KBRBN009Automotive Entry System

User’s Manual BCM SYSTEM Model No.: BN009 There is no User’s Manual because this equipment will not be sold to end- user directly. CONTENTS 1. PREFACE 2. PASSSIVE ACCSESS ENTRY FUNCTIONALITY 2.1. Door Unlocking 2.2. Engine Start 2.3. Engine Stop 2.4. Door Locking (Push switch) 3. ACTIVE ACCESS ENTRY FUNCTIONALITY 3.1. Door Unlocking 3.2. Engine Start 3.3. Engine Stop 3.4. Door Locking 3. 5. Trunk Open 4. ENTRY SYSTEM OPTIONS 4.1. System Schematic 4.2. Modules 4.2.1. FOB ECU 4.2.2. Entry System ECU 5. SYSTEM CHARACTERISTICS 5.1. Antenna Areas 5.2. Exciter Locations 5.3. Switch Input Locations (Door handle) 6. ELECTRICAL CHARACTERISTICS 6.1. FOB 6.2. Entry System ECU FCC WARNING NOTICE 1.Preface This document describes the requirements and operation of the Passive Entry System. However, this document is especially for the Entry system ECU (acronym for Electric Control Unit) and the FOB. The FOB consists the following functionality for passive access and active access: · Door unlocking / locking (however, only for request by means of switch operation) · Trunk open (however, only for request by means of switch operation) · LF decoding · RF encoding · Communication data encryption (cryptograph, anti-collision, rolling code and stuff) And the entry system ECU consists of the following functionality: · Door unlocking / locking · Trunk open · Engine start (/ stop) · LF encoding · RF encoding · Communication data encryption (cryptograph, anti-collision, rolling code and stuff) · LF antenna unit control · Communication with the node ECUs connected to the body bus (e.g. CAN, J1850, customer dependent bus) As a further function, both the FOB and the entry system ECU provides the following function: · Learning mode for programming the manufacturing data and stuff · Data locking and password protection · Diagnostic (based upon ISO9141 if required) 2.Passsive Accsess Entry Functionality A handle sw located on, for example the door handles, mirrors and trunk lid will be used for proximity check if user is in neighborhood of the vehicle. The switch input will trigger for unlocking and open the doors and trunk. Figure 1 2.1.Door Unlocking · User pushes door handle sw. · ECU sends LF-challenge via exterior antenna. · FOB sends RF-response to the ECU. · Door unlocking status is engaged. · Doors are opened. Figure 2 Door Handle SW Switch input (door LF RF FOB 2. 2.Engine Start · User operates the engine start knob. · ECU sends LF-challenge via interior antenna. · FOB sends RF-response to the ECU. · Immobilizer ECU receives and authorize the response. · Engine controller ECU receives the authorization for engine strat. · Start the engine. Figure 3 2.3.Engine Stop · User operates the engine stop knob. · ECU communicates with the other ECU for engine start request. · Engine controller ECU receives the request. · Stop the engine Fi gure 4 LF RF FOB 2.4.Door Locking (Push switch) · User closes the door and pushes the switch (sensing of door locking switch). · ECU sends LF-challenge via exterior antenna. · FOB sends RF-response to the ECU. · Door locking status is engaged. · Doors are locked. · (Indicates the door locking status by means of Flasher / Buzzer or stuff) Figure 5 3.Active Access Entry Functionality 3.1.Door Unlocking Same functionality as the current one. 3.2.Engine Start This function does not effect on the active entry system. 3.3.Engine Stop This function does not have influence on the active entry system. 3.4.Door Locking Same functionality as the current one. 3.5.Trunk Open Same functionality as the current one. 4.Entry System Options 4.1.System Schematic 4.2.Modules 4.2.1.FOB ECU 4.2.2.Entry System ECU OTHER ECUS LF (>2Kbps) Local Bus ECUECUECU Body Bus ENTRY SYSTEM ECU FOB 125kHz RF (>4Kbps) 434MHz FOB RF Amp LF Amp ASIC Z X Y Lock Unlock Trunk Emergency key (Transponder) 125kHz 434MHz ENTRY SYSTEM ECU MCU Dr Door handle As Door handle Trunk Push knob (Engine start knob) Body Bus Local Bus LF Exciter LF Exciter LF Exciter LF Exciter Room1 Dr As Trunk 125kHz Dr : Driver Door Antenna As : Assist Door Antenna Trunk : Bumper Antenna Exterior Antenna Room1: Console Antenna Room2: Inst. Antenna Room3: Trunk Antenna Interior Antenna LF Exciter LF Exciter Room2 Room3 Tuner signal Panic RF Tuner Tuner signal 5.System Characteristics 5.1.Antenna Areas Exterior operating range: 0.8m to 1.5m Interior operating range: Only inside the car Number of the exterior exciters : typ.3, however, it is depending on the type of the vehicle. Number of the interior exciters: max.4 (min.2) Figure 6 Exterior antenna functionality: · Unlock / lock doors. · Open trunk. · Activate / deactivate alarm system. · Activate immobilizer Interior antenna functionality: · Deactivate immobilizer · Engine start Exterior Interior Dr As Back 5.2.Exciter Locations Exterior exciters: 3 doors Interior exciters: 1 Center Console 2 Inst panel 3 Trunk Figure 7 Antenna location can be different among of type of the vehicle (e.g. coupe, sedan, mini and stuff). Exterior Interior Dr As Bumper 5.3.Switch Input Locations (Door handle) There are some switches, for instance the door handle contact switch will be used as a triggering for unlocking and open the door. Switch inputs: 3 doors Figure 8 Switch inputs can be different among of type of the vehicle (e.g. coupe, sedan, mini and stuff). Dr As Trunk 6.Electrical Characteristics 6.1.FOB · ASK / FSK modulation · Operating supply voltage 2.5V ~ 3.3V (3.0V Battery) · Operating supply current < 35mA · Stand-by current < 10.0uA · Operating ambient temperature -10 o C to +60 o C · Antenna direction 3-Dimension (X, Y, Z), to be considered · Battery life 1.5 Years (Low battery indication is considered) 6.2.Entry System ECU · Operating supply voltage 9.0V ~ 16.0V · Operating supply current < 55mA · Stand-by current < 4.0mA · Operating ambient temperature -30 o C to +80 o C · FCC WARNING Changes or modifications not expressly approved by the party responsible for compliance could void the user’s authority to…

Text truncated - open the document above for the full version.

External Photo Calsonic Kansei Corporation BCM SYSTEM [Model: BN009] External Photo Calsonic Kansei Corporation BCM SYSTEM [Model: BN009] External Photo Calsonic Kansei Corporation BCM SYSTEM [Model: BN009]

○Label Location ○Label Drawing CN1 : SICMA15(W) CN2 : SICMA15(B) CN3 : TH40VB CN4 : TH40HW BCM'sLabel FLN002FLJ001SAE J1690DOT PART NOLOT NOFCC IDMODEL No.IC 284B× ××××× ××××KBRBN009BN0092111B-BN009 Calsonic Kansei Corp. ID MARK BAR CODE IMMOBI PIN CODE

Internal Photo Calsonic Kansei Corporation BCM SYSTEM [Model: BN009]

Test report No. : 30EE0020-HO-01-A Page : 2 of 22 Issued date : December 18, 2009 FCC ID : KBRBN009 UL Japan, Inc. Head Office EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8116 Facsimile : +81 596 24 8124 CONTENTS PAGE SECTION 1: Customer information ..................................................................................................... 3 SECTION 2: Equipment under test (E.U.T.)........................................................................................ 3 SECTION 3: Test specification, procedures & results ........................................................................ 4 SECTION 4: Operation of E.U.T. during testing .................................................................................7 SECTION 5: Radiated emission (Fundamental and Spurious Emission) .......................................... 9 SECTION 6: -26dB Bandwidth............................................................................................................ 11 SECTION 7: 99% Occupied Bandwidth.............................................................................................11 APPENDIX 1: Photographs of test setup ............................................................................................ 12 Radiated Emission............................................................................................................................. 12 Worst Case Position .......................................................................................................................... 14 APPENDIX 2: Data of EMI test........................................................................................................... 16 Radiated Emission below 30MHz (Fundamental and Spurious Emission) ................................. 16 Radiated Emission above 30MHz (Spurious Emission)................................................................. 18 -26dB Bandwidth and 99% Occupied Bandwidth ......................................................................... 20 APPENDIX 3: Test instruments .......................................................................................................... 22 Test report No. : 30EE0020-HO-01-A Page : 3 of 22 Issued date : December 18, 2009 FCC ID : KBRBN009 UL Japan, Inc. Head Office EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8116 Facsimile : +81 596 24 8124 SECTION 1: Customer information Company Name : Calsonic Kansei Corporation Address : 2-1917 Nisshin-cho Kita-ku Saitama-shi Saitama, 331-8501 Japan Telephone Number : +81-48-661-2689 Facsimile Number : +81-48-661-1026 Contact Person : Daisuke Mori SECTION 2: Equipment under test (E.U.T.) 2.1 Identification of E.U.T. Type of Equipment : BCM SYSTEM Model No. : BN009 Serial No. : Refer to Section 4, Clause 4.2 Rating : DC13.5V Receipt Date of Sample : December 3, 2009 Country of Mass-production : Japan Condition of EUT : Production prototype (Not for Sale: This sample is equivalent to mass-produced items.) Modification of EUT : No Modification by the test lab 2.2 Product Description Model No: BN009 (referred to as the EUT in this report) is the BCM SYSTEM. Clock frequencies : 32.768kHz (Sleep; Keyless tuner OFF), 4MHz (Sleep; Keyless tuner ON) 40MHz (Wake up) Equipment Type : Transmitter Type of modulation : ASK Frequency of operation : 125kHz Bandwidth : 5kHz Antenna Gain : -38dBi Antenna Type : Bar Antenna Antenna connector Type : RK02 Operating Temperature : -30 deg. C. to +85 deg. C. Test report No. : 30EE0020-HO-01-A Page : 4 of 22 Issued date : December 18, 2009 FCC ID : KBRBN009 UL Japan, Inc. Head Office EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8116 Facsimile : +81 596 24 8124 SECTION 3: Test specification, procedures & results 3.1 Test Specification Test Specification : FCC Part15 Subpart C: 2009, final revised on December 2, 2009 Title : FCC 47CFR Part15 Radio Frequency Device Subpart C Intentional Radiators Section 15.209 Radiated emission limits, general requirements FCC 15.31 (e) This EUT provides stable voltage (DC 13.5V) constantly to RF part regardless of input voltage. Therefore, this EUT complies with the requirement. FCC Part 15.203 Antenna requirement It is impossible for end users to replace the antenna, because the antenna is mounted inside of vehicle. Therefore, the equipment complies with the antenna requirement of Section 15.203. 3.2 Procedures and results No. Item Test Procedure Specification Remarks Deviation Worst margin Results 1 Conducted Emission <FCC> ANSI C63.4:2003 7. AC powerline conducted emission measurements <IC> RSS-Gen 7.2.2 <FCC> Section 15.207 <IC> RSS-Gen 7.2.2 - N/A *1) N/A N/A 2 Electric Field Strength of Fundamental Emission <FCC> ANSI C63.4:2003 13. Measurement of intentional radiators <IC> RSS-Gen 4.8, 4.11 <FCC> Section 15.209 <IC> RSS-210 2.6, 2.7 Radiated N/A 11.0dB 0.12500MHz 0 deg. AV (Room Antenna) Complied 3 Electric Field Strength of Spurious Emission <FCC> ANSI C63.4:2003 13. Measurement of intentional radiators <IC> RSS-Gen 4.9, 4.11 <FCC> Section 15.209 <IC> RSS-210 2.6, 2.7 Radiated N/A 7.0dB 645.045MHz, Vertical, QP (Room Antenna) Complied 4 -26dB Bandwidth <FCC> ANSI C63.4:2003 13. Measurement of intentional radiators <IC> - <FCC> Reference data <IC> - Radiated N/A N/A N/A Note: UL Japan, Inc.’s EMI Work Procedures No.QPM05 and QPM15. *1) The test is not applicable since the EUT is not the device that is designed to be connected to the public utility (AC) power line. Test report No. : 30EE0020-HO-01-A Page : 5 of 22 Issued date : December 18, 2009 FCC ID : KBRBN009 UL Japan, Inc. Head Office EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8116 Facsimile : +81 596 24 8124 3.3 Addition to standard No. Item Test Procedure Specification Remarks Deviation Worst margin Results 1 99% Occupied Band Width RSS-Gen 4.6.1 RSS-Gen 4.6.1 Radiated N/A N/A N/A Other th…

Text truncated - open the document above for the full version.

Test report No. : 30EE0020-HO-01-A Page : 16 of 22 Issued date : December 18, 2009 FCC ID : KBRBN009 UL Japan, Inc. Head Office EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8116 Facsimile : +81 596 24 8124 APPENDIX 2: Data of EMI test Radiated Emission below 30MHz (Fundamental and Spurious Emission) Room Antenna DATA OF RADIATED EMISSION TEST UL Japan, Inc. Head Office EMC Lab. No.2 Semi Anechoic Chamber Date : 2009/12/08 Company : Calsonic Kansei Corp.Report No.:30EE0020-HO-01 Kind of EUT: BCM SYSTEM Power:DC 12V Model No. : BCM 009 Temp./ Humi.:22deg.C / 26% Serial No. : Indoor Antenna Engineer:Tomohisa Nakagawa Mode / Remarks : Tx 125kHz, Modulation ON, LIMIT : FCC15.209(a) 3m, 9-90kHz:PK, 110-490kHz:PK, other:QP FCC15.209(a) 3m, 9-90kHz:AV, 110-490kHz:AV, other:QP CHART: WITH FACTOR , ANT TYPE: LOOP , Except for the data below : adequate margin data below the limits. CALCULATION : RESULT[dBuV] = READING[dBuV] + ANT FACTOR[dB] + LOSS[dB]( CABLE + ATTEN.- AMP.) Frequency[Hz] [dBuV/m] << QP/AV/PEAK DATA >>0 deg :A 30M .01M .02M .03M .05M .07M .1M.2M.3M.5M.7M1M2M3M5M7M10M 20M 0 10 20 30 40 50 60 70 80 90 100 110 120 130 140 150 _ Freq . _ Reading _ DET _ Ant . Fac _ Loss _ Gain _ Result _ Limit _ Margin _ Antenna _ _ Table _ Comment _ Freq . _ Reading _ DET _ Ant . Fac _ Loss _ Gain _ Result _ Limit _ Margin _ Antenna _ _ Table _ Comment _ [ MHz ] _ [dBuV ] _ DET _ [ dB / m ] _ [dB] _ [dB] _ [dBuV/m] _ [dBuV/m] _ [dB] _ [deg] _ _ [deg] _ Comment _ 0 . 12500 _ 98 . 6 _ PEAK _ 20 . 0 _ 12.0 _ 32.4 _ 98.2 _ 125.6 _ 27.4 _ 0 _ A _ 104 _ 0 . 12500 _ 96 . 4 _ PEAK _ 20 . 0 _ 12.0 _ 32.4 _ 96.0 _ 125.6 _ 29.6 _ 45 _ A _ 240 _ 0 . 12500 _ 93 . 7 _ PEAK _ 20 . 0 _ 12.0 _ 32.4 _ 93.3 _ 125.6 _ 32.3 _ 90 _ A _ 3 _ 0 . 12500 _ 96 . 3 _ PEAK _ 20 . 0 _ 12.0 _ 32.4 _ 95.9 _ 125.6 _ 29.7 _ 135 _ A _ 330 _ 0 . 12500 _ 87 . 7 _ PEAK _ 20 . 0 _ 12.0 _ 32.4 _ 87.3 _ 125.6 _ 38.3 _ 0 _ A _ 349 _ Loop Hori _ 0 . 12500 _ 95 . 1 _ AV _ 20 . 0 _ 12.0 _ 32.4 _ 94.7 _ 105.7 _ 11.0 _ 0 _ A _ 104 _ 0 . 25000 _ 68 . 8 _ PEAK _ 19 . 9 _ 12.0 _ 32.3 _ 68.4 _ 119.6 _ 51.2 _ 0 _ A _ 359 _ 0 . 25000 _ 45 . 1 _ AV _ 19 . 9 _ 12.0 _ 32.3 _ 44.7 _ 99.6 _ 54.9 _ 0 _ A _ 359 _ 0 . 37500 _ 49 . 2 _ PEAK _ 19 . 8 _ 12.0 _ 32.2 _ 48.8 _ 116.1 _ 67.3 _ 0 _ A _ 358 _ 0 . 37500 _ 27 . 6 _ AV _ 19 . 8 _ 12.0 _ 32.2 _ 27.2 _ 96.1 _ 68.9 _ 0 _ A _ 358 _ 0 . 50000 _ 27 . 1 _ QP _ 19 . 8 _ 12.0 _ 32.2 _ 26.7 _ 73.6 _ 46.9 _ 0 _ A _ 94 _ 0 . 62500 _ 24 . 0 _ QP _ 19 . 8 _ 12.1 _ 32.2 _ 23.7 _ 71.7 _ 48.0 _ 0 _ A _ 0 _ NS _ 0 . 75000 _ 25 . 8 _ QP _ 19 . 8 _ 12.1 _ 32.2 _ 25.5 _ 70.1 _ 44.6 _ 0 _ A _ 328 _ 1 . 00000 _ 25 . 2 _ QP _ 19 . 8 _ 12.1 _ 32.2 _ 24.9 _ 67.6 _ 42.7 _ 0 _ A _ 0 _ NS _ 1 . 12500 _ 25 . 1 _ QP _ 19 . 8 _ 12.1 _ 32.2 _ 24.8 _ 66.5 _ 41.7 _ 0 _ A _ 0 _ NS NS: No detected signal *The test result is rounded off to one or two decimal places, so some differences might be observed. Test report No. : 30EE0020-HO-01-A Page : 17 of 22 Issued date : December 18, 2009 FCC ID : KBRBN009 UL Japan, Inc. Head Office EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8116 Facsimile : +81 596 24 8124 Radiated Emission below 30MHz (Fundamental and Spurious Emission) Door Antenna DATA OF RADIATED EMISSION TEST UL Japan, Inc. Head Office EMC Lab. No.2 Semi Anechoic Chamber Date : 2009/12/08 Company : Calsonic Kansei Corp. Report No. : 30EE0020-HO-01 Kind of EUT : BCM SYSTEM Power : DC 12V Model No. : BCM 009 Temp./ Humi. : 22deg.C / 26% Serial No. : Door Antenna Engineer : Tomohisa Nakagawa Mode / Remarks : Tx 125kHz, Modulation ON, LIMIT : FCC15.209(a) 3m, 9-90kHz:PK, 110-490kHz:PK, other:QP FCC15.209(a) 3m, 9-90kHz:AV, 110-490kHz:AV, other:QP CHART: WITH FACTOR , ANT TYPE: LOOP , Except for the data below : adequate margin data below the limits. CALCULATION : RESULT[dBuV] = READING[dBuV] + ANT FACTOR[dB] + LOSS[dB]( CABLE + ATTEN.- AMP.) Frequency[Hz] [dBuV/m]<< QP/AV/PEAK DATA >> 45 deg:B 30M.01M.02M.03M.05M.07M.1M.2M.3M.5M.7M1M2M3M5M7M10M20M 0 10 20 30 40 50 60 70 80 90 100 110 120 130 140 150 Freq.Reading DET Ant.FacLossGainResultLimitMarginAntenna Table Comment Freq.Reading DET Ant.FacLossGainResultLimitMarginAntenna Table Comment [MHz][dBuV] DET [dB/m][dB][dB][dBuV/m][dBuV/m][dB][deg] [deg] Comment 0.1250092.6PEAK20.012.032.492.2125.633.40B283 0.1250090.8PEAK20.012.032.490.4125.635.245B247 0.1250088.1PEAK20.012.032.487.7125.637.990B207 0.1250090.8PEAK20.012.032.490.4125.635.2135B324 0.1250075.3PEAK20.012.032.474.9125.650.70B180Loop Hori 0.1250060.7AV20.012.032.460.3105.745.40B283 0.2500029.7AV19.912.032.329.399.670.30B243 0.2500048.8PEAK19.912.032.348.4119.671.20B243 0.3750022.3AV19.812.032.221.996.174.20B0NS 0.3750035.7PEAK19.812.032.235.3116.180.80B0NS 0.5000027.8QP19.812.032.227.473.646.20B0NS 0.6250026.1QP19.812.132.225.871.745.90B0NS 0.7500025.9QP19.812.132.225.670.144.50B0NS 1.0000025.3QP19.812.132.225.067.642.60B0NS 1.2500025.2QP19.812.132.224.965.640.70B0NS NS: No detected signal *The test result is rounded off to one or two decimal places, so some differences might be observed. Test report No. : 30EE0020-HO-01-A Page : 18 of 22 Issued date : December 18, 2009 FCC ID : KBRBN009 UL Japan, Inc. Head Office EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8116 Facsimile : +81 596 24 8124 Radiated Emission above 30MHz (Spurious Emission) Room Antenna DATA OF RADIATED EMISSION TEST UL Japan, Inc. Head Office EMC Lab. No.2 Semi Anechoic Chamber Date : 2009/12/09 Company : Calsonic Kansei Corp.Report No.:30EE0020-HO-01 Kind of EUT: BCM SYSTEM Power:DC 12V Model No.: BCM 009 Temp./Humi.:22deg.C / 30% Serial No.: Inoor Antenna Engineer:Katsunori Okai Mode / Remarks : Tx 125kHz, Modulation ON LIMIT : FCC15.209 3m, below 1GHz:QP, above 1GHz:PK All other spurious emissions were less than 20dB for the limit. CHART:WITH FACTOR ANT TYPE: -30MHz:LOOP, 30-300MHz:BICONICAL, 300MHz-1000MHz:LOGPERIODIC, 1000MHz-:HORN CALCULATION:RESULT =…

Text truncated - open the document above for the full version.

Test report No. : 30EE0020-HO-01-A Page : 12 of 22 Issued date : December 18, 2009 FCC ID : KBRBN009 UL Japan, Inc. Head Office EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8116 Facsimile : +81 596 24 8124 APPENDIX 1: Photographs of test setup Radiated Emission Photo 1 Photo 2 Test report No. : 30EE0020-HO-01-A Page : 13 of 22 Issued date : December 18, 2009 FCC ID : KBRBN009 UL Japan, Inc. Head Office EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8116 Facsimile : +81 596 24 8124 Radiated Emission Photo 1 Photo 2 Test report No. : 30EE0020-HO-01-A Page : 14 of 22 Issued date : December 18, 2009 FCC ID : KBRBN009 UL Japan, Inc. Head Office EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8116 Facsimile : +81 596 24 8124 Worst Case Position BCM: X-axis (below 30MHz) BCM: [Horizontal: X-axis , Vertical: X-axis] (above 30MHz) BCM X-axis Y-axis Z-axis Test report No. : 30EE0020-HO-01-A Page : 15 of 22 Issued date : December 18, 2009 FCC ID : KBRBN009 UL Japan, Inc. Head Office EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8116 Facsimile : +81 596 24 8124 Worst Case Position Door Antenna: Y-axis, Room Antenna: X-axis (below 30MHz) Door Antenna: [Horizontal: X-axis , Vertical: X-axis] (above 30MHz) Room Antenna: [Horizontal: X-axis , Vertical: X-axis] (above 30MHz) Door Antenna Room Antenna X-axis X-axis Y-axis Y-axis Z-axis Z-axis