YHXESQ-3040R4Electric Smoker with RF

Masterbuilt Manufacturing, Inc. 1 Masterbuilt Ct. Columbus, GA 31907 Customer Service 1-800-489-1581 www.masterbuilt.com Manual Code: 9807120001 031612-23JH Tool needed for assembly: Phillips Head Screwdriver Approximate assembly time : 25 minutes CARBON MONOXIDE HAZARD WARNING Burning wood chips gives off carbon monoxide, which has no odor and can cause death. DO NOT burn wood chips inside homes, vehicles, tents, garages or any enclosed areas. Use only outdoors where it is well ventilated. This manual contains important information necessary for the proper and safe use of this unit. Read and follow all warnings and instructions before using smoker and during use. Keep this manual for future reference. Some parts may have sharp edges handle with care. Failure to follow these warnings and instructions properly could result in personal injury or death. ASSEMBLY, CARE & USE MANUAL WARNING & SAFETY INFORMATION ELECTRIC SMOKER MODELS 20070312, 20070512, 20072612, 20072712 THIS PRODUCT IS FOR OUTDOOR USE ONLY 1 GENERAL WARNINGS AND SAFETY INFORMATION READ ALL INSTRUCTIONS When using electrical appliances, basic safety precautions should always be followed including the following: • For outdoor use only. Do not operate in an enclosed area. • Unit MUST be on the ground. Do not place unit on tables or counters. Do NOT move unit across uneven surfaces. • Do not lift unit by rear handle. • Do not plug in electric smoker until fully assembled and ready for use. • Use only approved grounded electrical outlet. • Do not use during an electrical storm. • Do not expose electric smoker to rain or water at anytime. • To protect against electrical shock do not immerse cord, plug or control panel in water or other liquid. • Do not operate any appliance with a damaged cord or plug, or after appliance malfunctions or has been damaged in any manner. Contact Masterbuilt Customer Service for assistance at 1-800-489-1581. • Keep a fi re extinguisher accessible at all times while operating electric smoker. • Do not let cord hang touch hot surfaces. • Do not place on or near a hot gas or electric burner, or in a heated oven. • Keep children and pets away from electric smoker at all times. Do not allow children to use electric smoker. Close supervision is necessary should children or pets be in area where electric smoker is being used. • Fuel, such as charcoal briquettes or heat pellets, are not to be used in electric smoker. • Never use electric smoker as a heater (READ CARBON MONOXIDE HAZARD ON FRONT COVER). • Use electric smoker only on a level, stable surface to prevent tipping. • Electric smoker is HOT while in use and will remain HOT for a period of time afterwards. Use caution. • Do not touch HOT surfaces. • Do not allow anyone to conduct activities around electric smoker during or following its use until the unit has cooled. Electric smoker is HOT during operation and remains HOT for a period of time following use. • The use of alcohol, prescription or non-prescription drugs may impair the user’s ability to properly assemble or safely operate electric smoker. • Avoid bumping or impacting electric smoker. • Never move electric smoker when in use. Allow electric smoker to cool completely before moving or storing. • Be careful when removing food from electric smoker. All surfaces are HOT and may cause burns. Use protective gloves or long, sturdy cooking tools. WARNINGS & IMPORTANT SAFEGUARDS CONTINUED ON PAGE 2 18 LIMITED WARRANTY Masterbuilt warrants its products to be free from defects in material and workmanship under proper assembly, normal use and recommended care for 90 days from the date of original retail purchase. Masterbuilt warranty does not cover paint fi nish as it may burn off during normal use. Masterbuilt warranty does not cover rust of the unit.Masterbuilt requires reasonable proof of purchase for warranty claims and suggests that you keep your receipt. Upon the expiration of such warranty, all such liability shall terminate.Within the stated warranty period, Masterbuilt, at its discretion, shall repair or replace defective components free of charge with owner being responsible for shipping. Should Masterbuilt require return of component(s) in question for inspection Masterbuilt will be responsible for shipping charges to return requested item.This warranty excludes property damage sustained due to misuse, abuse, accident, damage arising out of transportation, or damage incurred by commercial use of this product.This expressed warranty is the sole warranty given by Masterbuilt and is in lieu of all other warranties, expressed or implied including implied warranty, merchantability, or fi tness for a particular purpose. Neither Masterbuilt nor the retail establishment selling this product, has authority to make any warranties or to promise remedies in addition to or inconsistent with those stated above. Masterbuilt’s maximum liability, in any event, shall not exceed the purchase price of the product paid by the original consumer/ purchaser. Some states do not allow the exclusion or limitation of incidental or consequential damages. In such a case, the above limitations or exclusions may not be applicable.California residents only: Not withstanding this limitation of warranty, the following speci fi c restrictions apply; if service, repair, or replacement of the product is not commercially practical, the retailer selling the product or Masterbuilt will refund the purchase price paid for the product, less the amount directlyattributable to use by the original buyer prior to the discovery of the nonconformity. Owner may take the product to the retail establishment selling this product in order to obtain performance under warranty.This expressed warranty gives you speci fi c legal rights, and you may also have other rights which vary from state to state. Go Online www.masterbuilt.com or complete and return to Attn: Warranty Registration Masterbuilt Mfg. Inc. 1 Masterbuilt Court - Columbus, GA 31907 Na…

Text truncated - open the document above for the full version.

    

1 Masterbuilt Court · Columbus, Georgia 31907 · www.masterbuilt.com 1.800.489.1581 · 706.327.5622 · Fax 706.327.5632 July 4 , 2012 To whom it may concern, Letter of Agency I, an officer of Masterbuilt Manufacturing, Inc. do hereby authorize Intertek Testing Services (Mr. Shawn Xing) to act on our behalf in front of the Federal Communications Commission with respect to all matters relating to certification of equipment under Part 15 and/or Part 95 of the FCC Rules until further notice. I further certify that no party (as defined in §1.2002(b) of FR 47, 2007) to this application, including myself, is subject to a enial of federal benefits, that includes FCC benefits, pursuant to Section 5301 of the Anti-Drug Abuse Act of 1988, 21 U.S.C., 862. Regards, Darryl Kraft Senior Quality Engineer

External Photos:

1 Masterbuilt Court · Columbus, Georgia 31907 · www.masterbuilt.com 1.800.489.1581 · 706.327.5622 · Fax 706.327.5632 FCC ID: YHXESQ-3040R4 30MM 5MM

Internal Photos:

Technical Description The Equipment under Test (EUT) is a Remote Controller of Electric Smoker operating at 2.4GHz band which is used for cooking and outdoor used only. The EUT was powered by DC 3.0V (2*1.5V “AAA” Batteries). For more information, pls. refer to the user manual. Antenna Type: Integral antenna Modulation Type: FSK Frequency: 2440MHz Main IC Function: 1) U1 is CPU (Small-signal processing, time operations). 2) U2 is 2.4G RF Chip. 3) X1 is 32.768KHz OSC for U1. 4) XT1 is 16MHz OSC for U2.

11 22 33 44 D D C C B B A A Ti tle Number Revision Size A4 Date: 2012/6/21 Sheet of File: E:\ 电烤 炉控制器 \..\ 40wfr 遥控 - 20110621.Sch Drawn By: PA5 1 PA6 2 PA7 3 PB0 4 PB1 5 PB2 6 VSS 7 PC0 8 PB6 9 VCCA1 & V LCD 10 V2 11 C1 12 C2 13 CO M0 14 CO M1 15 CO M2 16 CO M3 17 SE G19 18 SE G18 19 SE G17 20 SE G16 21 SE G15 22 SE G14 23 SE G13 24 SE G12 25 SE G11 26 SE G10 27 SEG9 28 SEG8 29 SEG7 30 SEG6 31 SEG5 32 SEG4 33 SE G3 34 OSC 4 35 OSC 3 36 VDD 37 OSC 1 38 RES B 39 PA0 40 PA1 41 PA2 42 PA3 43 PA4 44 U1 H T49RA0-44QFP K1 K2 K3 K4 K5 K6 K7 C310 4 R11K GND GND GND +3 V GND+3 V GND X1 32 .768K C2104 C1 10 4 GND 12 J2CON 2 R2 12 K +3V C420P +3 V C520 P E1100uF/1 0V GN D COM0COM1COM2COM3 REM PB0 PB2 GI O1 PA2PA4 /RES PB1 PA 1 PA3 PA5 PB 0 PA2 PA4 PA3 SC S SCK PB 1 PA5 R61K R71K R81K R91K R51K R1 3 1K R1 2 1K 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 J1 COM1 COM0 CO M9 COM10 COM11 COM12 COM13 COM14 COM15 COM16 COM17 COM18 COM4 COM5 COM6 COM7 COM8 COM9 COM10 COM11 COM12 COM13 COM14 COM15 COM16 COM17 COM18 COM4COM5COM6COM7COM8 C9 680pF R2200 C1 3 10nF SCSSCKSD IO C7120 pF VD D_D C42.2uF C1 0 22pF L31. 2nH C6 10pF GIO2 GIO1 VIN REGOA C8 1.5nF C1 2 100pF C50.1uF RE GOA REG OA RS SI BPBG C12.2uF SC S SCKSDIOGIO1GNDVIN VDPLL RS SI 1 BP BG 2 RF I 3 RF O 4 VD A2 5 VT 6 GND 7 XI 8 XO 9 VDA3 10 SCS 11 SCK 12 DVDD 13 SD IO 14 GN D 15 CKO 18 GIO2 17 GIO1 16 REGI 19 VDA1 20 A 7105PKG U 2 A 7105PKG C22.2uF ANT C3 0.1uF 1234567 J1CON7 C1 6 1pF C1 8 1pF L43.3nH TP 1 ANTENNA L1NC C1 5 33pF C1 4 33pF 1 3 GND 2 GN D 4 XT1CRYSTAL/3.0*2.5 2.44GHz 16MHz Remote Controller of the Electric Smoker

• The test results reported in this test report shall refer only to the sample actually tested and shall not refer or be deemed to refer to bulk from which such a sample may be said to have been obtained. • This report is for the exclusive use of Intertek's Client and is provided pursuant to the agreement between Intertek and its Client. Intertek's responsibility and liability are limited to the terms and conditions of the agreement. Intertek assumes no liability to any party, other than to the Client in accordance with the agreement, for any loss, expense or damage occasioned by the use of this report. Only the Client is authorized to copy or distribute this report. Any use of the Intertek name or one of its marks for the sale or advertisement of the tested material, product or service must first be approved in writing by Intertek. The observations and test results referenced from this report are relevant only to the sample tested. This report by itself does not imply that the material, product, or service is or has ever been under an Intertek certification program. • For Terms And Conditions of the services, it can be provided upon request. • The evaluation data of the report will be kept for 3 years from the date of issuance. TRF No.: FCC 15C_TX_b Intertek Testing Services Shenzhen Ltd. Kejiyuan Branch 6F, D Block, Huahan Building, Langshan Road, Nanshan District, Shenzhen, P. R. China Tel: (86 755) 8601 6288 Fax: (86 755) 8601 6751 Website: www.china.intertek-etlsemko.com Masterbuilt Manufacturing, Inc. Application For Certification FCC ID: YHXESQ-3040R4 Electric Smoker with RF Model: 20070512 Additional Model: 20072512, 20072612, 20072712, 20072812, 20073012, 20070312, 20072112, 20072212, 20072312, 20072412, 20072912 2.4GHz Transceiver Report No.: SZ12070003-2 We hereby certify that the sample of the above item is considered to comply with the requirements of FCC Part 15, Subpart C for Intentional Radiator, mention 47 CFR [ 10-1-11] Prepared and Checked by: Approved by: Sign on file Leo Lai Engineer Billy Li Supervisor Date: 18 July, 2012 INTERTEK TESTING SERVICES TRF No.: FCC 15C_TX_b FCC ID: YHXESQ-3040R4 Report No.: SZ12070003-2 i LIST OF EXHIBITS INTRODUCTION EXHIBIT 1: General Description EXHIBIT 2: System Test Configuration EXHIBIT 3: Emission Results EXHIBIT 4: Equipment Photographs EXHIBIT 5: Product Labelling EXHIBIT 6: Technical Specifications EXHIBIT 7: Instruction Manual EXHIBIT 8: Miscellaneous Information EXHIBIT 9: Test Equipment List INTERTEK TESTING SERVICES TRF No.: FCC 15C_TX_b FCC ID: YHXESQ-3040R4 Report No.: SZ12070003-2 ii MEASUREMENT/TECHNICAL REPORT Masterbuilt Manufacturing, Inc. - Model: 20070512 Additional Model: 20072512, 20072612, 20072712, 20072812, 20073012, 20070312, 20072112, 20072212, 20072312, 20072412, 20072912 FCC ID: YHXESQ-3040R4 18 July, 2012 This report concerns (check one:) Original Grant X Class II Change Equipment Type: DXX - Part 15 Low Power Communication Device Transmitter Deferred grant requested per 47 CFR 0.457(d)(1)(ii)? Yes No X If yes, defer until: date Company Name agrees to notify the Commission by: date of the intended date of announcement of the product so that the grant can be issued on that date. Transition Rules Request per 15.37? Yes No X If no, assumed Part 15, Subpart C for intentional radiator − the new 47 CFR [10-1-11 Edition] provision. Report prepared by: Billy Li Intertek Testing Services Shenzhen Ltd. Kejiyuan Branch 6F, Block D, Huahan Building, Langshan Road, Nanshan District, Shenzhen, P. R. China Phone: (86 755) 8601 6288 Fax: (86 755) 8601 6751 INTERTEK TESTING SERVICES TRF No.: FCC 15C_TX_b FCC ID: YHXESQ-3040R4 Report No.: SZ12070003-2 iii Table of Contents 1.0 General Description..................................................................................................... 2 1.1 Product Description .................................................................................................... 2 1.2 Related Submittal(s) Grants ....................................................................................... 2 1.3 Test Methodology ....................................................................................................... 3 1.4 Test Facility ................................................................................................................ 3 2.0 System Test Configuration......................................................................................... 5 2.1 Justification................................................................................................................. 5 2.2 EUT Exercising Software............................................................................................ 5 2.3 Special Accessories ................................................................................................... 5 2.4 Equipment Modification .............................................................................................. 6 2.5 Measurement Uncertainty .......................................................................................... 6 2.6 Support Equipment List and Description .................................................................... 6 3.0 Emission Results......................................................................................................... 8 3.1 Radiated Test Results ................................................................................................ 9 3.1.1 Field Strength Calculation ....................................................................................... 9 3.1.2 Radiated Emission Configuration Photograph....................................................... 10 3.1.3 Radiated Emissions............................................................................................. 10 3.1.4 Transmitter Spurious Emissions (Radiated) .......................................................... 12 4.0 Equipment Photographs..........................................................…

Text truncated - open the document above for the full version.

Radiated Photos