S5751307990Field device access point Gen3

OneWireless Field Device Access Point Gen3 User's Guide OWDOC-X256-en-322A November 2020 Release 322.1 2 www.honeywell.com Revision Supported Release Date Description A 322 November 2020 Initial release of the document Disclaimer This document contains Honeywell proprietary information. Information contained herein is to be used solely for the purpose submitted, and no part of this document or its contents shall be reproduced, published, or disclosed to a third party without the express permission of Honeywell International Sàrl. While this information is presented in good faith and believed to be accurate, Honeywell disclaims the implied warranties of merchantability and fitness for a purpose and makes no express warranties except as may be stated in its written agreement with and for its customer. In no event is Honeywell liable to anyone for any direct, special, or consequential damages. The information and specifications in this document are subject to change without notice. Copyright 2020 - Honeywell International Sàrl. 3 Contents 1 About this guide ........................................................................................................................................ 5 2 Introduction to FDAP ................................................................................................................................ 7 2.1 FDAP description .................................................................................................................................................. 8 2.2 Types of FDAPs .................................................................................................................................................. 10 2.3 Physical description of FDAP Gen3 ....................................................................................................................... 11 2.4 Physical description of FDAP1/FDAP2 .............................................................................................................. 12 2.5 Features of FDAP ................................................................................................................................................ 14 2.6 FDAP security ..................................................................................................................................................... 15 2.7 FDAP compliance information ........................................................................................................................... 16 3 FDAP Installation .................................................................................................................................... 18 3.1 Prerequisites for installation ................................................................................................................................ 19 3.2 Inspect FDAP and associated hardware .............................................................................................................. 20 3.3 Identify FDAP site locations ............................................................................................................................... 21 3.4 Connect antennas for FDAP Gen3 ...................................................................................................................... 22 3.5 Connect antennas for FDAP1/FDAP2 ................................................................................................................ 23 3.6 Recommendations for remote antenna connections. ........................................................................................... 23 3.7 Ground the FDAP Gen3 ...................................................................................................................................... 24 3.8 Ground the FDAP1/FDAP2 ................................................................................................................................ 24 3.9 Mount the FDAP Gen3 ....................................................................................................................................... 26 3.9.1 Pole mounting ...................................................................................................................................... 26 3.9.2 Wall or flat surface mounting ............................................................................................................... 27 3.10 Mount the FDAP1/FDAP2 .................................................................................................................. 28 3.10.1 Pole mounting .................................................................................................................................. 28 3.10.2 Wall or flat surface mounting .......................................................................................................... 29 3.11 Connect power cables and Ethernet cables for FDAP Gen3 ................................................................ 30 3.11.1 DC power wiring ............................................................................................................................. 30 3.11.2 Ethernet wiring ................................................................................................................................ 31 3.12 Connect power cables and Ethernet cables for FDAP1/FDAP2 ........................................................... 32 3.12.1 DC power wiring ............................................................................................................................. 32 3.12.2 AC power wiring ............................................................................................................................. 33 3.12.3 Ethernet wiring ................................................................................................................................ 34 3.13 Power on and startup for FDAP Gen3 ....................................................................................…

Text truncated - open the document above for the full version.

Contact name: Prasad Samudrala Designation: Senior Technology Specialist E-Mail ID: [email protected] Date: 08-12-2020 Authorization to Act as Agent On our behalf, I appoint Mr. Raghavendra Kulkarni of TUV Rheinland India Ltd. 27/B, 2nd cross, Electronic City, Phase 1 Bangalore – 560 100. INDIA to act as my agent in the preparation/signing of this application for equipment certification for the following FCC ID: S5751454941. I certify that the submitted documents properly describe the device or system for which equipment certification is sought. I also certify that each unit manufactured, imported or marketed, as defined in FCC’s regulations, will have affixed to it a label identical to that submitted for approval with this application. Date: 08-12-2020 Agency Agreement Expiration Date: 08-06-2021 By _____________ Signature Name : Prasad Samudrala Title: Senior Technology Specialist On behalf of Honeywell International Inc Phone: 917348936728 Company Name: Honeywell Technology Solution Lab Survey No. 96& 97, Boganahalli Village, Survey No. 72/2 & 72/5, Doddakannahalli Village, Varthur Hobli, Bengaluru 560103 Contact No. : 917348936728

Date: 29-01-2021 Federal Communications Commission Authorization and Evaluation division Subject: Confidentiality Request for Field Device Access Point Gen3 FCC ID: S5751307990 Pursuant to 47 CRF 0.457(d) and 0.459, Honeywell Internal Inc. Industrial Measurement & Control requests that a part of the subject application be held confidential Type of Confidentiality requested Exhibit Type File name Long Term Operational Description Operational Description GXRM Long Term Block Diagram Block Diagram GXRM Long Term Bill of Material Bill of Material GXRM Long Term Schematic -GXRM Schematics GXRM Long Term Schematic-Host Schematics FDAP Power Board Long Term Schematic-Host Schematics FDAP Base Board Short Term Host User Manual User Manual FDAP Short-term Host Internal Photos Internal Photos The above materials contain proprietary information not customarily released to the public. The public disclosure of these matters might be harmful to the applicant and provide unjustified benefits to its competitors. Short term confidentiality period is 45days. Hand signed (not electronic) Prasad Samudrala Company Honeywell International Inc Address: 1860, W. Rose garden Lane, Phoenix, Arizona, US-85027 Phone: 917348936728

Produkte Products www.tuv.com Prüfbericht - Nr.: Test Report No.: Referance Test Report Number ULR-TC568820300000071F Seite 1 von 4 Page 1 of 4 1 EUT External Photos Photo2: Front view Photo3: EUT Rear view Produkte Products www.tuv.com Prüfbericht - Nr.: Test Report No.: Referance Test Report Number ULR-TC568820300000071F Seite 2 von 4 Page 2 of 4 Photo 4: EUT dimensional view (Width) Photo 5: EUT dimensional view (Length) Produkte Products www.tuv.com Prüfbericht - Nr.: Test Report No.: Referance Test Report Number ULR-TC568820300000071F Seite 3 von 4 Page 3 of 4 Photo 6: EUT dimensional view (Height) Photo 8: EUT with Antenna External antenna connected Produkte Products www.tuv.com Prüfbericht - Nr.: Test Report No.: Referance Test Report Number ULR-TC568820300000071F Seite 4 von 4 Page 4 of 4 Photo 9: EUT with all supported antennas EUT with it accessories *****End of EUT External photos***** Laird Technologies - OD24M-5 AIR- ANT245 0V-N AIR-ANT2480V-N L-COM HGV-2409U 8dBi Omni Antenna

Label information: 51156751-003, FIELD DEVICE ACCESS POINT GEN3, FDAP31 51156751-002, FIELD DEVICE ACCESS POINT GEN3, FDAP32 51156751-001, FIELD DEVICE ACCESS POINT GEN3 PLUS,FDAP3P Label Location

Produkte Products www.tuv.com Prüfbericht - Nr.: Test Report No.: Reference test report No: ULR- TC568820300000071F Seite 1 von 3 Page 1 of 3 1 EUT Internal Photos EUT with top enclosure removed Photo 1: EUT PCB front view GXRM Radio module board 1 GXRM Radio module board 2 BLE module Produkte Products www.tuv.com Prüfbericht - Nr.: Test Report No.: Reference test report No: ULR- TC568820300000071F Seite 2 von 3 Page 2 of 3 Photo3: PCB Dimension View (Width) Photo4: PCB Dimension View (Length) Produkte Products www.tuv.com Prüfbericht - Nr.: Test Report No.: Reference test report No: ULR- TC568820300000071F Seite 3 von 3 Page 3 of 3 Photo5: GXRM module board dimensional view( Length) Photo5: GXRM module board dimensional view (Length) *****End of Internal photos****

Produkte Products Prüfbericht - Nr.: Test Report No. Error! Reference source not found. Seite 1 von 2 Page 1 of 2 Produkte Products 1 Safety Human Exposure 1.1 Radio Frequency Exposure Compliance 1.1.1 Electromagnetic Fields RESULT: Pass Test Specification Test standard : CFR47 FCC Part 2: Section 2.1091 CFR47 FCC Part 1: Section 1.1310 FCC KDB Publication 447498 v06, section 7 RSS-102 Issue 5 March 2015, section 2.5.2  FCC requirements FCC requirement: Systems operating under the provisions of this section shall be operated in a manner that ensures that the public is not exposed to radio frequency energy level in excess limit for maximum permissible exposure. In accordance with 47 CFR FCC Part 2 Subpart J, section 2.1091 this device has been defined as a mobile device whereby a distance of 20cm normally can be maintained between the user and the device. MPE Calculation Method according to KDB 447498 v06 Power Density: S (mW/cm 2 ) = PG/4πR 2 or EIRP/4πR 2 Where: S = power density (mW/cm 2 ) P = power input to the antenna (mW) G = power gain of the antenna in the direction of interest relative to an isotropic radiator R = distance to the center of radiation of the antenna (cm) From the peak RF output power, the minimum mobile separation distance, d=20 cm, as well as the antenna gain, the RF power density can be calculated as below: S (mW/cm 2 ) = PG/4πR 2 Produkte Products Prüfbericht - Nr.: Test Report No. Error! Reference source not found. Seite 2 von 2 Page 2 of 2 a) EUT RF Exposure Evaluation standalone operations Test Mode Measured Peak Power Antenna Gain (dBi) Measured e.i.r.p S (mW/cm 2 ) = PG/4πR 2 Limit (mW/cm 2 ) (dBm) (mW) (dBm) (mW) BLE 4.15 2.60 3 7.15 5.19 0.001 1.0 IEE 802.15.4 18.86 76.91 5 23.86 243.22 0.048 1.0 IEE 802.15.4 16.32 42.85 8 24.32 270.40 0.054 1.0 b) EUT RF Exposure Evaluation simultaneous transmission operations Simultaneous transmission mode The sum of the ratios Result BLE + IEE 802.15.4 0.001/1 + 0.054/1< 1 Pass  IC requirements: The EUT shall comply with the requirement of RSS-102 section 2.5.2. Exemption from Routine Evaluation Limits – RF Exposure Evaluation RF exposure evaluation is required if the separation distance between the user and/or bystander and the device’s radiating element is greater than 20 cm, except when the device operates as follows: at or above 300 MHz and below 6 GHz and the source-based, time-averaged maximum e.i.r.p. of the device is equal to or less than 1.31 x 10 -2 ƒ 0.6834 W (adjusted for tune-up tolerance), where ƒ is in MHz;  RF exposure evaluation exempted power: 2.670 W a) EUT RF Exposure Evaluation standalone operations: Test Mode Measured Peak Power Antenna Gain (dBi) Measured e.i.r.p (mW) (dBm) (mW) (dBm) (mW) BLE 4.15 2.60 3 7.15 5.19 IEE 802.15.4 18.86 76.91 5 23.86 243.22 IEE 802.15.4 16.32 42.85 8 24.32 270.40 b) EUT RF Exposure Evaluation simultaneous transmission operations Simultaneous transmission mode The sum of the ratios Result BLE + IEE 802.15.4 0.00519/2.67 + 0.2704/2.67< 1 Pass The e.i.r.p. are less than the RF exposure evaluation exempted power. So RF exposure evaluation is not required. “RF Radiation Exposure Statement Caution: This Transmitter must be installed to provide a separation distance of at least 20 cm from all persons.”

Prüfbericht – Produkte Test Report - Products Prüfbericht-Nr.: Test report no.: ULR- TC568820300000071F Auftrags-Nr.: Order no.: 166484900 0010 Seite 1 von 75 Page 1 of 75 Kunden-Referenz-Nr.: Client reference no.: NA Auftragsdatum: Order date: 2020-10-02 Auftraggeber: FCC Client: Honeywell international corp, 1860 W.Rosegarden lane,Phoenix,Arixona, United States 85027-2708 Auftraggeber: ISED Client: Honeywell Technology Solution Lab Devarabisanahalli Village,KR puram Hobli, Bangalore, Karnataka-560103,India Prüfgegenstand: Test item: Field Device Access Point Gen3 Bezeichnungs .: Identifications .: FDAP31,FDAP32,FDAP3P Auftrags-Inhalt: Order content: Testing and Issue of test report & Issue FCC and ISED grant certificate Prüfgrundlage: Test specification: FCC Part 15 Subpart C 15.247, 15.207 & RSS 247 Issue 2 and RSS Gen Issue 5 Wareneingangsdatum: Date of sample receipt: 2020-11-11 Prüfmuster-Nr & Serien-Nr.: Test sample no & serial no.: A002947320-001 A002947320-002 & Engineering sample Serial number not available Prüfzeitraum: Testing period: 2020-11-03 - 2020-11-13 Ort der Prüfung: Place of testing: Wireless laboratory, Bangalore Prüflaboratorium: Testing laboratory: TÜV Rheinland (India) Pvt. Ltd.27/B 2nd Cross Road,Electronic City Phase1,Bangalore-560 100,India FCC Test site registration number: 496599 ISED Test site registration number: 3466E-1 Prüfergebnis*: Test result*: Pass geprüft von: tested by: genehmigt von: authorized by: Datum: Date: 2020-11-03 Ausstellatum: Issue date: 2021-02-18 Stellung / Position: Srinivasa B R Engineer Stellung / Position: Mahammadgouse Kaladagi Assitant Manager Sonstiges / Other: FCC ID:S5751307990 IC:573W-51307990 Contains FCC ID:XPYNINAB1 Contains IC:8595A-NINAB1 Zustand des Prüfgegenstandes bei Anlieferung: Condition of the test item at delivery: Prüfmuster vollständig und unbeschädigt Test item complete and undamaged * Legende: 1 = sehr gut 2 = gut 3 = befriedigend 4 = ausreichend 5 = mangelhaft P(ass) = entspricht o.g. Prüfgrundlage(n) F(ail) = entspricht nicht o.g. Prüfgrundlage(n) N/A = nicht anwendbar N/T = nicht getestet * Legend: 1 = very good 2 = good 3 = satisfactory 4 = sufficient 5 = poor P(ass) = passed a.m. test specification(s) F(ail) = failed a.m. test specification(s) N/A = not applicable N/T = not tested Dieser Prüfbericht bezieht sich nur auf das o.g. Prüfmuster und darf ohne Genehmigung der Prüfstelle nicht auszugsweise vervielfältigt werden. Dieser Bericht berechtigt nicht zur Verwendung eines Prüfzeichens. This test report only relates to the a. m. test sample. Without permission of the test center this test report is not permitted to be duplicated in extracts. This test report does not entitle to carry any test mark. TÜV Rheinland (India) Pvt. Ltd, Plot No.27/B, 2nd Cross, Electronic city, Industrial Area, Phase I, Hosur Road Bangalore-560 100, India Mail: [email protected] ∙ Web: www.ind.tuv.com Produkte Products www.tuv.com Prüfbericht - Nr.: Test Report No.: ULR-TC568820300000071F Seite 2 von 75 Page 2 of 75 TEST SUMMARY Test Item Applicable Standard Result FCC ISED Maximum conducted (Peak) output power FCC 15.247(b)(3) RSS 247 Issue 2, Section 5.4 (d) Pass Maximum Power Spectral Density FCC 15.247(e) RSS 247 Issue 2, Section 5.2 (b) Pass DTS Bandwidth FCC 15.247(a)(2) RSS 247 Issue 2, Section 5.2 (a) Pass Emissions in non-restricted frequency bands FCC 15.247(d) RSS 247 Issue 2, Section 5.5 Pass Spurious Radiated Emissions and Restricted Bands of Operation FCC 15.209 / FCC 15.205 RSS-Gen Issue 5, Section 8.9 /8.10 Pass Conducted Emissions on a.c Power Lines FCC 15.207 RSS-Gen Issue 5, Section 8.8 Pass Note 1. Host products Field device access point (FDAP) has following model variants , all the models are electrically identical & RF characteristics are similar, please refer the model difference summary document filed with this certification for more details. Model name Model number Field device access point FDAP31 FDAP32 FDAP3P 2. Product Field device access point(FDAP) Unit has been integrated with following certified BLE module, and the Host product FDAP is listed with FCC ID: S5751307990 and IC:573W-51307990 by addressing the co- location of BLE transmitter with GXRM transmitter and simultaneous operation of GXRM and BLE transmitters. Sl No. Radio Protocol FCC ID IC No of transmitter in the Host Original module Tested By 1 BLE XPYNINAB1 8595A-NINAB1 1 7Layers GmbH 3. The product Field Device Access Point Gen3 has 2 RF ports and it is verified that the two ports are electrical identically, and full testing is performed on one single RF port. Product Category: Electronics Testing Test Discipline: EMC Test Facility Produkte Products www.tuv.com Prüfbericht - Nr.: Test Report No.: ULR-TC568820300000071F Seite 3 von 75 Page 3 of 75 REVISION HISTORY OF THIS REPORT Report Number Version Description Issue date ULR-TC568820300000071F 01 Initial issue of test report 2021-02-08 ULR-TC568820300000071F 02 Updated as per Reviwer comments 2021-02-18 Produkte Products www.tuv.com Prüfbericht - Nr.: Test Report No.: ULR-TC568820300000071F Seite 4 von 75 Page 4 of 75 Table of Contents 1 GENERAL REMARKS .......................................................................................................................................... 5 1.1 Attachments ................................................................................................................................................. 5 2 TEST SITES ......................................................................................................................................................... 6 2.1 Testing Facilities........................................................................................................................................... 6 2.2 List of Test and Measurement Instruments .................................................................................................. 6 3 GENERAL PRODUCT INFORMATION ...................................…

Text truncated - open the document above for the full version.

Produkte Products www.tuv.com Prüfbericht - Nr.: Test Report No.: Reference test report No: ULR- TC568820300000071F Seite 1 von 6 Page 1 of 6 Test setup photos Frequency range:9kHz-30MHz Polarization: Perpendicular Frequency range:9kHz-30MHz Polarization:Parallel Produkte Products www.tuv.com Prüfbericht - Nr.: Test Report No.: Reference test report No: ULR- TC568820300000071F Seite 2 von 6 Page 2 of 6 Frequency range:30MHz-200MHz Polarization: Vertical Frequency range:30MHz-200MHz Polarization: Horizontal Produkte Products www.tuv.com Prüfbericht - Nr.: Test Report No.: Reference test report No: ULR- TC568820300000071F Seite 3 von 6 Page 3 of 6 Frequency range:200MHz-1GHz Polarization: Vertical Frequency range:200MHz-1GHz Polarization: Horizontal Produkte Products www.tuv.com Prüfbericht - Nr.: Test Report No.: Reference test report No: ULR- TC568820300000071F Seite 4 von 6 Page 4 of 6 Frequency range:1GHz – 18GHz Polarization: Vertical Frequency range:1GHz – 18GHz Polarization: Horizontal Produkte Products www.tuv.com Prüfbericht - Nr.: Test Report No.: Reference test report No: ULR- TC568820300000071F Seite 5 von 6 Page 5 of 6 EUT Close-up Conducted Test Setup Produkte Products www.tuv.com Prüfbericht - Nr.: Test Report No.: Reference test report No: ULR- TC568820300000071F Seite 6 von 6 Page 6 of 6 Conducted Emissions Setup (With AC Adaptor) Conducted Emissions Setup (With POE Supply) ****END OF TEST REPORT****