S8L-100595HPRMHPRM850 Amplifier RF100595/NTN065JA

RF Power Amplifiers Andrew Corporation – Power Amplifier Group Propriety – Use pursuant to Company Instruction 1 of 3 High Power Radio Module Model: HPRM850 Operation Instruction Date: January 29, 2007 Version. 1.0 Ref#: FCC ID: S8L-100595HPRM Industry Canada: IC: 2237F-RF100595 RF Power Amplifiers Andrew Corporation – Power Amplifier Group Propriety – Use pursuant to Company Instruction 2 of 3 Introduction This document presents description of the Andrew Corporation 850 Band HPRM (High Power Radio Module) amplifiers. The HPRMA850 amplifier is a high power, RF amplifier intended to provide signal amplification and conditioning. The HPRM850 amplifier is compatible with GSM and EDGE air interfaces operating in U.S. domestic cell sites where FCC compliance is mandatory. The Cell band (869 MHz to 894 MHz) HPRM850 RF power amplifier is capable of amplifying a single carrier of different modulation types to a composite power level of 60Watts. HPRM850 Specifications The HPRM850 provide linear amplification of single-carrier signals in the cellular frequency band. The 850 Band HPRM850 has the following specifications: Parameter Specification Operating RF Band 869-894MHz In band RF gain 44dB Input signal types GSM or EDGE single carrier Operational Bandwidth 25 MHz (38MHz for-20dB bandwidth, nominal) Input / Output Impedances 50 Ohms Input DC Power +27 VDC, nominal DC voltage input range +26.5 to +27.5VDC Rated Output Power @ +26.5 to +27.5VDC input 60W average GSM or 45W EDGE DC-RF Efficiency 33%, rated output power, nominal input voltage Physical dimensions 7.5” x 4” x 1.4” Weight < 2lbs Cooling technique The HPRM is a module to be mounted onto the customer heat sink within his frame. The module provides a copper pallet interface for thermal cooling by conduction. Temperature Range 0°C to +60°C meeting specifications. Table 1 HPRM850 Specifications Installation and Operation Set-Up The HPRM850 is easy to operate and use, only requiring a special cables for DC power and a multipoint connector to provide the ON/OFF state and biasing points to the module and report the monitoring to the system. RF input and output connections are done with industry standard MCX and QN connectors. RF Power Amplifiers Andrew Corporation – Power Amplifier Group Propriety – Use pursuant to Company Instruction 3 of 3 FCC Statements: FCC ID: S8L-100595HPRM This device complies with Part 2, 15, & 22 of the FCC Rules. Operation is subject to the following two conditions: (1) this device may not cause harmful interference and (2) this device must accept any interference received, including interference that may cause undesired operation. Warning Changes of modifications not expressly approved by the manufacturer could void the user’s authority to operate the equipments. Industry Canada Statements: Industry Canada ID: IC: 2237F-RF100595 1. Quality Norms: The testing of the equipment is carried out as the norms stated in IC standards. 2. Labeling: HPRM850 when sold in Canada will have: (a) The certification number, prefixed by the term "IC: ", i.e. IC: 2237F-RF100595 (b) The manufacturer's name, trade name or brand name, i.e. Andrew Corporation (c) A model name or number. Model Name = RF100595/NTN065JA (d) This device complies with RSS-131, RSS-102 of the IC Rules. 3. External Control The HPRM850 does not have any external controls accessible to the user for any adjustments, to operate in violation of the limits prescribed in this Standard. Furthermore, information on internal adjustments, reconfiguration or programmability of the device shall only be made available to service depots and agents of the equipment supplier and NOT to the public. 4. Exposure of Humans to RF Field: The equipment conforms to RSS-102. RF Exposure compliance is also addressed at the time of licensing.

Google Gmail Calendar Photos Docs & Spreadsheets Groups all my services » [email protected] | Settings | Help | Sign out andrew] Search MailSearch the Web Show search options Create a filter « Back to Search results Report SpamDelete ‹ Newer 2 of 21 Older › Re: Andrew Corporation, Certification No.: 2237F- RF100595, Assessment NO.: A... Inbox Reply "[email protected]" to tim.dwyershow details Feb 15 (6 days ago) Hi, Tim. Thanks again. 1. For HPRM850: The PCB has only one side for the circuitry. The other side stays together with metal case/heat-sink. 2. The confidentiality letter will be provided again. Regards, Wei Reply Reply to all Forward Invite [email protected] to Gmail Reply "[email protected]" show details Feb 19 (2 days ago) Hi, Tim. Here are the confidentiality letters for FCC and IC applications. Hopefully we provide all the docs. THANKS A LOT! Best regards, Wei 2 attachments — Download all attachments FCCconfidentialityletter.pdf 342K View as HTML Download ICconfidentialityletter.pdf 329K View as HTML Download Compose Mail Inbox (278) Starred Chats Sent Mail Drafts (5) All Mail Spam (9) Trash Contacts Labels Edit labels Invite a friend Give Gmail to: 50 left Send Invite preview invite < > Sponsored Link Your 1 True Love - www.Your1Love.com - We Can Predict The Exact Name O ... More actions... New window Print all Collapse all Forward all Turn off highlighting Sponsored Links This 6-word formula makes copy writing easy. Free, no sales pitch. BencivengaBullets.com SOX Compliance via Rapid ITSM BS15000, ISO20000, CObIT, 17799 www.mountainview.ca Find Recently Open $100K Positions Search 20,000 New Opportunities www.TheLadders.com More about... Sample Letter Letter Example Letter Writing Template Business Letter About these links Page 1 of 2 2/21/2007http://mail.google.com/mail/?ik=2a69a1bf8a&view=cv&search=query&q=andrew%5D&t... Begin typing in the address fields and Gmail will suggest names from your contact list. You are currently using 180 MB (6%) of your 2819 MB. Gmail view: standard with chat | standard without chat | basic HTML Learn more ©2007 Google - Terms of Use - Privacy Policy - Program Policies - Google Home Reply Reply to all Forward Invite [email protected] to Gmail « Back to Search results Report SpamDelete ‹ Newer 2 of 21 Older › Compose Mail Inbox (278) Starred Chats Sent Mail Drafts (5) All Mail Spam (9) Trash Contacts Labels Edit labels Invite a friend Give Gmail to: 50 left Send Invite preview invite More actions... Page 2 of 2 2/21/2007http://mail.google.com/mail/?ik=2a69a1bf8a&view=cv&search=query&q=andrew%5D&t...

EUT: HRPM850 FCC ID: S8L-100595HPRM Model: RF100595/NTN065JA Report Number: 0048-070116-01-FCC Page 70 of 74 Advanced Compliance Laboratory, Inc. 6 Randolph Way, Hillsborough, NJ 08844, Tel: (908) 927 9288 RF100595 Top EUT: HRPM850 FCC ID: S8L-100595HPRM Model: RF100595/NTN065JA Report Number: 0048-070116-01-FCC Page 71 of 74 Advanced Compliance Laboratory, Inc. 6 Randolph Way, Hillsborough, NJ 08844, Tel: (908) 927 9288 RF100595 Side/Bottom

Approuvé : Echelle :Révision : 11 rue de Fieusal 33520 BRUGES Dess. : Fich. : Date : 30/01/2007 Dess. G DUPOUY PARM 850 REGULATORY LABEL Model Number : RF100595FCC ID: XXX-100595XXXXIC: XXXXX-RF100595 50.8 max 15 max 40 REGULATORY LABEL EXAMPLE LABEL POSITION PROPOSAL

EUT: HRPM850 FCC ID: S8L-100595HPRM Model: RF100595/NTN065JA Report Number: 0048-070116-01-FCC Page 64 of 74 Advanced Compliance Laboratory, Inc. 6 Randolph Way, Hillsborough, NJ 08844, Tel: (908) 927 9288 Section 10. Maximum Permissible Exposure MPE estimate is given per 2.1091 of FCC Rules: Calculation Equation: S d GP 20 10 282.0 + ×= Where, P--max. Output Power, G—Antenna Gain and S—Power Density Factor from §1.1310. Plug all three items into the equation, and yields, Power Density MPE Limit (mW/ cm 2 ) Output Power (dBm) Server Antenna Gain (dBi) Donor Antenna Gain (dBi) Server MPE Distance (cm) Donor MPE Distance (cm) NOTE: For mobile or fixed location transmitters, the minimum separation distance is 20 cm, even if calculations indicate that the MPE distance would be less. N/A FOR THIS CASE ----AMPLIFIER ONLY, NO ATENNNA PRESENT.

Electromagnetic Emission Compliance Test Report Equipment Under Test (EUT) HRPM850 RF100595/NTN065JA Applicant Andrew Corporation In Accordance With FCC Part 22 & Part 2 Tested by Advanced Compliance Laboratory, Inc. 6 Randolph Way Hillsborough, New Jersey 08844 Authorized by Wei Li Lab Manager Signature Date February 1, 2007 AC Lab Report Number 0048-070116-01-FCC The test result in this report is supported and covered by the NVLAP accreditation. Lab Code:200101-0 Advanced Compliance Laboratory 6 Randolph Way Hillsborough, NJ 08844 Tel: (908) 927 9288 Fax: (908) 927 0728 EUT: HRPM850 FCC ID: S8L-100595HPRM Model: RF100595/NTN065JA Report Number: 0048-070116-01-FCC Page 2 of 74 Advanced Compliance Laboratory, Inc. 6 Randolph Way, Hillsborough, NJ 08844, Tel: (908) 927 9288 Index Section 1. Summary of Test Results....................................................................... 3 Section 2. General Equipment Specification......................................................... 5 Section 3. RF Output Power....................................................................................... 7 Section 4. Occupied Bandwidth.............................................................................. 10 Section 5. Spurious Emissions at Antenna Terminals..................................... 24 Section 6. Field Strength of Spurious................................................................... 54 Section 7. Frequency Stability................................................................................ 60 Section 8. Test Equipment List............................................................................... 62 Section 9. FCC ID Labeling....................................................................................... 63 Section 10. Maximum Permissible Exposure...................................................... 64 Section 11. Setup Photos......................................................................................... 65 Section 12. EUT Photos............................................................................................. 69 EUT: HRPM850 FCC ID: S8L-100595HPRM Model: RF100595/NTN065JA Report Number: 0048-070116-01-FCC Page 3 of 74 Advanced Compliance Laboratory, Inc. 6 Randolph Way, Hillsborough, NJ 08844, Tel: (908) 927 9288 Section 1. Summary of Test Results Manufacturer: Andrew Corporation Product Name: HRPM850 Model No.: RF100595/NTN065JA General: All measurements are traceable to national standards These tests were conducted on a sample of the equipment for the purpose of demonstrating compliance with Part 22 & Part 2. New Submission Production Unit Class II Permissive Change Pre-Production Unit THIS TEST REPORT RELATES ONLY TO THE ITEM(S) TESTED. THE FOLLOWING DEVIATIONS FROM, ADDITIONS TO, OR EXCLUSIONS FROM THE TEST SPECIFICATIONS HAVE BEEN MADE. “See Summary of Test Data” NVLAP LAB CODE: 200101-0 Advance Compliance Laboratory, Inc. authorizes the above named company to reproduce this report provided it is reproduced in its entirety and for use by the company’s employees only. Any use which a third party makes of this report, or any reliance on or decisions to be made based on it, are the responsibility of such third parties. Advance Compliance Laboratory, Inc. accepts no responsibility for damages, if any, suffered by any third party as a result of decisions made or actions based on this report. This report applies only to the items tested. EUT: HRPM850 FCC ID: S8L-100595HPRM Model: RF100595/NTN065JA Report Number: 0048-070116-01-FCC Page 4 of 74 Advanced Compliance Laboratory, Inc. 6 Randolph Way, Hillsborough, NJ 08844, Tel: (908) 927 9288 Summary of Test Data 22.913(a) 500W ERP Complies** RF Power Output 24.232(a) 100W EIRP N/A* Occupied Bandwidth (Voice & SAT) 2.1049(i) Mask N/A* Occupies Bandwidth (Wideband Data) 2.1049(i) Mask N/A* Occupied Bandwidth (Digital) 2.1049(i) Mask Complies 22.917 -13 dBm Complies Spurious Emissions at Antenna Terminals 24.238 -13 dBm N/A* 22.917 -13 dBm Complies Field Strength of Spurious Emissions 24.238 -13 dBm E.I.R.P. N/A* 22.355 1.5 ppm N/A* Frequency Stability 24.235 0.05 ppm N/A* * These items are NOT applied to the EUT. ** See page 10. The estimated uncertainty of the test result is given as following. The method of uncertainty calculation is provided in Advanced Compliance Lab. Doc. No. 0048-01-01. Prob. Dist.Uncertainty(dB) Uncertainty(dB) Uncertainty(dB) 30-1000MHz 1-6.5GHz Conducted Combined Std. Uncertainty u c norm. ±2.36 ±2.99 ±1.83 Wei Li Date: February 1, 2007 Lab Manager Advanced Compliance Lab EUT: HRPM850 FCC ID: S8L-100595HPRM Model: RF100595/NTN065JA Report Number: 0048-070116-01-FCC Page 5 of 74 Advanced Compliance Laboratory, Inc. 6 Randolph Way, Hillsborough, NJ 08844, Tel: (908) 927 9288 Section 2. General Equipment Specification Supply Voltage 27VDC Cellular DL/869MHz-894MHz Frequency Range PCS N/A Modulation CDMA 2000 WCDMA GSM EDGE TDMA Type of Emissions F9W F9W GXW G7W DXW Rated Power 60 W for GSM/45W for EDGE Operating Power Max. 60W total power for single carrier (GSM) Output Impedance 50ohm F1-F1 F1-F2 N/A Frequency Translation Software Duplexer Change Full Band Coverage DC voltages and DC currents per 2.1033(c)(8) The input supply to the transmitter was set at 27VDC. The RF power output was measured with the indicated voltage and current applied into the final RF amplifying device(s). RF100595/NTN065JA Amplifier RF Output, DC Current and RF Input Power are all average values. Measured Rated RF output: 47.75dBm (GSM 60W) &46.5dBm (EDGE 45W) Measured DC voltage: 27.0V Measured DC current: 5.69A (GSM) & 4.68A(EDGE) Measured Minimum RF output: 14dBm Measured DC voltage: 27.0V Measured DC current: 1.2A EUT: HRPM850 FCC ID: S8L-100595HPRM Model: RF100595/NTN065JA Report Number: 0048-070116-01-FCC Page 6 of 74 Advanced Compliance Laboratory, Inc. 6 Randolph Way, Hillsborough, NJ 08844, Tel: (908) 927 9288 Tune-up procedure per 2.1033(c) (9) There are no user accessible adjustm…

Text truncated - open the document above for the full version.

EUT: HRPM850 FCC ID: S8L-100595HPRM Model: RF100595/NTN065JA Report Number: 0048-070116-01-FCC Page 65 of 74 Advanced Compliance Laboratory, Inc. 6 Randolph Way, Hillsborough, NJ 08844, Tel: (908) 927 9288 Section 11. Setup Photos RF Output Power EUT: HRPM850 FCC ID: S8L-100595HPRM Model: RF100595/NTN065JA Report Number: 0048-070116-01-FCC Page 66 of 74 Advanced Compliance Laboratory, Inc. 6 Randolph Way, Hillsborough, NJ 08844, Tel: (908) 927 9288 Spurious Emissions at Antenna Terminal EUT: HRPM850 FCC ID: S8L-100595HPRM Model: RF100595/NTN065JA Report Number: 0048-070116-01-FCC Page 67 of 74 Advanced Compliance Laboratory, Inc. 6 Randolph Way, Hillsborough, NJ 08844, Tel: (908) 927 9288 Occupied Bandwidth EUT: HRPM850 FCC ID: S8L-100595HPRM Model: RF100595/NTN065JA Report Number: 0048-070116-01-FCC Page 68 of 74 Advanced Compliance Laboratory, Inc. 6 Randolph Way, Hillsborough, NJ 08844, Tel: (908) 927 9288 Field Strength of Spurious