ROJ6222SAILOR 6222 VHF DSC class A for GMDSS

SAILOR 6222 VHF DSC User manual Document number: 98-131184-C Release date: June 20, 2011 Disclaimer Any responsibility or liability for loss or damage in connection with the use of this product and the accompanying documentation is disclaimed by Thrane & Thrane. The information in this manual is provided for information purposes only, is subject to change without notice and may contain errors or inaccuracies. Manuals issued by Thrane & Thrane are periodically revised and updated. Anyone relying on this information should acquire the most current version e.g. from http://www.thrane.com or from the distributor. Thrane & Thrane is not responsible for the content or accuracy of any translations or reproductions, in whole or in part, of this manual from any other source. Copyright © 2011 Thrane & Thrane A/S. All rights reserved. Trademark Acknowledgements •Thrane & Thrane is a registered trademark of Thrane & Thrane A/S in the European Union and the United States. •SAILOR is a registered trademarks of Thrane & Thrane A/S. •Other product and company names mentioned in this manual may be trademarks or trade names of their respective owners. GPL notification The software included in this product contains copyrighted software that is licensed under the GPL/LGPL. The verbatim licenses can be found online at: http://www.gnu.org/licenses/old-licenses/gpl-2.0.html http://www.gnu.org/licenses/old-licenses/lgpl-2.1.html You may obtain the complete corresponding source code from us for a period of three years after our last shipment of this product, which will be no earlier than December 31, 2015, by sending a money order or check for DKK 50 to: SW Technology/GPL Compliance, Thrane & Thrane A/S, Lundtoftegaardsvej 93D 2800 Lyngby DENMARK Please write "source for product SAILOR 6222 VHF DSC" in the memo line of your payment. You may also find a copy of the source at http://www.thrane.com/foss. This offer is valid to anyone in receipt of this information. Warranties Any attempt to install or execute software not supplied by Thrane & Thrane on this device will result in the warranty being void. Any attempt to modify the software on this device in a way not specified by Thrane & Thrane will result in the warranty being void. iv Safety warning1 The following general safety precautions must be observed during all phases of operation, service and repair of this equipment. Failure to comply with these precautions or with specific warnings elsewhere in this manual violates safety standards of design, manufacture and intended use of the equipment. Thrane & Thrane assumes no liability for the customer's failure to comply with these requirements. Ground the equipment To minimise shock hazard, the SAILOR 6222 VHF DSC unit must be connected to an electrical ground and the cable instructions must be followed. RF exposure hazards and instructions Your Thrane & Thrane radio set generates electromagnetic RF (radio frequency) energy when transmitting. To ensure that you and those around you are not exposed to excessive amounts of energy and thus to avoid health hazards from excessive exposure to RF energy, all persons must be at least 200 cm away from the antenna when the radio is transmitting. Warranty limitation IMPORTANT - The radio is a sealed waterproof unit (classified IPX8). To create and maintain its waterproof integrity it was assembled in a controlled environment using special equipment. The radio is not a user maintainable unit, and under no circumstances should the unit be opened except by authorized personnel. Unauthorized opening of the unit will invalidate the warranty. Installation and service Installation and general service must be done by skilled service personnel. Compass safe distance Minimum safety distance: 0.85 m from the SAILOR 6222 VHF DSC. v Emergency calls MM MM M AA AA A YY YY Y DD DD D AA AA A YY YY Y NANA NANA NA MEME MEME ME of the VV VV V EE EE E SS SS S SS SS S ELEL ELEL EL in distress CC CC C ALAL ALAL AL LL LL L SS SS S IGNIGN IGNIGN IGN or other IDENIDEN IDENIDEN IDEN TT TT T IFICIFIC IFICIFIC IFIC AA AA A TT TT T IONION IONION ION MM MM M MM MM M S S SS S II II I (If the initial alert is sent by DSC) PP PP P OO OO O SS SS S ITIT ITIT IT IONION IONION ION given as ll ll l atat atat at itit itit it udeude udeude ude and longitlongit longitlongit longit udeude udeude ude or If latitude and longitude are not known or if time is insufficient, in relation to a known geographical location NANA NANA NA TURETURE TURETURE TURE of distress Kind of AA AA A SS SS S SS SS S II II I SS SS S TT TT T ANCANC ANCANC ANC EE EE E required Any other useful INFINF INFINF INF OROR OROR OR MM MM M AA AA A TT TT T IONION IONION ION MM MM M AA AA A YY YY Y DD DD D AA AA A YY YY Y -M-M -M-M -M AA AA A YY YY Y DD DD D AA AA A YY YY Y -M-M -M-M -M AA AA A YY YY Y DD DD D AA AA A YY YY Y This is NANA NANA NA ME-NAME-NA ME-NAME-NA ME-NA ME-NAME-NA ME-NAME-NA ME-NA MEME MEME ME CC CC C ALAL ALAL AL LL LL L SS SS S IGNIGN IGNIGN IGN or other IDENTIFICATION MM MM M MM MM M SS SS S II II I (If the initial alert is sent by DSC) Use the HANDHAND HANDHAND HAND SS SS S ETET ETET ET for voice calling LL LL L ifif ifif if t Ct C t Ct C t C ovov ovov ov erer erer er PP PP P rr rr r ee ee e ss ss s s RED Buttons RED Button s RED Buttons RED Button s RED Button until beep sounds continuously (more than 3 seconds) SHIP‘s NAME: CALLSIGN: MMSI: OWN OWN OWN OWN OWN IDID IDID ID 99-132140 Press VHF MF HF4 HF6 HF8 HF12 HF16 Channel 70 2187.5 kHz 4207.5 kHz 6312.0 kHz 8414.5 kHz 12577.0 kHz 16804.5 kHz Channel 16 2182.0 kHz 4125.0 kHz 6215.0 kHz 8291.0 kHz 12290.0 kHz 16420.0 kHz - - - - - 2174.5 kHz 4177.5 kHz 6268.0 kHz 8376.5 kHz 12520.0 kHz 16695.0 kHz DD DD D SCSC SCSC SC RR RR R adiadi adiadi adi otot otot ot elephonelephon elephonelephon elephon yy yy y NBDPNBDP NBDPNBDP NBDP DIDI DIDI DI SS SS S TRETRE TRETRE TRE SS SS S SS SS S and C and C and C and C and C OMOM OMOM OM MM MM M UNICUNIC UNICUNIC UNIC AA AA A TT TT T IONION ION…

Text truncated - open the document above for the full version.

Thrane & Thrane A/S · Lundtoftegaardsvej 93 D · DK-2800 Kgs. Lyngby · Denmark T +45 39 55 88 00 · F +45 39 55 88 88 · [email protected] · www.thrane.com Bank: Danske Bank · Comp.reg.: 65 72 46 18 · VAT: DK-20 64 64 46 Federal Communications Commission, EQUIPMENT APPROVAL SERVICES, P.O. Box 358315 Pittsburgh, Pa 15251-5315 ATTN: Authorization & Evaluation Division Date: June 15. 2011 RE: FCC ID: ROJ6222 Model: TT-6222A Statement Thrane & Thrane A/S hereby declares that the above mentioned equipment complies with FCC part 80 subpart W, §80.1101, regarding performance standards for GMDSS equipment. The equipment meets the requirements of the following standards: IEC 60945 IMO Resolution A.694(17) IMO Resolution A.803(19) ITU-R Recommendation M.493-11 ITU-R Recommendation M.541-9. Test reports showing compliance with these requirements can be provided if requested by FCC and or USCG. Sincerely, Thrane & Thrane A/S Morten Becker Saul RF Senior Engineer BGAN Research & Development

Thrane & Thrane A/S · Lundtoftegaardsvej 93 D · DK-2800 Kgs. Lyngby · Denmark T +45 39 55 88 00 · F +45 39 55 88 88 · [email protected] · www.thrane.com Bank: Danske Bank · Comp.reg.: 65 72 46 18 · VAT: DK-20 64 64 46 Federal Communications Commission, EQUIPMENT APPROVAL SERVICES, P.O. Box 358315 Pittsburgh, Pa 15251-5315 ATTN: Authorization & Evaluation Division Date: June 15. 2011 RE: FCC ID: ROJ6222 Model: TT-6222A Statement Thrane & Thrane A/S hereby declares that the above mentioned equipment complies with FCC part 80 subpart W, §80.1101, regarding performance standards for GMDSS equipment. The equipment meets the requirements of the following standards: IEC 60945 IMO Resolution A.694(17) IMO Resolution A.803(19) ITU-R Recommendation M.493-11 ITU-R Recommendation M.541-9. Test reports showing compliance with these requirements can be provided if requested by FCC and or USCG. Sincerely, Thrane & Thrane A/S Morten Becker Saul RF Senior Engineer BGAN Research & Development

System 6000 Sailor 6222 VHF Pictures external and internal 15 November, 2010 Page 1 of 4 SAILOR 6222 front view SAILOR 6222 rear view

6222 VHF DSC GMDSS S/N xxxxxxxxxx P/N 406222A IC: 6200B-6222 G FCC ID: ROJ6222 Complies with the FCC requirements for two-way radiotelephone equipment Model: TT-6222A 6222 VHF DSC GMDSS S/N xxxxxxxxxx P/N 406222A IC: 6200B-6222 G FCC ID: ROJ6222 Complies with the FCC requirements for two-way radiotelephone equipment Model: TT-6222A System 6000 SAILOR 6222 VHF Type label picture 1 June, 2011 Page 1 of 1 Placing of type label for 6222 VHF at back side Thrane & Thrane A/S · Porsvej 2 · P.O. Box 7071 · DK-9200 Aalborg SV · Denmark T +45 39 55 88 00 · F +45 96 34 63 90 · [email protected] · www.thrane.com Bank: Danske Bank · Comp.reg.: 65 72 46 18 · VAT: DK-20 64 64 46 1/1 SAILOR 6222 GMDSS VHF Type label RE: FCC ID: ROJ6222 Description of type label The label is designed to withstand daily use in harsh environment at sea. Scratch resistant, not sensitive to water, oil and sun. Heat resistant >100 º C. Strong adhesive. It is a top-coated thermal transfer printable metalized silver matte polyester film coated with a permanent pressure sensitive acrylic adhesive and backed with a glassine liner Basic material: Manufacture: Flexcon, USA Top-coat no. TC-387 Material: Polyester, THERMLfilm SELECT Thickness: 128 mocron UL recognition: Flexcons UL file no. MH16635 Text film, Material: Wax/Resin Text film, Thickness: 4.6micron Aalborg, 2010 November 24 th Helge Hoff Senior Engineer HW Team leader

System 6000 Sailor 6222 VHF Pictures external and internal 15 November, 2010 Page 2 of 4 Front unit with screen Front unit without screen System 6000 Sailor 6222 VHF Pictures external and internal 15 November, 2010 Page 3 of 4 Main unit with screen Main unit without screen System 6000 Sailor 6222 VHF Pictures external and internal 15 November, 2010 Page 4 of 4 Main unit without housing -1 Main unit without housing -2 System 6000 SAILOR 6222 VHF Pictures of Internal Modules 15 November, 2010 Page 1 of 3 Control – Display module front view Control – Display modules back view System 6000 SAILOR 6222 VHF Pictures of Internal Modules 15 November, 2010 Page 2 of 3 HMI module front view HMI module back view Intercon module front view Intercon module back view System 6000 SAILOR 6222 VHF Pictures of Internal Modules 15 November, 2010 Page 3 of 3 Fro board module front view Fro board module back view

THRANE & THRANE TUNE UP PROCEDURE for SAILOR 6222 GMDSS VHF SAILOR 6222 GMDSS VHF always requires a license to operate. Channel programming SAILOR 6222 is pre-programmed by the manufacture with the International Maritime VHF Channel table according to Radio Regulation appendix 18 as well as the US channels, the Canadian channels and the Inland Waterways channels. The operator can select the channel set in question by a soft-key operation. The users have to apply the authority for a license and a private channel allocation. The private channels can only be programmed into the radio by a general agent or the manufacture by special Service tools. Users are not able to access or change any of the pre-programmed channels. Power settings Power settings are adjusted at the factory. The settings for the normal “High” power and the reduced “Low” power are saved and locked in the radio and is not accessible for the user. The user is not able to change any of the preset power settings. The user can only select the preset “Low power” or “High power” by pushing a button on the keyboard. Press the key 1W to toggle the transmit power between low (1 W, LO is displayed) and high (25 W). Power on and volume in handset and speaker The VHF radio has a dual-function on/off wheel knob for power on/off and volume control. • To power on the VHF radio press the on/off wheel knob. • To power off the VHF radio, press and hold the on/off wheel knob and follow the instructions in the display. • To adjust the speaker volume, turn the volume wheel knob (clockwise = louder, counter clockwise = softer, until muted). When muted, is shown in the display. Working channel and changing settings Use the selector wheel knob to browse and select: • To browse and select settings, turn the selector wheel knob and press for accept. • To select a working channel use the selector wheel knob or enter the channel number using the keypad. A single, short press on the 16/C key will always bring you to channel 16, the international calling and distress channel, no matter what state the radio is in. THRANE & THRANE Make a radio telephone call Press the PTT button on the handset device. When the TX indicator lights up in the display, the transmission is active. To enable reception of a radio signal release the PTT button. Also referring to the manual Aalborg, 2010 November 24 th Helge Hoff Senior Engineer HW Team leader

Prediction of MPE limit at a given distance Equation from page 18 of OET Bulletin 65, Edition 97-01 S=PG/(4 πR 2 ) where: S = power density P = power input to the antenna G = power gain of the antenna R = distance to the center of radiation of the antenna Valid for frequencies from 100 to 300.000 MHz Output Power:44.00(dBm) Output Power:25.1 (W) Antenna gai n:6.00(dBi) Antenna gai n:4.0 (numeri c) Distance:200 (cm) Frequency:157.425(MHz) MPE limit-uncontrolled:2.00 (W/m^2)OET 65C page 26 MPE limit controlled:10.00 (W/m^2)OET 65C page 26 Uncontrolled Exposure: Power density:1.99(W/m^2) Maximum allowable antenna gain:6.02(dBi) Margin of Compliance:0.02(dB) Controlled Exposure: Power density:1.99(W/m^2) Maximum allowable antenna gain:13.01(dBi) Margin of Compliance:7.01(dB) The above calculations are based on measured output power into the artificial antenna

Nemko AS, Gaustadalléen 30, P.O.Box 73 Blindern, NO-0314 Oslo Norway T +47 22 96 03 30 F +47 22 96 05 50 Enterprise number NO974404532 Visiting address: Nemko Kjeller, Instituttveien 6, P.O.Box 96, NO-2027 Kjeller Norway T +47 64 84 57 00 F +47 64 84 57 05 Test report no. : 158780/5 Item tested: Sailor 6222 VHF DSC Type of equipment: VHF Transceiver Client: Thrane &Thrane A/S FCC Part 80 IRC RSS-182, Issue 4 2011-06-20 Authorized by: .............................................. Geir Antonsen Technical Verificator Nemko AS is granted accreditation by Norwegian Accreditation under the registration number TEST 033 TEST REPORT FCC Part 80 / RSS-182 Project No.: 158780 Nemko AS, N-2027 Kjeller Page 2 (43) CONTENTS 1 GENERAL INFORMATION ................................................................................................ 3 1.1 Tested by ............................................................................................................................. 3 1.2 Client Information ................................................................................................................ 3 1.3 Manufacturer (if other than client) ....................................................................................... 3 2 TEST INFORMATION ......................................................................................................... 4 2.1 Tested Item ......................................................................................................................... 4 2.2 Test Environment ................................................................................................................ 5 2.3 Test Period .......................................................................................................................... 5 2.4 Test Engineers .................................................................................................................... 5 2.5 Test Equipment ................................................................................................................... 5 2.6 Comments ........................................................................................................................... 5 3 TEST REPORT SUMMARY ............................................................................................... 6 3.1 General ................................................................................................................................ 6 3.2 Test Summary ..................................................................................................................... 7 4 TEST RESULTS ................................................................................................................. 8 4.1 RF Output Power ................................................................................................................. 8 4.2 RF Output Power – TX timer ............................................................................................... 9 4.3 Modulation characteristics ................................................................................................. 10 4.4 Modulation characteristics ................................................................................................. 11 4.5 Modulation characteristics ................................................................................................. 12 4.6 Spurious Emissions in frequency band 9 kHz – 2 GHz ..................................................... 12 4.7 Spurious Emissions close to carrier .................................................................................. 13 4.8 Field strength of spurious radiation s ................................................................................ 14 4.9 Radiated emission limits ................................................................................................... 15 4.10 Frequency stability ............................................................................................................. 16 5 TEST EQUIPMENT USED................................................................................................ 17 6 MEASUREMENT PLOTS ................................................................................................. 18 6.1 Occupied Bandwidth ......................................................................................................... 18 6.2 Conducted Spurious Emissions – carrier at 156,525 MHz ................................................ 21 6.3 FCC Spectrum emission masks........................................................................................ 27 6.4 RSS-182 Spectrum emission masks ................................................................................ 32 6.5 Field strength of spurious radiation ................................................................................... 37 6.6 Radiated emission limits ................................................................................................... 42 TEST REPORT FCC Part 80 / RSS-182 Project No.: 158780 Nemko AS, N-2027 Kjeller Page 3 (43) 1 GENERAL INFORMATION 1.1 Tested by Name : Nemko A/S Address : Nemko Kjeller Instituttveien 6, Box 96 N-2027 Kjeller, NORWAY Telephone : +47 64 84 57 00 Fax : +47 64 84 57 05 E-mail: [email protected] Number of Pages: 43 1.2 Client Information Name : Thrane & Thrane A/S Address : Porsvej 2 DK-9200 Aalborg SV Telephone : +45 96 34 63 44 Fax : - Contact: Name : Henrik Kalstrup E-mail: [email protected] 1.3 Manufacturer (if other than client) Name : - Address : - TEST REPORT FCC Part 80 / RSS-182 Project No.: 158780 Nemko AS, N-2027 Kjeller Page 4 (43) 2 Test Information 2.1 Tested Item Name : Thrane & Thrane Model/version : TT-6222A Serial number : 0000000005 Hardware identity and/or version: 626222A Software identity and/or version : 1.01.0002 Build date Nov 19 2010 Frequency Range : 156.025 MHz – 157.425 MHz Tuneable Bands : / Number of Channels : 57 Channel spacing: 12.5 and …

Text truncated - open the document above for the full version.