BGBX1T265IMB11103Vehicle Security Device, Low Power Transmitter

Test report No. : 25FE0190-HO-1 Page : 2 of 14 Issued date : March 11, 2005 Revised date : March 25, 2005 FCC ID : BGBX1T265IMB11103 UL Apex Co., Ltd. Head Office EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8116 Facsimile : +81 596 24 8124 MF060b(10.04.03) CONTENTS PAGE SECTION 1: Client information .................................................................................................................... 3 SECTION 2: Equipment under test (E.U.T.)................................................................................................ 3 SECTION 3: Test specification, procedures & results ................................................................................ 4 SECTION 4: Operation of E.U.T. during testing ......................................................................................... 6 SECTION 5: Radiated emission (Fundamental and Spurious Emission) .................................................. 7 APPENDIX 1: Photographs of test setup ...................................................................................................... 8 Radiated Emission....................................................................................................................................................8 Worst Case Position (X-axis:Horizontal / X-axis:Vertical)...................................................................................9 APPENDIX 2:Test instruments .................................................................................................................... 10 APPENDIX 3: Data of EMI test.................................................................................................................... 11 Radiated Spurious Emission.................................................................................................................................. 11 99%Occupied bandwidth ......................................................................................................................................14 -26dB bandwidth ....................................................................................................................................................14 Test report No. : 25FE0190-HO-1 Page : 3 of 14 Issued date : March 11, 2005 Revised date : March 25, 2005 FCC ID : BGBX1T265IMB11103 UL Apex Co., Ltd. Head Office EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8116 Facsimile : +81 596 24 8124 MF060b(10.04.03) SECTION 1: Client information Company Name : Mitsubishi Electric Corporation Himeji Works Address : 840, Chiyoda-machi, Himeji, Hyogo, 670-8677 JAPAN Telephone Number : +81-792-98-8896 Facsimile Number : +81-792-98-9262 Contact Person : Yoshiharu Goto SECTION 2: Equipment under test (E.U.T.) 2.1 Identification of E.U.T. Type of Equipment : The Immobilizer System Model No. : IMB111-03 Serial No. : 1 Country of Manufacture : Japan Receipt Date of Sample : February 14, 2005 Condition of EUT : Production prototype (Not for Sale: This sample is equivalent to mass-produced items.) 2.2 Product Description Model No: IMB111-03 (referred to as the EUT in this report) is the Immobilizer System. Clock frequency CPU: 4MHz Feature of EUT 1) Normal EUT : When the correct key is inserted to the key-cylinder and the power supply is turned ON, the LED of the engine control unit is turned on for about 3 seconds and turned off afterward. If the incorrect key is inserted to the key-cylinder or the any key is not inserted to the key-cylinder, the LED is blinking 2) Continuous transmitting EUT for testing. When the power supply is turned ON, the transmitting is started and continues untill the power supply is turned OFF. Equipment Type Transceiver Receiver Frequency of Operation 134.45kHz 134.45kHz Bandwidth & Channel spacing N/A - Type of Modulation Unmodulated - Antenna Type Inductive loop Antenna Connector Type - Antenna Gain - Mode of Operation Simplex - Method of frequency generation Crystal ITU code N0N - Power Supply (Inner) DC 5.0V from Car Batery DC12V FCC 15.31 (e) This test was performed with the New Battery (DC 12V) and the constant voltage was supplied to this EUT during the tests. Therefore, this EUT complies with the requirement. FCC Part 15.203 Antenna requirement It is impossible for end users to replace the antenna, because the antenna is mounted inside of the EUT. Therefore, the equipment complies with the antenna requirement of Section 15.203. Test report No. : 25FE0190-HO-1 Page : 4 of 14 Issued date : March 11, 2005 Revised date : March 25, 2005 FCC ID : BGBX1T265IMB11103 UL Apex Co., Ltd. Head Office EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8116 Facsimile : +81 596 24 8124 MF060b(10.04.03) SECTION 3: Test specification, procedures & results 3.1 Test Specification Test Specification : FCC Part15 Subpart C : 2004 Title : FCC 47CFR Part15 Radio Frequency Device Subpart C Intentional Radiators Section 15.209 Radiated emission limits, general requirements : 2004 3.2 Procedures and results No. Item Test Procedure Specification Remarks Deviation Worst margin *0) Result 1 Electric Field Strength of Fundamental Emission ANSI C63.4:2003 FCC Section 15.209 Radiated N/A 48.6dB 0.135kHz 0 deg. AV Complied 2 Electric Field Strength of Spurious Emission ANSI C63.4:2003 FCC Section 15.209 Radiated N/A 10.8dB 160.522MHz, Horizontal, QP Complied 3 -26dB bandwidth ANSI C63.4:2003 ANSI C63.4 13.1.7 Radiated N/A N/A N/A 4 Conducted Emission ANSI C63.4:2003 FCC Section 15.207 AC Mains *1) N/A N/A N/A Note: UL Apex’s EMI Work procedures No. QPM05 *0) The result is rounded off to the second decimal place. Therefore, there may be 0.1 difference for the result. *1) This test is not applicable since the EUT does not have AC power port. Uncertainty: Spurious Emission (Radiated) The measurement uncertainty (with a 95% confidence level) for this test using Biconical antenna is ±4.5dB(3m)/ ±4.7dB(10m). T…

Text truncated - open the document above for the full version.

Test report No. : 25FE0190-HO-1 Page : 8 of 14 Issued date : March 11, 2005 Revised date : March 25, 2005 FCC ID : BGBX1T265IMB11103 UL Apex Co., Ltd. Head Office EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8116 Facsimile : +81 596 24 8124 MF060b(10.04.03) APPENDIX 1: Photographs of test setup Radiated Emission Front Rear Test report No. : 25FE0190-HO-1 Page : 9 of 14 Issued date : March 11, 2005 Revised date : March 25, 2005 FCC ID : BGBX1T265IMB11103 UL Apex Co., Ltd. Head Office EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8116 Facsimile : +81 596 24 8124 MF060b(10.04.03) Worst Case Position (X-axis:Horizontal / X-axis:Vertical) X-axis Z-axis