TFJMFC242Payment Reader

MFC242 RFID Card Reader Programmer’s Manual Revision 1.0 Aug. 14, 2014 MFC242Programmer’s Manual Rev. 1.0 I NOTICE The issuer of this manual has made every effort to provide accurate information. The issuer will not be held liable for any technical and editorial omission or errors made herein; nor for incidental consequential damages resulting from the furnishing, performance or use of this material. This document contains proprietary information that is protected by copyright. All rights are reserved. No part of this document may be photocopied, reproduced, or translated without the prior written consent of the issuer. The information provided in this manual is subject to change without notice. AGENCY APPROVED - FCC class B - CE class B NOTE：This equipment has been tested and found to comply with the limits for a Class B digital device, pursuant to part 15 of the FCC Rules. These limits are designed to provide reasonable protection against harmful interference in a residential installation. This equipment generates, uses and can radiate radio frequency energy and, if not installed and used in accordance with the instructions, may cause harmful interference to radio communications. However, there is no guarantee that interference will not occur in a particular installation. If this equipment does cause harmful interference to radio or television reception, which can be determined by turning the equipment off and on, the user is encouraged to try to correct the interference by one or more of the following measures： —Reorient or relocate the receiving antenna. —Increase the separation between the equipment and receiver. —Connect the equipment into an outlet on a circuit different from that to which the receiver is connected. —Consult the dealer or an experienced radio/ TV technician for help. You are cautioned that any change or modifications to the equipment not expressly approve by the party responsible for compliance could void your authority to operate such equipment. WARRANTY This product is served under one-year warranty to the original purchaser. Within the warranty period, merchandise found to be defective would be repaired or replaced. This warranty applies to the products only under the normal use of the original purchaser, and in no circumstances covers incidental or consequential damages through consumers’ misuse or modification of the products. PREFACE This manual provides detailed information relating to the overall operational, electrical, mechanical, environmental and functional aspects of the MFC242. This document should be read and understood prior to initial operation of the product. For ease of installation and programming use, we have addressed everything from its attractive features to its various configurations. When designing the MFC242, we selected what we feel are the most useful features and functions. If in some cases you find that your specific needs differ from our existing products, we welcome your comments and suggestions. Custom-designed models are also available. If further questions do arise, please call for technical support, our FAE will assist you in any way we can. MFC242Programmer’s Manual Rev. 1.0 Page 2 General Description This section presents general information about the basic characters of the MFC242. 1.1 Features The MFC242 provides the following features： 1 Read Type A 13.56Mhz RFID Mifare card 2 Programmable illuminated color bezel 3 Support GDS protocol 4 Firmware upgradeable 5 USB interface, no external power supply required 6 Light weight：130g 7 Compact size：108.0 L x 75 W x 32 H mm 1.2 Application This MFC242 card reader is designed to read RFIID Mifare card as well as performing programmable illuminated color bezel. For the RFID module, it can read and decode Type A 13.56Mhz RFID Mifare card. This product communicates with a host computer or a terminal via GDS protocol using an USB 2.0 full speed interface. The reader is widely accepted in the financial industry applications as its transmitting protocol is highly reliable and easy to use. 1.3 Operation Behavior 1.3.1 RFID Card read Operation: While operating, the MCU reads commands from host USB interface and send them to the RFID Reader IC PN512 for the control of reading contactless TAG, then getting the response from PN512 and send it back to host through USB interface. 1.3.2 Illuminated color bezel Operation. The MCU reads commands from host USB interface and send them to G5126TB1U circuitry. Then G5126TB1U circuitry will output the different output voltage to the 4 pieces of Red, Green and Blue color’s LED. In this way, LED components will have different color and emit to the bezel MFC242Programmer’s Manual Rev. 1.0 Page 3 1.4 Dimensions of MFC242 2 Technical Specifications 2.1 Magnetic Card Specifications 2.1.1 Card Type Mifare Ultralight C and 4K Mifare DESFire EV1 2.1.2 Card Format Mifare format 2.1.3 Card Operation Te s t C a r d Card reading distance from Bezel Mifare Ultralight C 0 cm Mifare Ultralight C 1 cm Mifare Ultralight C 2 cm 2.2 Mechanical Specifications 2.2.1 Body Material PC SABIC 945A 2.2.2 Dimension Length： 108mm Width： 75mm Height： 32mm MFC242Programmer’s Manual Rev. 1.0 Page 4 2.2.3 Weight Approx. 130g 2.3 Electrical Specifications 2.3.1 Power Required DC 5V  5% 2.3.2 Power Consumption Stand-by current <50mA Max operating current <300mA 2.3.3 Communication GDS Card Reader Communication Protocol Standard V1.04 2.3.4 Ripple 250mVp-p Max. 2.3.5 Dielectric Strength 250VDC for 1 minute 2.3.6 Insulation Resistance 10MΩ min. at 250VDC MFC242Programmer’s Manual Rev. 1.0 Page 5 2.4 Environmental Specifications 2.4.1 Temperature Operating： -10-55°C Storage： -30-70°C 2.4.2 Humidity Operating： 10-90% (non-condensing) Storage： 10-90% (non-condensing) MFC242Programmer’s Manual Rev. 1.0 Page 6 2.5 Pin Assignment PIN NO. DESCRIPTION 1 Power 2 Data ‐ 3 Data + 4 NC 5 Ground 2.6 Software Specification GDS® Card Reader: Communication Protocol v1.0.4 Universal Serial Bus (USB) Spe…

Text truncated - open the document above for the full version.

Date: Federal Communications Commission 7435 Oakland Mills Road Columbia, MD 21046 USA Subject: Authority to Act as FCC Agent and Request for Confidentiality / FCC lD: TFJMFC242 Gentlemen: On Behalf of Uniform lndustrial Corp., we hereby authorize Central Research Technology Co. to act on out behalf in matters relating to FCC equipment authorization, including the signing of documents relating to these matters. Any and all acts carried out by Central research Technology Co. on our behalf shall have the same effecl as acts of our own. ln accordance with provisions of section 0.457(d) of the Commission's Rules and section 552(bXa) of the Freedom of lnformation Act, we do not request confidentiality for all device's exhibits. Sincerely yours, of Sales and Marketing Josdpft Y. Kwong i Unifoim lndustrial lp.

It urc 47436 Fremont Blvd, Fremont, CA 94538 Tel: (510) 438-6799 Fax (510) 438-6790 Date: Federal Communications Commission 7435 Oakland Mills Road ColumbiaMD 21046 Subj ect: Request for Confi dentialify FCC ID: TFJMFC242 Subject: Confi dentiality Request Pursuant to 0.457 and 0.459 of the Commissionns Rules/ IC regulation, the Applicant hereby requests confidential treahnent of information accompanying this Application as outlined below: l Schematics 2. Operational Description 3. BlockDiagram The above materials contain trade secrets and proprietary information not customarily released to the public. The public disclosure of these matters might be harmful to the Applicant and provide unjustified benefits to its competitors. The Applicant understands that the disclosure of this Application and all accompanying documentation will not be made before the date of the Grant for this application. Sincerely Yours. ilr'h Joseph v. rwong \ J Director of Sales anYMarketing Uniform Industrial Corp.

FCC Test Report Report No.: RF- U010-1407-324 CENTRAL RESEARCH TECHNOLOGY CO. Page : A2-1 No. 11, Lane 41, Fushuen St., Jungshan Chiu, Taipei, Taiwan, 104, R.O.C. TEL. : 886-2-25984542 FAX. : 886-2-25984546 Attachment 2 External Photographs of EUT FCC Test Report Report No.: RF- U010-1407-324 CENTRAL RESEARCH TECHNOLOGY CO. Page : A2-1 No. 11, Lane 41, Fushuen St., Jungshan Chiu, Taipei, Taiwan, 104, R.O.C. TEL. : 886-2-25984542 FAX. : 886-2-25984546 FCC Test Report Report No.: RF- U010-1407-324 CENTRAL RESEARCH TECHNOLOGY CO. Page : A2-2 No. 11, Lane 41, Fushuen St., Jungshan Chiu, Taipei, Taiwan, 104, R.O.C. TEL. : 886-2-25984542 FAX. : 886-2-25984546 FCC Test Report Report No.: RF- U010-1407-324 CENTRAL RESEARCH TECHNOLOGY CO. Page : A2-3 No. 11, Lane 41, Fushuen St., Jungshan Chiu, Taipei, Taiwan, 104, R.O.C. TEL. : 886-2-25984542 FAX. : 886-2-25984546

Label Location

FCC Test Report Report No.: RF-U010-1403-251 CENTRAL RESEARCH TECHNOLOGY CO. No. 11, Lane 41, Fushuen St., Jungshan Chiu, Taipei, Taiwan, 104, R.O.C. Page : A3- TEL. : 886-2-25984542 FAX. : 886-2-25984546 0 Attachment 3 Internal Photographs of EUT FCC Test Report Report No.: RF-U010-1403-251 CENTRAL RESEARCH TECHNOLOGY CO. No. 11, Lane 41, Fushuen St., Jungshan Chiu, Taipei, Taiwan, 104, R.O.C. Page : A3- TEL. : 886-2-25984542 FAX. : 886-2-25984546 1 FCC Test Report Report No.: RF-U010-1403-251 CENTRAL RESEARCH TECHNOLOGY CO. No. 11, Lane 41, Fushuen St., Jungshan Chiu, Taipei, Taiwan, 104, R.O.C. Page : A3- TEL. : 886-2-25984542 FAX. : 886-2-25984546 2 FCC Test Report Report No.: RF-U010-1403-251 CENTRAL RESEARCH TECHNOLOGY CO. No. 11, Lane 41, Fushuen St., Jungshan Chiu, Taipei, Taiwan, 104, R.O.C. Page : A3- TEL. : 886-2-25984542 FAX. : 886-2-25984546 3 RF IC FCC Test Report Report No.: RF-U010-1403-251 CENTRAL RESEARCH TECHNOLOGY CO. No. 11, Lane 41, Fushuen St., Jungshan Chiu, Taipei, Taiwan, 104, R.O.C. Page : A3- TEL. : 886-2-25984542 FAX. : 886-2-25984546 4 Antenna Board FCC Test Report Report No.: RF-U010-1403-251 CENTRAL RESEARCH TECHNOLOGY CO. No. 11, Lane 41, Fushuen St., Jungshan Chiu, Taipei, Taiwan, 104, R.O.C. Page : A3- TEL. : 886-2-25984542 FAX. : 886-2-25984546 5

FCC Test Report Report No.: RF-U010-1407-324 CENTRAL RESEARCH TECHNOLOGY CO. Page : 1/45 No. 11, Lane 41, Fushuen St., Jungshan Chiu, Taipei, Taiwan, 104, R.O.C. TEL. : 886-2-25984542 FAX. : 886-2-25984546 FCC Test Report for MFC242 RFID Card Reader Trade Name : Uniform Model Number : MFC242 FCC ID : TFJMFC242 Report Number : RF-U010-1407-324 Date of Receipt : July 29, 2014 Date of Report : August 15, 2014 Prepared for Uniform Industrial Corp. 47436 Fremont Blvd., Fremont, CA 94538-6512, USA Prepared by Central Research Technology Co. EMC Test Laboratory No.11, Lane41, Fushuen St., Jungshan Chiu, Taipei, Taiwan, 104, R.O.C. NVLAP LAB CODE 200575-0 This report shall not be reproduced, except in full, without the written approval of Central Research Technology Co.. It may be duplicated completely in its entirely for legal use with the permission of the applicant. It should not be used to claim product endorsement by NVLAP, NIST or any U.S. government agency. The test result in the report applies only to the sample tested. FCC Test Report Report No.: RF-U010-1407-324 CENTRAL RESEARCH TECHNOLOGY CO. Page : 2/45 No. 11, Lane 41, Fushuen St., Jungshan Chiu, Taipei, Taiwan, 104, R.O.C. TEL. : 886-2-25984542 FAX. : 886-2-25984546 Certification Equipment under Test : MFC242 RFID Card Reader Model No. : MFC242 FCC ID : TFJMFC242 Manufacturer : Uniform Industrial Corp. Applicant : Uniform Industrial Corp. Address : 47436 Fremont Blvd., Fremont, CA 94538-6512, USA Date of Testing : July 30 ~ August 11, 2014 Applicable Standards : 47 CFR part 15, Subpart C Deviation : N/A Condition of Test Sample : Mass Production We, Central Research Technology Co., hereby certify that one sample of the designated product was tested in our facility during the period mentioned above. The test records, data evaluation and Equipment Under Test (EUT) configurations shown in the present report are true and accurate representation of the measurements of the sample’s RF characteristics under the conditions herein specified. The test results show that the EUT as described in the present report is in compliance with the requirements set forth in the standards mentioned above and apply to the tested sample identified in the present report only. The test report shall not be reproduced, except in its entirety, without the written approval of Central Research Technology Co. FCC Test Report Report No.: RF-U010-1407-324 CENTRAL RESEARCH TECHNOLOGY CO. Page : 3/45 No. 11, Lane 41, Fushuen St., Jungshan Chiu, Taipei, Taiwan, 104, R.O.C. TEL. : 886-2-25984542 FAX. : 886-2-25984546 Contents 1 General Description .............................................................................................. 5 1.1 G ENERAL DESCRIPTION OF EUT ................................................................................ 5 1.2 TEST MODE .............................................................................................................. 6 1.3 TEST METHODOLOGY ................................................................................................ 6 1.4 REQUIREMENT FOR COMPLIANCE................................................................................ 7 1.5 THE SUPPORT UNITS ................................................................................................. 9 1.6 LAYOUT OF SETUP ................................................................................................... 10 1.7 T EST CAPABILITY .................................................................................................... 11 1.8 MEASUREMENT UNCERTAINTY .................................................................................. 12 2 Conducted Emission Measurement .................................................................. 13 2.1 LIMITS FOR EMISSION MEASUREMENT ....................................................................... 13 2.2 T EST INSTRUMENTS ................................................................................................. 14 2.3 TEST PROCEDURES ................................................................................................. 15 2.4 TEST CONFIGURATIONS ........................................................................................... 16 2.5 TEST DATA .............................................................................................................. 17 3 Field Strength of fundamental ............................................................................ 21 3.1 APPLIED STANDARD ................................................................................................ 21 3.2 TEST INSTRUMENTS ................................................................................................. 22 3.3 MEASUREMENT PROCEDURE .................................................................................... 23 3.4 TEST CONFIGURATION ............................................................................................. 23 3.5 T EST DATA ............................................................................................................. 24 4 Radiated Emission .............................................................................................. 28 4.1 APPLIED STANDARD ................................................................................................ 28 4.2 TEST INSTRUMENTS ................................................................................................. 29 4.3 M EASUREMENT PROCEDURE .................................................................................... 30 4.4 TEST CONFIGURATION ............................................................................................. 31 4.5 TEST DATA ............................................................................................................. 32 5 Frequency Tolerence .......................................................................................... 34 5.1 APPLIED STANDARD ..................................................…

Text truncated - open the document above for the full version.

FCC Test Report Report No.: RF-U010-1407-324 CENTRAL RESEARCH TECHNOLOGY CO. Page : A1-1 No. 11, Lane 41, Fushuen St., Jungshan Chiu, Taipei, Taiwan, 104, R.O.C. TEL. : 886-2-25984542 FAX. : 886-2-25984546 Attachment 1 Photographs of the Test Configurations FCC Test Report Report No.: RF-U010-1407-324 CENTRAL RESEARCH TECHNOLOGY CO. Page : A1-1 No. 11, Lane 41, Fushuen St., Jungshan Chiu, Taipei, Taiwan, 104, R.O.C. TEL. : 886-2-25984542 FAX. : 886-2-25984546 Conducted Emission Measurement FCC Test Report Report No.: RF-U010-1407-324 CENTRAL RESEARCH TECHNOLOGY CO. Page : A1-2 No. 11, Lane 41, Fushuen St., Jungshan Chiu, Taipei, Taiwan, 104, R.O.C. TEL. : 886-2-25984542 FAX. : 886-2-25984546 Radiated Emission Measurement Below 30MHz FCC Test Report Report No.: RF-U010-1407-324 CENTRAL RESEARCH TECHNOLOGY CO. Page : A1-3 No. 11, Lane 41, Fushuen St., Jungshan Chiu, Taipei, Taiwan, 104, R.O.C. TEL. : 886-2-25984542 FAX. : 886-2-25984546 Above 30MHz