QPUWLAN6060SDWireless LAN modem card

WLAN6060SD Card User Manual 02/12/2003 preliminary Confidential Information Note: SyChip, Inc. reserves the right to make changes in specifications at anytime and without notice. The information furnished in this data sheet is believed to be accurate and reliable. However, no responsibility is assumed by SyChip for its use, nor any infringements of patents or other rights of third parties resulting from its use. No license is generated under any rights of SyChip or its supporters unless specifically agreed. WLAN6060SD Card User Manual WLAN6060SD Card User Manual Version Control Version Date Author Engineering Approval Marketing Approval Operation Approval Mark Preliminary 02/12/2003 PG SyChip Confidential Page 2 of 21 SyChip_WLAN6060SD WLAN6060SD Card User Manual Table of Content 1 INTRODUCTION INFORMATION...................................................................................................................5 1.1 Introduction....................................................................................................................................................................5 1.2 About this User Manual:...............................................................................................................................................6 1.3 Safety Precautions..........................................................................................................................................................7 1.4 Limitation of Liability..................................................................................................................................................7 1.5 Usage Conditions............................................................................................................................................................7 1.6 Warning..........................................................................................................................................................................7 1.7 Caution............................................................................................................................................................................7 1.8 Handling Instructions....................................................................................................................................................7 1.9 Notes................................................................................................................................................................................7 2 WLAN6060SD PACKAGE CONTENTS.........................................................................................................7 3 WLAN6060SD SPECIFICATIONS..................................................................................................................7 4 INSTALLATION AND CONFIGURATION......................................................................................................8 4.1 Preparation.....................................................................................................................................................................8 4.2 Supported Devices..........................................................................................................................................................8 4.3 Installing WLAN6060SD Card and Software.............................................................................................................8 4.4 Configuring WLAN6060SD Card................................................................................................................................9 4.4.1 Pegasus Card Configuration........................................................................................................................................9 4.4.2 Status Tab....................................................................................................................................................................9 4.4.3 Configuration Tab.....................................................................................................................................................11 4.4.4 Encryption Tab..........................................................................................................................................................12 4.4.5 Advanced Setting Tab...............................................................................................................................................13 4.4.6 Host Scan Tab...........................................................................................................................................................14 4.4.7 About Tab.................................................................................................................................................................16 4.5 Removing the radio card.............................................................................................................................................16 5 TROUBLESHOOTING..................................................................................................................................16 SyChip Confidential Page 3 of 21 SyChip_WLAN6060SD WLAN6060SD Card User Manual 6 DOCUMENTATION UPDATES.....................................................................................................................17 7 CONTACT INFORMATION...........................................................................................................................17 8 LEGAL INFORMATION................................................................................................................................18 8.1 Applying the Regulatory Country Stamp..................................................................................................................18 SyChip Confidential Page 4 of 21 SyChip_WLAN6060SD WLAN6060SD Card User Manual 1 Introduction Information 1.1 Introduction SyChip WL…

Text truncated - open the document above for the full version.

No t e : T h e s e c e r t i f ic a t i o n I D 's w ill b e lo c a t e d o n t h is s i de va r i ous l o ca t i on s sa m e fon t . D C B A AB C D 1 2 3 4 5 6 7 8 8 7 6 5 4 3 2 1 AP P L I C A T I O N DI M E N S I O NS A R E M E T R I C TOL E RA N C E S : FR A C T I O N A L AN GUL A R : M A C H B E N D TW O P L A C E D E C I MA L T H R EE P L AC E D E C I M A L I N T E R P RE T G E O M E T RI C TO LERA NC I N G PER: MAT E RI AL FI NI S H EN G E N G A PPR . CO M M E N T S : NA M E TI T L E : SI Z E B DW G . NO. REV WE I G H T : SC A L E : 2 . 5 : 1 RE V I S I O N S REV . DE S C R I PT I O N DATE A P PR O V E D ZO N E U N LE SS O T HE RW I S E SP E C I F I E D: S H EET 5 O F 5 S D I O 60 60- In j e ct i o n DO N O T S C AL E D R AW I N G Ch ar l i e W a n g Tel : 972- 202 - 8 880 C w a n g@ sych i p .com

WLAN6060SD Card Technical Information 02/12/2003 preliminary Confidential Information Note: SyChip, Inc. reserves the right to make changes in specifications at anytime and without notice. The information furnished in this data sheet is believed to be accurate and reliable. However, no responsibility is assumed by SyChip for its use, nor any infringements of patents or other rights of third parties resulting from its use. No license is generated under any rights of SyChip or its supporters unless specifically agreed. WLAN6060SD Card Technical Information WLAN6060SD Card Commercial Briefs Version Control Version Date Author Engineering Approval Marketing Approval Operation Approval Mark Preliminary 02/11/2003 PG SyChip Confidential Page 2 of 6 SyChip_WLAN6060SD WLAN6060SD Card Technical Information Table of Content 1 INTRODUCTION INFORMATION...................................................................................................................4 2 WLAN6060SD ARCHITECTURE....................................................................................................................5 3 WLAN6060SD PACKAGE CONTENTS.........................................................................................................6 4 WLAN6060SD SPECIFICATIONS..................................................................................................................6 SyChip Confidential Page 3 of 6 SyChip_WLAN6060SD WLAN6060SD Card Technical Information 1 Introduction Information SyChip WLAN6060SD Network Interface Card WLAN6060SD Card from SyChip Inc is a Secure Digital Card form factor Wireless LAN NIC(Network Interface Card) incorporating the popular wireless Ethernet standard 802.11b. It uses Direct Sequence Spread Spectrum (DSSS) Wireless LAN technology to provide bandwidths of up to 11Mbps at ranges of up to 400 feet. This card enables next generation Pocket PC/PDAs, Cellular Phones, and Ultra-thin notebook computers to access the internet, email, corporate networks and transfer streaming video or audio, images or large files from a WLAN-enabled environment. It allows an extension of the corporate resources by enabling the mobile workforce and telecommuters. The card is idea for vertical markets such as manufacturing floors, car rentals, retail spaces, hospitals etc. In the consumer market, this WLAN card is ideal for users of next generation Palms, Pocket PCs, Smartphones, printers and scanners. Additionally, the card gives users the ability to work whilst away from the office by connecting to the rapidly expanding public hotspot infrastructure. Such venues as coffee shops, airports, shopping malls, hotels, etc are offering this capability based on the IEEE802.11b standard. For mobile applications, battery life is extended through the use of enhanced power saving features, which reduce the current drain whilst in standby mode (the card is in this state for the majority of the time as it awaits data destined for it). Not only does the WLAN6060SD Card roam seamlessly among multiple 802.11b wireless network access point, it also operates in peer to peer mode (without an access point) to download data from wirelessly equipped laptops without a cradle or network connection, and can share data directly with wireless PDAs. This is a complete WLAN solution incorporating the Baseband Processor, Mac, Memory, VCO, Transceiver, Antenna, antenna switch and power amplifier and to realize a complete design. The card will be fully WiFi certified. SyChip Confidential Page 4 of 6 SyChip_WLAN6060SD WLAN6060SD Card Technical Information Key Features: • Wi-Fi Certified – interoperable with other Wi-Fi certified WLAN products • Very small footprint: card measured 54.0x24.0x2.1mm3. • Complete IEEE802.11b functionality integrated BB/MAC, RF, VCO, PA and SDIO interface • Reduced power consumption in standby mode • Support WinCE (v3.0 or greater), Palm OS • Support infrastructure or Peer to Peer connectivity 2 WLAN6060SD Architecture PA BBP/MAC RF FRONT END Direct conversion CLOCK vco Loop Filter 44MHz Clock TXI TXQ RXI DATA LATCH ENABLE RXQ TX AGC BB AGC RX AGC Balun T/R Switch BPF SDIO Interface IC Pins 1-9 WLAN6060SD NIC Block Diagram WLAN6060SD is a complete WLAN(802.11b) system and could be used as a standalone unit or as a plug-and-play accessory in different applications. The card is built with 2-chip design–an RF Transceiver and a Baseband Processor. The RF front-end integrated circuit includes a LNA, a transmit pre-amplifier, a quadrature up/down converter, a synthesizer, a low pass filter, and a RX amplifier. It utilizes Direct Conversion technology, eliminating the need for intermediate-frequency mixer(s), amplifier and filter components. The RF function provides programming of the RF channel frequency from 2.4 GHz to 2.5 GHz in steps of 1 MHz. This covers all of the RF channels frequencies specified in 802.11b standard. The RF channel frequency for transmission and reception is stable with 25kHz of its final value, 0.75ms after reprogramming or switching from sleep mode to receive mode. SyChip Confidential Page 5 of 6 SyChip_WLAN6060SD WLAN6060SD Card Technical Information The Baseband Processor is a highly integrated Baseband/MAC which complements the RF front-end, resulting in the significant reduction in component count and enable WLAN6060SD to be built to the world smallest form factor and very competitive for emerging consumer markets. Through dynamic throughput management, the WLAN6060SD can adjust its transmit/receive speed to 1, 2, 5.5, or 11Mbps. This technique ensures that the card is performing at the optimal transmission rate for the range signal strength while consuming minimum power. WLAN6060SD I/O interface supports SDIO standard. WLAN6060SD supports 802.11 WEP 64/128 bit security standard. Future versions will support LEAP and 802.1x. WLAN6060SD currently supports Win CE3.0 (Pocket PC2002 or higher version), Win CE.NET(4.2) Operating System. Future versions will include Palm OS…

Text truncated - open the document above for the full version.

Test Report S/N: 040203-359QPU Test Date(s): April 02, 2003 FCC SAR Evaluation © 2003 Celltech Labs Inc.1 of 21 Celltech Labs Inc. declares under its sole responsibility that this device was found to be in compliance with the Specific Absorption Rate (SAR) RF exposure requirements specified in FCC 47 CFR §2.1093 and Health Canada’s Safety Code 6. The device was tested in accordance with the measurement standards and procedures specified in FCC OET Bulletin 65, Supplement C, Edition 01-01 and Industry Canada RSS-102 Issue 1 (Provisional) for the General Population / Uncontrolled Exposure environment. I attest to the accuracy of data. All measurements were performed by me or were made under my supervision and are correct to the best of my knowledge and belief. I assume full responsibility for the completeness of these measurements and vouch for the qualifications of all persons taking them. This test report shall not be reproduced partially, or in full, without the prior written approval of Celltech Labs Inc. The results and statements contained in this report pertain only to the device(s) evaluated. Russell Pipe Senior Compliance Technologist Celltech Labs Inc. DECLARATION OF COMPLIANCE SAR EVALUATION Test Lab CELLTECH LABS INC. Testing and Engineering Lab 1955 Moss Court Kelowna, B.C. Canada V1Y 9L3 Phone: 250-448-7047 Fax: 250-448-7046 e-mail: [email protected] web site: www.celltechlabs.com Applicant Information SYCHIP INC. 2805 N. Dallas Parkway Plano, TX 75093 Rule Part(s):FCC 47 CFR §2.1093; IC RSS-102 Issue 1 (Provisional) Test Procedure(s):FCC OET Bulletin 65, Supplement C (01-01) Device Classification:Digital Transmission System (DTS) EUT Type:DSSS WLAN Module for Handheld PDAs Host PDA:NEC Pocket PC (S/N: 100162330110) EUT FCC ID:QPUWLAN6060SD Model(s):WLAN6060SD Modulation:Direct Sequence Spread Spectrum (DSSS) Tx Frequency Range:2412 - 2462 MHz Max. Output Power Tested:14.5 dBm Conducted (2412 MHz) 14.9 dBm Conducted (2437 MHz) 15.0 dBm Conducted (2462 MHz) Antenna Type(s):Embedded Power Supply:3.7V Lithium-ion Battery (from host PDA) Max. SAR Measured:1.51 W/kg (1g average) Test Report S/N: 040203-359QPU Test Date(s): April 02, 2003 FCC SAR Evaluation © 2003 Celltech Labs Inc.2 of 21 TABLE OF CONTENTS 1.0INTRODUCTION..................................................................... 3 2.0DESCRIPTION OF EUT............................................................ 3 3.0SAR MEASUREMENT SYSTEM ............................................... 4 4.0MEASUREMENT SUMMARY..................................................... 5 5.0DETAILS OF SAR EVALUATION............................................... 6 6.0EVALUATION PROCEDURES................................................... 7 7.0SYSTEM PERFORMANCE CHECK............................................ 8 8.0EQUIVALENT TISSUES........................................................... 9 9.0SAR LIMITS........................................................................... 9 10.0SYSTEM SPECIFICATIONS......................................................10 11.0PROBE SPECIFICATION.........................................................11 12.0SAM PHANTOM......................................................................11 13.0DEVICE HOLDER....................................................................11 14.0TEST EQUIPMENT LIST...........................................................12 15.0MEASUREMENT UNCERTAINTIES............................................13 16.0REFERENCES.......................................................................14 APPENDIX A - SAR MEASUREMENT DATA............................................15 APPENDIX B - SYSTEM CHECK DATA....................................................16 APPENDIX C - SYSTEM VALIDATION.....................................................17 APPENDIX D - PROBE CALIBRATION....................................................18 APPENDIX E - MEASURED FLUID DIELECTRIC PARAMETERS................19 APPENDIX F - SAM PHANTOM CERTIFICATE OF CONFORMITY..............20 APPENDIX G - SAR TEST SETUP & EUT PHOTOGRAPHS........................21 Test Report S/N: 040203-359QPU Test Date(s): April 02, 2003 FCC SAR Evaluation © 2003 Celltech Labs Inc.SYCHIP INC. FCC ID: QPUWLAN6060SD3 of 21 DSSS WLAN Module for Handheld PDAs (2412-2462MHz) 1.0 INTRODUCTION This measurement report demonstrates compliance of SyChip Inc. Model: WLAN6060SD DSSS WLAN Module FCC ID: QPUWLAN6060SD (for Handheld PDAs) with the RF exposure requirements specified in FCC 47 CFR §2.1093 (see reference [1]), and Health Canada’s Safety Code 6 (see reference [2]) for the General Population / Uncontrolled Exposure environment. The test procedures described in FCC OET Bulletin 65, Supplement C, Edition 01-01 (see reference [3]) and IC RSS-102 Issue 1 (Provisional) (see reference [4]), were employed. A description of the product, operating configuration, detailed summary of the test results, methodology and procedures used in the evaluation, equipment used, and the various provisions of the rules are included within this test report. 2.0 DESCRIPTION of Equipment Under Test (EUT) FCC Rule Part(s) 47 CFR §2.1093 IC Rule Part(s) RSS-102 Issue 1 (Provisional) Test Procedure(s) FCC OET Bulletin 65, Supplement C (01-01) FCC Device Classification Digital Transmission System (DTS) Device Type DSSS WLAN Module for Handheld PDAs Host PDA NEC Pocket PC (S/N: 100162330110) EUT FCC ID QPUWLAN6060SD Model(s) WLAN6060SD Serial No. Pre-production Modulation Direct Sequence Spread Spectrum (DSSS) Tx Frequency Range 2412 - 2462 MHz Max. RF Output Power Tested 14.5 dBm Conducted (2412 MHz) 14.9 dBm Conducted (2437 MHz) 15.0 dBm Conducted (2462 MHz) Antenna Type(s) Embedded Power Supply 3.7V Lithium-ion Battery (from host PDA) Test Report S/N: 040203-359QPU Test Date(s): April 02, 2003 FCC SAR Evaluation © 2003 Celltech Labs Inc.SYCHIP INC. FCC ID: QPUWLAN6060SD4 of 21 DSSS WLAN Module for Handheld PDAs (2412-2462MHz) 3.0 SAR MEASUREMENT SYSTEM Ce…

Text truncated - open the document above for the full version.

Nemko Test Report: 3L0018RUS1 Applicant: SyChip, Inc. 1700 Alma Drive Suite 240 Plano, TX 75075 Equipment Under Test: WLAN6060SD (E.U.T.) In Accordance With: FCC Part 15, Subpart C, 15.247 Direct Sequence Spread Spectrum Transmitters Tested By: Nemko Dallas Inc. 802 N. Kealy Lewisville, Texas 75057-3136 Authorized By: Tom Tidwell, Frontline Manager Date: 11 February 2003 Total Number of Pages: 40 Nemko Dallas FCC PART 15, SUBPART C DIRECT SEQUENCE SPREAD SPECTRUM TRANSMITTER EQUIPMENT: WLAN6060SD PROJECT NO.: 3L0018RUS1 Page 2 of 40 Table of Contents Section 1. Summary of Test Results..................................................................3 Section 2. Equipment Under Test (E.U.T.)........................................................5 Section 3. Powerline Conducted Emissions.......................................................7 Section 4. Minimum 6 dB Bandwidth.............................................................11 Section 5. Maximum Peak Output Power........................................................14 Section 6. RF Exposure..................................................................................15 Section 7. Spurious Emissions (conducted).....................................................16 Section 8. Spurious Emissions (radiated)........................................................19 Section 9. Peak Power Spectral Density..........................................................23 Section 10. Test Equipment List.........................................................................26 ANNEX A - TEST DETAILS.............................................................................27 ANNEX B - TEST DIAGRAMS.........................................................................37 Nemko Dallas FCC PART 15, SUBPART C DIRECT SEQUENCE SPREAD SPECTRUM TRANSMITTER EQUIPMENT: WLAN6060SD PROJECT NO.: 3L0018RUS1 Page 3 of 40 Section 1. Summary of Test Results Manufacturer: SyChip, Inc. Model No.: WLAN6060SD Serial No.: None General: All measurements are traceable to national standards. These tests were conducted on a sample of the equipment for the purpose of demonstrating compliance with Part 15, Subpart C, Paragraph 15.247 for Direct Sequence Spread Spectrum devices. Radiated tests were conducted is accordance with ANSI C63.4-1992. Radiated emissions are made on an open area test site. A description of the test facility is on file with the FCC. New Submission Production Unit Class II Permissive Change Pre-Production Unit THIS TEST REPORT RELATES ONLY TO THE ITEM(S) TESTED. THE FOLLOWING DEVIATIONS FROM, ADDITIONS TO, OR EXCLUSIONS FROM THE TEST SPECIFICATIONS HAVE BEEN MADE. NONE See “ Summary of Test Data”. NVLAP LAB CODE: 100426-0 Nemko Dallas Inc. authorizes the above named company to reproduce this report provided it is reproduced in its entirety and for use by the company’s employees only. Any use which a third party makes of this report, or any reliance on or decisions to be made based on it, are the responsibility of such third parties. Nemko Dallas Inc. accepts no responsibility for damages, if any, suffered by any third party as a result of decisions made or actions based on this report. This report applies only to the items tested. Nemko Dallas FCC PART 15, SUBPART C DIRECT SEQUENCE SPREAD SPECTRUM TRANSMITTER EQUIPMENT: WLAN6060SD PROJECT NO.: 3L0018RUS1 Page 4 of 40 Summary Of Test Data NAME OF TEST PARA. NO. SPEC. RESULT Powerline Conducted Emissions 15.207(a) Mask Complies Minimum 6 dB Bandwidth 15.247(a)(2) >500 kHz Complies Maximum Peak Power Output 15.247(b)(1) <1 Watt Complies Spurious Emissions (Antenna Conducted) 15.247(c) -20 dBc/100kHz Complies Spurious Emissions (Restricted Bands) 15.247(c) < 74 dBuV/m Peak < 54 dBuV/m Avg Complies Peak Power Spectral Density 15.247(d) +8 dBm/3kHz Complies Footnotes: Nemko Dallas FCC PART 15, SUBPART C DIRECT SEQUENCE SPREAD SPECTRUM TRANSMITTER EQUIPMENT: WLAN6060SD PROJECT NO.: 3L0018RUS1 Page 5 of 40 Section 2. Equipment Under Test (E.U.T.) General Equipment Information Frequency Band: 2412 to 2462 MHz Channel Spacing: 4.5 MHz User Frequency Adjustment: Software controlled Nemko Dallas FCC PART 15, SUBPART C DIRECT SEQUENCE SPREAD SPECTRUM TRANSMITTER EQUIPMENT: WLAN6060SD PROJECT NO.: 3L0018RUS1 Page 6 of 40 Theory of Operation WLAN6060SD Card from SyChip Inc is a Secure Digital Card form factor Wireless LAN NIC(Network Interface Card) incorporating the popular wireless Ethernet standard 802.11b. It uses Direct Sequence Spread Spectrum (DSSS) Wireless LAN technology to provide bandwidths of up to 11Mbps at ranges of up to 400 feet. This card enables next generation Pocket PC/PDAs, and Ultra-thin notebook computers to access the internet, email, corporate networks and transfer streaming video or audio, images or large files from a WLAN-enabled environment. It allows an extension of the corporate resources by enabling the mobile workforce and telecommuters. The card is idea for vertical markets such as manufacturing floors, car rentals, retail spaces, hospitals etc. In the consumer market, this WLAN card is ideal for users of next generation Palms, Pocket PCs, printers and scanners. Additionally, the card gives users the ability to work whilst away from the office by connecting to the rapidly expanding public hotspot infrastructure. Such venues as coffee shops, airports, shopping malls, hotels, etc are offering this capability based on the IEEE802.11b standard. For mobile applications, battery life is extended through the use of enhanced power saving features, which reduce the current drain whilst in standby mode (the card is in this state for the majority of the time as it awaits data destined for it). System Diagram Nemko Dallas FCC PART 15, SUBPART C DIRECT SEQUENCE SPREAD SPECTRUM TRANSMITTER EQUIPMENT: WLAN6060SD PROJECT NO.: 3L0018RUS1 Page 7 of 40 Section 3. Powerline Conducted Emissions NAME OF TEST: Powerline Conducted Emissions PARA. NO.: 15.207(a) TESTED BY: David Light DATE: 2/3…

Text truncated - open the document above for the full version.