92FT6002 Silkscreen FCC Label Illustration Silkscreen Area on PCB IC: 109U 92FT6002 Template Version 01.00

Applicant: Motorola Solutions Inc. FCC ID: AZ492FT6002 EXHIBIT 9 SHEET 1 OF 7 EXHIBIT 9 Internal Photographs The following photographs are attached. Exhibit 2. Bluetooth board without & with Shields (Front). 9C 3. Bluetooth board without & with Shields (Rear). 9D Applicant: Motorola Solutions Inc. FCC ID: AZ492FT6002 EXHIBIT 9 SHEET 2 OF 3 EXHIBIT 9C Bluetooth board without & with Shields (Front) Applicant: Motorola Solutions Inc. FCC ID: AZ492FT6002 EXHIBIT 9 SHEET 3 OF 3 EXHIBIT 9D Bluetooth board without & with Shields (Rear)

FinalReporton O2BluetoothModule (PMHN4193A) ODE_MUS_MOTOR_1201_FCCa acc.Title47CFRchapterIpart15subpartC ReportReference: March29,2012Date: TestLaboratory: 7LayersAG Borsigstr.11 40880Ratingen Germany Note: Thefollowingtestresultsrelateonlytothedevicesspecifiedinthisdocument.Thisreportshallnotbereproducedinparts withoutthewrittenapprovalofthetestlaboratory.  7LayersAGAufsichtsratsvorsitzender hRegistergerichthregisteredin: Borsigstrasse11ChairmanoftheSupervisoryBoard: Düsseldorf,HRB44096 40880Ratingen,GermanyRalfMertensUSt7IdNr hVATNo.: Phone:+49(0)21027490 VorstandhBoard:DE203159652 Fax:+49(0)2102749350Dr.H.7J.MeckelburgTAX No.147/5869/0385 www.7Layers.com  Reference:ODE_MUS_MOTOR_1201_FCCa acc.Title47CFRchapterIpart15subpartC 2.3 OUTFeatures FeaturesforOUT: O2BluetoothModule Allowed ValuesDesignation Description Supported Value(s) Featuresforscope:FCC_v2 BTEUTsupportsBluetoothdatarateof1Mbps withGFSKmodulationintheband2400MHz7 2483.5MHz DCTheOUTispoweredbyorconnectedtoDC Mains EDR2EUTsupportsBluetoothusingdatarateof2 MbpswithPI/4DQPSKmodulationintheband 2400MHz72483.5MHz EDR3EUTsupportsBluetoothusingdatarateof3 Mbpswith8DPSKmodulationintheband2400 MHz72483.5MHz IantIntegralAntenna:permanentfixedantenna, whichmaybebuilt7in,designedasan indispensablepartoftheequipment PantCpermanentfixedantennaconnector,whichmay bebuilt7in,designedasanindispensablepartof theequipment 2.4 SetupsusedforTesting Foreachsetuparelationisgiventodetermineifandwhichsamplesandauxiliaryequipmentisused. TheleftsidelistallOUTsamplesandtherightsidelistsallauxiliaryequipmentforthegivensetup. Sample No. Sample Description AE No. AE Description Setup No. List of OUT samplesList of auxiliary equipment A01(O2Setup) a01O2SampleModuleSample: Page4of92 Reference:ODE_MUS_MOTOR_1201_FCCa acc.Title47CFRchapterIpart15subpartC 3Results 3.1 General Availableatthetestlaboratory. Theresultsoftheinspectionaredescribedonthefollowing pages,where'Conformity'or'Passed'meansthatthe certificationcriteriawereverifiedandthatthetesteddeviceis conformtotheappliedstandard. Incaseswhere'Declaration'isprinted,therequireddocuments areavailableinthemanufacturersproductdocumentation. Incaseswhere'notapplicable'isprinted,thetestcase requirementsarenotrelevanttothespecificequipment implementation. Documentationoftested devices: Interpretationofthe testresults: 1)Thelaboratoryenvironmentalconditionsareavailableand recordedintheInterlabSystem. 2)SpecialSoftwarefortesting: TheOUTcouldbesetintoBluetoothTestModesbyusingthe program"SBEPCommunication"providedbytheapplicant. Thespecifictestmodescouldbesetandcontrolledbythe signallingunit"CBT"byRohde&Schwarzovertheair. Note: 3.2 ListoftheApplicableBody (BodyforScope:FCC_v2) Designation Description SubpartC7IntentionalRadiators;15.247Operationwithinthe bands9027928MHz,240072483.5MHz,and572575850MHz. FCC47CFRChIPART15c247RADIO FREQUENCYDEVICES 3.3 ListofTestSpecification Test Specification:FCCpart2and15 Version1071710Edition Title:PART27GENERALRULESANDREGULATIONS PART157RADIOFREQUENCYDEVICES Page5of92 Reference:ODE_MUS_MOTOR_1201_FCCa acc.Title47CFRchapterIpart15subpartC 3.4 Summary Test Case Identifier / Name SetupDate of TestResultTest (condition)Ref. Lab 15c.2 Spuriousradiatedemissions§15.247(d),§15.35(b),§15.209 15c.2;Frequency=2402,Mode=BT transmitusing1MbpswithGFSKmodulation, Channel=low 2012/03/07A01Lab1Passed 15c.2;Frequency=2402,Mode=BT transmitusing2MbpswithPI/4DQPSK modulation 2012/03/07A01Lab1Passed footnote:1 15c.2;Frequency=2402,Mode=BT transmitusing3Mbpswith8DPSKmodulation 2012/03/07A01Lab1Passed footnote:1 15c.2;Frequency=2441,Mode=BT transmitusing1MbpswithGFSKmodulation, Channel=mid 2012/03/08A01Lab1Passed 15c.2;Frequency=2441,Mode=BT transmitusing2MbpswithPI/4DQPSK modulation 2012/03/07A01Lab1Passed footnote:1 15c.2;Frequency=2441,Mode=BT transmitusing3Mbpswith8DPSKmodulation 2012/03/07A01Lab1Passed footnote:1 15c.2;Frequency=2480,Mode=BT transmitusing1MbpswithGFSKmodulation, Channel=highest 2012/03/07A01Lab1Passed 15c.2;Frequency=2480,Mode=BT transmitusing2MbpswithPI/4DQPSK modulation 2012/03/07A01Lab1Passed footnote:1 15c.2;Frequency=2480,Mode=BT transmitusing3Mbpswith8DPSKmodulation 2012/03/07A01Lab1Passed footnote:1 15c.3 Occupiedbandwidth§15.247(a)(1) 15c.3;Frequency=2402,Mode=BT transmitusing1MbpswithGFSKmodulation 2012/03/08A01Lab2Passed 15c.3;Frequency=2402,Mode=BT transmitusing2MbpswithPI/4DQPSK modulation 2012/03/08A01Lab2Passed 15c.3;Frequency=2402,Mode=BT transmitusing3Mbpswith8DPSKmodulation 2012/03/08A01Lab2Passed 15c.3;Frequency=2441,Mode=BT transmitusing1MbpswithGFSKmodulation 2012/03/08A01Lab2Passed 15c.3;Frequency=2441,Mode=BT transmitusing2MbpswithPI/4DQPSK modulation 2012/03/08A01Lab2Passed 15c.3;Frequency=2441,Mode=BT transmitusing3Mbpswith8DPSKmodulation 2012/03/08A01Lab2Passed 15c.3;Frequency=2480,Mode=BT transmitusing1MbpswithGFSKmodulation 2012/03/08A01Lab2Passed 15c.3;Frequency=2480,Mode=BT transmitusing2MbpswithPI/4DQPSK modulation 2012/03/08A01Lab2Passed 15c.3;Frequency=2480,Mode=BT transmitusing3Mbpswith8DPSKmodulation 2012/03/08A01Lab2Passed Page6of92 Reference:ODE_MUS_MOTOR_1201_FCCa acc.Title47CFRchapterIpart15subpartC Test Case Identifier / Name SetupDate of TestResultTest (condition)Ref. Lab 15c.4 Peakpoweroutput§15…

Text truncated - open the document above for the full version.

Test Laboratory: Borsigstr. 11 Germany 7Layers AG 40880 Ratingen Note: The following test results relate only to the devices specified in this document. This report shall not be reproduced in parts without the written approval of the test laboratory. 7Layers AG Aufsichtsratsvorsitzender h Registergerichth registered in: Borsigstrasse 11 Chairman of the Supervisory Board: Düsseldorf, HRB 44096 40880 Ratingen, Germany Markus Becker USt-IdNr h VAT No.: Phone: +49 (0) 2102 749 0 Vorstandh Board: DE 203159652 Fax: +49 (0) 2102 749 350 Dr. H.-J. Meckelburg TAX No. 147/5869/0385 www.7Layers.com Photo Report Bluetooth transceiver O2 Bluetooth Module (PMHN4193A) Report Reference: ODE_MUS_MOTOR_1201_FCCa_Photo Test report Reference: ODE_MUS_MOTOR_1201_FCCa_Photo Page 2 of 3 1 Photo Report 1.1 Photos of test setups Photo 1: Test setup for radiated measurements (below 30 MHz) Test report Reference: ODE_MUS_MOTOR_1201_FCCa_Photo Page 3 of 3 Photo 2: Test setup for radiated measurements (30 MHz to 1 GHz) Photo 3: Test setup for radiated measurements (above 1 GHz)