P4U-MCTA3REMOTE TRANSMITTER

APPLICANT: KAR-TECH INC. FCC ID: P4U-MCTA3 EXTERNAL PHOTOS

APPLICANT: KAR-TECH INC. FCC ID: P4U-MCTA3 Label sample and location

APPLICANT: KAR-TECH INC. FCC ID: P4U-MCTA3 Internal photos

Introduction The MCTA3 is a frequency hopped spread spectrum transceiver module designed to be compatible with US (FCC Part 15.249) and Canadian (RSS-210) regulations for license free use in the 900 MHz ISM band. The MCTA3 transceiver is integrated into the Mega 143 remote control products. Theory of Operation The MCTA3 is a radio transceiver for the 900 MHz ISM bands. The transceiver microcontroller includes a CPU, GPI/O, a fully integrated frequency synthesizer, a power amplifier, a modulator and a receiver unit. The MCTA3 microcontroller GPI/O port is connected to switches, display and LEDs through protection circuit. The switch data is sent through Serial port to RF processor and then to RF circuit to the antenna and the data received from antenna is sent to the LEDs and display. The microcontroller is responsible for the control of the entire board. The MCTA3 transceiver contains a linear regulator which generates a constant 2.5 VDC. It also includes a battery charger circuit for charging a LiPO battery when connected to the external 5 VDC car charger or universal wall charger. . Specifications Frequency Range: Min.: 902.2 MHz Max.: 927.8 MHz Supply Voltage: 4.2 VDC Nominal Operating Temperature: -40 +85 degree C Transmitter R.F. Power Output: +10 dBm Max. Receive sensitivity: -100 dBm Type of Emission: Frequency Hopping Spread Spectrum Transmitted data rate (Manchester-encoder embedded): 100 kbps

FCC PART 15.249 AND IC RSS-210 TEST REPORT UNLICENSED INTENTIONAL RADIATOR Applicant KAR-TECH INC. Address 111 ENTERPRISE ROAD P.O. BOX 180606 DELAFIELD WISCONSIN 53018 USA FCC ID P4U-MCTA3 IC 4534A-MCTA3 Model Number MCTA3 Product Description REMOTE CONTROL TRANSMITTERS Date Sample Received 9/27/2012 Date Tested 9/28/2012 Tested By John A. Day Approved By Mario R. de Aranzeta Report Number 2530AUT12TestReport.doc Test Results PASS FAIL THE ATTACHED REPORT SHALL NOT BE REPRODUCED EXCEPT IN FULL WITHOUT THE WRITTEN APPROVAL OF TIMCO ENGINEERING, INC. Certificate #0955-01 849 NW State Road 45 Newberry, FL 32669 USA Ph: 888.472.2424 or 352.472.5500 Fax: 352.472.2030 Email: [email protected] Website: www.timcoengr.com APPLICANT: KAR-TECH INC. FCC ID: P4U-MCTA3 IC: 4534A-MCTA3 REPORT: O:\K\KAR-TECH\2530AUT12\2530AUT12TestReport.doc Page 2 of 15 mdea 9.20.2007 TABLE OF CONTENT GENERAL REMARKS ........................................................................................................................ 3 GENERAL INFORMATION ................................................................................................................. 4 EMC EQUIPMENT LIST ..................................................................................................................... 5 TEST PROCEDURES ......................................................................................................................... 6 RADIATION INTERFERENCE ............................................................................................................ 7 OCCUPIED BANDWIDTH .................................................................................................................. 9 BAND EDGE COMPLIANCE ............................................................................................................ 11 DUTY CYCLE .................................................................................................................................. 13 POWER LINE CONDUCTED INTERFERENCE ................................................................................. 15 APPLICANT: KAR-TECH INC. FCC ID: P4U-MCTA3 IC: 4534A-MCTA3 REPORT: O:\K\KAR-TECH\2530AUT12\2530AUT12TestReport.doc Page 3 of 15 mdea 9.20.2007 GENERAL REMARKS The attached report shall not be reproduced except in full without the written permission of Timco Engineering Inc. Summary The device under test does: fulfill the general approval requirements as identified in this test report not fulfill the general approval requirements as identified in this test report Attestations This equipment has been tested in accordance with the standards identified in this test report. To the best of my knowledge and belief, these tests were performed using the measurement procedures described in this report. All instrumentation and accessories used to test products for compliance to the indicated standards are calibrated regularly in accordance with ISO 17025 requirements. Certificate # 0955-01 I attest that the necessary measurements were made, under my supervision, at: Timco Engineering Inc. 849 NW State Road 45 Newberry, Fl 32669 Authorized Signatory Name: Mario de Aranzeta C.E.T. Compliance Engineer/ Lab. Supervisor Date: September/28/2012 APPLICANT: KAR-TECH INC. FCC ID: P4U-MCTA3 IC: 4534A-MCTA3 REPORT: O:\K\KAR-TECH\2530AUT12\2530AUT12TestReport.doc Page 4 of 15 mdea 9.20.2007 GENERAL INFORMATION DUT Specification The test results relate only to the items tested. Applicable Standard FCC Part 15.249, IC RSS-210, RSS-GEN DUT Description REMOTE CONTROL TRANSMITTER FCC ID P4U-MCTA3 IC 4534A-MCTA3 Model Number MCTA2 Operating Frequency TX: 903-927 MHz RX: Same No. of Channels 60 DUT Power Source 110–120Vac/50– 60Hz DC Power Battery Operated Exclusively Test Item Prototype Pre-Production Production Type of Equipment Fixed Mobile Portable Antenna Connector FCC Rules require that the antenna connector be unique. Test Facility Timco Engineering Inc. located at 849 NW State Road 45 Newberry, FL 32669 USA. Test Conditions Temperature: 26ºC Relative humidity: 50% Test Exercise The DUT was placed in continuous transmit mode of operation. Modifications none Test Supporting Equipment Supporting Device Manufacturer Model / FCC ID Serial Number N/A APPLICANT: KAR-TECH INC. FCC ID: P4U-MCTA3 IC: 4534A-MCTA3 REPORT: O:\K\KAR-TECH\2530AUT12\2530AUT12TestReport.doc Page 5 of 15 mdea 9.20.2007 EMC EQUIPMENT LIST Device Manufacturer Model Serial Number Cal/Char Date Due Date 3/10-Meter OATS TEI N/A N/A 12/31/11 12/31/13 3-Meter OATS TEI N/A N/A 12/31/11 12/31/13 Antenna: Passive Loop EMC Test Systems EMCO 6512 9706-1211 06/14/12 06/14/14 Frequency Counter HP 5385A 2730A03025 08/17/11 08/17/13 Frequency Counter HP 5352B 2632A00165 06/22/11 06/22/13 Digital Multimeter Fluke FLUKE-77-3 79510405 06/13/11 06/13/13 Antenna: Active Loop ETS-Lindgren 6502 00062529 09/23/10 09/23/13 Analyzer Open- Frame Tower Preamplifier HP 8449B 3008A01075 07/22/09 09/15/13 LISN Electro-Metrics ANS-25/2 2604 10/28/11 10/28/13 LISN Electro-Metrics EM-7820 2682 02/01/11 02/01/13 DC Power Supply HP 6264B 03/21/11 03/21/13 3-Meter Semi- Anechoic Chamber Panashield N/A N/A 12/31/11 12/31/13 Temperature Chamber Tenney Engineering TTRC 11717-7 07/03/12 07/03/14 Antenna: Biconnical Electro-Metrics BIA-25 1171 06/13/12 06/13/14 Temperature Chamber Thermotron Corp. S1.2 Mini Max 25-1420-09 07/03/12 07/03/14 Digital Multimeter Fluke 77 35053830 09/09/11 09/09/13 Antenna: Biconnical Eaton 94455-1 1096 05/04/11 05/04/13 Analyzer Tan Tower Preamplifier HP 8449B-H02 3008A00372 11/21/09 10/28/13 Analyzer Tan Tower Quasi- Peak Adapter HP 85650A 3303A01690 11/22/09 10/28/13 Analyzer Tan Tower RF Preselector HP 85685A 3221A01400 11/21/09 10/28/13 Analyzer Tan Tower Spectrum Analyzer HP 8566B Opt 462 3138A07786 3144A20661 11/24/09 10/28/13 Antenna: Biconnical Eaton 94455-1 1057 05/31/11 05/31/13 Antenna: Log- Periodic Eaton 96005 1243 05/31/11 05/31/13 APPLICANT: KAR-TECH INC. FCC ID: P4U-MCTA3 IC…

Text truncated - open the document above for the full version.