PURMCRB10MCRB

RadioFrame Networks MC-Series System Installation & Testing April 19, 2005 998-4001-00 Rev C Deleted: February 11 MC-Series System Installation & Testing ii RadioFrame Networks, Inc. Service Information This equipment complies with part 15 of the FCC Rules. Operation is subject to the two following conditions: This device may not cause harmful interference, and this device must accept any interference received, including interference that may cause undesired operation. This equipment has been tested and found to comply with the limits pursuant to part 90.691 of the FCC Rules. These limits are designed to provide reasonable protection against harmful interference when the equipment is operated in a commercial environment. Notices These installation standards have been prepared to provide Nextel Communications with general standards necessary to ensure that installed RadioFrame Networks equipment operates in accordance with the design parameters in the owned or leased buildings of Nextel Communications and its customers, and to make certain equipment is installed safely and efficiently. RadioFrame Networks reserves the right to revise this document for any reason, including, but not limited to, conformity with standards promulgated by various governmental or regulatory agencies, utilization of advances in the state of the technical arts, or to reflect changes in the design of equipment, techniques, or procedures described or referred to herein. Liability to anyone arising out of use or reliance upon any information set forth herein is expressly disclaimed, and no representation or warranties, expressed or implied, are made with respect to the accuracy or utility of any information set forth herein. Copyrights and Trademarks RadioFrame Networks, RadioBlade, and the RadioFrame Networks logo are trademarks or service marks, and RadioFrame is a registered trademark of RadioFrame Networks, Inc. You may not use these or any other RadioFrame Networks trademarks or service marks without the written permission of RadioFrame Networks, Inc. All other trademarks and trade names are the property of their respective owners. Throughout this publication, the terms RadioFrame Networks, RadioFrame and RFN signify RadioFrame Networks, Inc., and Nextel signifies Nextel Communications. MC-Series System Installation & Testing © Copyright 2005 RadioFrame Networks, Inc. All Rights Reserved. MC-Series System Installation & Testing RadioFrame Networks, Inc. iii Contents 1 Introduction ........................................................................................................................... 1 1.1 Record of Revisions....................................................................................................... 1 1.2 References .................................................................................................................... 1 1.3 General Safety Information ............................................................................................ 2 1.4 Repair and Technical Support ....................................................................................... 3 2 System Description ..............................................................................................................6 2.1 MC-Series System Configuration................................................................................... 7 2.2 RadioFrame Networks Hardware................................................................................... 9 2.3 System Manager Software........................................................................................... 24 2.4 Non-RFN Hardware ..................................................................................................... 25 2.5 Specifications............................................................................................................... 27 3 Pre-Installation .................................................................................................................... 33 3.1 Site Planning ............................................................................................................... 33 3.2 Scheduling / Logistics .................................................................................................. 36 3.3 MC-Series System Installation Kit................................................................................ 36 3.4 iDEN Configuration ...................................................................................................... 37 4 Installation .......................................................................................................................... 38 4.1 Site Inspection ............................................................................................................. 38 4.2 Receipt of Equipment .................................................................................................. 38 4.3 Mounting the MC-Series System Cabinet .................................................................... 39 4.4 Mounting Non-RFN Equipment in the MC-Series System Cabinet .............................. 39 4.5 Mounting Auxiliary Equipment ..................................................................................... 43 4.6 Cabinet-to-Site Cabling................................................................................................ 43 4.7 Intra-cabinet Cabling.................................................................................................... 46 5 Final Checkout and Commissioning ................................................................................. 47 5.1 Prerequisites................................................................................................................ 47 5.2 Checkout Procedures .................................................................................................. 48 5.3 Initial Powering Procedure .........................................................…

Text truncated - open the document above for the full version.

Northwest EMC TCB Compliance Opinion Rev. 9/15/03 RAFN0060 Information about the Applicant Company Name Radioframe Networks, Inc. Grantee Dean Busch Address 1120 112th Ave NE, Suite 600 City, State, Zip Bellevue, WA 98004 Job Number RAFN0060 Model MCRB FCC ID PURMCRB10 Agent Radioframe Networks, Inc. Approval Type Original Equipment Class TNB Licensed Non-Broadcast Station Transmitter Rule Part 90 Overview Reference applicant provided cover letter. Recommendation All items have been resolved and completed to my satisfaction; therefore I recommend this application for approval. Signature 4/14/2006 Dean Ghizzone, TCB Committee

System Transmit Path Transmit antenna ports Receive Antenna Ports Receive Div. Antenna Ports Transmit signal in from Radio in RBS 800 MHz 900 MHz Transmit signal out to Antenna Transmit Signals out from Radios

Transmit signals from radio to combiner board. 8 radios per slice (combiner) and a total of 3 slices. The top cable is transmit and the bottom is receive. RadioBlade Photos MCRB PCB Front MCRB PCB Back

MCRB Front MCRB Back MCRB Connectors RF Shelf Photos

RF Shelf Back Input Output Input Output Receive RF Connections Transmit RF Connections RF Shelf Front -30 dB Test Ports RF Shelf Inside PCB Front Power Amplifier Control Board Low Noise Amplifier (Rx)

3/27/2006 5:55:46 PM RadioFrame Networks ProprietaryCreated by: Dean Busch 101-0507-01 BOM EXPLOSION REPORT MC-SERIES DUAL BAND RACK BUILD -ELECTRORACKE Part NumberPart DescriptionPart Revision Level Part Type Item Number Rev Item Description Find Num Qty Ref Des BOM Notes 0 1-Ops/RFN Mfg 101-0507-01 MC-SERIES DUAL BAND RACK BUILD - .1 1-Ops/RFNMfg 101-0502-01 B SUB ASY, CHASSIS UNIT, -48VDC 0 2 ..2 5-Misc Part 519-0502-03 B ASY, CHASSIS UNIT FRAME, W/O POWER 0 1 ...3 5-Misc Part 510-0502-04 D CHASSIS UNIT, 4U 0 1 ....4 5-Misc Part 522-0500-99 1 NUTSERT, #6-32, 0.040 SHEET 0 38 ....4 5-Misc Part 522-0640-99 1 STUD, 1/4-20 X 3/4 0 1 ....4 5-Misc Part 539-1100-01 1 SCR, #4-40 X 3/16, PPH B, SELF-TAPPING, ST ZN 0 5 ....4 5-Misc Part 539-1400-06 1 STUD, FLUSH HEAD, #6-32 X .375, ST ZN 0 1 ....4 5-Misc Part 539-1600-01 1 PILOT PIN, .125DIA. X .375, FLUSH-MOUNTED, 0 2 ...3 5-Misc Part 510-0511-03 A COVER, MAIN, CU 0 1 ...3 5-Misc Part 510-0760-01 A BRACKET, RIB SUPPORT, BACKPLANE, CU 0 2 ...3 5-Misc Part 510-1245-00 B BRKT, FAN ASY PWR HARNESS, 4U CHASSIS 0 1 ...3 5-Misc Part 519-1219-00 B ASY, COVER, FAN, CHASSIS UNIT 0 1 ....4 1-Ops/RFN Mfg 102-0012-00 D ASY, FAN, 120MM X 120MM X 38MM, 48VDC, W/CONNECTOR 01 .....5 5-Misc Part 518-0003-00 1 FAN, 120MM X 120MM X 38MM, 48VDC 0 2 .....5 8- Connector/Socket 806-0616-05 1 CONN., PLUG, BMI, 6 CKT, DUAL ROW, PNL MNT 0 1 .....5 8- Connector/Socket 806-0617-05 1 CONN., TERMINAL, 24-18AWG, MALE, CRIMP 0 6 ....4 5-Misc Part 510-1219-03 B COVER, FAN, CU 0 1 ....4 5-Misc Part 520-0900-99 1 SCREW, #4-40 X 1, ZOS, PPH 0 4 ....4 5-Misc Part 521-0680-99 1 TIE WRAP, 5.6", BLACK 0 2 Page 1 of 32 3/27/2006 5:55:48 PM RadioFrame Networks ProprietaryCreated by: Dean Busch 101-0507-01 BOM EXPLOSION REPORT MC-SERIES DUAL BAND RACK BUILD -ELECTRORACKE Part NumberPart DescriptionPart Revision Level Part Type Item Number Rev Item Description Find Num Qty Ref Des BOM Notes ....4 5-Misc Part 535-0209-02 1 WASHER, #4, LOW CARBON, SAE, ST ZN 0 4 ...3 5-Misc Part 520-0590-99 2 SCREW, #10-32 X 1/2, ZOS, PPH, EXT SEMS 0 4 ...3 5-Misc Part 521-0520-99 C HANDLE, ALUMINUM, 5" CTC 0 2 ...3 5-Misc Part 533-0205-03 1 SCR, #6-32 X 5/16, BLK OX, INT SEMS 0 37 ...3 8- Connector/Socket 820-0619-01 C ASY, CABLE, FAN LOOP, PNL MNT1 0 1 ...3 1-Ops/RFN Mfg ASY-0501-06 B CHASSIS BACKPLANE V0.6, GSM COMPLIANT 0 1 ....4 1-Ops/RFN Mfg 123-0650-00 1 LABEL, BARCODE, BLANK STOCK, 1.25 X .25 0 1 ....4 3-Capacitor 369-331-9M 1 CAP, 330UF, 63V, CAP, ELECTROLYTIC, 10X20(DXL MM) FOR BACKPLANE 04 ....4 8- Connector/Socket 804-0640-02 2 CONN, P4 TYPE A VERTICAL MALE FEED-THRU FOR BACKPLANE, 5X25, KEYED REV 1 011 ....4 8- Connector/Socket 804-0660-02 1 CONN, TERMINAL BLOCK, SCREWLESS, 3POS REV 1 04 ....4 8- Connector/Socket 806-0550-05 2 RP4 SHROUD, TYPE A FOR BACKPLANE, KEYED REV 1 011 ....4 Document 920-0501-06 A FAB DRAWING, CHASSIS UNIT BACKPLANE 0 0 ....4 Document 923-0501-06 B ASSEMBLY DRAWING, BOARD LEVEL, CHASSIS UNIT BACKPLANE 00 ....4 Document 928-0501-05 A SCHEMATIC, CHASSIS UNIT BACKPLANE 0 0 ....4 1-Ops/RFN Mfg PCB-0501-01 A PCB, CHASSIS UNIT BACKPLANE 0 1 ..2 5-Misc Part 533-0205-03 1 SCR, #6-32 X 5/16, BLK OX, INT SEMS 0 2 ..2 8- Connector/Socket 820-0550-05 1 CABLE, CHASSIS UNIT POWER CABLE ASSEMBLY, NEG 48VDC INPUT, FILTERED 01 ..2 Document 910-0502-01 B SUB-LEVEL ASSEMBLY DRAWING, 101-0502-01 (CHASSIS UNIT, -48VDC) 00 .1 1-Ops/RFNMfg 101-0535-03 C RBS (RADIOBLADE SHELF) 0 1 Page 2 of 32 3/27/2006 5:55:50 PM RadioFrame Networks ProprietaryCreated by: Dean Busch 101-0507-01 BOM EXPLOSION REPORT MC-SERIES DUAL BAND RACK BUILD -ELECTRORACKE Part NumberPart DescriptionPart Revision Level Part Type Item Number Rev Item Description Find Num Qty Ref Des BOM Notes ..2 1-Ops/RFN Mfg 102-0011-04 C ASY, FAN 60MM X 25MM 12VDC 37 CFM 3 WIRE 0 3 ...3 5-Misc Part 518-0002-00 1 FAN, 60MM X 25MM 12VDC 37 CFM 3 WIRE 0 1 ...3 5-Misc Part 543-0001-00 1 TUBING, HEAT SHRINK, 1/4" EXPANDED, 1/8" SHRUNKEN, PVC 00 ...3 8- Connector/Socket 806-0601-05 1 CONN., 3 CKT RECEPTACLE HOUSING 0 1 ...3 8- Connector/Socket 806-0609-05 1 CONN., CONTACT, #18-24, 4.20MM, FEMALE, CRIMP 03 ..2 1-Ops/RFN Mfg 123-0680-02 1 LABEL STOCK, 1/2 X 2, WHITE BLANK, SERIAL/PN/MAC ADDRESS 01 ..2 5-Misc Part 508-0631-99 1 FAN, FINGER GUARD, METAL, 60MM 0 3 ..2 5-Misc Part 510-0760-01 A BRACKET, RIB SUPPORT, BACKPLANE, CU 0 1 ..2 5-Misc Part 510-1221-04 A TRAY, CHASSIS, RBS 0 1 ..2 5-Misc Part 510-1222-02 C COVER, CHASSIS, RBS 0 1 ..2 5-Misc Part 510-1223-04 A PANEL, BACK, RBS 0 1 ..2 5-Misc Part 510-1224-03 B PLATE, RADIOBLADE, RBS 0 1 ..2 5-Misc Part 510-1225-03 B SHIELD, COMBINER, RBS 0 3 ..2 5-Misc Part 510-1236-03 A GUIDE, RADIOBLADE, RBS 0 3 ..2 5-Misc Part 520-0550-99 2 NUT, JAM, 1/2-28, .093 THICK 0 1 ..2 5-Misc Part 520-0590-99 2 SCREW, #10-32 X 1/2, ZOS, PPH, EXT SEMS 0 2 ..2 5-Misc Part 520-0960-00 1 SCREW, #6-32 X 1/4, ZOS, PPH, INT SEMS 0 22 ..2 5-Misc Part 521-0520-99 C HANDLE, ALUMINUM, 5" CTC 0 1 ..2 5-Misc Part 523-0571-20 1 GASKET, EMI, .120 X .360 D-SHAPE W/PSA, 4.25" 0 2 ..2 5-Misc Part 523-0571-30 1 GASKET, EMI, .120 X .360 D-SHAPE W/PSA, 0 2 Page 3 of 32 3/27/2006 5:55:52 PM RadioFrame Networks ProprietaryCreated by: Dean Busch 101-0507-01 BOM EXPLOSION REPORT MC-SERIES DUAL BAND RACK BUILD -ELECTRORACKE Part NumberPart DescriptionPart Revision Level Part Type Item Number Rev Item Description Find Num Qty Ref Des BOM Notes ..2 5-Misc Part 525-0003-00 1 COMPOUND, THERMAL PASTE 0 0.02 ..2 5-Misc Part 530-0203-72 1 SCREW, #6-32 X 3/16, FL HD PH, ST ZN, U-CUT 0 7 ..2 5-Misc Part 530-0220-02 1 SCREW, #6-32 X 1 1/4, PPH, ST ZN 0 12 ..2 5-Misc Part 533-0103-02 1 SCREW, #4-40 X 3/16, PPH, INT SEMS, ST ZN 0 21 ..2 5-Misc Part 533-7108-02 1 SCREW, #6-32 X 1/2, PPH, EXT SEMS, ST ZN 0 16 ..2 5-Misc Part 534-0204-02 1 NUT, #6-32, KEP, ST ZN 0 3 ..2 5-Misc Part 536-0304-00 1 STANDOFF, JACK SCREW, 3/16 HEX M/F, #4-40 X 1/4, SS 012 ..2 5-Misc Part 539-0002-00 1 SCREW, 8-32 X 1/4 SLOTTED PH, ST ZN 0 16 ..2 5-Misc Part 539-1703-00 A RIVE…

Text truncated - open the document above for the full version.

3/27/2006 6:10:26 PM RadioFrame Networks ProprietaryCreated by: Dean Busch 176-0860-00 BOM EXPLOSION REPORT FRU, MULTI-CHANNEL RADIOBLADE (MCRB), IDENPA Part NumberPart DescriptionPart Revision Level Part Type Item Number Rev Item Description Find Num Qty Ref Des BOM Notes 0 1-Ops/RFN Mfg 176-0860-00 FRU, MULTI-CHANNEL RADIOBLADE (MCRB), .1 1-Ops/RFNMfg 120-1000-00 B CARDBOARD, RSC, RFU 0 .033 .1 1-Ops/RFNMfg 120-1012-01 A CARDBOARD, DIVIDERS, RB FRU KIT 0 .033 .1 1-Ops/RFNMfg 121-7000-00 C FOAM, PCA 0 .033 .1 1-Ops/RFNMfg 122-0002-00 A BAG, ESD BUBBLE W/ADHESIVE SEAL, 4" X 6" 0 1 .1 5-Misc Part 510-1206-03 A STRAP, RADIOBLADE MOUNTING 0 1 .1 8-Connector/Socket 820-0001-05 E ASY, CABLE, LMR-100A, SMA ST/RA, 6.5" 0 2 ..2 8- Connector/Socket 802-0166-05 1 CONN, CONN., CABLE, PLUG, SMA RA, CRIMP 0 1 ..2 8- Connector/Socket 802-0167-05 1 CONN, CONN., CABLE, PLUG, SMA ST, CRIMP 0 1 ..2 8- Connector/Socket 825-0546-00 1 CABLE, LMR-100A 0 1 .1 Document 900-0860-00 PA TOP LEVEL ASY DRAWING, FRU, MCRB IDEN 0 0 .1 1-Ops/RFNMfg FCT-0860-01 PA MULTI-CHANNEL RADIOBLADE, FUNCTIONALLY TESTED 01 ..2 1-Ops/RFN Mfg 101-0860-01 PD SUB ASY, MULTI-CHANNEL RADIOBLADE (MCRB), IDEN 01 ...3 1-Ops/RFN Mfg 123-1031-00 1 LABEL, BARCODE, BLANK STOCK, 1.00 X .25 0 1 ...3 5-Misc Part 510-0790-99 4 RADIOBLADE, SHIELD, EU GSM, BOTTOM 0 1 ...3 5-Misc Part 510-0800-99 3 RADIOBLADE, SHIELD, EU GSM, TOP 0 1 ...3 Document 910-0860-01 PA SUB-LEVEL ASSEMBLY DRAWING, MCRB, IDEN 0 0 ...3 1-Ops/RFN Mfg ASY-0860-07 A MULTI-CHANNEL RADIOBLADE (MCRB), IDEN, 0 1 Page 1 of 13 3/27/2006 6:10:31 PM RadioFrame Networks ProprietaryCreated by: Dean Busch 176-0860-00 BOM EXPLOSION REPORT FRU, MULTI-CHANNEL RADIOBLADE (MCRB), IDENPA Part NumberPart DescriptionPart Revision Level Part Type Item Number Rev Item Description Find Num Qty Ref Des BOM Notes ....4 2-Resistor 200-0-0 2 RES, 0, 0402 0 51 C81, C147, C177, C202, C214, C275, C290, C345, FL25, FL26, FL28, FL30, FL56, FL60-FL63, L13, L26, L57, L59, L60, L67, L70, L71, L73, L74, R2, R37, R50, R62, R66, R76,R78, R81, R82, R96,R105, R120, R123, R166, R176, R178, R208, R232, R252, R255, R257, R261, R262, R267 ....4 2-Resistor 200-100-0J 1 RES, 10, +/-5%, 0402 0 1 R167 ....4 2-Resistor 200-1000-0F 1 RES, 100, 1% 0402 0 12 R40, R43, R69, R73, R79, R80, R98, R99,R102, R104, R156, R169 ....4 2-Resistor 200-1001-0F 1 RES, 1.0K, 1%, 0402 0 60 R4-R6, R9, R10, R13, R14, R19, R23,R26, R45, R46, R52,R53, R55-R57, R59, R60, R64, R72, R85,R100, R101, R110, R111, R113, R125-R127, R131, R133, R137, R138, R143, R145, R148, R149, R157, R158, R197, R203, R204, R213, R214, R223, R229, R230, R237-R241, R245, R246, R253, R254, R258, R269, R270 ....4 2-Resistor 200-1003-0F 1 RES, 100K, 1%, 0402 0 4 R12, R24, R48, R153 ....4 2-Resistor 200-1022-0F 1 RES, 10.2K, 0402, 1% 0 1 R128 Page 2 of 13 3/27/2006 6:10:32 PM RadioFrame Networks ProprietaryCreated by: Dean Busch 176-0860-00 BOM EXPLOSION REPORT FRU, MULTI-CHANNEL RADIOBLADE (MCRB), IDENPA Part NumberPart DescriptionPart Revision Level Part Type Item Number Rev Item Description Find Num Qty Ref Des BOM Notes ....4 2-Resistor 200-103-0J 1 RES, 10K, +/-5%, 0402 0 22 R20, R27, R71, R86, R93, R94, R115, R119, R121, R124, R190-R193, R216, R221, R224, R231, R235, R236, R242, R243 ....4 2-Resistor 200-1102-0F A RES, 11.0K, 1%, 1/16W, 0402 0 1 R174 ....4 2-Resistor 200-11R5-0F 1 RES, 11.5, 1%, 0402 0 1 R264 ....4 2-Resistor 200-121-0J 1 RES, 120, +/-5%, 0402 0 4 R89, R91, R181, R189 ....4 2-Resistor 200-1212-0F A RES, 12.1K, +/-1%, 0402 0 1 R25 ....4 2-Resistor 200-1243-0F A RES, 124K 1%, 0402 0 1 R142 ....4 2-Resistor 200-1500-0F 1 RES, 150, 1%, 0402 0 3 R152, R227, R228 ....4 2-Resistor 200-1692-0F A RES, 16, 9K, 1%, 0402 0 1 R172 ....4 2-Resistor 200-17R4-0F 1 RES, 17.4, 1%, 0402 0 2 R199, R249 ....4 2-Resistor 200-181-0J 1 RES, 180, 0402, 5% 0 8 R129, R140, R185, R195, R200, R209, R210, R212 ....4 2-Resistor 200-2001-0F A RES, 2.00K, 1%, 1/16W, 0402 0 3 R51, R84, R97 ....4 2-Resistor 200-203-0J A RES, 20K, 5%, 1/16W, 0402 0 1 R233 ....4 2-Resistor 200-225-0J A RES, 2.2M, +/-5%, 0402 0 1 R164 ....4 2-Resistor 200-240-0J 1 RES, 24, 5%, 0402 0 2 R154, R171 ....4 2-Resistor 200-243-0J A RES, 24K, 5%, 1/16W, 0402 0 2 R160, R161 ....4 2-Resistor 200-2430-0F A RES, 243, 1%, 1/16W, 0402 0 3 R21, R75, R247 ....4 2-Resistor 200-2940-0F 1 RES, 294, 1%, 0402 0 5 R179, R205, R206, R248, R250 ....4 2-Resistor 200-2943-0F A RES, 294K, 1%, 0402 0 1 R159 Page 3 of 13 3/27/2006 6:10:35 PM RadioFrame Networks ProprietaryCreated by: Dean Busch 176-0860-00 BOM EXPLOSION REPORT FRU, MULTI-CHANNEL RADIOBLADE (MCRB), IDENPA Part NumberPart DescriptionPart Revision Level Part Type Item Number Rev Item Description Find Num Qty Ref Des BOM Notes ....4 2-Resistor 200-300-0J-55 A RES, 30, 5%, 1/16W, 0402 0 3 R180, R182, R211 ....4 2-Resistor 200-330-0J 1 RES, 33, 0402, 5% 0 10 R3, R11, R130, R134, R135, R139, R146, R147, R184, R196 ....4 2-Resistor 200-3321-0F A RES, 3.32K, 1%, 1/16W, 0402 0 2 R114, R132 ....4 2-Resistor 200-361-0J A RES, 360, 5%, 1/16W, 0402 0 5 R31, R155, R168, R187, R188 ....4 2-Resistor 200-363-0J A RES, 36K, 5%, 1/16W, 0402 0 1 R35 ....4 2-Resistor 200-37R4-0F 1 RES, 37.4, 1%, 0402 0 1 R222 ....4 2-Resistor 200-3832-0F-55 A RES, 38.3K, 1%, 1/16W, 0402 0 1 R136 ....4 2-Resistor 200-391-0J A RES, 390, 5%, 1/16W, 0402 0 3 R39, R163, R170 ....4 2-Resistor 200-4320-0F 1 RES, 432, 1%, 0402 0 2 R263, R265 ....4 2-Resistor 200-471-0J A RES, 470, 5%, 1/16W, 0402 0 2 R29, R32 ....4 2-Resistor 200-472-0J 1 RES, 4.7K, 0402, 5% 0 9 R30, R33, R68, R112, R117, R118, R122, R244, R268 ....4 2-Resistor 200-4990-0F 1 RES, 499, 1%, 0402 0 1 R217 ....4 2-Resistor 200-49R9-0F 1 RES, 49.9, 1%, 0402 0 11 R36, R42, R65, R67, R77, R92, R95, R108, R183, R186, R198 ....4 2-Resistor 200-511-0J 1 RES, 510, 0402, 5% 0 4 R15-R18 ....4 2-Resistor 200-680-0J A RES, 68, 5%, 1/16W, 0402 0 11 R44, R107, R109, R150, R162, R194, R201, R215, R218-R220 ....4 2-Resistor 200-750-0F 2 RES, 75, 1%, 0402 0 1 R34 ....4…

Text truncated - open the document above for the full version.

Radioframe Networks, Inc. MCRB March 29, 2006 Report No. RAFN0060 Report Prepared By www.nwemc.com 1-888-EMI-CERT © 2006 Northwest EMC, Inc 22975 NW Evergreen Parkway Suite 400 Hillsboro, Oregon 97124 Certificate of Test Issue Date: March 29, 2006 Radioframe Networks, Inc. Model: MCRB Emissions Test Description Specification Test Method Pass Fail Radiated Emissions FCC 15.109(b) Class A:2005-10 ANSI C63.4:2003 Conducted Emissions FCC 15.107 Class A:2005-10 ANSI C63.4:2003 Emission Mask 47 CFR 90.691:2005 TIA/EIA - 603:2002 Frequency Stability 47 CFR 2.1055, 90.217:2005 TIA/EIA - 603:2002 Output Power 47 CFR 2.1046 & 90.217:2005 TIA/EIA - 603:2002 Spurious Conducted Emissions- Transmit 47 CFR 2.1051 & 90.691:2005 TIA/EIA - 603:2002 Spurious Conducted Emissions- Receive 47 CFR 15.111(a) ANSI C63.4:2003 Spurious Radiated Emissions FCC 90.691 and 2.1053 Spurious Emissions:2005 TIA/EIA - 603-B:2002 Modifications made to the product See the Modifications section of this report Test Facility The measurement facility used to collect the data is located at: Northwest EMC, Inc. 22975 NW Evergreen Parkway, Suite 400; Hillsboro, OR 97124 Phone: (503) 844-4066 Fax: 844-3826 This site has been fully described in a report filed with and accepted by the FCC (Federal Communications Commission) and Industry Canada. Approved By: Greg Kiemel, Director of Engineering This report must not be used to claim product certification, approval, or endorsement by NVLAP, NIST, or any agency of the federal government of the United States of America. Product compliance is the responsibility of the client, therefore the tests and equipment modes of operation represented in this report were agreed upon by the client, prior to testing. This Report may only be duplicated in its entirety. The results of this test pertain only to the sample(s) tested, the specific description is noted in each of the individual sections of the test report supporting this certificate of test. Northwest EMC Revision History Revision 05/05/03 Revision Number Description Date Page Number 00 None Northwest EMC Accreditations and Authorizations Revision 03/18/05 FCC: Accredited by NVLAP for performance of FCC radio, digital, and ISM device testing. Our Open Area Test Sites, certification chambers, and conducted measurement facilities have been fully described in reports filed with the FCC and accepted by the FCC in letters maintained in our files. Northwest EMC has been accredited by ANSI to ISO / IEC Guide 65 as a product certifier. We have been designated by the FCC as a Telecommunications Certification Body (TCB). This allows Northwest EMC to certify transmitters to FCC specifications in accordance with 47 CFR 2.960 and 2.962. NVLAP: Northwest EMC, Inc. is accredited under the United States Department of Commerce, National Institute of Standards and Technology, and National Voluntary Laboratory Accreditation Program for satisfactory compliance with the requirements of ISO/IEC 17025 for Testing Laboratories. The NVLAP accreditation encompasses Electromagnetic Compatibility Testing in accordance with the European Union EMC Directive 89/336/EEC, ANSI C63.4, MIL- STD 461E, DO-160D and SAE J1113. Additionally, Northwest EMC is accredited by NVLAP to perform radio testing in accordance with the European Union R&TTE Directive 1999/5/EEC, the requirements of FCC, and the RSS radio standards for Industry Canada. NVLAP LAB CODE 200629-0 NVLAP LAB CODE 200630-0 NVLAP LAB CODE 200676-0 Industry Canada: Accredited by NVLAP for performance of Industry Canada RSS and ICES testing. Our Open Area Test Sites and certification chambers comply with RSS 212, Issue 1 (Provisional) and have been filed with Industry Canada and accepted. Northwest EMC has been accredited by ANSI to ISO / IEC Guide 65 as a product certifier. We have been designated by NIST and recognized by Industry Canada as a Certification Body (CB) per the APEC Mutual Recognition Arrangement (MRA). This allows Northwest EMC to certify transmitters to Industry Canada technical requirements. CAB: Designated by NIST and validated by the European Commission as a Conformity Assessment Body (CAB) to conduct tests and approve products to the EMC directive and transmitters to the R&TTE directive, as described in the U.S. - EU Mutual Recognition Agreement. TÜV Product Service: Included in TUV Product Service Group's Listing of Recognized Laboratories. It qualifies in connection with the TUV Certification after Recognition of Agent's Testing Program for the product categories and/or standards shown in TUV's current Listing of CARAT Laboratories, available from TUV. A certificate was issued to represent that this laboratory continues to meet TUV's CARAT Program requirements. Certificate No. USA0401C. TÜV Rheinland: Authorized to carryout EMC tests by order and under supervision of TÜV Rheinland. This authorization is based on "Conditions for EMC-Subcontractors" of November 1992. Northwest EMC Accreditations and Authorizations Revision 03/18/05 NEMKO: Assessed and accredited by NEMKO (Norwegian testing and certification body) for European emissions and immunity testing. As a result of NEMKO's laboratory assessment, they will accept test results from Northwest EMC, Inc. for product certification (Authorization No. ELA 119). Technology International: Assessed in accordance with ISO Guide 25 defining the general international requirements for the competence of calibration and testing laboratories and with ITI assessment criteria LACO196. Based upon that assessment, Interference Technology International, Ltd., has granted approval for specifications implementing the EU Directive on EMC (89/336/EEC and amendments). The scope of the approval was provided on a Schedule of Assessment supplied with the certificate and is available upon request. Australia/New Zealand: The National Association of Testing Authorities (NATA), Australia has been appointed by the ACA as an accreditation body to accredit test laboratories and com…

Text truncated - open the document above for the full version.

NORTHWEST EMC Conducted Emissions PSA 2006.03.15 NORTHWEST EMC Conducted Emissions PSA 2006.03.15 NORTHWEST EMC Radiated Emissions PSA 2006.03.15 NORTHWEST EMC Radiated Emissions PSA 2006.03.15 NORTHWEST EMC Radiated Emissions PSA 2006.03.15 NORTHWEST EMC Radiated Emissions PSA 2006.03.15 NORTHWEST EMC Radiated Emissions PSA 2006.03.15 NORTHWEST EMC Spurious Radiated Emissions PSA 2006.03.15