I28-QL320352Wireless Portable Printer

UMAN-QL3 Rev.F August, 2002 iiQL 320 User’s Guide Proprietary Statement This manual contains proprietary information of Zebra Technologies Corporation. It is intended solely for the information and use of parties operating and maintaining the equip- ment described herein. Such proprietary information may not be used, reproduced, or disclosed to any other parties for any other purpose without the expressed written permis- sion of Zebra Technologies Corporation. Product Improvements Since continuous product improvement is a policy of Zebra Technologies Corporation, all specifications and signs are subject to change without notice. FCC Compliance Statement NOTE: This equipment has been tested and found to comply with the limits for a Class B digital device, pursuant to Part 15 of FCC Rules. These limits are designed to provide reasonable protection against harmful interference when the equipment is operated in a commercial environment. This equipment generates, uses, and can radiate radio fre- quency energy and, if not installed and used in accordance with the instruction manual, may cause harmful interference to radio communications. Operation of this equipment in a residential area is likely to cause harmful interference in which case the user will be required to correct the interference at his own expense. WARNING: Exposure to Radio Frequency radiation. To conform to FCC RF exposure requirements this device shall be used in accordance with the operating conditions and instructions listed in this manual. Note that there are several radio options available with this printer. Additional regulatory information is contained in later sections devoted to each radio type. NOTE: This unit was tested with shielded cables on the peripheral devices. Shielded cables must be used with the unit to insure compliance Changes or modifications to this unit not expressly approved by Zebra Technologies Cor- poration could void the user’s authority to operate this equipment. Canadian Compliance Statement "IC:" before the equipment certification number signifies that the Industry Canada techni- cal specifications were met. It does not guarantee that the certified product will operate to the user's satisfaction. Liability Disclaimer Inasmuch as every effort has been made to supply accurate information in this manual, Zebra Technologies Corporation is not liable for any erroneous information or omissions. Zebra Technologies Corporation reserves the right to correct any such errors and dis- claims liability resulting therefrom. No Liability for Consequential Damage In no event shall Zebra Technologies Corporation or anyone else involved in the creation, production, or delivery of the accompanying product (including hardware and software) be liable for any damages whatsoever (including, without limitation, damages for loss of busi- ness profits, business interruption, loss of business information, or other pecuniary loss) arising out of the use of or the results of use of or inability to use such product, even if Zebra Technologies Corporation has been advised of the possibility of such damages. Because some states do not allow the exclusion of liability for consequential or incidental damages, the above limitation may not apply to you. Copyrights The copyrights in this manual and the system described therein are owned by Zebra Technologies Corporation. All rights are reserved. Unauthorized reproduction of this manual or the software in any of the system modules may result in imprisonment of up to one year and fines of up to $10,000 (17 U.S.C.506). Copyright violators may be subject to civil liability. All products and brand names are trademarks of their respective companies. All rights reserved. © 2002 Zebra Technologies Corporation Mobile Printer User’s Guide ivQL 320 User’s Guide Contents Introduction ............................................ 7 Unpacking and Inspection .............................................. 7 Reporting Damage .......................................................... 7 Getting Ready to Print............................. 9 Battery............................................................................. 9 Installing the Battery........................................................ 9 Charging the Battery........................................................ 9 Loading the Media ........................................................ 10 Installing the Media ........................................................ 10 Operator Controls ......................................................... 13 Standard Keypad........................................................... 13 LCD Control Panel .........................................................15 Verify the Printer Is Working......................................... 18 Printing a Configuration Label ....................................... 18 Connecting the Printer .................................................. 18 Cable Communications................................................. 19 IR Communications....................................................... 20 SRRF Communications................................................. 21 Zebra SRRF Network Overview.................................... 21 Bluetooth™ Networking Overview................................. 22 Wireless Local Area Network (WLAN) Module Using CF Radio .............................................................................24 Wireless Local Area Network (WLAN) Module Using PCMCIA Radio .............................................................. 25 Setting Up the Software ................................................ 26 Adjustable Shoulder Strap ............................................ 27 Belt Clip ......................................................................... 28 Preventive Maintenance ........................ 29 Extending Battery Life ................................................... 29 Cleaning.......................................…

Text truncated - open the document above for the full version.

Rhein Tech Laboratories Report number 2002112 360 Herndon Parkway, Suite 1400 FCC Part 15.247 Herndon, VA 20170 Industry Canada RSS-210 FCC ID I28-QL320352 http://www.rheintech.com M/N QL320 Page 42 of 78 APPENDIX D: AGENCY AUTHORIZATION LETTER Please see the following page. .Zebra Technologies Corporation 30 Plan Way ill ... Warwick, RI 02886 U.S.A. Telephone + 1401.739.5800 /800.556.7266 Facsimile +1.401.732.7808 www.zebra.com 5/10/2002 i LETTER OF AGENCY I hereby authorize, until further notice, Rhein Tech Laboratories, Inc. of 360 Herndon Parkway, Suite 1400, Herndon, VA 20170, to act on our behalf in dealings before the Federal Communications Commission with respect to all matters relating to equipment authorizations for the Zebra OL320 portable printer with Cisco AIR-LMC352 802.11 b direct sequence spread spectrum transmitter (FCC ID# 128-0L320352) under Part 15 of 47 CFR. I further certify that no party (as defined in Paragraph 1.2002(b) of CFR47, 1992) to this application, including myself, is subject to a denial of federal benefits, that includes FCC benefits, pursuant to Section 5301 of the Anti-Drug Abuse Act of 1988, 21 U. S. C., 853(a). If ~ J (()~-_-I.:.. Certified by: .r~~Tl~ ~ ..:l~ ~ U Steven F. Petteruti V.P., Engineering Zebra Technologies Corporation

Rhein Tech Laboratories Report number 2002112 360 Herndon Parkway, Suite 1400 FCC Part 15.247 Herndon, VA 20170 Industry Canada RSS-210 FCC ID I28-QL320352 http://www.rheintech.com M/N QL320 Page 44 of 78 APPENDIX F: ATTESTATION LETTERS (IF APPLICABLE) Please see the following page.

Engineering and Testing for EMC and Safety Compliance 360 Herndon Parkway, Suite 1400 Herndon, VA 20170 Phone: 703-689-0368; Fax: 703-689-2056; Metro: 703-471-6441 Mr. William Graff American TCB 6731 Whittier Ave, Suite C110 McLean, VA 22101 Ref: Grantee Code: I28 Zebra Technologies QL320 / FCC ID: I28-QL320352 August 1, 2002 Dear Mr. Graff, In reference to the Zebra Technologies QL320 (FCC ID: I28-QL320352), the output power of the Cisco AIR-LMC352 used in this host is higher than the power listed on the original Cisco grant for this device (FCC ID: LDK102040). The Zebra Technologies QL320 controls the Cisco AIR- LMC352 utilizing firmware developed by Zebra Technologies that is based on routines and drivers supplied by Cisco. Because these routines and drivers are customized by Zebra Technologies for use in their device and operating system, there are differences in the way the AIR-LMC352 is controlled and programmed, specifically the PA stage of the AIR-LMC352. These programming differences account for the power discrepancy between the grant issued for FCC ID LDK102040 and the above referenced Zebra Technologies application. Sincerely, Richard B. McMurray

Rhein Tech Laboratories Report number 2002112 360 Herndon Parkway, Suite 1400 FCC Part 15.247 Herndon, VA 20170 Industry Canada RSS-210 FCC ID I28-QL320352 http://www.rheintech.com M/N QL320 Page 56 of 78 APPENDIX N: EXTERNAL PHOTOGRAPHS PHOTOGRAPH 7: TOP VIEW OF DEVICE Rhein Tech Laboratories Report number 2002112 360 Herndon Parkway, Suite 1400 FCC Part 15.247 Herndon, VA 20170 Industry Canada RSS-210 FCC ID I28-QL320352 http://www.rheintech.com M/N QL320 Page 57 of 78 PHOTOGRAPH 8: BOTTOM VIEW WITH BATTERY Rhein Tech Laboratories Report number 2002112 360 Herndon Parkway, Suite 1400 FCC Part 15.247 Herndon, VA 20170 Industry Canada RSS-210 FCC ID I28-QL320352 http://www.rheintech.com M/N QL320 Page 58 of 78 PHOTOGRAPH 9: FRONT VIEW OF DEVICE Rhein Tech Laboratories Report number 2002112 360 Herndon Parkway, Suite 1400 FCC Part 15.247 Herndon, VA 20170 Industry Canada RSS-210 FCC ID I28-QL320352 http://www.rheintech.com M/N QL320 Page 59 of 78 PHOTOGRAPH 10: FRONT OF LCD DISPLAY Rhein Tech Laboratories Report number 2002112 360 Herndon Parkway, Suite 1400 FCC Part 15.247 Herndon, VA 20170 Industry Canada RSS-210 FCC ID I28-QL320352 http://www.rheintech.com M/N QL320 Page 60 of 78 PHOTOGRAPH 11: REAR OF LCD DISPLAY Rhein Tech Laboratories Report number 2002112 360 Herndon Parkway, Suite 1400 FCC Part 15.247 Herndon, VA 20170 Industry Canada RSS-210 FCC ID I28-QL320352 http://www.rheintech.com M/N QL320 Page 61 of 78 PHOTOGRAPH 12: TOP OF DEVICE WITH PRINTER PAPER Rhein Tech Laboratories Report number 2002112 360 Herndon Parkway, Suite 1400 FCC Part 15.247 Herndon, VA 20170 Industry Canada RSS-210 FCC ID I28-QL320352 http://www.rheintech.com M/N QL320 Page 62 of 78 PHOTOGRAPH 13: LEFT SIDE VIEW Rhein Tech Laboratories Report number 2002112 360 Herndon Parkway, Suite 1400 FCC Part 15.247 Herndon, VA 20170 Industry Canada RSS-210 FCC ID I28-QL320352 http://www.rheintech.com M/N QL320 Page 63 of 78 PHOTOGRAPH 14: RIGHT SIDE VIEW Rhein Tech Laboratories Report number 2002112 360 Herndon Parkway, Suite 1400 FCC Part 15.247 Herndon, VA 20170 Industry Canada RSS-210 FCC ID I28-QL320352 http://www.rheintech.com M/N QL320 Page 64 of 78 PHOTOGRAPH 15: OVERALL VIEW, INCLUDING WLAN CARD Rhein Tech Laboratories Report number 2002112 360 Herndon Parkway, Suite 1400 FCC Part 15.247 Herndon, VA 20170 Industry Canada RSS-210 FCC ID I28-QL320352 http://www.rheintech.com M/N QL320 Page 65 of 78 PHOTOGRAPH 16: FRONT OF CHARGER Rhein Tech Laboratories Report number 2002112 360 Herndon Parkway, Suite 1400 FCC Part 15.247 Herndon, VA 20170 Industry Canada RSS-210 FCC ID I28-QL320352 http://www.rheintech.com M/N QL320 Page 66 of 78 PHOTOGRAPH 17: REAR OF CHARGER

Rhein Tech Laboratories Report number 2002112 360 Herndon Parkway, Suite 1400 FCC Part 15.247 Herndon, VA 20170 Industry Canada RSS-210 FCC ID I28-QL320352 http://www.rheintech.com M/N QL320 Page 46 of 78 APPENDIX H: LABEL AND LABEL LOCATION PHOTOGRAPH 1: LABEL LOCATION ON TOP OF DEVICE Rhein Tech Laboratories Report number 2002112 360 Herndon Parkway, Suite 1400 FCC Part 15.247 Herndon, VA 20170 Industry Canada RSS-210 FCC ID I28-QL320352 http://www.rheintech.com M/N QL320 Page 47 of 78 PHOTOGRAPH 2: IDENTIFICATION LABEL ON DEVICE Please see the diagram on the following page. ( C ) F C C I D : I 2 8 - Q L 3 2 0 3 5 2 ; C a n a d a I D : 3 7 9 8 A - Q L 3 2 0 3 5 2 Network Printer (Cisco PCMCIA) AA16403-10

Rhein Tech Laboratories Report number 2002112 360 Herndon Parkway, Suite 1400 FCC Part 15.247 Herndon, VA 20170 Industry Canada RSS-210 FCC ID I28-QL320352 http://www.rheintech.com M/N QL320 Page 67 of 78 APPENDIX O: INTERNAL PHOTOGRAPHS PHOTOGRAPH 18: PCB1 TOP WITH LCD DISPLAY Rhein Tech Laboratories Report number 2002112 360 Herndon Parkway, Suite 1400 FCC Part 15.247 Herndon, VA 20170 Industry Canada RSS-210 FCC ID I28-QL320352 http://www.rheintech.com M/N QL320 Page 68 of 78 PHOTOGRAPH 19: PCB1 BOTTOM WITH LCD DISPLAY Rhein Tech Laboratories Report number 2002112 360 Herndon Parkway, Suite 1400 FCC Part 15.247 Herndon, VA 20170 Industry Canada RSS-210 FCC ID I28-QL320352 http://www.rheintech.com M/N QL320 Page 69 of 78 PHOTOGRAPH 20: PCB1 BOTTOM WITH LCD DISPLAY Rhein Tech Laboratories Report number 2002112 360 Herndon Parkway, Suite 1400 FCC Part 15.247 Herndon, VA 20170 Industry Canada RSS-210 FCC ID I28-QL320352 http://www.rheintech.com M/N QL320 Page 70 of 78 PHOTOGRAPH 21: PCB2 TOP Rhein Tech Laboratories Report number 2002112 360 Herndon Parkway, Suite 1400 FCC Part 15.247 Herndon, VA 20170 Industry Canada RSS-210 FCC ID I28-QL320352 http://www.rheintech.com M/N QL320 Page 71 of 78 PHOTOGRAPH 22: PCB2 BOTTOM Rhein Tech Laboratories Report number 2002112 360 Herndon Parkway, Suite 1400 FCC Part 15.247 Herndon, VA 20170 Industry Canada RSS-210 FCC ID I28-QL320352 http://www.rheintech.com M/N QL320 Page 72 of 78 PHOTOGRAPH 23: FRONT OF WLAN Note: The WLAN card is Cisco M/N AIR-LMC352, FCC ID: LDK102040. Internal and external pictures are on file with the Commission. Rhein Tech Laboratories Report number 2002112 360 Herndon Parkway, Suite 1400 FCC Part 15.247 Herndon, VA 20170 Industry Canada RSS-210 FCC ID I28-QL320352 http://www.rheintech.com M/N QL320 Page 73 of 78 PHOTOGRAPH 24: REAR OF WLAN Rhein Tech Laboratories Report number 2002112 360 Herndon Parkway, Suite 1400 FCC Part 15.247 Herndon, VA 20170 Industry Canada RSS-210 FCC ID I28-QL320352 http://www.rheintech.com M/N QL320 Page 74 of 78 PHOTOGRAPH 25: WLAN CONNECTION TO ANTENNA

Engineering and Testing for EMC and Safety Compliance 360 Herndon Parkway, Suite 1400 Herndon, VA 20170 Phone: 703-689-0368; Fax: 703-689-2056; Metro: 703-471-6441 CERTIFICATION APPLICATION REPORT FCC PART 15.247 CERTIFICATION & INDUSTRY CANADA CERTIFICATION Test Lab: Rhein Tech Laboratories, Inc. Phone: 703-689-0368 360 Herndon Parkway Fax: 703-689-2056 Suite 1400 Web Site: www.rheintech.com Herndon, VA 20170 E-Mail : [email protected] Applicant Information: Zebra Technologies Phone: 401-739-5800 ext. 352 Contact: Bob Heon Fax: 401-732-0145 30 Plan Way E-Mail: [email protected] Warwick, RI 02886 FCC ID: I28-QL320352 GRANTEE FRN NUMBER: 0006-3040-75 PLAT FORM: N/A RTL WORK ORDER NUMBER: 2002112 MODEL(S): QL320 RTL QUOTE NUMBER: QRTL02-466 DATE OF TEST REPORT: July 30, 2002 Standards and Procedures: ANSI 63.4, DA00-705 (FHSS) and FCC 97-114 (DSSS) FCC Classification: DSSS Direct Sequence Spread Spectrum FCC Rule Part(s): Part 15.247: Operation within the bands 920-928 MHz, 2400-2483.5 MHz and 5725-5850 MHz Direct Sequence System Industry Canada Standard: RSS-210: Low Power License-Exempt Radio Communication Devices (All Frequency Bands) Digital Interface Information Digital Interface was found to be compliant Receiver Information Receiver was found to be compliant Frequency Range (MHz) Output Power* (W) Frequency Tolerance Emission Designator 2412-2462 0.1549 N/A N/A * output power is maximum peak conducted We, the undersigned, hereby declare that the equipment tested and referenced in this report conforms to the identified standard(s) as described in this test report. No modifications were made to the equipment during testing in order to achieve compliance with these standards. Furthermore, there was no deviation from, additions to, or exclusions from the FCC Part 2, FCC Part 15, Industry Canada RSS-210, ANSI 63.4, DA00-705 (FHSS) and FCC 97-114 (DSSS). Signature: Date: July 30, 2002 Typed/Printed Name: Desmond A. Fraser Position:President Rhein Tech Laboratories Report number 2002112 360 Herndon Parkway, Suite 1400 FCC Part 15.247 Herndon, VA 20170 Industry Canada RSS-210 FCC ID I28-QL320352 http://www.rheintech.com M/N QL320 Revision 1 Page 2 of 21 TABLE OF CONTENTS 1 GENERAL INFORMATION...................................................................................................................................................................................................5 1.1 SCOPE..................................................................................................................................................................5 1.2 TEST FACILITY...................................................................................................................................................5 1.3 RELATED SUBMITTAL(S)/GRANT(S)...............................................................................................................5 2 TEST INFORMATION.............................................................................................................................................................................................................6 2.1 TEST JUSTIFICATION.........................................................................................................................................6 2.2 EXERCISING THE EUT.......................................................................................................................................6 2.3 TEST RESULT SUMMARY..................................................................................................................................6 2.4 TEST SYSTEM DETAILS.....................................................................................................................................7 2.5 CONFIGURATION OF TESTED SYSTEM...........................................................................................................8 3 COMPLIANCE WITH THE RESTRICTED BAND EDGE - §15.205.............................................................................................................................9 3.1 TEST PROCEDURE..............................................................................................................................................9 3.2 COMPLIANCE WITH THE RESTRICTED BAND EDGE TEST DATA...............................................................9 3.3 RESTRICTED BAND EDGE PLOTS..................................................................................................................10 4 CONDUCTED LIMITS - §15.207........................................................................................................................................................................................14 4.1 TEST METHODOLOGY FOR CONDUCTED EMISSIONS MEASUREMENTS................................................14 4.2 CONDUCTED EMISSION TEST........................................................................................................................14 4.3 CONDUCTED EMISSION TEST DATA.............................................................................................................15 5 RADIATED EMISSION FOR RECEIVER/DIGITAL INTERFACE - §15.209.............................................................................................................21 5.1 RADIATED EMISSION TEST PROCEDURE FOR RECEIVER/DIGITAL INTERFACE....................................21 5.2 RADIATED EMISSION TEST DATA RECEIVER/DIGITAL INTERFACE........................................................21 6 RADIATED EMISSION RADIATED HARMONICS/SPURIOUS NOISE - §15.247.................................................................................................23 6.1 RADIATED EMISSION TEST PROCEDURE FOR HARMONICS/SPURIOUS NOISE......................................23 6.2 RADIATED EMISSIONS HARMONICS/SPURIOUS TEST DATA....................................................................23 6.3 TEST EQUIPMENT USED FOR TESTING..........................................…

Text truncated - open the document above for the full version.

Rhein Tech Laboratories Report number 2002112 360 Herndon Parkway, Suite 1400 FCC Part 15.247 Herndon, VA 20170 Industry Canada RSS-210 FCC ID I28-QL320352 http://www.rheintech.com M/N QL320 Page 52 of 78 APPENDIX M: TEST PHOTOGRAPHS PHOTOGRAPH 3: RADIATED EMISSION FRONT VIEW Rhein Tech Laboratories Report number 2002112 360 Herndon Parkway, Suite 1400 FCC Part 15.247 Herndon, VA 20170 Industry Canada RSS-210 FCC ID I28-QL320352 http://www.rheintech.com M/N QL320 Page 53 of 78 PHOTOGRAPH 4: RADIATED EMISSION REAR VIEW Rhein Tech Laboratories Report number 2002112 360 Herndon Parkway, Suite 1400 FCC Part 15.247 Herndon, VA 20170 Industry Canada RSS-210 FCC ID I28-QL320352 http://www.rheintech.com M/N QL320 Page 54 of 78 PHOTOGRAPH 5: CONDUCTED EMISSION FRONT VIEW Rhein Tech Laboratories Report number 2002112 360 Herndon Parkway, Suite 1400 FCC Part 15.247 Herndon, VA 20170 Industry Canada RSS-210 FCC ID I28-QL320352 http://www.rheintech.com M/N QL320 Page 55 of 78 PHOTOGRAPH 6: CONDUCTED EMISSION REAR VIEW