AX2PF3636Car Audio

User Manual This device is installed in vehicle. Since it is not sold to general end users directly, there is no user manual of this device. The following statements must be described on the user manual of the host vehicle of this device; [for FCC] FCC CAUTION Changes or modifications not expressly approved by the party responsible for compliance could void the user’s authority to operate the equipment. This equipment complies with FCC radiation exposure limits set forth for an uncontrolled environment and meets the FCC radio frequency (RF) Exposure Guidelines. This equipment has very low levels of RF energy that it deemed to comply without maximum permissive exposure evaluation (MPE). But it is desirable that it should be installed and operated keeping the radiator at least 20cm or more away from person’s body. [for IC] This device complies with Industry Canada licence-exempt RSS standard(s). Operation is subject to the following two conditions: (1) this device may not cause interference, and (2) this device must accept any interference, including interference that may cause undesired operation of the device. Le présent appareil est conforme aux CNR d'Industrie Canada applicables aux appareils radio exempts de licence. L'exploitation est autorisée aux deux conditions suivantes : (1) l'appareil ne doit pas produire de brouillage, et (2) l'utilisateur de l'appareil doit accepter tout brouillage radioélectrique subi, même si le brouillage est susceptible d'en compromettre le fonctionnement. This equipment complies with IC radiation exposure limits set forth for an uncontrolled environment and meets RSS-102 of the IC radio frequency (RF) Exposure rules. This equipment has very low levels of RF energy that it deemed to comply without maximum permissive exposure evaluation (MPE). But it is desirable that it should be installed and operated keeping the radiator at least 20cm or more away from person's body. Cet équipement est conforme aux limites d’exposition aux rayonnements énoncées pour un environnement non contrôlé et respecte les règles d’exposition aux fréquences radioélectriques (RF) CNR-102 de l’IC. Cet équipement émet une énergie RF très faible qui est considérée conforme sans évaluation de l’exposition maximale autorisée. Cependant, il est souhaitable qu'il devrait être installé et utilisé en gardant une distance de 20 cm ou plus entre le dispositif rayonnant et le corps. Audio set Eject Button Power/Volume Button Home Button Tune/Audio Button Seek/Track Up Button Seek/Track Down Button PHONE Button Power and audio controls Eject Button Power/Volume Button Home Button Press the “▲” button to eject aPush the dial for ON or OFF. Press the button to indicate main menu. disc loaded in the audio set.Turn the dial to control volume. Tune/Audio Button Seek/Track Up Button Turn “Tune” dial clockwise to increase the tuning frequency and Press the button and hold 2s, the radio will automatically turn the “Tune” dial counterclockwise to decrease it. search for a receivable station and stop at the first one it finds. Press switch to select desired tone and balance control modes.Press the button to select the next folder. Press the button to select the previous. Seek/Track Down Button PHONE Button Press the button and hold 2s, the radio will automatically Press the button to pair with your cell phone. search for a receivable station and stop at the first one it finds. Press the button to select the previous. FM MODE Preset Channel List Preset Channel Key Band Display Area Frequency Display Area Band Select Key STEREO Display Area Setting Key SCAN Key Source Select Key Preset Channel List Preset Channel Key Band Display Area You can preset the channel in You can select the channel when In the area,you can select the Preset Channel List. you press the key.the band that you want. Frequency Display Area Band Select Key STEREO Display Area The CurrentFrequency that You can select the band when The area is used to judge you are receving you press the key.whether the stereo or not. Setting Key SCAN Key Source Select Key Press the key to enter the Press the key,the radio Press the key to enter the audio setting.starts to scan the channel.Multimedia Select Interface. AM MODE Preset Channel List Preset Channel Key Band Display Area Frequency Display Area Band Select Key STEREO Display Area Setting Key SCAN Key Source Select Key Preset Channel List Preset Channel Key Band Display Area You can preset the channel in You can select the channel when In the area,you can select the Preset Channel List. you press the key.the band that you want. Frequency Display Area Band Select Key The CurrentFrequency that You can select the band when you are receving you press the key. Setting Key SCAN Key Source Select Key Press the key to enter the Press the key,the radio Press the key to enter the audio setting.starts to scan the channel.Multimedia Select Interface. RDS/Radio Preset Channel List Preset Channel Key Receiving Status Display Area Band Display Area Frequency Display Area Band Select Key STEREO Display Area Setting Key TA Icon Display Area NEWS Icon Display Area Radio Text Display Area SCAN Key Source Select Key Preset Channel List Preset Channel Key Receiving Station Display Area You can preset the channel in You can select the channel when In the area,you can the current the Preset Channel List. you press the key.status about the radio receiving. Band Display Area Frequency Display Area Band Select Key In the area,you can select The CurrentFrequency that You can select the band when the band that you want.you are receving you press the key. STEREO Display Area Setting Key TA Icon Display Area The area is used to judge Press the key to enter the In the area,you can see the whether the stereo or not.audio setting."TA" mark. NEWS Icon Display Area Radio Text Display Area SCAN Key In the area,you can see the In the area,you can see the Press the key,the radio "NEWS" mark.radio text information.starts to scan the ch…

Text truncated - open the document above for the full version.

External Photos PF3547, PF3688 Front View PF3636, PF3689 Front View Rear View External Photos Right side View Left side View External Photos Top View Bottom View

Internal Photos Internal Photos Bl uetooth RF Antenna Internal Photos <Bl uetooth part> Bl uetooth part <Bluetooth part – without Shield>

UL Japan, Inc. Shonan EMC Lab. 1-22-3 Megumigaoka, Hiratsuka-shi, Kanagawa-ken, 259-1220 JAPAN Telephone : +81 463 50 6400 Facsimile : +81 463 50 6401 Applicant: Clarion Co., Ltd. T ype of Equipment : Car Audio M odel No. : PF-3547 FCC ID: AX2PF3636 C larion Co., Ltd. declares that M odel : Car Audio complies with FCC radiation exposure requirement specified in the FCC Rules 2.1091. RF Exposure Calculations: The following information provides the minimum separation distance for the highest gain antenna provided with the “PF-3547“ as calculated from FCC Part 1, §1.1310, TABLE 1 (B) Limits for General Population / Uncontrolled Exposure. This calculation is based on the highest EIRP possible from the system, considering maximum power and antenna gain, and considering a 1.0mW /cm^2 uncontrolled exposure limit. The Friis formula used was: S = (P * G) / (4* π * r 2 ) Where P = 0.94 mW (M aximum peak output power) G = 1.00 Numerical Antenna gain; equal to0.00dB i r =20.0 cm For: PF-3547S =0.00019 mW/cm 2 No. : 10066163S-A RF Exposure / SAR Statement

Test report No. : 10066163S-A Page : 2 of 49 Issued date : December 20, 2013 Revised date : January 10, 2014 FCC ID : AX2PF3636 UL Japan, Inc. Shonan EMC Lab. 1-22-3 Megumigaoka, Hiratsuka-shi, Kanagawa-ken, 259-1220 JAPAN Telephone: +81 463 50 6400 Facsimile: +81 463 50 6401 REVISION HISTORY Original Test Report No.: 10066163S-A Revision Test report No. Date Page revised Contents - (Original) 10066163S-A December 20, 2013 - - 1 10066163S-A January 7, 2014 4 Update of clock frequency 2 10066163S-A January 10, 2014 4, 21-24 P4: Addition of description about derived models P21-24: Update of dwell time data Test report No. : 10066163S-A Page : 3 of 49 Issued date : December 20, 2013 FCC ID : AX2PF3636 UL Japan, Inc. Shonan EMC Lab. 1-22-3 Megumigaoka, Hiratsuka-shi, Kanagawa-ken, 259-1220 JAPAN Telephone: +81 463 50 6400 Facsimile: +81 463 50 6401 Contents Page SECTION 1: Customer information .................................................................................. 4 SECTION 2: Equipment under test (E.U.T.) ..................................................................... 4 SECTION 3: Test specification, procedures & results ...................................................... 5 SECTION 4: Operation of E.U.T. during testing .............................................................. 8 SECTION 5: Carrier frequency separation ..................................................................... 11 SECTION 6: 20dB bandwidth & Occupied bandwidth (99%) ....................................... 11 SECTION 7: Number of hopping frequency ................................................................... 11 SECTION 8: Dwell time.................................................................................................... 11 SECTION 9: Maximum peak output power .................................................................... 11 SECTION 10: Spurious emissions (Antenna port conducted) ........................................ 11 SECTION 11: Radiated emission ..................................................................................... 12 Contents of APPENDIXES .................................................................................................. 14 APPENDIX 1: Data of radio tests..................................................................................... 15 APPENDIX 2: Test instruments ....................................................................................... 48 APPENDIX 3: Photographs of test setup ......................................................................... 49 Test report No. : 10066163S-A Page : 4 of 49 Issued date : December 20, 2013 Revised date : January 10, 2014 FCC ID : AX2PF3636 UL Japan, Inc. Shonan EMC Lab. 1-22-3 Megumigaoka, Hiratsuka-shi, Kanagawa-ken, 259-1220 JAPAN Telephone: +81 463 50 6400 Facsimile: +81 463 50 6401 SECTION 1: Customer information Company Name : Clarion Co., Ltd. Address : 7-2 Shintoshin, Chuo-ku, Saitama-shi, Saitama, 330-0081 Japan Telephone Number : +81-48-601-4120 Facsimile Number : +81-48-601-3802 Contact Person : Matsuhiro Hirano SECTION 2: Equipment under test (E.U.T.) 2.1 Identification of E.U.T. Type of Equipment : Car Audio Model Number : PF-3547 Serial Number : Refer to 4.2 of this report. Rating : DC12V (car battery) Country of Mass-production : China Condition of EUT : Engineering prototype (Not for Sale: This sample is equivalent to mass-produced items.) Receipt Date of Sample : October 23, 2013 Modification of EUT : No modification by the test lab. 2.2 Product description Model: PF-3547 (referred to as the EUT in this report) is a Car Audio. Specification of the EUT and its derived models: Model Quantity of Speaker PF-3547 6 PF-3688 4 PF-3636 6 PF-3689 4 These models have the same acoustic circuit, and 4-speaker models and 6-speaker models have the different acoustic characteristic parameter. Front Speakers and Tweeters of 6-speaker models are connected in parallel to Front Left cable and Front Right cable. Clock frequency(ies) in the system : 41.6MHz (Xtal), 26MHz (Xtal), 32MHz Bluetooth specification: Equipment type : Transceiver Frequency of operation : 2402-2480MHz Bandwidth & channel spacing : 79MHz & 1MHz Type of modulation : FHSS Antenna type : Pattern Antenna connector type : None Antenna gain : -7.1dBi ITU code : F1D, G1D Operation temperature range : -20 to +60 deg.C. FCC 15.31 (e) The EUT provides stable voltage (DC3.3V) constantly to the wireless transmitter regardless of input voltage. Therefore, this EUT complies with the requirement. FCC 15.203 The antenna is not removable from the EUT. Therefore the equipment complies with the requirement. Test report No. : 10066163S-A Page : 5 of 49 Issued date : December 20, 2013 FCC ID : AX2PF3636 UL Japan, Inc. Shonan EMC Lab. 1-22-3 Megumigaoka, Hiratsuka-shi, Kanagawa-ken, 259-1220 JAPAN Telephone: +81 463 50 6400 Facsimile: +81 463 50 6401 SECTION 3: Test specification, procedures & results 3.1 Test specification Test specification : FCC Part 15 Subpart C: 2013, final revised on September 30, 2013 and effective October 30, 2013 Title : FCC 47CFR Part15 Radio Frequency Device Subpart C Intentional Radiators Section 15.207 Conducted limits Section 15.209 Radiated emission limits, general requirements Section 15.247 Operation within the bands 902-928MHz, 2400-2483.5MHz, and 5725-5850MHz * The revision on September 30, 2013 does not affect the test specification applied to the EUT. 3.2 Procedures & Results Item Test Procedure Specification Remarks DeviationWorst Margin Results Conducted emission ANSI C63.4:2009 7. AC powerline conducted emission measurements FCC 15.207 - N/A *1) - - Carrier frequency separation FCC Public Notice DA 00-705 & ANSI C63.4:2009 13. Measurement of intentional radiators FCC 15.247 (a)(1) ConductedN/A *See data. Complied 20dB bandwidth FCC Public Notice DA 00-705 & ANSI C63.4:2009 13. Measurement of intentional radiators FCC 15.247 (a)(1) ConductedN/A - Number of hopping frequency FCC Public Noti…

Text truncated - open the document above for the full version.

UL Japan, Inc. Shonan EMC Lab. 1-22-3 Megumigaoka, Hiratsuka-shi, Kanagawa-ken, 259-1220 JAPAN Telephone : +81 463 50 6400 Facsimile : +81 463 50 6401 APPENDIX 3: Photographs of test setup Radiated emission Front view Rear view (below 1GHz) Rear view (above 1GHz) END OF REPORT Test Report No 10066163S-A 49 of 49